Kia Sorento Complaints (2016)

1,262 consumer complaints on file.

#11519575April 29, 2023
ENGINE
111k mile car engine has had oil changed how it's suppose to going down the road an engine just lost power an now knocking from rod bairings almost causing a wreck on the highway
Crash:
No
Fire:
No
Injuries:
0
Deaths:
0
#11518840April 25, 2023
ENGINE
The contact owns a 2016 Kia Sorento. The contact stated that while driving at an undisclosed speed, the vehicle stalled. No warning lights were illuminated. The contact pulled over and turned off the vehicle. The vehicle was later restarted; however, the failure recurred. The vehicle was towed to the residence and then to an independent mechanic, who diagnosed that the engine needed to be replaced. The vehicle was not repaired. The manufacturer was made aware of the failure and confirmed that the Knock Sensor Detection System (KSDS) software was not installed. The contact stated that she had not received notification for the Knock Sensor Detection System (KSDS). The failure mileage was 100,575.
Crash:
No
Fire:
No
Injuries:
0
Deaths:
0
#11518870April 25, 2023
ENGINE, VEHICLE SPEED CONTROL, STEERING
I was backing up a residential driveway. My backup camera showed my wheels were in line. My steering wheel turned and my car had a sudden unintended acceleration. My car destroyed a double steel garage door. Pushed a parked vehicle forward approximately 10-12”. The vehicle crushed a riding lawn mower, pushing the mower through a sheet rock wall. If anyone had been in this area of the garage, they could have possibly suffered serious injury or even fatality. I am trying to arrange to have my vehicle taken to local Kia dealership for diagnostic testing. At this time, the vehicle has not been inspected. There were no warning signs that appeared and I did not hear my backup camera alert.
Crash:
Yes
Fire:
No
Injuries:
0
Deaths:
0
#11518692April 24, 2023
STEERING
Steering column resistance measure at 5.3 NM indication an internal issue of the column which needed to be replaced. Power Steering sticking and stiff while driving causing clear and present danger to driver passengers and possibly other property. Kia Dealer was apologetic that this was not covered by warranty or recall. However there were other reports of this issue in the KIA System.
Crash:
No
Fire:
No
Injuries:
0
Deaths:
0
#11518713April 24, 2023
ENGINE
This 2016 Kia Sorento is burning a LOT of oil. Every month we are adding 4 quarts of oil. The oil light is not coming on to indicate that the oil is low. Because of the oil burning, it's causing things to get dirty and clogged. We've had to replace plugs and coils twice already and we are experiencing the same problem again now. The car is having (and previously had) trouble accelerating and runs rough (happened in both prior incidents as well). The problem accelerating can be put us in danger, potentially other vehicles hitting us, in heavy traffic situations, when making turns etc.
Crash:
No
Fire:
No
Injuries:
0
Deaths:
0
#11518748April 24, 2023
ENGINE
Car is overheating, mechanic stated head gasket bolts are stripped and it's a defect in these Kia Sorento 3.3L V6 engines. I am the 2nd owner even though it was purchased in the same year it became available (2016). On November 14th, 2023 it will be 7 years old, with 110,000 miles. It's regularly serviced with no issues until the overheating which started on April 22, 2023. My portfolio warranty ended on 100,000 miles. There are hundreds of complaints on various websites with this exact issue. Please help me as I'm a disabled retiree on a fixed income pension and cannot afford 7,000.00 to replace the engine.
Crash:
No
Fire:
No
Injuries:
0
Deaths:
0
#11518331April 21, 2023
ENGINE AND ENGINE COOLING, ENGINE
The contact owns a 2016 Kia Sorento. The contact stated while driving at an undisclosed speed, the vehicle lost motive power and overheated. There were no warning lights illuminated. The vehicle was taken to the local dealer where it was diagnosed that the head bolts had a gap between the head gasket and the engine block. The mechanic recommended an engine replacement. The vehicle was not repaired. The manufacturer was contacted and informed the contact that the vehicle was not covered under recall or warranty. The failure mileage was approximately 80,000.
Crash:
No
Fire:
No
Injuries:
0
Deaths:
0
#11518024April 20, 2023
ENGINE
The contact owns a 2016 Kia Sorento. The contact stated that there was an abnormal knocking sound from the engine while the vehicle was idling and upon depressing the accelerator pedal. There was no warning light illuminated. The vehicle was initially taken to an independent mechanic where the contact was informed that the vehicle was consuming an excessive amount of engine oil, resulting in engine damage. The dealer and the manufacturer were notified of the failure and the contact was informed that the vehicle was not covered under recall or warranty. The vehicle was not repaired. The failure mileage was approximately 137,000.
