Toyota Tundra Complaints (2003)

399 consumer complaints on file.

#10538649September 3, 2013
AIR BAGS
I AM DRIVING WITHOUT AIRBAG SAFETY BECAUSE TOYOTA DEALERSHIP DID NOT CORRECT PROBLEM THEY QUOTED ME $85 TO CHECK IT OUT AND AROUND $1000 TO FIX. ON 09/03/2013, I TOOK MY VEHICLE TO TOYOTA DEALERSHIP FOR URGENT SAFETY RECALL TO CORRECT AIRBAG DEFECT. I MENTIONED THE AIRBAG LIGHT AGAIN. I WAS ADVISED THE AIRBAG RECALL WILL CORRECT MY PROBLEM AND THE LIGHT WILL GO AWAY. I PICKED UP MY VEHICLE AND NOTICED MY AIRBAG LIGHT WAS STILL ON. TOYOTA ADVISED ME THAT THE TROUBLE IS THE CENTER AIRBAG MODULE. I ASKED THEM IF THE AIRBAGS WILL ENGAGE ON IMPACT. TOYOTA SAID THE AIRBAGS WILL NOT DEPLOY WITH THIS LIGHT ON. WHY DID I WASTE MY TIME TAKING MY VEHICLE TO TOYOTA TO CORRECT AN AIRBAG DEFECT AND TO LEAVE WITH AN AIRBAG DEFECT? TOYOTA SHOULD HAVE CORRECTED THIS ISSUE A LONG TIME AGO WHEN THIS WAS UNDER WARRANTY.*JB
Crash:
No
Fire:
No
Injuries:
0
Deaths:
0
#10535151August 13, 2013
FUEL SYSTEM, GASOLINE
I WAS DRIVING DOWN THE ROAD WHEN THE 'CHECK ENGINE' LIGHT CAME ON. I TOOK IT TO THE DEALER TO SEE WHAT THE ISSUE WAS AND THEY STATED IT WAS A LEAK IN THE GAS CAP AND THAT I DIDN'T HAVE CAP TIGHT ENOUGH. ON THE WAY HOME FROM THE DEALER THE 'CHECK ENGINE' LIGHT CAME BACK ON, SO I TOOK IT BACK TO THE DEALER. THEY STATED THAT THE FUEL FILLER NECK NEEDED TO BE REPLACED AND IT'S NOT COVERED UNDER WARRANTY. *TR
Crash:
No
Fire:
No
Injuries:
0
Deaths:
0
#10521902June 26, 2013
POWER TRAIN, POWER TRAIN:AUTOMATIC TRANSMISSION:LEVER AND LINKAGE:COLUMN SHIFT
TL* THE CONTACT OWNS A 2003 TOYOTA TUNDRA. THE CONTACT STATED THAT WHILE SHIFTING FROM PARK TO REVERSE, THE SHIFT LEVER FRACTURED AND DETACHED FROM THE VEHICLE. THE VEHICLE REMAINED IN REVERSE. THE VEHICLE WAS TAKEN TO THE DEALER, WHO REPLACED THE SHIFT ASSEMBLY, LEVER SUB ASSEMBLY, TILT LEVER AND THE SHIFT LEVER. THE FAILURE WAS REPORTED TO THE MANUFACTURER, WHO REFUSED TO PROVIDE ANY ASSISTANCE. THE FAILURE MILEAGE WAS 125,426. THE CURRENT MILEAGE WAS 125,540. ..UPDATED 08-07-13 *BF THE DEALER REPLACED THE COLUMN AND REPLACED THE BROKEN SHIFT COMPONENTS. UPDATED 08/13/13
Crash:
No
Fire:
No
Injuries:
0
Deaths:
0
#10508140April 13, 2013
SUSPENSION, STRUCTURE:BODY
UPON INSPECTION THERE IS TOTAL RUST OF THE FRAME AND BOLTS ON THE SUSPENSION. UNUSUAL TIRE WEAR. I HAVE READ ABOUT SOME RECALLS BUT THIS IS AN EXCEPTIONAL LOW MILES VEHICLE (LESS THEN 50,000) AND IT IS FOUND TO BE IN UNSOUND CONDITION AND CURRENT VALUE SHOULD BE AT LEAST $18,000. *TR
Crash:
No
Fire:
No
Injuries:
0
Deaths:
0
#10504374March 25, 2013
POWER TRAIN
