Nissan Titan Complaints (2004)

1,046 consumer complaints on file.

#10352371August 27, 2010
POWER TRAIN:DRIVELINE:DIFFERENTIAL UNIT
I HAVE A 2004 NISSAN TITAN TRUCK. A REAR AXLE SEAL LEAKED. THIS IS THE SECOND TIME I'VE HAD IT LEAK. DIFFERENTIAL GEAR OIL LEAKS, WHICH COULD GET ON THE BRAKES. THE FIRST TIME, I HAD TO REPLACE THE DIFFERENTIAL WHICH ALSO FAILED. I REPLACED THE SEAL AND BEARINGS. THIS WILL BE THE SECOND TIME I WILL BE REPLACING THEM. IF I HAD NOT CHECKED IT WOULD HAVE BEEN A SAFETY ISSUE, AS OIL COULD GET ON THE BRAKES. ALSO, DUE TO NISSAN'S POLICY OF NOT SELLING REAR END PARTS (IN THE DIFFERENTIAL) I HAD TO BUY A WHOLE NEW REAR END THE FIRST TIME. I DID NOT SAVE THE OLD PARTS. *TR
Crash:
No
Fire:
No
Injuries:
0
Deaths:
0
#10351639August 25, 2010
POWER TRAIN
MY NISSAN TITAN CREWS BRAKES WERE NOT PERFORMING WELL ON A TRIP I TOOK. AFTER GETTING HOME I NOTICED OIL ON MY GARAGE FLOOR AT BOTH REAR BRAKES. THE REAR DIFF. WAS LEAKING ALL OVER THE BRAKE BACKING PLATE TO THE EXTENT THAT OIL WAS BEING SLUNG THROUGHOUT THE WHEEL WELL THE REAR AXLE HAS FAILED THE DRIVER SIDE REAR SEAL REQUIRED REPLACEMENT DUE TO EXCESSIVE LEAKAGE WHEN I PARKED THE TRUCK IT HAD MOVED SEVERAL INCHES BACK UNTIL ANOTHER GEAR ENGAGED THE PROBLEM IS NOT DESIGN ITSELF IT IS THE QUALITY OF THE METAL BEING USED FOR THE GEARS I FEEL NISSAN SHOULD BE FORCED TO RECALL THIS POTENTIALLY DANGEROUS MANUFACTURER DEFECT. *TR
Crash:
No
Fire:
No
Injuries:
0
Deaths:
0
#10351823August 25, 2010
POWER TRAIN
I WAS DRIVING IN LOOSE GRAVEL AND I FELT AN UNUSUALLY FEELING IN MY REAR AXEL, SO I DROVE THE VEHICLE SLOWLY HOME NEVER FELT IT UNTIL I ARRIVED TO MY HOME AND THEN I PARKED IT. I THEN CALLED A TRANSMISSION MECHANIC AND HAD THE VEHICLE TOWED TO TRANSMISSION REPAIR SHOP. THE REPAIR SHOP CALLED AND TRIED TO GET REPLACEMENT PARTS FOR MY REAR AXLE AND WHERE UNABLE TO. SO THEY HAD TO GET A HOLE NEW REAR AXLE NOT JUST NEW PARTS BUT A COMPLETELY NEW REAR AXLE. THE NEW REAR AXLE IS COMPLETELY DIFFERENT FROM THE ORIGINAL, WHICH MAKES ME AND THE MECHANIC THAT OWNS THE REPAIR SHOP BELIEVE THAT THE ORIGINAL REAR AXLE WAS FAULTY. OTHER WISE WHY WOULDN'T THE REAR END BE THE SAME AND BE ABLE TO GET REPLACEMENT PARTS FOR THE OLD REAR AXLE LIKE YOU CAN WITH MOST VEHICLES. *TR
Crash:
No
Fire:
No
Injuries:
0
Deaths:
0
