Nissan Titan Complaints (2004)

1,046 consumer complaints on file.

#10438453December 3, 2011
POWER TRAIN
REAR DIFF STARTED WITH SMALL WINE NOISE IN AM ON WAY TO WORK - 11.6 MILES. WENT TO LUNCH - ANOTHER 6 MILES - NOISE A LITTLE LOUDER - NOT BAD - JUST A LITTLE LOUDER. GO HOME IN EVENING - MADE IT ANOTHER 6 MILES AND NOISE SOUNDED LIKE SOME ONE WAS CRASHING INTO THE BACK OF THE TRUCK AS THE BACK END LOCKED UP AND SENT ME SKIDDING ACROSS THE ROAD. LUCKILY NO ONE WAS IN THE LANE NEXT ME!! FAILURE ACCORDING TO DEALER WAS FROM THE 'VENT' TUBE BEING CLOGGED AND CAUSING IT OVERHEAT AND BLOW THE SEALS... SO, ALMOST A CATASTROPHIC ACCIDENT IF WAS ON HIGHWAY, AND NOW 3500 DOLLARS TO FIX BECAUSE OF A 5 DOLLAR CHECK VALVE! THIS IS INSANE. GOOGLE AROUND FOR THE TITAN REAR DIFF, AND I AM NOT THE ONLY ONE OUT THERE!!!! *TR
Crash:
No
Fire:
No
Injuries:
0
Deaths:
0
#10438474December 3, 2011
POWER TRAIN
THE REAL AXLE SEALS IN BOTH SIDES ARE GONE AND CONTINUOUS LEAKING IS INEVITABLE. *TR
Crash:
No
Fire:
No
Injuries:
0
Deaths:
0
#10438081December 2, 2011
POWER TRAIN
THE SEAL ON THE DRIVERS SIDE REAR FAILED, BEGAN TO LEAK OIL ALL OVER THE INSIDE OF THE RIM AND THE BRAKES. THIS WAS WITHIN A FEW MILES AFTER HAVING HAD A DEALERSHIP PRESS A NEW BEARING ONTO THE AXLE AND OCCURRED WITHIN AN HOUR OF THE VEHICLE HAVING BEEN PICKED UP FROM THE SHOP. DEALERSHIP ADMITS TO HAVING SEEN AN ISSUE WITH THE REAR DIFFERENTIAL AND KNOWING THAT IT WOULD LEAK BUT HAVING DECIDED TO NOT INFORM THE CUSTOMER ABOUT THE ISSUE. *TR
Crash:
No
Fire:
No
Injuries:
0
Deaths:
0
#10437957December 1, 2011
ENGINE AND ENGINE COOLING:EXHAUST SYSTEM:MANIFOLD/HEADER/MUFFLER/TAIL PIPE
TL* THE CONTACT OWNS A 2004 NISSAN TITAN. THE CONTACT STATED THERE WAS A LEAK IN THE EXHAUST MANIFOLD. THE DEALER AND MANUFACTURER WERE NOTIFIED, BUT DENIED ANY ASSISTANCE WITH REPAIRING THE DEFECT. THE VEHICLE WAS NOT REPAIRED. THE FAILURE MILEAGE WAS 82,000 AND THE CURRENT MILEAGE WAS 82,500. THE VIN WAS UNAVAILABLE.
