Toyota Tundra Complaints (2005)

377 consumer complaints on file.

#10672044January 13, 2015
ENGINE
TOYOTA HAS EXTENDED ITS WARRANTY FOR THE AIR INJECTION PUMP AND AIR SWITCHING VALVES ON 2007-2010 TUNDRAS. THE EXTENSION IS FOR 10 YEARS OR 150,000 MILES FROM FIRST USE. I HAVE A 2005 TUNDRA THAT HAS A FAILING AIR INJECTION SYSTEM. I AM WITHIN THE MILEAGE RANGE OF FIRST USE . THE TRUCK HAS THE SAME AIR INJECTION SYSTEM AS THE TUNDRAS WITHIN THE WARRANTY EXTENSION, BUT TOYOTA REFUSES TO HONOR THE WARRANTY EXTENSION ON MY TRUCK. THIS IS A $4000 FIX AND THE TRUCK IS UNSAFE TO DRIVE IN THE CURRENT STATE. *TR
Crash:
No
Fire:
No
Injuries:
0
Deaths:
0
#10670792January 7, 2015
SERVICE BRAKES
I PULLED MY TRUCK OUT OF THE GARAGE (IT WAS BACKED IN) AND WHEN I APPROACHED THE STREET APPLIED THE BRAKES. THE BRAKE PEDAL WENT TO THE FLOOR AND THE TRUCK BARELY STOPPED BEFORE ENTERING THE STREET. (DRIVEWAY WAS LUCKILY ON FLAT TERRAIN) I CHECKED THE BRAKE RESERVOIR AND IT WAS ALMOST EMPTY. FILLED UP RESERVOIR, PUMPED BRAKES TO GET STIFF PEDAL AND CHECKED FOR LEAKS. COULD FIND NONE SO DROVE TRUCK ON ABOUT 5 MILE ROUNDTRIP. PULLED TRUCK OUT THE NEXT DAY AND RESERVOIR WAS AGAIN EMPTY BUT COULD FIND NO FLUID ON CONCRETE IN GARAGE. FILLED RESERVOIR & BROUGHT TO MY MECHANIC. HE FOUND THAT THE BOOSTER PUMP WAS LEAKING INTO THE MASTER CYLINDER WHICH WAS WHY THERE WAS NOT FLUID ON THE CONCRETE. HE HAD TO REPLACE THE ENTIRE UNIT SINCE TOYOTA DOES NOT SELL THE COMPONENTS SEPARATELY. THIS COULD HAVE BEEN DISASTROUS UNDER DIFFERENT CIRCUMSTANCES. THE BRAKES HAD WORKED PERFECTLY FINE THE PREVIOUS TIME THE TRUCK WAS DRIVEN. IN FACT IT WAS DRIVEN OVER 250 MILES ON A HUNTING TRIP THROUGH ROADS THAT RAN ALONG CLIFFS. IF THE BRAKES HAD SUDDENLY FAILED JUST 4 DAYS EARLIER, SOMEONE COULD HAVE DIED. *TR
Crash:
No
Fire:
No
Injuries:
0
Deaths:
0
#10670515January 6, 2015
FUEL/PROPULSION SYSTEM
I BOUGHT MY TRUCK NEW AND HAD EVERY SCHEDULED MAINTENANCE PERFORMED. THE SECONDARY AIR INJECTION SYSTEM HAS FAILED AND THE TRUCK IS IN LIMP MODE AND WILL NOT DRIVE OR PASS EMISSIONS. I HAVE BEEN TOLD THE REPAIR IS AROUND 3500 AND THE DEALER NOR TOYOTA CORPORATION WILL TAKE RESPONSIBILITY FOR THE FAULTY PART. EVEN THOUGH THEY KNOW IT HAS BEEN A PROBLEM FOR YEARS AND THEY EXTENDED THE WARRANTY ON 2007 THRU 2010 MODELS WHICH USE THE SAME PARTS. I AM TRYING TO TAKE LEGAL ACTION TO GET SOME RESOLUTION.