#10351566August 24, 2010
SERVICE BRAKES, HYDRAULIC
I WAS PULLING OUT OF PARKING LOT AT LOW SPEED AND THE BRAKE PEDAL FELL TO THE FLOOR AND I HEARD A GRINDING/CLICKING NOISE. THE TRUCK WAS ALMOST UNABLE TO STOP BEFORE ONCOMING TRAFFIC. I PULLED BACK INTO THE PARKING LOT AND INSPECTED THE BRAKE ASSEMBLIES AND MADE SURE THERE WAS FLUID IN THE MASTER CYLINDER RESERVOIR. I CYCLED THE IGNITION SYSTEM A FEW TIMES AND STARTED BACK UP. THE PROBLEM WENT AWAY FOR THE TIME BEING. *TR
Crash:
No
Fire:
No
Injuries:
0
Deaths:
0
#10351190August 22, 2010
SERVICE BRAKES, HYDRAULIC, ELECTRONIC STABILITY CONTROL (ESC)
WHILE DRIVING APPLIED BRAKES , BRAKE PEDAL WENT TO FLOOR AND METAL TO METAL SOUND HEARD IN FRONT END BRAKES, I STOPPED NOTICED BRAKE WARNING LIGHT ON . I TURNED VEHICLE OFF AND RESTARTED .THE BRAKE WARNING LIGHT WENT OFF AND BRAKE PEDAL WENT TO WORKING NORMAL . THIS SITUATION HAS HAPPENED AT LEAST 5 TIMES IN THE LAST MONTH. THERE HAVE BEEN NUMEROUS REPORTS INVOLVING THIS SAME SITUATION AND IT SHOULD BE ADDRESSED BY NISSAN BEFORE SOMEONE IS INJURED ARE KILLED. I HAVE MADE APPOINTMENT WITH NISSAN DEALER. VEHICLE MILEAGE IS 40,000. *TR
Crash:
No
Fire:
No
Injuries:
0
Deaths:
0
#10350196August 17, 2010
POWER TRAIN
THE EVENTS LEADING UP TO MY FRONT END AXLE FAILURE WAS DUE TO SLIGHT USE OF THE 4WD IN MILD SNOW CONDITIONS THE FIRST TIME. I HAD IT REPAIRED BY A FACTORY NISSAN AUTHORIZED DEALER AND HAD THE SAME PROBLEM OCCUR LESS THAN 30,000 MILES LATER. NISSAN IS SAYING ITS NOT THEIR FAULT BUT I WAS NOT ABUSING THE 4WD SIMPLY JUST USING IT. BASICALLY THE FRONT LEFT AXLE BREAKS A CLIP AND THE AXLE SHAFT GOING INTO THE DIFFERENTIAL SLIDES DOWN. OVER TIME UNNOTICED I'M SURE THIS COULD BE DETRIMENTAL TO THE FRONT END COMPONENTS UNTIL A CATASTROPHIC STEERING/WHEEL FAILURE. I WILL BE TRYING TO CONTACT NISSAN TO GET THEIR STORY OF WHY THIS KEEPS OCCURRING. *TR
Crash:
No
Fire:
No
Injuries:
0
Deaths:
0
#10349747August 16, 2010
SUSPENSION:REAR
WHILE LOADING TRUCK FOR A VACATION TRIP, I NOTICED A LARGE BULGE COMING UP THROUGH THE TRUCK BED IN THE LEFT REAR PORTION. UPON FURTHER INSPECTION, THE LEFT REAR SHACKLE HOLDING HOLDING THE LEAF SPRING TO THE FRAME SNAPPED IN HALF. THE TRUCK IS A GARAGE KEPT, 35,000 MILE LIMITED PERSONAL USE VEHICLE. IF I HAD NOT BEEN GOING AWAY, THE SPRING WOULD HAVE PUSHED ITS WAY THROUGH THE BED. *TR