Crash:
No
Fire:
No
Injuries:
0
Deaths:
0
#11517910April 19, 2023
POWER TRAIN
Engine Failure - 3.3L Head Bolts Backed Out of Block Emissions Seeping In to Cooling System (coolant blowing out of reservoir tank) Dealer Verified Issue and Know this to Be an Issue (with various 3.3L cars) Overheating Claimed to Be the Cause - Car Maintenance By Dealer Only on Routine Basis Vehicle Driven Around Town - Not Pushed Beyond Local Driving Internet Search Shows Others with Same Problem Reports from Mechanics of Blocks with Poor Castings and Material/Quality Issues 119,000K miles with no prior mechanical issues Dangerous Issue Repair Estimate $10000 - Unethical, Unsafe, Predadatory for those who Still paying off vehicles
Crash:
No
Fire:
No
Injuries:
0
Deaths:
0
#11517550April 18, 2023
ENGINE
I was driving the car when I suddenly smelled coolant. No warning lights came on and the temperature gauge was in the normal range when I first smelled coolant. Then, steam began to come through my vents. This is when the temperature gauge began to rise. I drove the car to get it to a safe place before shutting it off. I had it towed to a service center to get the problems diagnosed. The service center told me the engine and cooling system would need to be replaced. I can provide the diagnostic assessment. This could have been extremely dangerous if the problem occurred on the highway, as I fear the engine could have caught fire. I was blessed that this happened on a city street. There was a very sudden loss of coolant, and the inspection revealed metal shavings in the oil. I have had this vehicle regularly maintained and checked the oil myself to keep it at the proper level. None of my prior service visits noted any presence of metal in the oil.
Crash:
No
Fire:
No
Injuries:
0
Deaths:
0
#11517559April 18, 2023
ENGINE
In 2020 Kia replaced the engine on our 2016 Sorento. The new engine is doing the same thing with regards to oil consumption and causing us to repeatedly have to put oil in the vehicle at almost every fuel stop. There are no obvious oil leaks observed by us or Kia, we are also experiencing error code 0420 on the vehicle as often as 2-3 times a week. The dealership states that the engine replaced in 2020 only had a 1 year, 12000 mile warranty on it and it is no longer covered. The check engine light was unable to be diagnosed by the dealership despite being illuminated when taken to the dealer. We believe the engine oil leak and 0420 code are related as there are no other codes being shown on the vehicle.
Crash:
No
Fire:
No
Injuries:
0
Deaths:
0
#11517701April 18, 2023
UNKNOWN OR OTHER
My 2016 Kia Sorento was parked in my garage. When I went out in the morning to start the car, I turned on the ignition and the red warning light indicating a power steering failure went on and the power steering wasn't functioning. It was much harder to turn the wheel in either direction than it had been previously. I backed out of my driveway and with some difficulty drove another 2-3 blocks. At that point the power steering started functioning again and I was able to continue driving it to a nearby automotive repair place. When I dropped the Kia off they suggested that I leave it there overnight to give them as much time as possible to see if they could replicate the problem I just had. The problem didn't repeat while the car was in the shop, but I was told the power steering could go out again at any time. This is a major safety concern since I don't know if I'd be able to maintain control of the vehicle if this happened unexpectedly - particularly if I was traveling at a high rate of speed. Since then I've read reports of similar incidents with other 2016 Kia Sorentos. I've also learned that Kia has extended the warranty for the steering mechanism on my vehicle to 150,000 miles, but that is of no help if the problem doesn't present itself when it's in for repair at the dealership because if it doesn't service will be denied. To the best of my knowledge there is currently no recall for this issue. I've tried contacting the Kia Consumer Assistance Center about this, but finally gave up after being put on hold for over an hour. My vehicle is available for inspection at any time.
Crash:
No
Fire:
No
Injuries:
0
Deaths:
0
#11517749April 18, 2023
ENGINE
Rod bearings failed while driving down busy road had to immediately pull over. Car was just recently serviced. Even after engine failed the check engine light never came on which is highly unsafe!