NOTICED OILY SUBSTANCE ON DRIVEWAY, TOOK TRUCK TO MECHANIC AND HE INFORMED ME THE REAR AXLE HOUSING HAD RUSTED THROUGH! I WAS SHOCKED AT THE NEWS AND DUMBFOUNDED TO FIND OUT THIS IS A COMMON PROBLEM WITH TUNDRA'S AND TACOMA'S AND THERE IS NO RECOURSE EXCEPT TO PAY UPWARDS OF $2000 TO HAVE IT FIXED. I HAVE NEVER HEARD OF ANY NEWER VEHICLE HAVING THE AXLE RUST THROUGH AT ONLY 104,000 MILES. THIS IS LOW MILES FOR A 2003 AND THE TRUCK HAS BEEN TAKEN CARE OF TOO. *TR
Crash:
No
Fire:
No
Injuries:
0
Deaths:
0
#10503531March 18, 2013
STRUCTURE:BODY
FRAME HAS SEVERAL RUST PERFORATION HOLES. TOYOTA REFUSES TO REPAIR. VEHICLE BOUGHT USED IN MARCH OF 2013. *TR
Crash:
No
Fire:
No
Injuries:
0
Deaths:
0
#10502781March 14, 2013
SUSPENSION
TL* THE CONTACT OWNS A 2003 TOYOTA TUNDRA. THE CONTACT STATED THAT WHILE DRIVING 70 MPH, THE FRONT DRIVER'S SIDE WHEEL BECAME DETACHED FROM THE VEHICLE. THE CONTACT APPLIED THE BRAKES AND BEGAN TO SKID UNTIL THE VEHICLE CAME TO A STOP. THE VEHICLE WAS NOT TAKEN TO THE DEALER FOR INSPECTION AND WAS REPAIRED. THE MANUFACTURER WAS NOTIFIED AND STATED THAT THEY WOULD ASSIST WITH THE COST OF THE FAILED BALL JOINT BUT NOT FOR ANY ADDITIONAL DAMAGES AS A RESULT OF THE FAILURE. THE FAILURE MILEAGE WAS 174,000. UPDATED 5/17/13 *CN
Crash:
No
Fire:
No
Injuries:
0
Deaths:
0
#10502581March 12, 2013
SERVICE BRAKES
TRUCK WAS BEING DRIVEN 250MI FROM DESTINATION A TO B. WHILE ENROUTE, LEAVING THE HIGHWAY FOR A REST STOP, THE BRAKE PEDAL WENT TO THE FLOOR. BRAKE FAILURE, UNABLE TO PROPERLY STOP. HAD TRUCK TOWED TO A LOCAL DEALER WHO IDENTIFIED FAILURE IN (2) FRONT STEEL BRAKE LINES. TOTAL $ 428; AND OF COURSE THE SITUATION COULD HAVE BEEN A LOT WORSE. VEHICLE HAS BEEN MAINTAINED, ALL RECOMMENDED SERVICE INTERVALS, ETC. SERVICE TECH STATED LOOKED TO BE DUE TO RUST - CORROSION. I HAVE NEVER HAD THIS OCCUR ON A VEHICLE THIS LITTLE MI. AND YEARS. I AM GOING TO WRITE TOYOTA AS WELL. *TR
Crash:
No
Fire:
No
Injuries:
0
Deaths:
0
#10496912February 8, 2013
AIR BAGS
AIRBAG LIGHT CAME ON. BROUGHT TO DEALER. DEALER FOUND TWO CODES TRIPPED, B0108 AND B1100. DEALER RESET CODES AND CODES DID NOT RETURN. AFTER OWNER DROVE VEHICLE FOR 5 MILES AND UPON RESTART, THE AIRBAG LIGHT CAME BACK ON. BROUGHT VEHICLE BACK TO THE DEALER WHO FOUND THAT THE SAME CODES HAD TRIPPED. CORRECTED BY DEALER BY REPLACING THE PASSENGER AIRBAG ON/OFF SWITCH AND AIRBAG ECU. PARTS WERE $599.51 AND LABOR WAS $374.50. BACKGROUND: THE PASSENGER AIRBAG SWITCH WAS NEVER USED (TURNED OFF) BY OWNER (ORIGINAL OWNER). OWNER (AN ENGINEER) SUSPECTS THAT A SHORT ORIGINATED IN THE SWITCH ASSEMBLY OR ASSOCIATED HARNESS WHICH DAMAGED THE ECU. OWNER DID NOT ABUSE THE VEHICLE AND DROVE MOSTLY ON THE HIGHWAY. FIRST VEHICLE THAT OWNER HAS EVER HAD AN AIRBAG ISSUE. *TR
