Nissan Titan Complaints (2004)

1,046 consumer complaints on file.

#10251062December 8, 2008
POWER TRAIN:DRIVELINE
TL*THE CONTACT OWNS A 2004 NISSAN TITAN. THE CONTACT STATED THAT THE REAR AXLE WAS LEAKING ON THE DRIVER AND PASSENGER WHEELS. CURRENTLY, THE REAR DIFFERENTIAL IS MAKING NOISES. THE DEALER HAS NOT YET BEEN NOTIFIED, ALTHOUGH THE CONTACT HAS FOUND SEVERAL COMPLAINTS PERTAINING TO THE FAILURE. THE FAILURE MILEAGE WAS 56,000 AND CURRENT MILEAGE WAS 57,000.
Crash:
No
Fire:
No
Injuries:
0
Deaths:
0
#10251070December 8, 2008
LATCHES/LOCKS/LINKAGES
2004 NISSAN TITAN SE 4X4 OFF ROAD KING CAB ANYTIME THE WEATHER IS AT OR BELOW 20 DEG F BOTH DOORS FREEZE SHUT. I CANNOT USE THE DOOR HANDLES ON EITHER SIDE OF THE TRUCK TO OPEN THE DOORS. IF I ATTEMPT TO MANUALLY ROLL DOWN THE WINDOW TO OPEN THE DOOR FROM THE INSIDE THE WINDOW IS SOMETIMES FROZEN AS WELL AND WILL NOT MOVE. IN WEATHER AROUND 20-25 DEF F THE DOOR HANDLES WILL SOMETIMES WORK TO OPEN THE DOORS BUT THE HANDLES AND INTERNAL DOOR CABLES WILL NOT MOVE BACK TO THEIR ORIGINAL POSITION TO ALLOW THE DOOR TO CLOSE AND LATCH PROPERLY LEAVING THE DOORS IN AN OPEN STATE. THIS POSSES A SAFETY RISK TO THE OCCUPANTS OF THE VEHICLE IF IT IS DRIVEN IN THIS STATE. THIS OCCURS ANYTIME THE AMBIENT AIR TEMPERATURE REACHES AROUND +20 DEG F NISSAN HAS SO FAR REFUSED TO REPAIR THE PROBLEM UNDER WARRANTY ALTHOUGH A TSB NTB05-118A EXISTS FOR THIS PROBLEM. I HAVE REPLACED ONE EXTERNAL DOOR HANDLE THAT WAS BROKEN AS A RESULT OF EXCESS FORCE BY TRYING TO OPEN A FROZEN DOOR. *TR
Crash:
No
Fire:
No
Injuries:
0
Deaths:
0
#10250493December 2, 2008
POWER TRAIN:DRIVELINE
COMPLETE REAR END FAILURE AT 28,000 MILES. DIFFERENTIAL LOCK LIGHT KEPT COMING ON, DASH UNTIL SPIDER GEARS BROKE. LOUD CLUNKING WHEN MAKING TURNS UNTIL VEHICLE WAS TOTALLY IMMOBILIZED. DEALER REPLACED ENTIRE ASSEMBLY. HOWEVER DIFF LOCK LIGHT COMING ON AGAIN, REAR END IS HAVING PROBLEMS AT 63,000 MILES. *TR
Crash:
No
Fire:
No
Injuries:
0
Deaths:
0
#10250438December 1, 2008
POWER TRAIN:DRIVELINE
2004 NISSAN TITAN, 63,000 MILES. LOUD "WHINING" NOISE COMING FROM THE REAR OF THE VEHICLE. BROUGHT VEHICLE TO DEALERSHIP TO HAVE THEM INVESTIGATE NOISE, FOUND FAULTY REAR DIFFERENTIAL. DEALERSHIP REPLACED REAR END. NOISE IS GONE. ALL COVERED UNDER EXTENDED WARRANTY PLAN. *TR
Crash:
No
Fire:
No
Injuries:
0
Deaths:
0
#10250152November 29, 2008
POWER TRAIN:DRIVELINE
I BROUGHT MY 2004 NISSAN TITAN IN FOR A ROUTINE OIL CHANGE AT 53,157 MILES. THE SERVICE TECH INFORMED ME THAT MY REAR AXEL SEAL WAS LEAKING . DEALER REPLACED SEAL, BEARING, SPACER & SNAP RING. THIS WAS COVERED UNDER A 5 YEAR EXTENDED WARRANTY AND TOOK 6 HRS FOR THE DEALER TO COMPLETE. PARTS: (1) SEAL-OIL R # 43252-7S200 (1) BEARING-RE # 40210-7S210 (1) SPACER AXLE # 43070-7S200 (1) RING-SNAP 01541-0001U. *TR