Crash:
No
Fire:
No
Injuries:
0
Deaths:
0
#10669133December 30, 2014
FUEL/PROPULSION SYSTEM
I NOTICED A GAS LEAK UNDER THE VEHICLE. TECHNICIAN TOLD ME IT IS DANGEROUS TO DRIVE THE VEHICLE WITH GAS LEAK. DEALER REFUSES TO REPAIR IT AS HE CLAIMS THAT IT IS NOT MANUFACTURER'S DEFECT. *JS
Crash:
No
Fire:
No
Injuries:
0
Deaths:
0
#10664851December 17, 2014
AIR BAGS
TL* THE CONTACT OWNS A 2005 TOYOTA TUNDRA. THE CONTACT RECEIVED A NOTIFICATION OF NHTSA CAMPAIGN NUMBER: 14V350000 (AIR BAGS) HOWEVER, THE PART NEEDED TO DO THE RECALL REPAIR WAS UNAVAILABLE. THE CONTACT STATED THAT THE MANUFACTURER EXCEEDED A REASONABLE AMOUNT OF TIME FOR THE RECALL REPAIR. THE MANUFACTURER WAS MADE AWARE OF THE ISSUE. THE CONTACT HAD NOT EXPERIENCED A FAILURE. UPDATED 1/21/15*CN UPDATED 01/26/15*JB
Crash:
No
Fire:
No
Injuries:
0
Deaths:
0
#10664241December 15, 2014
ELECTRICAL SYSTEM
TOYOTA HAS EXTENDED ITS WARRANTY FOR THE AIR INJECTION PUMP AND AIR SWITCHING VALVES ON 2007-2010 TUNDRAS. THE EXTENSION IS FOR 10 YEARS OR 150,000 MILES FROM FIRST USE. I HAVE A 2005 TUNDRA THAT HAS A FAILING AIR INJECTION SYSTEM. I AM WITHIN 10 YEARS OF FIRST USE. THE TRUCK HAS THE SAME AIR INJECTION SYSTEM AS THE TUNDRAS WITHIN THE WARRANTY EXTENSION, BUT TOYOTA REFUSES TO HONOR THE WARRANTY EXTENSION ON MY TRUCK. THIS IS A $4000 FIX AND THE TRUCK IS UNSAFE TO DRIVE IN THE CURRENT STATE. *TR
Crash:
No
Fire:
No
Injuries:
0
Deaths:
0
#10664127December 14, 2014
ELECTRICAL SYSTEM
I HAD A CHECK ENGINE LIGHT THAT CAME ON WHICH, AFTER CHECKED BY A COMPUTER, WAS DETERMINED TO BE PART NUMBER 1445 (P1445). I RESEARCHED IT OUT AND DISCOVERED THAT THIS IS A COMMON PROBLEM WITH THE TOYOTA TUNDRA 2005 MODELS, YET TOYOTA WOULD NOT COVER THE COST NOR DID THEY CARE UNLESS I WAS WILLING TO PAY FOR IT. P1445 IS FOR THE SECONDARY AIR INJECTION SYSTEM VALVE #2 STUCK CLOSED. IS THERE ANY WAY I CAN BE REIMBURSED BY TOYOTA FOR HAVING TO PAY FOR THE REPLACEMENT OF A PART THAT MANY HAVE HAD THE SAME PROBLEM WITH? THIS IS CLEARLY A FAULTY PART PUT INTO THE 2005 TOYOTA TUNDRAS AND TOYOTA SHOULD BE REQUIRED TO PAY FOR IT'S REPLACEMENT. *TR
Crash:
No
Fire:
No
Injuries:
0
Deaths:
0
#10663357December 10, 2014
AIR BAGS
TL* THE CONTACT OWNS A 2005 TOYOTA TUNDRA. THE CONTACT RECEIVED A NOTIFICATION OF NHTSA CAMPAIGN NUMBER: 14V350000 (AIR BAGS). HOWEVER, THE PART NEEDED TO DO THE REPAIR WAS UNAVAILABLE. THE CONTACT STATED THAT THE MANUFACTURER EXCEEDED A REASONABLE AMOUNT OF TIME FOR THE RECALL REPAIR. THE MANUFACTURER WAS MADE AWARE OF THE ISSUE. THE CONTACT HAD NOT EXPERIENCED A FAILURE.