Crash:
No
Fire:
No
Injuries:
0
Deaths:
0
#11517750April 18, 2023
ENGINE
While driving on i95 the car suddenly stopped without warning. After getting the car towed twice, to find out the engine seized up after a mechanic took a look at it.
Crash:
No
Fire:
No
Injuries:
0
Deaths:
0
#11517427April 17, 2023
ENGINE
The engine was built with a known defect. The bolts securing the head to block were all fine thread bolts. Fine thread bolts will strip out under torque and compression. The antifreeze will flood the compartment.
Crash:
No
Fire:
No
Injuries:
0
Deaths:
0
#11517281April 16, 2023
UNKNOWN OR OTHER
1.Kia installed Trailer hitch. 2. Fire hazard. 3.Dealer says they do not have a repair for it. 4. No warnings, or symptoms, NO FIRE YET. I parked my car outside ALL WINTER.
Crash:
No
Fire:
No
Injuries:
0
Deaths:
0
#11516618April 12, 2023
POWER TRAIN
Car will not drive, sputters and will not accelerate at all. Car shakes and then loses power.
Crash:
Yes
Fire:
No
Injuries:
0
Deaths:
0
#11516272April 10, 2023
ENGINE, ELECTRICAL SYSTEM, POWER TRAIN
Most recently the engine burned up the oil prior to my next service date. After oil was added and the engine drove fine. The next day the engine ran fine and after driving through an intersection 1/2 mile from my house the car died. It lost complete power, putting myself and my family in danger. (Thank God we were able to get off to the side of the busy roadway safely). At that moment, a battery light came on first, then an oil and engine light illuminated at the same time. The car wouldn’t start and had to be towed off the side of the road. The mechanic that looked at it said it needed an engine. Due to lack of maintenance records, the extended warranty company chose to deny my claim. The dealer has my car and will do a diagnostic test. About a year ago I had the transmission looked at for hard shifting into first and the dealer said it needed a flush. The problem continued not too long after they flushed it. It only happens if you release the brake and push to start too quickly and put in gear too quickly. No recalls I’m being told for that issue as well. ZERO indicators on dash prior to any issues happening that would have given me the opportunity to maintenance/service my vehicle before resulting in engine failure and potentially costing my thousands I don’t have. I love my Kia and want my baby back in great working order but I’m afraid I won’t be able to have her back if the repairs are more expensive than the cars worth. I’m still financing this vehicle as well. Please KIA/Hyundai I need your grace and good faith to repair my vehicle under warranty.
Crash:
No
Fire:
No
Injuries:
0
Deaths:
0
#11516307April 10, 2023
ENGINE, FUEL/PROPULSION SYSTEM, UNKNOWN OR OTHER
The engine was going through over 5 quarts of oil about once a month. There were no visible leaks. For months, there was no check engine light illuminated so the dealership couldn't help determine and fix the problem without charging over $10,000 to open the engine, which I couldn't afford. A Service Advisor, in their words, told me to, "Run it until it dies," so that they can start using the warranty. This to me was very unsafe, especially for my infant who was there when she said this. Months later, the car started shaking intensely and the check engine light finally came on. The car stopped working in the middle of the freeway but I was able to exit and take it to the nearest dealership. They were able to run a diagnosis and said it was an engine misfire and they replaced it (I was able to use my warranty for some of the repairs but still had to pay about $4000). It didn't take long for the car to stop working again. They then said there was a problem with the fuel pump so I had them replace it. I had barely just left the dealership when the car stopped working again. They replaced the catalytic converter, which was a part of a voluntary recall. For months after, they've been trying to figure out the issue with no success. It has been sitting at their service center since November 2022 with no solution.
Crash:
No
Fire:
No
Injuries:
0
Deaths:
0
#11516379April 10, 2023
POWER TRAIN
My gear shift locks in place unless the shift lock release is pressed. Multiple other vehicles of this same Make and Model have a recall for this same issue but my car isn't on the list for it's vin number so the dealer wants to charge $950 for the BCM to be replaced first before then moving to the shifter and components which will total almost another $600. My sister's 2016 Kia Sorento is also experiencing the same issue. I don't understand how my vehicle has the same issue but they want to charge me to correct an issue that manufacturing causes in so many of this Make and Model. Side note: after recall for anti theft system was "fixed" my steering wheel controls for menu settings and stereo no longer work.
Crash:
No
Fire:
No
Injuries:
0
Deaths:
0

← Back to Kia Sorento