Crash:
No
Fire:
No
Injuries:
0
Deaths:
0
#10491021January 4, 2013
STRUCTURE:BODY
TL* THE CONTACT OWNS A 2003 TOYOTA TUNDRA. THE VEHICLE WAS INCLUDED AND REPAIRED UNDER NHTSA CAMPAIGN ID NUMBER: 09V444000 (STRUCTURE: FRAME AND MEMBERS:UNDERBODY SHIELDS). AFTER THE REPAIRS WHILE THE CONTACT WAS DRIVING APPROXIMATELY 45 MPH, HE NOTICED THAT THE FRONT DRIVER'S SIDE OF THE VEHICLE WAS UNBALANCED. THE VEHICLE WAS TAKEN TO AN INDEPENDENT MECHANIC FOR DIAGNOSTIC TESTING. THE TECHNICIAN ADVISED THAT THE RINGS AROUND THE STRUT HAD BECOME CORRODED, CAUSING THE SPRING TO DETACH FROM THE VEHICLE. THE VEHICLE WAS REPAIRED. THE CONTACT LATER DISCOVERED THAT THE FUEL FILTER BRACKET, REAR DIFFERENTIAL SEALS AND THE FRONT RACK WERE ALSO CORRODED. THE VEHICLE WAS NOT FURTHER REPAIRED. THE APPROXIMATE FAILURE MILEAGE WAS 60,000.
Crash:
No
Fire:
No
Injuries:
0
Deaths:
0
#10489486December 21, 2012
STRUCTURE:BODY
TL* THE CONTACT OWNS A 2003 TOYOTA TUNDRA. THE CONTACT NOTICED DAMAGE TO THE FRAME. THE VEHICLE WAS TAKEN TO AN AUTHORIZED DEALER AND REPAIRED UNDER A RECALL ASSOCIATED WITH NHTSA CAMPAIGN ID NUMBER 09V444000 (STRUCTURE: FRAME AND MEMBERS:UNDERBODY SHIELDS). IN CONJUNCTION TO THE REMEDY REPAIR THE BRAKE CALIPERS WERE A REQUIRED REPLACEMENT WHICH WAS NOT MENTIONED IN THE RECALL; HOWEVER, THEY WERE REPLACED AT THE OWNER'S EXPENSE. THE MANUFACTURER WAS NOTIFIED AND OFFERED TO REIMBURSEMENT FOR THE PARTS AND PARTIAL LABOR COST. THE FAILURE MILEAGE WAS 154,000. UPDATED 06/18/13*LJ THE CONSUMER STATED AFTER BEING REFUNDED FOR THE REPAIRS OF THE CALIPERS, ON 1/31/13, RUST WAS FOUND ON THE NEW FRAME. UPDATED 06/24/2013 *JS
Crash:
No
Fire:
No
Injuries:
0
Deaths:
0
#10489143December 18, 2012
POWER TRAIN
TL* THE CONTACT OWNS A 2003 TOYOTA TUNDRA. THE CONTACT STATED THAT WHILE DRIVING 30 MPH, HE SWITCHED FROM FOUR WHEEL DRIVE TO TWO WHEEL DRIVE AND THE ENTIRE FRONT END OF THE VEHICLE ABRUPTLY AND VIOLENTLY SEIZED. THE VEHICLE WAS TAKEN TO THE DEALER FOR DIAGNOSIS AND THE ENTIRE FRONT DIFFERENTIAL WAS REPLACED. THE MANUFACTURER WAS NOT NOTIFIED. THE VEHICLE WAS REPAIRED. THE FAILURE MILEAGE WAS 120,00 AND THE CURRENT MILEAGE WAS 125,000. ... UPDATED 02/27/13 *BF
Crash:
No
Fire:
No
Injuries:
0
Deaths:
0
#10483681November 8, 2012
STRUCTURE:FRAME AND MEMBERS:UNDERBODY SHIELDS, SERVICE BRAKES, FUEL/PROPULSION SYSTEM, POWER TRAIN
