Kia Sedona Complaints (2017)

134 consumer complaints on file.

#11678952August 7, 2025
ENGINE
I was driving and my engine seized and my car is now undrivable. I immediately looked up recalls and see that there were several recalls and recalls surrounding the engine as well. I am told I now need a brand new engine and was referred to file a report as the issue experienced should not have been happening.
Crash:
No
Fire:
No
Injuries:
0
Deaths:
0
#11678706August 6, 2025
ENGINE
Engine stared clattering at the end of a 2 hour drive home. Engine died entering a round about 1-1/2 miles from home. It restarted and limped to my home. Arranged to have it towed to mechanic shop. They informed me there is issues with rod bearings and that Kia has a class action suite but Kia is telling me that my vin is not involved.
Crash:
No
Fire:
No
Injuries:
0
Deaths:
0
#11676139July 25, 2025
UNKNOWN OR OTHER
The Sedona is showing paint damage on the rear trunk door. The unit is white. It is starting to flake where the glass ends.
Crash:
No
Fire:
No
Injuries:
0
Deaths:
0
#11675598July 23, 2025
ENGINE
Without warning lights coming on my engine started knocking on May 15, 2025. Turns out the bearing between the top of the motor and the bottom of the motor is stripped. 5 months before this happened they replaced the 2 fuel pumps, cvvt, cam shaft sensor and assembly, timing chain and spark plugs. Again I had no warning about that work that the dealership said I needed. Now I need a new motor and they won’t do anything for me except charge over $10,000.
Crash:
No
Fire:
No
Injuries:
0
Deaths:
0
#11675356July 22, 2025
AIR BAGS
The contact owns a 2017 Kia Sedona. The contact stated that upon start of the vehicle, the air bag warning light illuminated on the instrument panel. The vehicle was taken to a dealer where a diagnostic test was performed, and the dealer discovered that the front passenger's side air bag module was defective and needed to be replaced. The vehicle was not repaired. The contact related the failure to NHTSA Campaign Number: 22V031000 (Air Bags). The dealer acknowledged the recall but informed the contact that the repair would be an out-of-pocket expense. The manufacturer was notified of the failure. The failure mileage was unknown.
Crash:
No
Fire:
No
Injuries:
0
Deaths:
0
#11664626June 3, 2025
ENGINE
I heard a knocking sound in my car which I thought was coming from the engine towards the end of May. It was really bad on May 29, 2025, so I did not drive it again. I called my local dealership and scheduled an appointment for June 2, 2025. The vehicle had to be towed from my house to the dealership as it did not seem safe to drive. The battery had died when I tried to start it, so I called AAA for a tow. They were able to jump start the car, but I still did not feel safe driving it with the loud knocking noise. I had AAA tow my car to the dealership. This is what they found: LOWER ENGINE KNOCK, METAL IN THE OIL, LOWER ROD BEARING FAILURE. No lights were on at the time the severe knocking occurred. How and why was my VIN not included in the recall notice on the engines? This was clearly a safety hazard. This problem SHOULD BE COVERED by the engine recall. Now I have to get a new vehicle with extremely limited funds.
Crash:
No
Fire:
No
Injuries:
0
Deaths:
0
#11662481May 22, 2025
ENGINE
Catalytic converter system failure
Crash:
No
Fire:
No
Injuries:
0
Deaths:
0
#11656748April 25, 2025
AIR BAGS
The contact owns a 2017 Kia Sedona. The contact stated while starting the vehicle, the air bag warning light illuminated. The vehicle was taken to an independent mechanic who diagnosed that the front passenger's side air bag module needed to be replaced. The vehicle was not repaired. The contact related the failure to NHTSA Campaign Number: 22V031000 (Air Bags). The failure persisted. The manufacturer was notified of the failure. The failure mileage was approximately 86,000.
Crash:
No
Fire:
No
Injuries:
0
Deaths:
0
#11655621April 19, 2025
ENGINE
On [XXX] my family and I were on our way to Oklahoma. Luckily we were on a highway instead of interstate when our Kia motor blew. There were no oil warning lights illuminated, nothing. My husband luckily was able to steer the van to the side of the road safely. My vehicle had to be towed and when codes were run on it by the oil changers, NO CODES POPPED UP and there were metal shaving in my oil filter. My husband contacted the dealer, they said the only issue they could find was not a recall, but an extended warranty for an oil pressure switch, but that with it not working it "would not make an engine blow." However, another mechanic said it absolutely would. This van does have the 3.3 engine that has been recalled in other models, but not the 2017. We had to rent a UHAUL to have my van pulled by another vehicle. In the picture you can see all the oil which was lost. How was our safety at risk? We had to pull on the side of the road on a main highway (not interstate), but there wasn't much room between the road side and our vehicle, not to mention the traffic right behind us who could have parked in our trunk when the failure occurred. INFORMATION REDACTED PURSUANT TO THE FREEDOM OF INFORMATION ACT (FOIA), 5 U.S.C. 552(B)(6)
Crash:
No
Fire:
No
Injuries:
0
Deaths:
0
#11645215February 27, 2025
ENGINE
Using lots of oil
Crash:
No
Fire:
No
Injuries:
0
Deaths:
0
#11645216February 27, 2025
UNKNOWN OR OTHER
My right side turn signal keeps getting water inside and not working
Crash:
No
Fire:
No
Injuries:
0
Deaths:
0
#11643821February 19, 2025
UNKNOWN OR OTHER, STEERING, AIR BAGS
Intermittent air bag light come and goes Window fluid leaking Power steering leaking Bad reception AM radio (Lots static)
Crash:
No
Fire:
No
Injuries:
0
Deaths:
0
#11642728February 14, 2025
ENGINE, UNKNOWN OR OTHER