Crash:
No
Fire:
No
Injuries:
0
Deaths:
0
#10347910August 7, 2010
PARKING BRAKE, SERVICE BRAKES, HYDRAULIC
I HAVE A NISSAN TITAN 2004 THAT I HAD FOR 3 YEARS. THE FIRST COUPLE OF MONTHS EVERYTHING WAS FINE, BUT THEN MY BRAKES WOULD MAKE THIS WEIRD SOUND WHEN I PRESSED THE GAS AND THE BRAKE LIGHT WOULD COME ON. I COULD NOT HIT THE BRAKES ALL THE WAY BECAUSE IT WOULD FEEL LIKE IF THEY WERE LOCK.. I HAD TO STOP IN THE MIDDLE OF THE ROAD AND TURN OFF THE TRUCK AND TURN ON AGAIN ,AND THE PROBLEM WOULD FIX IT SELF. AFTER A COUPLE OF TIMES THAT IT KEPT DOING THAT , I DECIDED TO TAKE TO THE DEALER AND THEY TOLD ME THAT THE SENSOR LIGHT NEEDED TO BE RESTED AND THAT THE PROBLEM SHOULD BE SOLVE. A COUPLE AMONTHS LATER IT'S STARTED DRIVING IT AGAIN. IT WOULD MAYBE HAPPENS EVERY OTHER MONTH . I USED TO ALWAYS TAKE THE TRUCK TO GET MY OIL CHANGE AT THE NISSAN DEALER SHOP AND SINCE THE DOS COURTESY CHECK THEY TOLD ME THAT MY CV AXLES NEEDED SOME WORK DONE BECAUSE SOMETHING WAS WRONG WITH THEM. OF COURSE THEY WANTED TO CHARGE ME A LOT, SO I HAD TO SAY NO. NOW I HAVE A TRUCK THAT NEEDS TO HAVE WORK DONE AND VERY EXPENSIVE. NOW I CAN SEE OIL LEAKAGE AT THE WHEEL BEARING. MY TRUCK DID NOT PASSED INSPECTION THIS YEAR BECAUSE OF THAT PROBLEM, SO REGISTER MY TRUCK AT ANOTHER CITY AND IT PASSED CUZ THEY WERE NOT CHECKING THOSE THINGS. I HAVE HEARD AND READ COUPLE OF THE SAME ISSUES THAT PEOPLE ARE HAVING WITH THE BACK CV AXLE SEALS AND BEARINGS. WHY WOULD I BE SPENDING MONEY ON SOMETHING THAT I WOULD LEAST EXPECTED. I WOULD LIKE TO SEE IF THIS ISSUE BE INVESTIGATED. I GOT 2 KIDS UNDER THE AGE OF 3 AND I'M VERY CONCERN ON THEIR SAFETY. IF NISSAN IS RESPONSIBLE FOR THIS , THEY NEED TO TAKE ACTION IMMEDIATELY. *TR
Crash:
No
Fire:
No
Injuries:
0
Deaths:
0
#10347515August 5, 2010
ELECTRICAL SYSTEM
MY 2004 NISSAN TITAN CAUGHT FIRE AND BURNED TO THE GROUND ON 7/29/10 AT 4:30PM. IT ALL STARTED AS I WAS BACKING UP AND I NOTICED AN ELECTRICAL BURNING SMELL. I LOOKED DOWN AND SAW SMOKE AND INSPECTED IT CLOSER AND NOTICED THAT THE SMOKE WAS BLOOMING FROM AN ELECTRICAL COMPONENT WHICH APPEARED TO BE THE COMPUTER. I TOOK SOME VIDEO OF IT AS PROOF OF WHAT WAS GOING ON NOT KNOWING THAT MY TRUCK WOULD BE ENGULFED IN FLAMES MINUTES LATER. THE VIDEO IS CLEAR THAT IT WAS MANUFACTURER DEFECT. I TRIED