Crash:
No
Fire:
No
Injuries:
0
Deaths:
0
#10436879November 23, 2011
POWER TRAIN
I BOUGHT A BRAND NEW 2004 NISSAN TITAN FROM A DEALERSHIP IN OHIO IN SEPTEMBER OF 2004. HAD A FEW OTHER ISSUES ABOUT THE TRUCK DURING ALL THIS TIME OF OWNERSHIP BUT NISSAN HAD ISSUED RECALLS TO TAKE CARE OF THOSE ISSUES AND I WAS PLEASED WITH THEM AND THEIR SERVICE. I AM AT PRESENT EXPERIENCING REAR DIFFERENTIAL PROBLEMS RELATED TO LEAKING REAR SEALS AND FAULTY COMPONENTS IN THE ENTIRE REAR DIFFERENTIAL ASSEMBLY. I HAVE READ THOUSANDS OF REPORTED DIFFERENTIAL PROBLEMS ON THE 2004 THROUGH 2010 TITANS AND NISSAN NORTH AMERICA REFUSES TO TAKE RESPONSIBILITY TO ELIMINATE THIS SAFETY DEFECT AND RECALL ALL THE TITANS FOR NEW DIFFERENTIAL REPLACEMENTS AT NISSANS EXPENSE. I HOPE TO GOD PEOPLE DRIVING THE TITANS ARE NOT KILLED BECAUSE OF THIS OBVIOUS PROBLEM AND DEFECT IN WORKMANSHIP AND MATERIAL. I WILL NEVER DEAL WITH NISSAN EVER AGAIN FOR ANYTHING AND EVERYONE I COME IN CONTACT WITH FOR THE REST OF MY LIFE WILL BE TOLD BY ME HOW UNRELIABLE AND HONEST THE NISSAN COMPANY IS I JUST SPENT 2900.00 DOLLARS TO REPLACE MY DIFFERENTIAL WITH A NEWLY ENGINEERED AND DESIGNED DIFFERENTIAL MADE BY DESIGNED BY AND INSTALL ON MY TRUCK BY NISSAN EMPLOYEE'S. NEVER AGAIN! *TR
Crash:
No
Fire:
No
Injuries:
0
Deaths:
0
#10436639November 21, 2011
POWER TRAIN
I HAVE NOW ONLY OWNED THIS TRUCK FOR ONE YEAR. I AM ONLY THE SECOND OWNER. I HAVE HAD MULTIPLE DRIVE TRAIN ISSUES NOW WITH THIS TRUCK AND IT IS ONLY CURRENTLY AT 75,000 MILES AS OF 11/20/2011. 04/22/11 TURNED A CORNER FROM A FOUR WAY STOP TO HEAR A LIGHT GRINDING NOISE THAT TURNED TO A HEAVY CLUNK AND TIRE HOP. TOOK IT TO A LOCAL TRUSTED AUTO REPAIR TECH TO FIND THAT MY E-LOCKER DETERIORATED AND LITERALLY GRENADED MY WHOLE CARRIER ASSEMBLY. THE ONLY FIX ACCORDING TO NISSAN IS TO REPLACE THE WHOLE REAR DIFFERENTIAL AS IN NEW CASE FULLY ASSEMBLED W/ ROTORS AND ALL. LOCAL SHOP DID RESEARCH AND SAID THIS IS A COMMON ISSUE THEY HAVE A LOT AND NISSAN DOES NOT SELL INDIVIDUAL PARTS TO REPLACE. LOCAL SHOP HAD TO BUILD WHOLE NEW CUSTOM REAR END FROM SEALS IN W/ A DETROIT TRUE TRAC MECHANICAL LOCKER. AT THE SAME TIME SHORTLY AFTER FOUND GEAR OIL IN DRIVEWAY FROM FRONT PUMPKIN TO FIND DRIVERS SIDE C-CLIP BROKE AND AXLE SHAFT IS NOT ENGAGING (IN OTHER WORDS NO DEPENDABLE 4WD) HAD THAT ALL FIXED IN 05/2011 AND SEEMED OKAY NEVER HAD USED THE 4WD. NOW 11/19/11 WENT TO GO FIND A CHRISTMAS TREE AND TURNED ON THE 4WD AGAIN JUST IN CASE. ONCE AGAIN A BROKEN C-CLIP OUT OF NOWHERE. I HAVE NOW HAD TWO BROKEN C-CLIPS WITHIN ABOUT 6 MONTHS OF EACH OTHER W/O 4WD BEING USED. BOUGHT THE TRUCK FOR $16K AND HAVE NOW PUT IN ALMOST ANOTHER $4K IN FRONT AND REAR END REPAIRS. NISSAN IS LOSING A LOT OF CUSTOMERS BY NOT OWNING UP TO THEIR MISTAKES AND DESIGN FLAWS. *TR
Crash:
No
Fire:
No
Injuries:
0
Deaths:
0
