Toyota Prius Complaints (2014)

223 consumer complaints on file.

#11619899October 15, 2024
SERVICE BRAKES
My 2014 prius experienced a failing brake booster actuator assembly. I was driving when suddenly my traction control light came on and my brake pedal turned mushy. I pulled over to a parking lot and put my vehicle in park. As soon as I did this, the ABS and parking brake light both turned on. I had the vehicle towed to the Toyota dealership. They diagnosed the problem as an internal leak in the brake booster actuator assembly. This is a common problem with these vehicles, but instead of Toyota issuing a recall, they only did an extended warranty coverage of which my prius didn't fit the parameters. Now I am stuck with a vehicle that is unsafe to drive and a repair estimate of $3,900 because of one of their parts failing. This should clearly have been made a recall with the volume of prius owners experiencing this problem. What a disappointment after having 3 Toyotas for many years.
Crash:
No
Fire:
No
Injuries:
0
Deaths:
0
#11619508October 12, 2024
SERVICE BRAKES
On [XXX] my brakes failed while driving, (brake booster and actuator) moving at 25 mph, all of a sudden lights ABS and brakes indicator light started flashing and beep. I was approaching a yellow light and attempting to slow down, my foot went to to floor and the were NO BRAKES. I used the EMG brake slow down me pulled into an empty parking lot. My vehicle is available for inspection at request. My safety was was put at risk due to having no control and coming very close to crashing into another car putting that driver at risks as well, but was blessed I was able to avoid an accident. This problem has been confirmed by Phillips Toyota in Leesburg FL #(352)728-3020. The vehicle components have not been inspected by others besides the dealer. I am 2 months over the 10yr customer support program at 102k miles. I have been complaining for the past YEAR to the dealer regarding strange noises like chirping, air deflating when pressing brakes, constant buzzing sounds from system even when car is off, and being propelled forward when going over gravel or railroad track surfaces of the ABS light goes on. This is on record and each time I’d ask, they’d mention it is the brake booster going but because there was no indicator lights or code coming up, they were unable to do anything. My last service in may 2024, I requested a diagnostic on the brake system, which I paid extra for, knowing the 10yr program was about to be expired in July. The dealer found no codes and assured me it was safe to drive and that if I were to see those warning light come on, that I was to drive the car straight to the dealer to inspect. Well, long story short, the lights came on, and immediately the were NO Brakes and I was completely out of control with no time to drive it safely to the dealer. I had it towed to the dealer and they quoted me $3000 to repair brake booster/actuator. I am working with Toyota corporate for compensation. This is a major safety issue that should be a RECALL! INFORMATION REDACTED PURSUANT TO THE FREEDOM OF INFORMATION
Crash:
No
Fire:
No
Injuries:
0
Deaths:
0
#11619377October 11, 2024
SERVICE BRAKES
The braking system is failing with the following codes I tested with the BlueDriver scanner. Code TypeCodeDescription ABS CodesC1241Low or high power supply coltage ABS CodesC1391Abnormal leak in accumulator Main BodyB1206P/W Master SW ECU Communication Stop Main BodyB2321D-Door Motor ECU Communication Stop Main BodyB2430LED Headlight LH Entry and StartU0142Mainbody Ecu Communication Circuit Entry and StartU0155Lost Communication with Instrument Panel Cluster Control Module The car is available for inspection. This puts the drivers, myself and fiance, at risk of catastrophic collision in the event that the brakes fail while driving. I will call Toyota to obtain a replacement of the system that has occurred with many other drivers. The vehicle has not been inspected by manufacturer yet but it is important to know that this is a serious problem that could kill people. The problem was identified when warning lights came up on the dashboard but there is also a sound coming from the brake actuator that shows a problem. The problem is due to manufacturer error, I have driven the vehicle normally.