TOOK 2003 TOYOTA TUNDRA IN FOR FRAME RUST CORROSION PROGRAM 09V-444000. WAS TOLD FRAME AND OTHER COMPONENTS HAD EXTENSIVE RUST AND MULTIPLE 10MM HOLES BY LEAD SERVICE TECHNICIAN AT LOCAL TOYOTA DEALERSHIP. SERVICE MANAGER EXPLAINED THAT MY 2003 TOYOTA TUNDRA FRAME WAS EXTENSIVELY RUSTED AND UNSAFE TO BE ON THE ROAD AND THEY WANTED TO TAKE MY TRUCK IMMEDIATELY AND PROVIDE A RENTAL CAR DUE TO SAFETY CONCERNS. ASKED FOR A PLAN OF ACTION OF THE SCOPE OF WORK TO BE PERFORMED (CORROSION COMPOUND VERSES FRAME REPLACEMENT) BEFORE GIVING POSSESSION OF VEHICLE. PHOTOS OF 2003 TOYOTA TUNDRA FRAME, REAR CROSS MEMBERS, SPARE TIRE CARRIER, REAR BRAKE LINES & FUEL TANK MOUNTING SYSTEM WERE TAKEN AND SENT TO LEAD SERVICE TECH THREE STATES AWAY IN TEXAS. WAS INFORMED EXTENSIVE FRAME RUST EXISTS ON ALL COMPONENTS (FRAME, REAR CROSS MEMBERS, SPARE TIRE CARRIER, REAR BRAKE LINES & FUEL TANK MOUNTING SYSTEM) BUT IT IS NOT COVERED BECAUSE VEHICLE IS NO LONGER REGISTERED IN WISCONSIN. PURCHASED THIS 2003 TOYOTA CERTIFIED VEHICLE IN WISCONSIN IN APRIL OF 2010 AND NO INFORMATION WAS GIVEN TO ME AT REGARDING THE NHTSA INVESTIGATION OR ANY RUST INSPECTIONS THAT WERE PERFORMED. TOYOTA CORPORATION REFUSES TO REPAIR, REPLACE OR ADD CORROSION RESISTANT COMPOUND TO ANY SEVERELY AFFECTED RUSTED COMPONENTS. SIGNIFICANT RUST ISSUES EXIST ON THIS VEHICLE AND STILL TOYOTA CORPORATION REFUSES TO PROVIDE ANY DOCUMENTATION OF THEIR INSPECTIONS. TOYOTA CORPORATION WILL NOT PUT IN WRITING THAT THE FRAME, REAR CROSS MEMBERS, SPARE TIRE CARRIER, REAR BRAKE LINES & FUEL TANK MOUNTING SYSTEM IS SAFE OR ROAD WORTHY. DEADLINE FOR ALL RUST REPAIRS IS DECEMBER 31, 2012. TOYOTA CORPORATION IS STALLING CONSUMERS TO KEEP FROM DOING ANY REPAIRS AND LEAVING UNSAFE RUSTED 2003 TOYOTA TUNDRA'S ON THE HIGHWAYS. PLEASE INITIATE A NEW NHTSA INVESTIGATION REGARDING THIS MATTER FOR THE SAFETY OF CONSUMERS. *TR
Crash:
No
Fire:
No
Injuries:
0
Deaths:
0
#10482610October 30, 2012
POWER TRAIN, STEERING
FOR THE THIRD TIME SINCE I HAVE OWNED THE VEHICLE WHERE THE SHIFT CONTROL GOES INTO THE STEERING COLUMN, WHERE IT CONNECTS HAS BROKEN. THIS IS A PIECE OF METAL THAT HAS AGAIN SNAPPED MAKING IT UNABLE TO SHIFT THE CAR. WHAT HAPPENS IF I WAS IN DRIVE AND COULD NOT SHIFT INTO PARK? I HAVE HAD THIS FIXED TWICE BEFORE, ONCE WHEN I WAS STUCK ON THE ROAD AND ONCE TOWED TO TOYOTA. *TR
Crash:
No
Fire:
No
Injuries:
0
Deaths:
0
#10481375October 22, 2012
STRUCTURE:BODY
TL* THE CONTACT OWNS A 2003 TOYOTA TUNDRA. THE CONTACT STATED THERE WAS A RECALL ASSOCIATED WITH NHTSA CAMPAIGN ID NUMBER 09V444000 (STRUCTURE: FRAME AND MEMBERS: UNDERBODY SHIELDS). THE CONTACT STATED THAT THE PARTS CONTINUED TO REMAIN ON A MASSIVE BACK ORDER FOR OVER A YEAR. THE DEALER WAS UNCERTAIN WHEN THE PARTS WOULD BECOME AVAILABLE. THE CONTACT HAD CONCERN OF THE SAFETY DEFFECT MENTIONED IN THE RECALL. THE MANUFACTURER WAS NOT NOTIFIED OF THE PROBLEM. THE CONTACT HAD NOT EXPERIENCED FAILURE AT THIS TIME.