Crash:
No
Fire:
No
Injuries:
0
Deaths:
0
#10249994November 27, 2008
POWER TRAIN:DRIVELINE
REAR AXLE SEALS LEAKING ALL OVER REAR DISC BRAKES. JUST FOUND OUT DUE TO LACK OF BRAKING POWER. LOOKS TO HAVE BEEN LEAKING FOR A LONG TIME! *TR
Crash:
No
Fire:
No
Injuries:
0
Deaths:
0
#10249837November 25, 2008
LATCHES/LOCKS/LINKAGES
DOOR HANDLE FREEZES(COLD WEATHER) OPEN. THE DOOR CANNOT BE LATCHED SHUT. *TR
Crash:
No
Fire:
No
Injuries:
0
Deaths:
0
#10249855November 25, 2008
POWER TRAIN:AUTOMATIC TRANSMISSION
AUTOMATIC TRANSMISSION FAILED IN 2004 NISSAN TITAN SE, CREW CAB, 4X4, 5.6L V8 AT 76,000 MILES. *TR
Crash:
No
Fire:
No
Injuries:
0
Deaths:
0
#10248682November 13, 2008
ENGINE AND ENGINE COOLING, SUSPENSION
ONLY 65,000 MILES ON MY TRUCK AND NO MODIFICATIONS. RIGHT REAR SEAL LEAKING, PINION SEAL IS SHOT AND FRONT LEFT AXLE NEEDS TO BE REPLACED. NOTHING COVERED UNDER WARRANTY. I AM LOOKING AT A $3,000 REPAIR BILL ON A 4 YEAR OLD TRUCK THAT HAS NEVER BEEN OFF ROAD AND DOESN'T HAVE HIGH MILES. MY EXHAUST MANIFOLD ALSO CRACKED AT ABOUT 60000 MILES. THIS WAS ABLE TO BE REPLACED UNDER WARRANTY. *TR
Crash:
No
Fire:
No
Injuries:
0
Deaths:
0
#10248555November 12, 2008
SERVICE BRAKES, ELECTRIC
BRAKES ON 2004 NISSAN TITAN FAILED WHILE STOPPING AT TRAFFIC LIGHT. JUST PRIOR TO FAILURE, BRAKE LIGHT LIT UP ON DASHBOARD. NISSAN DEALER INFORMED ME THAT THE BRAKES THEMSELVES WERE FINE BUT THAT THE COMPUTER THAT CONTROLS THE BRAKES "LOST ITS PROGRAMMING." I WAS ALSO INFORMED THAT I AM THE 3RD CUSTOMER IN 6 MONTHS TO HAVE THIS EVENT OCCUR TO THEM. TO FIX THE PROBLEM, THE DEALER MUST "REPROGRAM THE VDC SYSTEM." DEALER WAS UNABLE TO TELL ME WHY THIS HAPPENED OR ASSURE ME THAT THE BRAKE FAILURE WILL NOT REOCCUR. I WAS TOLD THAT THIS IS A KNOWN ISSUE AND NISSAN HAS ISSUED A SERVICE BULLETIN REGARDING THIS PROBLEM. THIS PROBLEM COULD HAVE LED TO A CATASTROPIC ACCIDENT HAD THE BRAKES FAILED DURING A CRITICAL TIME. I AM CONCERNED THAT NISSAN HAS A KNOWN BRAKE PROBLEM, BUT THERE IS NO SAFETY RECALL IN PLACE. *TR
Crash:
No
Fire:
No
Injuries:
0
Deaths:
0
#10248326November 10, 2008
POWER TRAIN
CATASTROPHIC FAILURE OF REAR DIFFERENTIAL RING AND PINION ASSY. ORIGINAL OWNER, NO ABUSE. GEARSET SHOWED TOO MUCH GEAR LASH AT AROUND 48,000 MILES, BUT EXHIBITED NO SIGNS OF FAILURE UNTIL 62,000 MILES. NISSAN TITAN WITH E-LOCKER DIFFERENTIAL (OFF ROAD PACKAGE)>. *TR
Crash:
No
Fire:
No
Injuries:
0
Deaths:
0
#10247626November 4, 2008
POWER TRAIN:DRIVELINE
REAR AXLE SEALS FAILED (BOTH SIDES) PART # 43252-7S200. *TR
Crash:
No