#10435719November 15, 2011
POWER TRAIN
DISCOVERED THE DRIVER'S SIDE REAR AXLE OIL SEAL LEAKING. VEHICLE MAINTENANCE HAS BEEN ACCOMPLISHED IN ACCORDANCE WITH NISSAN MAINTENANCE SCHEDULES. DISCOVERED NISSAN TECHNICAL SERVICE BULLETIN (TSB)NTB10-032 STATING ENTIRE AXLE SHAFT ASSEMBLY (AXLE, NEW RETAINER, AXLE BEARING, OIL SEAL, BEARING CAGE, AND ABS ROTOR) BE REPLACED ON 2004-2008 MODELS WHEN OIL LEAKS ARE DISCOVERED TO CORRECT THE PROBLEM. THE TSB DID NOT ELABORATE WHY THE ENTIRE ASSEMBLY IS TO BE REPLACED. IT CAN ONLY BE ASSUMED THAT ALL PARTS OF THE ASSEMBLY ARE CONSIDERED DEFECTIVE AND REQUIRE REPLACEMENT. I PRESENTED THE TSB TO MY NISSAN SERVICE DEPARTMENT AND THEY SAID THEY ONLY NEED TO REPLACE THE OIL SEAL, AXLE BEARING, AND SPACER CONTRARY TO THE PRESCRIBED SERVICE PROCEDURE IN THE TSB. WITHIN 200 MILES OF REPLACEMENT, THE NEW OIL SEAL LEAKS INDICATING THE CAUSE OF THE SEAL FAILURE HAS NOT BEEN RESOLVED. UNRESOLVED AXLE SEAL LEAKS WILL RESULT IN AXLE FAILURE AND BRAKE FAILURES WHEN PADS ARE SOAKED BY GEAR OIL LEAKS. *TR
Crash:
No
Fire:
No
Injuries:
0
Deaths:
0
#10435991November 15, 2011
POWER TRAIN
RIGHT SIDE AXLE IS LEAKING FLUID TO REAR DISK BRAKE. TO FIX ONE SIDE IS 2200. AFTER SEARCHING ON TITAN FORUMS, DISCOVERED THIS TO BE A DEFECT WITH THIS TRUCK. THIS IS A TRUCK THAT HAD SYNTHETIC DIFF OIL AND NEVER TOWED, YET HAS SUCH MAJOR FAILURE SO SOON? THIS IS A SERIOUS SAFETY ISSUE. *TR
Crash:
No
Fire:
No
Injuries:
0
Deaths:
0
#10434396November 6, 2011
SUSPENSION, POWER TRAIN
THE REAR AXLE SEALS ARE LEAKING AND HAS CAUSED MY REAR BRAKES TO SLIP DUE TO THE DIFFERENTIAL OIL GETTING ON MY BRAKE PADS AND ROTORS. THIS IS MY SECOND ENCOUNTER OF THIS PROBLEM AND NISSAN STILL REFUSES TO DO ANYTHING ABOUT IT. *TR
Crash:
No
Fire:
No
Injuries:
0
Deaths:
0
#10434194November 4, 2011
ENGINE AND ENGINE COOLING
TL* THE CONTACT OWNS A 2004 NISSAN TITAN. THE CONTACT STATED WHEN DRIVING AT VARIOUS SPEEDS HE NOTICED THAT THE VEHICLE WOULD DRIVE SLUGGISHLY AND IT WAS LOSING GAS MILEAGE. THE VEHICLE WAS TAKEN TO AN INDEPENDENT MECHANIC WHO ADVISED HIM THAT HIS MANIFOLD FRACTURED AND NEEDED TO BE REPLACED. THE VEHICLE WAS NOT REPAIRED. THE MANUFACTURER WAS CONTACTED AND OFFERED NO ASSISTANCE. THE FAILURE MILEAGE WAS APPROXIMATELY 118,000.
Crash:
No
Fire:
No
Injuries:
0
Deaths:
0
#10434062November 3, 2011
SUSPENSION
TL* THE CONTACT OWNS A 2004 NISSAN TITAN. THE CONTACT STATED THE REAR AXLE SEAL LEAKED AND BEGAN SPRAYING DIFFERENTIAL FLUID ON THE BRAKES WHILE DRIVING 70 MPH. WHEN THE FAILURE OCCURRED THE BRAKING DISTANCE INCREASED ON THE VEHICLE. THE CONTACT TOOK THE VEHICLE TO A DEALER WHO STATED THE REAR AXLE SEAL LEAK WAS VERY COMMON. THE DEALER STATED THE ENTIRE REAR AXLE NEEDED TO BE REPLACED IN ORDER TO REMEDY THE FAILURE. THE CONTACT DID NOT REPLACE THE REAR AXLE. THE FAILURE MILEAGE WAS 75,000.