TO STOP IT BY DISCONNECTING THE BATTERY BUT THAT WAS NOT SUCCESSFUL. LATER MY FIRE INSPECTOR SAID IT WAS NISSANS BCM THAT FAILED! HE WAS VERY HAPPY HAD THE VIDEO OTHERWISE HE WOULD HAVE NEVER BEEN ABLE TO IDENTIFY. HE SAID THE VIDEO IS REALLY CLEAR AND APPARENT WHAT HAPPENED. NISSAN NEVER RECALLED JUST SENT SERVICE BULLETINS. MY INSURANCE MAY COVER THE REMAINDER OF THE LOAN BUT THAT DOES NOT PUT ME ANOTHER VEHICLE. I HAVE CONTACTED NISSAN ON THIS MATTER AND THEY SAY THERE IS NOTHING THEY CAN DO TO LET MY INSURANCE DEAL WITH IT, WHICH I EXPLAINED ABOVE HOW THAT DOES NOT WORK FOR ME. I FEEL LIKE THIS IS NISSANS FAULT AND THEY SHOULD HELP ME BUT THEY ARE NOT. APPARENTLY I NEED TO HIRE AN ATTORNEY THAT DEALS WITH FIRE AND I HAVE BEEN INFORMED THAT THIS IS VERY EXPENSIVE, WHICH I CAN NOT AFFORD. I TOLD NISSAN I HAD THE VIDEO BUT THEY DID NOT CARE. YOU WOULD THINK AFTER ALL THE TOYOTA INCIDENTS THAT THEY MAY HELP ESPECIALLY SINCE I HAD THE VIDEO OF PROOF AND THEY DID NOT . I HAVE SENT THE VIDEO AND ALL PICTURES I HAVE TO MY INSURANCE COMPANY AS WELL BUT ALL THEY WILL PROBABLY GET IS THE MONEY THEY PAID FOR LOAN. SO MY INSURANCE COMPANY IS COVERED BUT I'M LEFT OUT TO DRY. PLEASE READ THIS PART. THE FIRE INSPECTOR FOR MY INSURANCE COMPANY AND AN OUTSIDE INDEPENDENT FIRE INSPECTOR HAVE CONCLUDED IT WAS THE BCM ( BODY CONTROL MODULE). NISSAN KNEW OF THE PROBLEM BUT JUST SENT OUT SERVICE LETTERS AND NOT RECALLS. MY INSURANCE WILL BE PURSUING NISSAN AS WELL ! *TR
Crash:
No
Fire:
Yes
Injuries:
0
Deaths:
0
#10347012August 3, 2010
SERVICE BRAKES, HYDRAULIC:FOUNDATION COMPONENTS:DISC:ROTOR
TL* THE CONTACT OWNS A 2004 NISSAN TITAN. THE CONTACT STATED WHEN THE BRAKES WERE APPLIED, THE VEHICLE WOULD VIOLENTLY SHAKE. THE VEHICLE WAS TAKEN TO AN AUTHORIZED DEALER WHERE THE CONTACT WAS INFORMED THAT THE ROTORS WERE OUT OF ROUND. THE BRAKE PADS WERE REPLACED AND THE ROTORS WERE RESURFACED UNDER WARRANTY. THE FAILURE RECURRED A FEW MORE TIMES AND THE MANUFACTURER ISSUED AND UNKNOWN BRAKE RECALL. THE VEHICLE WAS REPAIRED UNDER THE RECALL BUT THE FAILURE CONTINUED TO RECUR. HE STATED THE VEHICLE WAS TAKEN TO THE DEALER APPROXIMATELY SEVEN TIMES FOR THE BRAKE FAILURE WHERE THE ROTORS WOULD BE RESURFACED. THE FAILURE CONTINUED TO RECUR. THE FAILURE MILEAGE WAS 3,000 AND THE CURRENT MILEAGE WAS 49,000.