Crash:
No
Fire:
No
Injuries:
0
Deaths:
0
#11617482October 1, 2024
SERVICE BRAKES
So my wife is pulling into our driveway with my little ones and notices the ABS, traction control and Brake light come on. I then had the vehicle looked at by a local Toyota dealership and they tell me I'm getting code C1391 and that it's a known issue. They then tell me I'm out of my extended customer support warranty time frame and I will have to pay. According to NHTSA this is a known defect on this vehicle and it affects more than 100k Toyota Prius vehicles. So basically, we've been driving around in a vehicle that the brakes may fail at any moment and potentially kill us all but is only addressed by the manufacturer when the known failure occurs. Even then, they only address it if the error occurs during their set time frame. It seems this has been brought to NHTSA's attention on a few occasions and nothing has been done. I would think brakes are something that warrants a recall on a known defect. Thankfully my wife and kids weren't doing 70mph down the highway when the brakes all of the sudden stopped working.
Crash:
No
Fire:
No
Injuries:
0
Deaths:
0
#11616706September 26, 2024
SERVICE BRAKES, HYDRAULIC:FOUNDATION COMPONENTS:MASTER CYLINDER
The contact owns a 2014 Toyota Prius. The contact stated while driving at an undisclosed speed, the brake pedal was depressed with several unknown warning lights illuminated. The vehicle was towed to the dealer to be diagnosed. The contact was informed that the brake master cylinder and the brake booster pump assembly had failed and needed to be replaced. The manufacturer was not made aware of the failure. The failure mileage was approximately 82,000.
Crash:
No
Fire:
No
Injuries:
0
Deaths:
0
#11614051September 11, 2024
SERVICE BRAKES
This vehicle lost braking assist while in motion on a well known problem from TOYOTA. There has been class action lawsuits on this very fact. Toyota issued a customer service warranty for vehicles that have less than 150,000 and filed before March 2024! My car has 127k and failure was Sept 9 out of the warranty. I understand that there is a line if the sand however this needs to be a recall as it effects so many vehicles and it is dangerous! I am asking you urge them to make a recall for this! I have paid for this repair and am furious but I had to do it!
Crash:
No
Fire:
No
Injuries:
0
Deaths:
0
#11612147September 2, 2024
SERVICE BRAKES
ABS actuator failed in April of 2023 after more than a year of constant whirling, which my mechanic didn't diagnose until after my dashboard lit up with errors. The issue was diagnosed by AAA mechanics after the dashboard warning lights lit up, with a $4,000 cost to repair. Brakes are spongy, car is rarely driven at this time. We were told that the brakes would continue to work, but the ABS system would not. Now the vehicle beeps constantly when driving, which appears to mean the brakes could fully fail at any time. Based on subsequent research, Toyota was quietly fixing the ABS acuator issue until last year, but it was not offered when my vehicle was brought in last year during another recall. When it failed the car was under 10 years and 150K.
Crash:
No
Fire:
No
Injuries:
0
Deaths:
0
#11609232August 18, 2024
SERVICE BRAKES
My car started exhibiting signs of a known brake booster/brake systems failure for Priuses in the 2010-2015 range. These include the ABS, brake system, and skid/traction lights coming on and a 3-5 cycling whirring noise. The brake sensitivity is also altered. This happened suddenly today. I checked the battery voltage (normal), so this is not causing the issue. After investigating online, I have discovered that many consumers have experienced the same issue and are being denied a recall/repair coverage by Toyota. Today, I am reaching out to Toyota to see if the replacement/repair, which should be in the range of $3-4k will be covered by Toyota. According to numerous other Prius owners online, this issue is being denied by Toyota for coverage, even though it is something they are fully aware of. This is unacceptable and dangerous on their part. My vehicle has 110k miles, was leased used last year, and has not had any issues otherwise. I am up to date with all routine maintenance, including getting my pads replaced and rotors maintained last year as well as new tires.