Crash:
No
Fire:
No
Injuries:
0
Deaths:
0
#10432245October 20, 2011
POWER TRAIN
RIGHT REAR DIFFERENTIAL SEAL FAILED - LEAKED OIL INTO RIGHT REAR BRAKE. *TR
Crash:
No
Fire:
No
Injuries:
0
Deaths:
0
#10432282October 20, 2011
POWER TRAIN
WINDING NOISE COMING OUT OF REAR END, REAR DIFFERENTIAL FAILING, BEARINGS FAILING. *TR
Crash:
No
Fire:
No
Injuries:
0
Deaths:
0
#10430742October 18, 2011
POWER TRAIN, WHEELS
I WAS DRIVING ON THE FREEWAY WHERE THE SPEED LIMIT IS 65 MPH. I WAS GOING THAT SPEED WHEN, WHAT I THOUGHT WAS MY DRIVE SHAFT, BASICALLY EXPLODED AND FELL APART WHILST I WAS IN MOTION. I HAVE KEPT UP ONE ALL MANDATORY AND BASIC MAINTENANCE WORK AND HAVE NEVER HAD A PROBLEM WITH IT BEFORE. PARTS FLEW OUT FROM ALL AROUND MY TRUCK AND IT SLAMMED INTO A COMPLETE STOP AS IF I HAD MADE IMPACT INTO SOMETHING. PASSING VEHICLES HAD TO STAY CLEAR OF THE DEBRIS AN I HAD TO PUSH MY TRUCK INTO THE EMERGENCY LANE. HIGHWAY PATROL ASKED IF I WAS ALRIGHT AND I STATED TO HAVE ALREADY HAD A TOW TRUCK ON ITS WAY. WHEN MY TRUCK WAS TOWED TO THE SHOP THEY SAID THE REAR END ACTUALLY GAVE WAY AND BROKE, INCLUDING THE DRIVE SHAFT WHICH SNAPPED INTO TWO PIECES, ONE OF WHICH WAS LAUNCHED INTO TRAFFIC. LUCKILY NO OTHER VEHICLES WERE DAMAGED NOR PEOPLE HURT. THE MECHANICS SAID THEY'VE BEEN IN BUSINESS FOR 57 YEARS AND I WAS LUCKY TO HAVE COME OUT OF THAT THE WAY I DID, BECAUSE IN MOST CASES THE TRUCK WOULD HAVE FLIPPED AND ROLLED. THE DAMAGES WERE EXTENSIVE AND EXTREME FOR SOMETHING I HAD NO CONTROL OVER. THE SHOP INFORMED ME THAT THIS WAS NOTHING TO DO WITH THE WAY I WAS DRIVING IT OR ANYTHING I COULD HAVE DONE, AND THEY FOUND IT "WEIRD" THAT IT HAPPENED THE WAY IT DID. VERY DANGEROUS AND NEAR TRAUMATIZING. I WAS UNABLE TO SELECT THE CORRECT COMPONENTS ABOVE SO I JUST WANTED TO BE CLEAR THAT IT HAD EVERYTHING TO DO WITH MY DRIVE SHAFT, REAR DIFFERENTIAL, AND POWER LINE. *TR
Crash:
No
Fire:
No
Injuries:
0
Deaths:
0
#10429276October 10, 2011
POWER TRAIN, POWER TRAIN:DRIVELINE:DIFFERENTIAL UNIT
DURING A TURN ONTO ANOTHER STREET, THE REAR DIFFERENTIAL BROKE APART AND SEIZED, STOPPING THE TRUCK IN THE MIDDLE OF THE INTERSECTION. *KB
Crash:
No
Fire:
No
Injuries:
0
Deaths:
0
#10429141October 7, 2011
ENGINE AND ENGINE COOLING, EQUIPMENT
2004 NISSAN TITAN EXHAUST MANIFOLD CRACKED THIS IS A EMISSION ISSUE. *TR
Crash:
No
Fire:
No
Injuries:
0
Deaths:
0
#10429145October 7, 2011
ENGINE AND ENGINE COOLING
