Kia Carnival Complaints

515 consumer complaints on file.

#11733125April 22, 2026
ENGINE, FUEL/PROPULSION SYSTEM
I was on the on-ramp getting on the highway and whenever I started to increase speed and try to get over into the next lane, I noticed the car all of a sudden jumped a little bit and then it started consistently jumping in the check engine light was flashing, and I couldn’t keep the car over what ended up being 50 mph anytime I tried to go over 50 mph. The car jumped in was shaking pretty pretty aggressively I was able to finally make it to a gas station at the very next highway stop and after I shut the car off and turn it back on it seems like it was OK, but I’m still very scared to drive it. I then took it to the dealership to have them check for any store or pending codes because after we had stopped and turned the car back on it no longer had the check engine light on, and the dealership was not able to locate any stored codes in the system to see what it happened nor were they able to replicate the issue that we had found. Is a rec out on my vehicle, but no remedy is available and notices will not be sent for another month and a half at this point I am extremely uncomfortable driving my vehicle as I have young children and anything with a fire hazard is not safe.
Crash:
No
Fire:
No
Injuries:
0
Deaths:
0
#11732931April 22, 2026
ELECTRICAL SYSTEM, FUEL/PROPULSION SYSTEM
4/6/2026 vehicle stalled in traffic multiple times, entered "Limp Mode", unable to accelerate after stopping or after deceleration. I had to press the gas to the floor to get the vehicle to move. While driving, if I had to brake or lay off the gas at all, the vehicle would not accelerate back to the original speed quickly. This put myself and my four children at risk of being rear-ended. I drove with the hazard lights on to Kia of Wesley Chapel Service center. The Battery Management System Warning displayed at the time of the stalling. The Kia Access App displayed the BMS Warning and code P0AA600 (High Voltage Isolation Fault). Initially, Kia of Wesley Chapel Service Advisor stated No warnings displayed and No historical or active codes found. I provided a screenshot of the Kia Access App showing the active BMS Warning and active P0AA600 code at 2:48PM on 4/8/2026. The Service Advisor maintained that they could not find any active or history codes. At 3:00PM the same day, the Kia Access App suddenly showed "No Issues Found". The code was obviously manually cleared. I filed a complaint with Kia Customer Care the same day (4/8/2026) and requested a Kia Technical Specialist be assigned to the case. On 4/12/2026, the original Kia Service Advisor stated "the history code has finally appeared which was the one presented in the screenshot but we cannot replace parts based off of a code that is no longer active unfortunately". He stated they would "keep driving and testing" to try and duplicate the issue. The Kia Access App shows the last trip was 4/7/2026 (the day after I dropped off the vehicle). Interestingly, the vehicle was not moved from the drive up lane at the Service Center until 10:40AM that day, after being dropped off at approximately 6PM the evening prior. I believe they could not get the car to move the evening of 4/6/2026. The vehicle remains at Kia of Wesley Chapel. I am sending the Motor Vehicle Defect Notification to Kia Corporate today.
Crash:
No
Fire:
No
Injuries:
0
Deaths:
0
#11732656April 21, 2026
FUEL/PROPULSION SYSTEM
Kia has a recall (Campaign SC 368) on a fuel pipe that may be defective causing a gas leak leading to fire. I called the dealer I bought the vehicle from to request an inspection of the part. I was told Kia will not send letters out until June 2 so dealers are under no obligation to inspect the impacted area before then. Why should a family have to wait six weeks or more on such a critical issue for it even to be visually inspected. Kia's direction is simply to be on the lookout for gas smell and park the vehicle outside. The length of time that they are going to be taking shows a lack of concern for safety, especially since the initial step simply requires inspection of the part. Does the NHTSA have any plans to require car manufacturers to handle all recall matters in a more expedient manner?