Crash:
No
Fire:
No
Injuries:
0
Deaths:
0
#10481702October 18, 2012
AIR BAGS, ELECTRICAL SYSTEM:WIRING
2003 TOYOTA TUNDRA. CONSUMER STATES PROBLEM WITH VEHICLE AIR BAGS *TGW THE CONSUMER STATED IN SEPTEMBER, THE AIR BAG LIGHT STARTED BLINKING. HE TOOK THE VEHICLE TO THE DEALER, WHERE THEY SUPPOSEDLY FIXED THE PROBLEM AT A COST OF $ 177.12. HOWEVER, THAT SAME EVENING, THE LIGHT STARTED BLINKING AGAIN. HE TOOK THE VEHICLE BACK TO THE DEALER THE NEXT MORNING. THE DEALER STATED THE PROBLEM WAS WITH THE WIRING HARNESS AND THE COST TO REPAIR IT, WOULD BE ANYWHERE FROM $ 2,506.00- $ 3,177.76 PLUS $ 975 FOR LABOR. *JB
Crash:
No
Fire:
No
Injuries:
0
Deaths:
0
#10471426August 19, 2012
STRUCTURE:FRAME AND MEMBERS:UNDERBODY SHIELDS, FUEL/PROPULSION SYSTEM
MY TOYOTA HAD A FRAME RECALL FOR RUSTING WHICH THEY FIXED. NOW I'M BEING TOLD MY GAS TANK IS RUSTING AND NEEDS TO BE REPLACED. TOYOTA WILL FIX IT FOR 1500. 00 DOLLARS I BELIEVE THIS IS A SAFETY PROBLEM AND IS A TOYOTA PROBLEM. *TR
Crash:
No
Fire:
No
Injuries:
0
Deaths:
0
#10469684August 8, 2012
EXTERIOR LIGHTING
THE VEHICLE'S THIRD BRAKE LIGHT ASSEMBLY HAS MELTED HOLES ALL THE WAY THROUGH THE INTERNAL PLASTIC STRUCTURE ABOVE THE BOTH CARGO LAMP BULBS. AFTER INVESTIGATING THIS PROBLEM ON THE INTERNET IT IS APPARENTLY VERY COMMON PROBLEM. THERE ARE ALSO PREVIOUS COMPLAINTS FILED WITH THE U.S. DEPARTMENT OF TRANSPORTATION, ADDRESSING THE SAME ISSUE. MY CONCERN IS OF FIRE AND/OR FAILURE OF THE THIRD BRAKE LIGHT. THIS IS A SAFETY PROBLEM THAT TOYOTA HAS NOT ADDRESSED. *TR
Crash:
No
Fire:
No
Injuries:
0
Deaths:
0
#10466388July 18, 2012
STRUCTURE:FRAME AND MEMBERS:UNDERBODY SHIELDS
TL* THE CONTACT OWNS A 2003 TOYOTA TUNDRA. THE CONTACT STATED THAT THE VEHICLE WAS TAKEN FOR STATE INSPECTION AND THE CONTACT WAS TOLD THERE WAS SEVERE RUST ON THE FRAME. THE CONTACT REFERENCED NHTSA CAMPAIGN ID NUMBER:09V444000(STRUCTURE: FRAME AND MEMBERS: UNDERBODY SHIELDS) AND SPOKE WITH THE MANUFACTURER BUT WAS TOLD THAT THE RECALL HAD EXPIRED. THE FAILURE AND THE CURRENT MILEAGES WERE 47,000. UPDATED 08/28/12*LJ
Crash:
No
Fire:
No
Injuries:
0
Deaths:
0
#10461402June 13, 2012
STRUCTURE:BODY
RECEIVED THE RECALL NOTICE, BROUGHT VEHICLE TO LOCAL DEALER WHICH STATED THERE WAS NO CORROSION, DEALER DID NOT SPRAY UNDER CARRIAGE. FAMILY MEMBER ALSO OWNS THIS TRUCK AND STATED THAT HIS WAS SPRAYED AND THEN SUBSEQUENTLY ERODED AND REPLACED. I WILL BE CALLING THE DEALER TOMORROW FOR REEVALUATION AS THE FUEL FILLER MAY BE ERODED OR CRACKED. *TR
Crash:
No
Fire:
No
Injuries:
0
Deaths:
0

← Back to Toyota Tundra