Crash:
No
Fire:
No
Injuries:
0
Deaths:
0
#10663379December 10, 2014
STRUCTURE:FRAME AND MEMBERS:UNDERBODY SHIELDS, SERVICE BRAKES
TL* THE CONTACT OWNS A 2005 TOYOTA TUNDRA. THE CONTACT STATED THAT THE SERVICE BRAKE LIGHT ILLUMINATED ON THE INSTRUMENT PANEL. THE CONTACT CHECKED THE FLUID LEVEL AND NOTICED THAT THE BRAKE FLUID WAS NEARLY DEPLETED. THE CONTACT REPLENISHED THE FLUID AND THE LIGHT DIMMED. WHEN THE BRAKE PEDAL WAS DEPRESSED, IT SANK TO THE FLOORBOARD. THE VEHICLE WAS TAKEN TO AN INDEPENDENT MECHANIC FOR DIAGNOSTIC TESTING. THE TECHNICIAN DIAGNOSED THAT THE ENTIRE UNDER CARRIAGE WAS EXCESSIVELY CORRODED AND THE BRAKE LINES FRACTURED. THE MANUFACTURER AND DEALER WERE MADE AWARE OF THE FAILURE. THE VEHICLE WAS NOT REPAIRED. THE FAILURE MILEAGE WAS 36,121. UPDATED 01/20/15*LJ UPDATED 01/10/15. *JB UPDATED 02/05/15*JB UPDATED 03/10/15*LJ UPDATED 06/17/2015 *JS
Crash:
No
Fire:
No
Injuries:
0
Deaths:
0
#10662022December 3, 2014
SERVICE BRAKES
BRAKE FLUID LOW-TOYOTA SERVICE CENTER SAID MASTER CYLINDER WAS LEAKING ONTO VACUUM PACK THUS BOTH HAD TO BE REPLACED, AN EXTREMELY EXPENSIVE REPAIR THAT SHOULD NOT BE NECESSARY ON A LOW-MILEAGE VEHICLE. *JS
Crash:
No
Fire:
No
Injuries:
0
Deaths:
0
#10660889November 25, 2014
AIR BAGS
TL* THE CONTACT OWNS A 2005 TOYOTA TUNDRA. THE CONTACT STATED THAT NHTSA CAMPAIGN NUMBER: 14V655000 (AIR BAGS) EXCEEDED A REASONABLE AMOUNT OF TIME FOR REPAIR. THE DEALER STATED THAT THE PARTS WERE NOT AVAILABLE FOR REPAIR. THE MANUFACTURER WAS NOT MADE AWARE OF THE DELAY. THE VEHICLE WAS NOT REPAIRED. THE CONTACT HAD NOT EXPERIENCED THE FAILURE.
Crash:
No
Fire:
No
Injuries:
0
Deaths:
0
#10659751November 20, 2014
ELECTRICAL SYSTEM
TL* THE CONTACT OWNS A 2005 TOYOTA TUNDRA. THE CONTACT INDICATED THAT BURNING WIRES FUMES EMITTED FROM THE FRONT OF THE VEHICLE. THE CONTACT STATED THAT THE FAILURE HAD OCCURRED BEFORE AND THE HEAT FROM THE FIRE PREVENTED HIM FROM LIFTING THE HOOD LATCH. AFTER INSPECTING THE VEHICLE, THE CONTACT NOTICED THE FIRE WAS BURNING ON THE FLOOR OF THE FRONT DRIVERS SIDE. THE VEHICLE WAS DESTROYED. THE CONTACT DID NOT SUSTAIN ANY INJURIES AND WAS ABLE TO EXIT THE VEHICLE. THE VEHICLE WAS TO BE FURTHER INSPECTED AND DIAGNOSED BY THE MANUFACTURER. THE MANUFACTURER WAS NOTIFIED OF THE FAILURE. THE APPROXIMATE FAILURE MILEAGE WAS 100,000.