2004 NISSAN TITAN VIN [XXX] AT 90K MILES THE EXHAUST MANIFOLDS CRACKED ON MY 2004 NISSAN TITAN. NISSAN COVERS THIS UNDER WARRANTY UNTIL 80K MILES FOR THE EXHAUST SYSTEM. THE TRUCK HAS HAD NO MODIFICATION AND WILL NOT PASS STATE EMISSIONS AND GETS HORRIBLE GAS MILEAGE DUE TO THIS. NOW AT 104 K I HAVE VISITED MULTIPLE DEALERS AND THEY AGREE THIS IS COMMON ISSUE WITH THE TITAN'S AND THE CRACK WILL MAKE A 5 YEAR OLD TRUCK NOT PASS STATE EMISSIONS. TO REPLACE THE EXHAUST MANIFOLD WITH STOCK PARTS IS $1200; WHICH FRUSTRATES ME SINCE THIS IS A FAULTY DESIGN WHICH CAUSES THE MANIFOLDS TO MOVE DIFFERENTLY THEN THE ENGINE MOUNTS ALLOW THE ENGINE TO. INFORMATION REDACTED PURSUANT TO THE FREEDOM OF INFORMATION ACT (FOIA), 5 U.S.C. 552(B)(6). *TR
Crash:
No
Fire:
No
Injuries:
0
Deaths:
0
#10428790October 5, 2011
ENGINE AND ENGINE COOLING, POWER TRAIN
CAR INTO DEALER FOR SERVICE. FOUND TWO CRACKED MANIFOLDS ON BOTH SIDES OF THE ENGINE RESULTING IN EXCESSIVE NOISE AND EXHAUST GASES TO BE RELEASED INTO THE CAB. BOTH SIDES NEED FULL REPLACEMENT AT NEARLY $1,200 PER SIDE. THIS IS RIDICULOUS ON A VEHICLE WITH ONLY 70K MILES ON THE CLOCK. *TR
Crash:
No
Fire:
No
Injuries:
0
Deaths:
0
#10428113October 1, 2011
ELECTRICAL SYSTEM, UNKNOWN OR OTHER, ENGINE AND ENGINE COOLING
WHILE TRAVELING TO GO ON A 13 HOUR DRIVE, ALL OF OUR ENGINE LIGHTS CAME ON AND THE TRUCK BECAME SLUGGISH. WE HAD TRUCK TOWED AND GOT A CALL FROM DEALERSHIP SAYING WHAT HAPPEN WAS MUFFLER/EXHAUST UNIT FELL OFF DURING TRAVEL AND THE UNIT REMAINING GOT SO HOT IT BURNED OUT ENTIRE PART OF TRUCK INCLUDING, ECU, REAR RIGHT HARNESS, AND 3 OTHER THINGS. COST TO FIX OVER $3,000. AFTER PAYING HEFTY BILL SHOP MANAGER SAID THIS WAS THE 5TH TITAN IN OUR SMALL TOWN HE HAD SAME ISSUE WITH AND THAT HE AGREES THIS IS THE WORST PLACE FOR A UNIT ON A TRUCK AND MANUFACTURER SHOULD OF PUT OTHER LOCATION. I THEN FILED A COMPLAINT WITH NISSAN CONSUMER AFFAIRS. THEY ACTED LIKE THEY CARED AND THEN 3 WEEKS LATER THEY DENIED HELPING ME AT ALL SAYING IT WAS OUT OF WARRANTY. I DID RESEARCH ON LINE AND LOTS OF PEOPLE ARE HAVING SAME ISSUE. THIS IS A HUGE SAFETY CONCERN AND I THINK NEEDS TO BE RECALLED AND I NEED TO BE REIMBURSED FOR MY REPAIRS. I FIND IT ODD THAT THE EXHAUST MANIFOLD ALSO CRACKED ON THE TRUCK ON THE RIGHT AND LEFT SIDE AND NISSAN COVERS THAT UNTIL 80,000 MILES. *TR
Crash:
No
Fire:
No
Injuries:
0
Deaths:
0
#10427974September 29, 2011
POWER TRAIN, UNKNOWN OR OTHER
WITHIN A 5 MILE RANGE THE VEHICLE STARTED TO WHINE, THEN CLANK, THEN LOCK-UP. EMERGENCY BRAKES FAILED AND REAR DIFFERENTIAL FAILED... VEHICLE WAS UNDRIVEABLE. THIS VEHICLE JUST HIT 100,000 MILES. REPAIR IS > 1/5TH OF VEHICLE VALUE. THIS IS A VERY COMMON FAILURE IN 2004 NISSAN TITANS. VERY DANGEROUS - ESPECIALLY IF TOWING A TRAILER (WHICH IS WHAT THIS VEHICLE IS ADVERTISED TO DO) *TT
Crash:
No
Fire:
No
Injuries:
0
Deaths:
0

← Back to Nissan Titan