Crash:
No
Fire:
No
Injuries:
0
Deaths:
0
#11608304August 13, 2024
SERVICE BRAKES
Brake warning lights illuminated and loud beeping for the first time. Took the car to local repair shop who advised me to take it to the dealership. Dealership indicates that R&R Brake Booster assembly with master cylinder and brake booster pump assembly need to be replaced at over $3100 and brakes are at risk of failure. I researched and found the NHTSA Customer Support Bulletin - [XXX] indicating this known issue. The support period expired in March and mileage has now exceeded the limit for support. Though I have had the car in the dealership for service many times, this was never brought to my attention. The dealership advised me to contact Toyota. Toyota then advised me to contact NHTSA about the problem. Further research indicates ongoing problems with this issue that have not been resolved - [XXX] should have issued a recall for this important safety issue. INFORMATION REDACTED PURSUANT TO THE FREEDOM OF INFORMATION ACT (FOIA), 5 U.S.C. 552(B)(6)
Crash:
No
Fire:
No
Injuries:
0
Deaths:
0
#11607559August 9, 2024
SERVICE BRAKES
Brake Booster Assembly in my 2014 Toyota Prius began cycling more often than usual in December 2023. By March 2024 it began cycling approximately every 30 seconds. Randomly while stopped or parked, there would be four warning lights illuminated on the dash - SLIP indicator, both Brake System Warning Lights - the word "Brake" and the "((!))", and ABS Warning Light. By June 2024, I would also randomly lose stopping power & a great distance was necessary to stop the vehicle. I took the Prius into my local Toyota Service Center where it was recommended both the Brake Booster Pump and Brake Booster Actuator be replaced. When I brought up Toyota's Customer Support Program for which my Prius is eligible in terms of age, mileage, and symptoms, I was told a DTC is required to verify the issue. According to this local Toyota dealership, the Master Tech confirming the issue and recommending replacement is not sufficient. Since the lights were illuminated, I asked why there was no stored DTC. They responded "Well, I'm not sure" and continued to reference the required DTC. This brake assembly is an issue that Toyota has acknowledged, but fails to accept full responsibility by issuing a recall. This gross negligence by a vehicle manufacturer.
Crash:
No
Fire:
No
Injuries:
0
Deaths:
0
#11607341August 8, 2024
SERVICE BRAKES, HYDRAULIC
The contact owns a 2014 Toyota Prius. The contact stated that while driving at an undisclosed speed and attempting to stop the vehicle, the brake pedal was stiff and would not depress easily, requiring exhaustive effort to depress and bring the vehicle to a complete stop. The brake, traction control, and ABS warning lights were illuminated. The vehicle was taken to the dealer, who diagnosed a brake booster and brake pump assembly failure. The vehicle was repaired. The manufacturer was notified of the failure and referred the contact to the NHTSA Hotline for assistance. The failure mileage was 116,000. The VIN was not available.
Crash:
No
Fire:
No
Injuries:
0
Deaths:
0
#11606273August 3, 2024
SERVICE BRAKES
I lost the brakes. The Brake actuator failed. I was able to swerve around traffic to avoid a collision and get the car towed home. No warning lamps until it failed. The brake actuator was replaced and I saved the old, defective component.
Crash:
No
Fire:
No
Injuries:
0
Deaths:
0
#11604167July 23, 2024
SERVICE BRAKES
Complete failure of ABS system. Error code C1391. This is a well-known problem with Gen 2 and 3 Priuses.
Crash:
No
Fire:
No
Injuries:
0
Deaths:
0
#11602995July 17, 2024
SERVICE BRAKES, HYDRAULIC, TRACTION CONTROL SYSTEM
The contact owns a 2014 Toyota Prius Plug-In Hybrid. The contact stated while driving at various speeds and attempting to depress the brake pedal, the brake pedal was very stiff. The contact stated that the ABS, brake lights, and traction control warning lights were illuminated. The vehicle was taken to an independent mechanic, who diagnosed a failure with the brake power booster and brake power gasket. The vehicle was not repaired. The manufacturer was made aware of the failure and referred the contact to the NHTSA Hotline for assistance. The failure mileage was approximately 167,000.
Crash:
No
Fire:
No
Injuries:
0
Deaths:
0
#11596246June 24, 2024
SERVICE BRAKES
The brake booster and master cylinder failed on my Prius. The diagnostic code is C1391 Abnormal leakage in accumulator, which is a code covered by Toyota’s prior recall on this vehicle.