Crash:
No
Fire:
No
Injuries:
0
Deaths:
0
#10347023August 3, 2010
POWER TRAIN
2004 NISSAN TITAN 67000 MILES, DRIVING ON REGULAR ROAD IN GOOD REPAIR, REAR DIFFERENTIAL STARTING MAKING NOISE. NEXT DAY, DIFFERENTIAL LOCKED UP. INSPECTION SHOWED BROKEN TEETH ON RING AND PINION GEARS. *TR
Crash:
No
Fire:
No
Injuries:
0
Deaths:
0
#10346630August 1, 2010
ENGINE AND ENGINE COOLING:ENGINE
DRIVING 70 MPH ON INTERSTATE WITH CRUISE CONTROL ON, ENGINE JUST STOPPED. COASTED TO SIDE OF ROAD. NISSAN DEALER DIAGNOSED PROBLEM AS FAILED IPDM (INTERGRATED POWER DISTRIBUTION MODULE). NEW PART SEEMS TO HAVE SOLVED THE PROBLEM. DEALERS MECHANIC SAID THE FACTORY TOLD HIM THEY HAD EXPERIENCED PROBLEMS WITH THESE PARTS. IT'S VERY UNNERVING TO HAVE THE ENGINE SHUT OFF ON A BUSY 6 LANE HIGHWAY. VEHICLE IS A 2004 NISSAN TITAN. *TR
Crash:
No
Fire:
No
Injuries:
0
Deaths:
0
#10343443July 15, 2010
POWER TRAIN:DRIVELINE, POWER TRAIN
REAR AXLE SEALS BEGAN TO LEAK AT 75000 MILES. VEHICLE HAS BEEN DRIVEN ON HIGHWAY AT ALL TIMES. THE NISSAN DEALER NOTICE THE LEAK DURING AN INSPECTION. NUMEROUS FORUMS HAVE COMPLAINTS OF THE AXLE SEALS FAILING DUE TO IMPROPER VENTING. LEAKAGE OF GEAR OIL ONTO REAR BRAKES PRESENTS A SAFETY HAZARD TO MY FAMILY. REQUEST NISSAN REPLACE AXLE SEALS AND DO A RECALL TO REENGINEER A NEW VENTING SYSTEM FOR AXLE SEALS. *TR
Crash:
No
Fire:
No
Injuries:
0
Deaths:
0
#10341661July 6, 2010
POWER TRAIN:DRIVELINE
PASSENGER REAR AXLE SEAL FLUID LEAK ONTO REAR BRAKES. *TR
Crash:
No
Fire:
No
Injuries:
0
Deaths:
0
#10341420July 5, 2010
POWER TRAIN:DRIVELINE
NISSAN TITAN 2004 4X4SE REAR DIFFERENTIAL WENT BAD AND NEEDS REPAIR.WAS REPAIRED FOR AXLE LEAK ABOUT 3 YEARS AGO BY DEALER AND REPLACED DIFFERENTIAL COVER AND FLUID BUT AM NOW OUT OF WARRANTY. THIS IS A WELL KNOWN PROBLEM IN JUST ABOUT ALL YEAR TITANS WHETHER THEY ARE 2 OR 4 WHEEL DRIVE. *TR
Crash:
No
Fire:
No
Injuries:
0
Deaths:
0
#10340765June 30, 2010
POWER TRAIN:DRIVELINE
THE REAR AXLE SEALS (BOTH) ON MY 2004 STARTED LEAKING AT 56,000 MILES. THE LEAK OCCURRED AT 5 YEARS AND 4 MONTHS SO THE DEALER DENIED ANY WARRANTY RESPONSIBILITY. THIS VEHICLE IS USED FOR MOSTLY FOR LOCAL TRIPS WITH OCCASIONAL TRAILER TOWING THAT IS WELL WITHIN THE DESIGN LIMITS AS ADVERTISED BY THE MANUFACTURER. IN REPLACING THE SEALS IT WAS NOTED THAT THEY APPEAR TO SPIN IN THE AXLE HOUSING THUS WEARING OFF THE OUTER SEALING SURFACE. IT APPEARS THAT THE ONLY PROVISION TO PREVENT THIS IS THE CLAMPING ACTION OF THE BEARING RETAINER THAT SANDWICHES THE SEAL BETWEEN IT AND THE BEARING WHICH IS THEN FORCED AGAINST A SHOULDER IN THE AXLE HOUSING. PREVIOUS DESIGNS OF THIS AXLE, AS USED BY OTHER MANUFACTURERS, PRESSED THE SEAL INTO THE RETAINER AND THEN SEALED THE RETAINER TO THE HOUSING WITH A GASKET. LEAKS SUCH AS I EXPERIENCED WERE ALMOST NON-EXISTENT. WHILE THE LEAK IS MOSTLY ANNOYING, IT DOES HAVE THE POTENTIAL TO CONTAMINATE THE BRAKES THUS IMPAIRING THE STOPPING ABILITY OF THE VEHICLE. *TR
