ON CERTAIN VEHICLES, VARIATIONS IN THE MANUFACTURING PROCESS OR EXPOSURE TO HIGH AMBIENT TEMPERATURES MAY LEAD TO FRACTURE OF THE FUEL TANK INLET CHECK VALVE (ICV).
CERTAIN DELPHI FUEL PRESSURE REGULATORS, P/NOS. FP10020-11B1, FP10026-11B1, AND FP10027-11B1, SOLD AFTER JANUARY 9, 2007, AS AFTERMARKET EQUIPMENT FOR VARIOUS PASSENGER VEHICLES LISTED ABOVE. THE UNIVERSAL PRESSURE REGULATORS (UPR) WERE PRODUCED WITHOUT AN O'RING AND RETAINER.
ON CERTAIN SPORT UTILITY VEHICLES, CONTAMINATION ON IGNITION RELAY CONTACTS CAN CAUSE HIGH RESISTANCE. THIS CAN AFFECT SIGNALS TO THE POWERTRAIN CONTROL MODULE AND, COULD CAUSE INTERMITTENT VEHICLE STALLS AT ANY TIME.
ON CERTAIN PASSENGER VEHICLES, A WELD BETWEEN THE FUEL TANK INLET CHECK VALVE AND THE FUEL TANK CAN FAIL.
I HAVE BEEN SMELLING GAS FROM MY CAR FOR YEARS BUT JUST NEVER HAD THE MONEY TO GET IT LOOKED AT. I EVEN CALLED ABOUT RECALLS CONCERNING THE FUEL SYSTEM THAT I FOUND OUT ABOUT THROUGH RESEARCH IN 2015 BUT WAS TOLD THEY HAD BEEN CLOSED SO I WOULD BE CHARGED FOR THE REPAIRS EVEN IF IT WAS PREVIOUSLY COVERED UNDER RECALL. I NO LONGER FILL MY TANK WITH GAS BECAUSE THERE IS A LEAK. I JUST GOT MY CAR BACK FROM THE DEALERSHIP, THEY STATE THAT I NEED A NEW FUEL TANK, AND FUEL LEVER SENSOR AND SENDER. ALSO, HAVE OIL LEAKS IN 2 PLACES, THEY TELL ME I NEED UPPER & LOWER INTAKE GASKETS. AS WELL AS VALVE COVER GASKETS & OIL PUMP DRIVE O-RING REPLACED AND OIL PAN GASKET REPLACED. ALSO, NEEDS WATER PUMP AND DRIVE BELT REPLACED.I ALSO FOR THE PAST 3 OR SO YEARS HAVE TO KEEP A PEN OR PENCIL IN MY CAR TO INSERT UNDER THE STEERING WHEEL TO RELEASE MY KEY .
No injuries · No fire · No crash
FUEL TANK IS LEAKING; THERE IS A HISTORY OF A RECALL THAT HAS NEVER BEEN REPAIRED ON THIS VEHICLE. IT IS A SAFETY ISSUE.
No injuries · No fire · No crash
TL* THE CONTACT OWNS A 2004 PONTIAC AZTEC. THE CONTACT STATED THAT WHILE DRIVING 20 MPH CRASHED INTO A GMC ENVOY AND FLIPPED OVER LANDING ON THE ROOF. THE CONTACT STATED THAT THE AIR BAGS FAILED TO DEPLOY. THERE WERE NO WARNING LIGHTS ILLUMINATED PRIOR TO THE FAILURE. A POLICE REPORT WAS FILED. THE SEAT BELT FAILED TO UNLOCK AS THE CONTACT WAS CUT FROM THE VEHICLE. THE CONTACT STRUCK THE STEERING WHEEL, WAS UNCONSCIOUS, AND SUSTAINED INJURIES TO THE EYE WHICH REQUIRED MEDICAL ATTENTION. THE VEHICLE WAS TOWED TO AN INDEPENDENT LOT. THE OCCUPANT OF THE GMC HAD NO REPORTED INJURIES. THE LOCAL DEALER WAS NOT CONTACTED. THE MANUFACTURER WAS CONTACTED BUT NO FURTHER ASSISTANCE WAS PROVIDED. THE FAILURE MILEAGE WAS 171,000. *DT CONSUMER STATED SHE HAS LOST HER EYE SIGHT DUE TO AIRBAG FAILURE.*JB*DT*JB
TL* THE CONTACT OWNS A 2004 PONTIAC AZTEK. WHILE DRIVING 35 MPH, THE CONTACT ATTEMPTED TO STOP THE VEHICLE AND THE BRAKE PEDAL TRAVELED TO THE FLOORBOARD. THE VEHICLE FINALLY STOPPED BEFORE REACHING AN INTERSECTION. THE CONTACT NOTICED THAT BRAKE FLUID WAS LEAKING AND THE BRAKE HOSES WERE FRACTURED. THERE WERE NO WARNING INDICATORS ILLUMINATED. THE VEHICLE WAS TAKEN TO A LOCAL MECHANIC WHO DIAGNOSED THAT THE BRAKE SYSTEM WAS FRACTURED. THE BRAKES AND HOSES WERE REPAIRED. THE MANUFACTURER WAS NOTIFIED AND DID NOT ASSIST. THE DEALER WAS NOT NOTIFIED. THE FAILURE MILEAGE WAS 95,000.. *BF CONSUMER STATED POWERSTEERING HIGH PRESSURE RUPTURED DUE TO RUST. THE DAY THE BRAKE LINES WERE GETTING REPAIRED CONSUMER WAS TOLD FUEL LINE FROM THE PUMP TO THE INJECTORS WAS ALSO RUSTED AND WOULD LEAK ANYTIME. *JB
No injuries · No fire · No crash
MY CAR TURN OFF ON MY CHILDREN AND I ON THE HIGHWAY THANK GOD WE WAS ABLE TO COAST ON THE SIDE OF THE ROAD. MY MECHANIC SAID THAT MY IGNITION CONTROL MODULE WENT OUT OUTTA NO WHERE NOT ONLY THAT CRANKSHAFT SENSOR AND FUEL LINE EXHAUSTED SYSTEM SOMETHING WRONG ENGINE LIGHT STILL ON. WITH THAT BEING SAID I'M GREAT MY CHILDREN WAS NOT HURT DOING THIS ORDEAL. I LEARNED THAT THESE CARS HAVE FEW COMPLAINTS. BUT DO HAVE SOME ISSUES WITH ELECTRICAL SYSTEM AND VACUUM HOW'S EXHAUSTED. JUST GOT THE CAR I MARCH AND FOUND OUT BOUT THIS RECALL I'M SO DISAPPOINTED SCARED TO DRIVE THIS CAR RIGHT NOW.
No injuries · No fire · No crash