Crash:
No
Fire:
No
Injuries:
0
Deaths:
0
#11591042May 28, 2024
SERVICE BRAKES
Drove car to work one morning and it was VERY difficult to brake almost causing an accident. Brought it into the Toyota shop and they said this code came up: DTC code C1391: Abnormal leak of accumulator pressure ,recommending to replace brake booster and brake booster pump assembly internal malfunction of components.The necessity of its routine replacement is vital as an old or malfunctioning unit leads to decreased braking performance and ultimately brake failure. They told me that there was a program offered to customers where they would replace this known issue, but I'm 2 months outside of this so the issue is no longer covered under Toyota. The fact that this is a known issue that Toyota does not want to recall is ridiculous and now they want customers to pay for it.
Crash:
No
Fire:
No
Injuries:
0
Deaths:
0
#11589472May 18, 2024
ENGINE, UNKNOWN OR OTHER
2014 Toyota Prius: While driving at high speed the engine stalled unexpectedly, steering and braking were not effected. Was able to safely coast to a stop in the breakdown lane and after a few minutes, restart the engine and proceed driving. Another event occurred on the entrance ramp onto an interstate highway. I was able to pull over safely and the car restarted after a short delay. This seems to be a very dangerous condition. Toyota dealer service said they could not determine the cause and they know of no recall. I found online a reference to NHTSA Recall # 20V369000 that referred to "unexpected hybrid power system shut down." That is what happened to me.
Crash:
No
Fire:
No
Injuries:
0
Deaths:
0
#11586612May 2, 2024
SERVICE BRAKES
Noticed a whirring/hydraulic sound that occurred every 5-10 seconds. Could only hear sound if no music was playing and not driving at highway speeds. Sound was noticeable upon parking or exiting vehicle. Only noticed sound because it occurred more frequently than usual. Spouse who is hard of hearing could not hear sound at all. My understanding of sound was that it was normal for vehicle, however, within the time span of approximately 2 weeks, sound became more frequent. Researched noise, and found it was the brake booster assembly pressurizing. Took vehicle to dealership to have it confirmed. Per dealership "Accumulator inside brake booster has internal leak causing accumulator to constantly run." Brakes did not show signs of loss of function and there was no indicator lights on dash to warn me of problem with vehicle. When I inquired with dealership of how much longer they would last, they informed me they could not say, and that it was likely they could go out at any time. Called Toyota Customer support to see if they could provide any assistance. They stated a support program had been issued back in 2021, but is now expired. According to support program 21TE01, Toyota was willing to replace brake boosters that had already failed and could be confirmed with diagnostic code. However, as the part had not failed or showed signs of failure at that time, vehicle would not have qualified, and it was prior to current ownership. Owners should not have to wait for their brakes to fail in order to recognize they have an issue. If I had not heard the noise and brought it in BEFORE an accident occurred, it could have been very dangerous indeed. Now I am left to pay $2500 out of pocket for repair of a faulty/failing brake booster assembly.
Crash:
No
Fire:
No
Injuries:
0
Deaths:
0
#11585686April 28, 2024
SERVICE BRAKES
We were on the interstate when suddenly our cruise control stopped working. We then noticed several lights on the dashboard lit up, related to traction control, brakes, and ABS system. We could still use the car brakes, but it took more pressure than usual to engage the brakes. We pulled over to an auto parts store, but they stated there were no ODB codes logged. After researching online, I suspected a brake booster failure as described in Toyota's Customer Support Bulletin ZJB. At my earliest convenience, I brought the car in to a Toyota dealership, who confirmed that the brake booster and master cylinder were failing and needed to be replaced. Thankfully, the brakes did not fail outright, but the situation could have ended much worse. I understand by reading online that this is not an isolated incident. I encourage this issue be more thoroughly investigated so that a proper recall can be issued if needed, to bring this to the attention of other drivers of affected vehicles.
Crash:
No
Fire:
No
Injuries:
0
Deaths:
0
#11576759March 12, 2024
UNKNOWN OR OTHER
Error code P0A94 Inverter/converter came and message to pull over. 9 yr 6 months.103365 miles. Toyota has this issue but never did a recall on my vehicle.
Crash:
No
Fire:
No
Injuries:
0
Deaths:
0

← Back to Toyota Prius