Fire:
No
Injuries:
0
Deaths:
0
#10247573November 3, 2008
ENGINE AND ENGINE COOLING:EXHAUST SYSTEM
I HAVE HAD AN ODD EXHAUST SOUND FROM MY NISSAN TITAN FOR OVER 18 MONTHS. WHEN I FINALLY TOOK IT INTO THE DEALER BOTH EXHAUST MANIFOLDS WERE CRACKED AND REPAIRS COST $1400.00. I WAS TOLD A THE DEALER AND AT SEVERAL MUFFLER SHOPS THAT THIS IS A VERY COMMON DEFECT DUE THE CAST NATURE OF THE MANIFOLD AND THE EXCESSIVE WEIGHT OF THE CATALYTIC CONVERTER WELDED ONTO THE MANIFOLD. THE REPLACEMENT PART WERE A NEW DESIGN AND THE DEALER SAID THEY WILL NOT CRACK. SINCE MY TRUCK HAD 105,000 MILES ON IT WHEN THE SERVICE WAS DONE THERE IS NO WARRANTY COVERAGE. I FEEL THAT THIS IS A DESIGN FLAW WITH THE 2004 AND 2005 NISSAN TITAN PICKUPS AND THE COST OF REPAIRS SHOULD BE BORNE BY NISSAN AND NOT BY THE CONSUMER. I AM HOPING THAT THERE WILL BE A CLASS ACTION SUITE FILED ON THE CONSUMER'S BEHALF EITHER BY AN INDIVIDUAL, THE STATE OR THE FEDERAL GOVERNMENT. *TR
Crash:
No
Fire:
No
Injuries:
0
Deaths:
0
#10246844October 27, 2008
SERVICE BRAKES, HYDRAULIC
2004 NISSAN TITAN - REPEATED PROBLEMS WITH FRONT BRAKES. ROTORS, CALIPERS REPLACED OR RESURFACED 5 TIMES. ABS WHEEL SENSORS. CURRENTLY NO EMERGENCY BRAKE - NISSAN STATES NO ADJUSTMENTS TO FIX - ON OCCASSION FRONT BRAKES FAIL TO THE POINT THE TRUCK WILL NOT STOP. THIS HAPPENS WITH OUT WARNING. WHEN IT HAPPENS THE BRAKE PEDDLE GOES TO THE FLOOR AND YOU CAN HEAR AND FEEL THE FRONT BRAKES VIBRATING. I HAVE TO TURN OFF THE TRUCK, WAIT A FEW MINUTES AND IT WILL THEN WORK FINE. THERE IS NO WARNING WHEN THIS OCCURS. BRAKE ISSUES HAS BEEN A MAJOR ISSUE WITH THE TRUCK SINCE THE DAY I PURCHASED. *TR
Crash:
No
Fire:
No
Injuries:
0
Deaths:
0
#10246380October 22, 2008
POWER TRAIN:DRIVELINE
BOTH REAR AXLE SEALS FAILED ALLOWING OIL TO LEAK ON BREAKS. I WILL HAVE TO HAVE THE SEALS REPLACED. *TR
Crash:
No
Fire:
No
Injuries:
0
Deaths:
0
#10246014October 19, 2008
SERVICE BRAKES, HYDRAULIC
IN JULY OF '08, MY WIFE CALLED TO TELL ME SHE WAS HAVING A PROBLEM WITH OUR TRUCK. SHE WAS AFRAID TO DRIVE IT, AS SHE REPORTED A BRAKE FAILURE THAT AND WAS NEARLY IN AN ACCIDENT. SHE WAS EXITING A PARKING LOT TO A BUSY ROAD. AS SHE APPROACHED THE END OF THE PARKING LOT, SHE BRAKED TO WAIT FOR A CLEARING IN TRAFFIC. SHE SAID THE BRAKE PEDAL WENT TO THE FLOOR, THE TRUCK MADE A LOUD RUMBLING NOISE, AND THE TRUCK ROLLED OUT TO THE EDGE OF THE BUSY STREET UNTIL SHE PUMPED THE BRAKE PEDAL AND STOPPED THE TRUCK. SHE LEFT IT THERE AND WAITED FOR ME, AFRAID TO MOVE IT. I INSPECTED THE TRUCK AND FOUND NO MECHANICAL PROBLEMS. I FIGURED THAT THERE WAS A FAULT WITH THE ABS SYSTEM, WHICH WENT AWAY AFTER THE TRUCK WAS TURNED OFF AND THE SYSTEM