Crash:
No
Fire:
No
Injuries:
0
Deaths:
0
#11732059April 18, 2026
ELECTRICAL SYSTEM, EXTERIOR LIGHTING
Car Problems Purchased March of 2025 #1 First black out summer 2025-Driving at 10 PM and lost all electric driven items. Headlights turned off as well while driving 70 MPH in the dark Scheduled an appointment to get the car looked over. They said that there was a part that they were waiting on to help with electrical issues. #2 Next black out fall of 2025 Used the update part to see if that would fix the problem #3 February 6th, 2026 Got my oil changed and it blacked out when I left the dealership. Went back to tell them and they documented it. #4 April 14th, 2026
Crash:
No
Fire:
No
Injuries:
0
Deaths:
0
#11731853April 17, 2026
SEATS, ELECTRICAL SYSTEM
The component of the vehicle that malfunction was the front passenger seat. The driver came to a stop at an intersection and the front passenger seat started auto reclining. The seat was reclining into a life, flat position, almost. The driver was concerned because no one was pressing buttons and put the vehicle in park in the seat did not stop auto reclining so the driver turned off the vehicle, but the seat reclined as far as it could into the middle section of the vehicle and encountered the driver’s child in a car seat. The seat reclined onto the child's legs and pinned them down against the car seat and the seat below them. The driver was unable to remove the child from under the seat nor able to physically lift the seat, but the buttons on the front passenger seat on the lower right side, did work in order to lift the seat back into an upright position and unpinned the childs legs. The driver took it and to a dealership to get it looked at and they failed to reproduce the issue. The local dealership did look at the vehicle, but failed to reproduce the issue. There were no warning lights to indicate this was going to occur. The local dealership suggested this was a user error, and that something must have damaged the components of the seat to activate an auto recline, which is still problematic. The dealership said due to the owner unplugging the power to the seat that the issue could not occur again, but they did not solve the mystery or issue of how it actually occurred. The child was restrained in a car seat, and the seat was pushed back in the middle section of the vehicle as far back as it can go. The front seat was still able to auto recline somehow into the child’s car seat and pin them down.
Crash:
No
Fire:
No
Injuries:
0
Deaths:
0
#11731536April 16, 2026
FUEL/PROPULSION SYSTEM, UNKNOWN OR OTHER
The fuel pipe in my 2024 Kia Carnival has been identified by Kia as part of Safety Recall SC368 due to a fire risk. The component is available for inspection at the dealership where the vehicle is currently located. My safety and the safety of my family — including young children in car seats — was put at risk because the vehicle carries a known fire hazard related to the fuel pipe, yet no remedy is available until June 2026 at the earliest, according to Kia Customer Care. Kia confirmed the recall and the fire risk but has not provided adequate alternative transportation, leaving a family with young children without a safe vehicle for an extended period. The problem has been confirmed by Kia Customer Care, who verified that my vehicle is included in recall SC368. The dealership also confirmed the recall exists but stated the remedy is not yet available. However, when I contacted NHTSA by phone to file a complaint, the representative stated they could not find my vehicle in their recall database, directly contradicting Kia's confirmation. This discrepancy between Kia's internal records and NHTSA's database is concerning and may prevent other affected owners from being aware of the safety risk. The vehicle has been surrendered to the dealership via tow due to the fire risk. It has not yet been inspected or diagnosed by the dealership service department. I have requested written confirmation that the vehicle is safe to drive before accepting it back. I was notified via a CARFAX alert and the risk was identified/confirmed by the manufacturer.
Crash:
No
Fire:
No
Injuries:
0
Deaths:
0
#11731411April 15, 2026
FUEL/PROPULSION SYSTEM
I reported a fuel smell in the cabin of my vehicle in June 2024. It was dismissed because they could not recreate the smell. I reported it again and they said that is just how the vehicle purges fuel. I reported it again and drove it right to the dealer when it smelled and multiple mechanics at KIA confirmed they smelled it. Reported it again in September 2024, then tried to deal with it, and reported it again in June and July 2025. In July they confirmed I had raw fuel in my evaporator canister. I also had misfire notifications on my dashboard which were dismissed as they could not determine where the misfire was coming from. The misfire stopped after they replaced my fuel canister but the smell never fully went away. I received an email follow up in July 2025 and I reported the smell was not as strong, but still occurring intermittently. They closed the case. I reported and had 2 open cases with KIA, and noted that I was feeling lightheaded and nauseous, as well as 2 of my 3 kids at the time.
Crash:
No
Fire:
No
Injuries:
0
Deaths:
0
#11731247April 14, 2026
UNKNOWN OR OTHER
The car now auto locks on the vehicle upon exit, even with key fobs in the car. The first few months I had the car this did not happen. I left me keys and phone in the car. I turned vehicle off, exited the vehicle and walked around to get my daughter out of her car seat. After about 5-8 seconds of walking around. The car automatically locked. The key fob was placed in the center console. My 1 year old daughter was left trapped in the vehicle, placing her life in danger. I had to call emergency services and have them open it for me. This is a huge saftey concern. I never changed any setting to allow for this. The car should not auto lock, and definitely should not lock with keys in the vehicle a few seconds after exiting.
Crash:
No
Fire:
No
Injuries:
0
Deaths:
0
#11730937April 13, 2026
UNKNOWN OR OTHER
I am writing concerning the Driver Attention Warning system and how it seems to be way too sensitive and when it keeps going off, trying to see what is causing this issue. This seems to be creating more distractions than it is designed to solve. From my understanding Kia through a software update removed any sensitivity adjustments which makes this problematic.