All maintenance performed at same manufacturer authorized dealership. My engine is currently full of sludge due the oil pressure switch under the recall not operating correctly before and after repair The was reported to dealer in October 2023 who engaged the manufacturer who authorized the repairs in May 2024 when vehicle would not hold oil at all.Car has not maintained oil level since repair .It has been in dealers since October 2024 seeking assistance from the manufacturer Recall MC-10210267-0001
Crash:
No
Fire:
No
Injuries:
0
Deaths:
0
#11639812January 31, 2025
ENGINE
I own a 2017 Kia Sedona with approximately 120,000. It has the 3.3L V6 engine. While driving, the vehicle lost power and would not run. The lights and the dashboard would come on, but it would not turn over to start. I took it to a mechanic, and they confirmed that the engine had seized up and would have to be replaced costing $11,000. I then had it towed to the dealership that I purchased the vehicle. They also confirmed that the engine had seized up and would have to be replaced at a significant cost. I had no warning that anything was wrong with my vehicle as the check engine light did not come on. I did hear a slight knocking the day before this happened. My husband checked the oil and added a quart of oil, which was unusual since we had not seen any oil on our driveway. I did have a warranty, but it lapsed due to being over the mileage cap by 2,000 miles.
Crash:
No
Fire:
No
Injuries:
0
Deaths:
0
#11630586December 13, 2024
ENGINE AND ENGINE COOLING, LATCHES/LOCKS/LINKAGES
The contact owns a 2017 Kia Sedona. The contact stated that the vehicle failed to immediately start and was experiencing rough driving with the check engine warning light illuminated. The vehicle was taken to the local mechanic who diagnosed the vehicle and informed the contact of the head gasket, head gasket bolts, fuel pump, and fuel injector failures. The vehicle was not yet repaired. Additionally, the passenger’s side electronic sliding door failed to properly latch due to a faulty electrical locking mechanism. The vehicle was not repaired. The manufacturer and local dealer were notified of the failures, but no assistance was provided. The manufacturer informed the contact that the vehicle was not included in an undisclosed Extend Warranty Coverage for the failure. The failure mileage was 50,000.
Crash:
No
Fire:
No
Injuries:
0
Deaths:
0
#11628499December 3, 2024
ENGINE
The Engine failed at 63,758 miles. Lancaster KIA in Lancaster, PA indicated the engine has metal shavings everywhere.
Crash:
No
Fire:
No
Injuries:
0
Deaths:
0
#11626877November 22, 2024
ENGINE
Motor has been consuming oil.all oil and maintence was done to this vehicle.on Monday the 18of November 2024 while driving too work the motor blew up putting oil everywhere.almost cause a major accident it had too be tow back to my house.
Crash:
No
Fire:
No
Injuries:
0
Deaths:
0
#11626591November 21, 2024
ENGINE, ELECTRICAL SYSTEM
Engine seized. Purchased car on 9-16-24. One 9-17-24 I went to Valvoline and purchased a full synthetic oil change. Within 2000 miles driven since oil change mechanic advised that there was no oil and no leaks. Valvoline assisted my mechanic in the investigation and claimed the Sedona had a oil consumption issues. Manufacturing issues. Car shut off while driving. No light illuminated prior to the shut off and even with no oil there is no check engine light or oil pressure warning.
Crash:
No
Fire:
No
Injuries:
0
Deaths:
0
#11623997November 7, 2024
ENGINE AND ENGINE COOLING, LATCHES/LOCKS/LINKAGES
The contact owns a 2017 Kia Sedona. The contact noticed a green puddle underneath the vehicle with the low coolant message displayed. The vehicle was initially taken to an independent mechanic where the contact was informed that either the head gasket or the entire engine needed to be replaced. The contact was referred to the dealer for further assistance. The vehicle was towed to a dealer where the contact was informed that leak was caused by stripped bolts inside the engine which caused coolant to leak. The vehicle was diagnosed with engine failure. The engine was replaced by the dealer. The manufacturer was notified of the failure and the contact was informed that there were no recalls or warranties associated with the vehicle. In addition, the contact stated that the driver’s side sliding door intermittently failed to close as needed. The contact stated that while driving at various speeds, the door ajar warning light was illuminated. The vehicle was taken to a dealer where an estimate for the repair was provided; however, the dealer could not guarantee that the repair would fix the vehicle. The vehicle was not repaired. The failure mileage was 85,012.
Crash:
No
Fire:
No
Injuries:
0
Deaths:
0
#11621137October 21, 2024
ENGINE
My engine seized. When I took it to my mechanic they stated it was due to low compression and that Kia engines were known for this issue. He suggested I take it to a Kia dealer to have them replace the engine. I took it and I was denied the replacement. I did some research and found that this issue was in fact very popular among Kia owners. Some expressing their engines actually ignited. I also found there was a class-action lawsuit against Kia for this exact issue. I noticed all Kia models were included in the suit except for the Sedona. During my research I found a mass of Sedona owners who had the same compression issues. It baffles me why my car wasn't included when it has the exact isdues as the other models made by the same manufacturer. I would like to file a complaint in hopes that other Sedona owners have done the same, and we can bring light to this issue, and possibly a solution.
Crash:
No
Fire:
No
Injuries:
0
Deaths:
0

← Back to Kia Sedona