Crash:
No
Fire:
No
Injuries:
0
Deaths:
0
#10340600June 29, 2010
SERVICE BRAKES, HYDRAULIC
THE BRAKES ON MY 2004 NISSAN TITAN HAVE BEEN REPLACED 3 TIMES IN THE LAST 1.5 YEARS. NISSAN ADMITS THERE IS A PROBLEM, AND PROVIDED AN UPGRADE KIT THE CONSUMERS HAVE TO PAY FOR. I HAVE THE UPGRADE KIT THE LAST 3 TIMES THE BRAKES WERE CHANGED, AND THEY STILL GO BAD. THIS MORNING WITHOUT WARNING THE CALIPER DOVE IN THE ROTOR, AND I NEARLY WENT' THRU AN INTERSECTION. SOMETHING NEEDS TO BE DONE ABOUT THESE VEHICLE NOW. THERE ARE THOUSANDS OF COMPLAINTS ABOUT THE BRAKES ON THESE TRUCKS. WHEN WILL THE DOT MAKE NISSAN DO SOMETHING ABOUT THIS? *TR
Crash:
No
Fire:
No
Injuries:
0
Deaths:
0
#10340640June 29, 2010
POWER TRAIN
I HAVE JUST HAD THE REAR DIFFERENTIAL FAIL ON MY 2004 NISSAN TITAN AT 95K MILES. THE TRUCK HAD BEEN USED FOR TOWING BUT ONLY ABOUT 5 TIMES A YEAR. IT HAS A TOW PACKAGE AND MOST OF THE MILES ON IT ARE HIGHWAY MILES. *TR
Crash:
No
Fire:
No
Injuries:
0
Deaths:
0
#10339598June 22, 2010
POWER TRAIN
2004 NISSAN TITAN SPIDER GEARS BUSTED, WORKING ON GETTING IT FIXED NOW. *TR
Crash:
No
Fire:
No
Injuries:
0
Deaths:
0
#10339287June 21, 2010
ELECTRICAL SYSTEM
WHILE PULLING MY BOAT TO THE LAKE YESTERDAY AT APPROXIMATELY 65 MPH ON THE INTERSTATE WITH MY 2004 TITAN 4X4 KING CAB (MILEAGE APPROXIMATELY 78,000), THE ABS, SLIP, AND VDC LIGHTS ILLUMINATED. BEFORE I COULD REACH AN EXIT TO PULL OFF, THE ENGINE SHUT DOWN. THIS HAPPENED WITHIN A MATTER OF LESS THAN 3 MINUTES. I WAS ABLE TO PULL TO THE SIDE OF THE INTERSTATE BUT THE ENGINE WOULD NOT RE-FIRE. UPON INSPECTION, I NOTICED SMOKE POURING FROM REAR PASSENGER WHEEL WELL. I GOT ALL OCCUPANTS OUT OF THE TRUCK AND WHEN I RETURNED SECONDS LATER, I SPOTTED A FIRE COMING FROM THE WIRING HARNESS JUST WHERE IT GOES OVER THE FRAME RAIL IN THE REAR PASSENGER WHEEL WELL. LUCKILY I HAD A FIRE EXTINGUISHER ON THE BOAT AND WAS ABLE TO PUT THE FIRE OUT BEFORE CAUSING MAJOR DAMAGE TO THE TRUCK, MY FAMILY OR PASSERS-BY. I HAVE HAD THE VEHICLE TOWED TO THE DEALERSHIP TO BE INSPECTED AND THEY "BELIEVE" A NEW WIRING HARNESS WILL FIX THE PROBLEM ALTHOUGH THEY HAVE "NO IDEA" HOW A FIRE COULD HAVE HAPPENED. A "BELIEF" THAT THE PROBLEM IS FIXED IS NOT COMFORTING. *TR
Crash:
No
Fire:
Yes
Injuries:
0
Deaths:
0

← Back to Nissan Titan