Crash:
No
Fire:
Yes
Injuries:
0
Deaths:
0
#10653225November 6, 2014
AIR BAGS
TRUCK RAN INTO ANOTHER VEHICLE, AIR BAGS DID NOT WORK TO PROTECT THE DRIVER...UPDATED 12/03/14 *BF UPDATED 9/14/2015*JS
Crash:
Yes
Fire:
No
Injuries:
0
Deaths:
0
#10645006October 16, 2014
UNKNOWN OR OTHER
COLD START OF VEHICLE, VERY LARGE NOISE, LASTED ABOUT 1 MINUTE. ONLY DOES THIS WHEN COLD START. IF VEHICLE HAS BEEN DRIVEN NO SOUND. RESEARCH INDICATE, THAT OTHER PROBLEMS NOTED ON THE INTERNET WERE THE AIR INJECTION PUMP, AND SWITCHING VALUES, HAS FOAM THAT HAS DETERIORATED AND FELL DOWN ON THE DC MOTOR AND BURNED THE MOTOR OUT. SEEMS THE MANUFACTURE KNOWS OF THE PROBLEM BUT HAS ONLY CERTAIN MODEL YEARS THEY ARE COVERING. SAME PART IN ALL YEARS BUT NOT COVERING 2005 WHICH IS THE MODEL YEAR OF MY TRUCK. IF SAME PART IS ON DIFFERENT MODEL YEARS THEY SHOULD COVER ALL MODEL YEARS THAT HAVE THIS PART AS IT SEEMS THIS IS A VERY EXPENSIVE REPAIR. THIS IS A REQUIREMENT TO UTILIZED TO IMPROVE COLD-START EMISSIONS, WHICH IS MANDATED REQUIREMENT. TOYOTA'S CUSTOMERS HAVE A CUSTOMER SUPPORT PROGRAM TO EXTEND THE WARRANTY SHOULD BE WITH ALL MODEL YEARS THAT HAVE THIS PART. I HAVE AS OF YESTERDAY TAKEN MY TRUCK TO THE DEALERSHIP AS I AM PRETTY SURE THIS IS THE PROBLEM. DIAGNOSIS SHOULD BE FORTH COMING. MANY COMPLAINTS ON INTERNET FOR THIS SAME MODEL YEAR AND PROBLEM. *TR
Crash:
No
Fire:
No
Injuries:
0
Deaths:
0
#10644257October 13, 2014
STRUCTURE
FACTORY DEFECT, PART OF DASHBOARD MELTING/STICKY. *TR
Crash:
No
Fire:
No
Injuries:
0
Deaths:
0
#10640438October 1, 2014
POWER TRAIN, SUSPENSION, STRUCTURE:FRAME AND MEMBERS:UNDERBODY SHIELDS
WE RECEIVED SEVERAL RECALL NOTICES FOR FRAME DETERIORATION AND THE NEED FOR INSPECTION, CORRECTION AND ANTI-CORROSION CHEMICAL APPLICATION. WE TOOK IT TO THE TOYOTA DEALER AS REQUESTED. THEY CALLED THE NEXT MORNING TO HAVE US PICK UP THE VEHICLE AND THE ANTI-CORROSION SPRAY (BLACK GOOEY STUFF SIMILAR TO UNDERCOATING) THAT THEY USED WAS EVERYWHERE, INCLUDING ON THE WIRING HARNESSES, BRAKE LINES, THE STEP BARS THAT WE INSTALLED AFTERMARKET LAST YEAR, INSIDE OF THE WHEEL WELLS, THE MUD FLAPS - IT WAS STILL WET AND SMELLED AWFUL. WE CONTACTED THE SERVICE MANAGER WHO BLEW US OFF, WE CALLED TOYOTA AND THEY REFUSED TO ASSIST, OTHER THAN TO TAKE DOWN THE COMPLAINT ON PAPER. I CAN'T SEEM TO FIND AN ATTORNEY EVEN REMOTELY INTERESTED IN ASSISTING WITH THIS CASE. TOYOTA SAYS THAT THE COATING MAY NEVER DRY SO IT WILL ATTRACT ALL DIRT AND GRIME THAT IT'S EXPOSED TO. IT LOOKS AND SMELLS HORRIBLE. WE CAN'T EVEN SELL IT BECAUSE IT SMELLS SO BAD! TOYOTA WON'T REMOVE IT OR EVEN REPAIR IT, NOR WILL THEY REPLACE THE VEHICLE. *TR