WAS REBOOTED/SELF TESTED. ON AUGUST 22, 2008, THE FAULT RETURNED. MY WIFE BACKED THE TRUCK OUT OF OUR DRIVEWAY, AND THE TRUCK DISPLAYED THE SAME SYMPTOMS WHEN SHE TRIED TO STOP AT THE BOTTOM OF THE DRIVEWAY. SHE AVOIDED HITTING A PARKED VEHICLE ON THE OTHER SIDE OF THE STREET. SHE LEFT THE ENGINE RUNNING SO AS TO NOT RESET THE ABS COMPUTER, AND CALLED ME OUT TO CHECK THE TRUCK. I COULD FIND NO MECHANICAL FAULT, AND FOUND THE ABS FULLY ENGAGING WHEN PRESSING THE BRAKES, RESULTING IN VERY LITTLE STOPPING POWER. PUMPING THE BRAKES CAUSE NEAR FULL APPLICATION OF BRAKING FORCE, EVEN AT LIGHT PEDAL PRESSURE. I DETERMINED THAT IT WAS AN ABS ISSUE. BOTH TIMES THE FAULT OCCURRED, THE "BRAKE" LIGHT ILLUMINATED. TURNING OFF THE TRUCK AND RESTARTING RESOLVED THE PROBLEM, CONFIRMING MY SUSPICION OF A SOFTWARE FAULT. I SEARCHED ON LINE AND FOUND A NISSAN TSB THAT ADDRESSED THE ISSUE. I BROUGHT THE TRUCK TO DIRITO BROTHERS NISSAN IN CONCORD, CA TO HAVE THE TSB APPLIED, WHICH INVOLVED A ABS SOFTWARE UPDATE. I WAS SURPRISED AND UPSET TO LEARN THAT THE REPAIR WAS NOT COVERED UNDER WARRANTY, AS THE SOFTWARE UPDATE WAS CONSIDERED AN "ADJUSTMENT." I WAS CHARGED $150 FOR THIS SERVICE. THE SERVICE WRITER STATED HE SAW A NUMBER OF TRUCKS WITH THE PROBLEM. *TR
Crash:
No
Fire:
No
Injuries:
0
Deaths:
0
#10245647October 16, 2008
POWER TRAIN:DRIVELINE
REAR AXLE SEALS LEAKING CAUSING READ AXLE AND DIFFERENTIAL TO FAIL. AXLE LUBRICANT CONTAMINATING REAR BRAKES RESULTING IN LOSS OF STOPPING POWER. *TR
Crash:
No
Fire:
No
Injuries:
0
Deaths:
0
#10245567October 15, 2008
SERVICE BRAKES, HYDRAULIC, EQUIPMENT
MY 2004 NISSAN TITAN LEAKS PROFUSELY ONTO BY EMERGENCY BRAKES. MY EMERGENCY BRAKES DO NOT WORK AT ALL ON A HILL. THE NISSAN MECHANIC HAS POINTED THIS OUT TO ME WHILE THE TRUCK WAS UP ON THE RACK. HE STATED THAT THE LEFT REAR AXLE SEAL WAS AND STILL LEAKING. I WOULD HAVE TO REPLACE THE SEAL SPACER AND BEARING, FOR A GRAND TOTAL OF $171.00 FOR PARTS, AND ALMOST $200.00 FOR LABOR. THIS HAS HAPPEN REPEATEDLY ON ALL NISSAN TITAN TRUCKS. THERE SHOULD BE A RECALL ON THIS ITEM. OWNERS SHOULD BE COMPENSATED FOR THEIR EXPENSES ON SUCH A DEFECTIVE PART. *TR
Crash:
No
Fire:
No
Injuries:
0
Deaths:
0
#10244659October 7, 2008
POWER TRAIN
NISSAN TITAN REAR AXLE SEALS LEAK. *TR
Crash:
No
Fire:
No
Injuries:
0
Deaths:
0
#10244351October 3, 2008
SERVICE BRAKES, HYDRAULIC
2004 NISSAN TITAN BRAKE FAILURE/JUDDER NISSAN IS AWARE OF THIS ISSUE AND HAS YET TO ISSUE A RECALL. NISSAN HAS SEVERAL TSB ON THIS ISSUE. THE GOVERNMENT NEEDS TO DEMAND NISSAN RECALL AND REPAIR THE BRAKE SYSTEM OF THESE VEHICLES. *TR
Crash:
No
Fire:
No
Injuries:
0
Deaths:
0

← Back to Nissan Titan