Crash:
No
Fire:
No
Injuries:
0
Deaths:
0
#10630572September 4, 2014
STEERING
FOR A WEEK I HAD NOTICED A LEAK ON THE SURFACE OF THE PARKING LOT OF MY APARTMENT BUILDING WHERE I ALMOST ALWAYS PARK MY TRUCK. SINCE IT'S AN APARTMENT, I DIDN'T PAY MUCH ATTENTION TO IT, THINKING IT WAS SOMEONE ELSE'S VEHICLE. THEN ON SUNDAY AUGUST 31ST, I HAD DRIVEN ROUND TRIP TO AKRON, OHIO AND BACK TO WILLOUGHBY, OHIO AND NOTICED A HUGE LEAK. I TOOK IT TO THE DEALER WHO SAID IT WAS THE POWER STEERING AND THAT THERE ARE TWO OF THE PARTS THAT NEED TO BE REPLACED. I RESEARCHED THIS PROBLEM AND FOUND THEY HAVE RUSTED AND LEAKED ON OTHER TUNDRA'S OF THE SAME YEAR AS MINE. *TR
Crash:
No
Fire:
No
Injuries:
0
Deaths:
0
#10628402August 26, 2014
AIR BAGS
TL* THE CONTACT OWNS A 2005 TOYOTA TUNDRA. THE CONTACT STATED WHILE DRIVING APPROXIMATELY 1 MPH, THE SIDE CURTAIN AIRBAGS DEPLOYED WITHOUT WARNING. THE VEHICLE WAS TOWED TO THE DEALER FOR DIAGNOSIS. THE TECHNICIAN WAS UNABLE TO DIAGNOSE THE FAILURE. THE VEHICLE HAS NOT BEEN REPAIRED. THE MANUFACTURER WAS NOTIFIED OF THE FAILURE. THE APPROXIMATE FAILURE MILEAGE WAS 91,302.
Crash:
No
Fire:
No
Injuries:
0
Deaths:
0
#10626298August 19, 2014
ENGINE AND ENGINE COOLING
TL* THE CONTACT OWNS A 2005 TOYOTA TUNDRA. IMMEDIATELY AFTER STARTING THE VEHICLE, AIR BEGAN LEAKING FROM THE AIR INJECTION SYSTEM AND THE CHECK ENGINE WARNING INDICATOR ILLUMINATED. THE FAILURE OCCURRED MULTIPLE TIMES. AN INDEPENDENT MECHANIC STATED THAT THE AIR INJECTION SYSTEM NEEDED TO BE REPLACED. THE VEHICLE WAS NOT REPAIRED AND THE MANUFACTURER WAS NOT NOTIFIED. THE APPROXIMATE FAILURE MILEAGE WAS 126,000.
Crash:
No
Fire:
No
Injuries:
0
Deaths:
0
#10625702August 16, 2014
TIRES
I HAVE MULTI MILE WILD COUNTRY TIRES INSTALLED ON MY TRUCK WHICH ARE ONLY A FEW MONTHS AND A FEW THOUSAND MILES OLD. TWO OF THE TIRES HAVE SIDEWALL SEPARATION CRACKS AND ONE IS LEAKING AIR THROUGH THE CRACK. THEY ARE: SIZE 265/70R16 DOT# U9C2 T93 3213. *TR
Crash:
No
Fire:
No
Injuries:
0
Deaths:
0

← Back to Toyota Tundra