Crash:
No
Fire:
No
Injuries:
0
Deaths:
0
#11729561April 6, 2026
ENGINE, FUEL/PROPULSION SYSTEM, POWER TRAIN
Engine light turns on every couple months. The Kia either stops accelerating and goes into “limp mode” or gives code for misfiring cylinders. Took to dealership several times, they did nothing but reset battery so light goes off. Unsafe when driving my family around and has turned into an unreliable vehicle. SO frustrating for a new vehicle to have these issues.
Crash:
No
Fire:
No
Injuries:
0
Deaths:
0
#11729116April 3, 2026
ELECTRICAL SYSTEM
Due to soy-insulated wiring used in wiring harnesses, rodents are attracted to the wiring components in the engine bay. Even using deterrents doesn't see to affect them. What started as a simple check engine light for what was assumed to be a faulty sensor turned into a total wiring harness replacement. Without knowing that the wiring provided an added risk to damage from external factors, there was no need to check any of the wiring. If the check engine light didn't come on, it was possible that total power loss to the vehicle could've occurred at any time, due to the various wires damaged by the rodents. We were driving on the freeway at the time when the initial check engine light came on, and a loss of power while going 65 mph could've been devastating to both our family and other drivers on the road at the same time. Insurance confirmed that the cause of the wiring damage was related to the rodents being attracted to the material, and at the dealership there were at least 2 other cars needing full wiring harness replacements due to similar damage from rodents.
Crash:
No
Fire:
No
Injuries:
0
Deaths:
0
#11728723April 2, 2026
ENGINE
My Kia vehicle has an ongoing engine oil leak that has not been properly repaired under warranty. The vehicle was taken to an authorized Kia dealership for diagnosis and repair of the oil leak. I was informed by the dealership that Kia engineers indicated that in similar situations the typical resolution is engine replacement. However, in my case, the dealership was instructed to attempt sealing the oil pan instead of replacing the engine. I was advised that if this repair did not resolve the issue, I could bring the vehicle back for further service. Unfortunately, the oil warning light has now returned on the dashboard, indicating the issue persists and the repair attempt was not successful. An unresolved engine oil leak presents a serious safety concern because loss of engine oil can lead to engine damage, stalling, or failure while driving. This creates a risk of unsafe driving conditions, especially when transporting passengers. My family relies on this vehicle for daily transportation, and the continued presence of the warning light makes the vehicle unreliable and concerning from a safety standpoint. In addition, the dealership has not provided a suitable loaner or rental vehicle large enough to accommodate my family while the vehicle is undergoing repair. This has created significant hardship as we do not currently have reliable transportation. The manufacturer should correct this defect properly and ensure the vehicle is safe to operate rather than attempt temporary or experimental repairs that do not resolve the root cause. The persistence of the oil leak after warranty repair raises concerns about the reliability and safety of the engine. I am submitting this complaint to document a potential engine defect that may pose a safety risk if engine oil loss leads to engine failure while the vehicle is in operation.
Crash:
No
Fire:
No
Injuries:
0
Deaths:
0
#11728640April 1, 2026
ELECTRICAL SYSTEM, SEATS, UNKNOWN OR OTHER
2026 Kia Carnival MPV Hybrid SX Prestige(Exterior: Astra Blue Interior: Tuscan Umber / Off-Black) purchased December 2025. Two separate safety-related defects have gone unresolved for 31+ cumulative days across two dealer repair visits. DEFECT 1 — INSTRUMENT CLUSTER: Instrument cluster screen goes blank while driving, eliminating speedometer, TPMS, and all warning indicators. First observed February 2026. Dealer visit February 13–17 (4 days): technician said could not replicate. Defect recurred. Kia has since issued a federal safety recall confirming this exact defect — citing FMVSS noncompliance and stating the blank screen increases crash risk due to a software error causing overheat protection mode. Vehicle was at dealer for an active safety recall defect that went undiagnosed during a repair visit. DEFECT 2 — SEAT MODULE: Second-row seat module failed. Vehicle returned to dealer March 5 (still there, 27+ days). Wiring harness replacement attempted approximately March 21 — failed, defect persisted. Kia Engineering formally escalated approximately March 24. Seat module ordered but not yet installed. No resolution or completion date provided. Vehicle has been out of service 31+ cumulative days. Safety recall defect went undetected during prior dealer repair visit. Both defects remain unresolved on a vehicle purchased just 97 days ago.
Crash:
No
Fire:
No
Injuries:
0
Deaths:
0
#11728404March 31, 2026
UNKNOWN OR OTHER
Sliding Door Sensor Failed My daughter was getting in the van, when her brother hit the door button, if my husband wouldn’t have glanced over at that exact moment and pulled her back, this would’ve been another story. THE SENSOR IS NOT SENSITIVE ENOUGH! We as mothers are demanding sensors sensitive enough to detect smaller, fragile children!
Crash:
No
Fire:
No
Injuries:
0
Deaths:
0
#11728026March 30, 2026
POWER TRAIN, ELECTRICAL SYSTEM, SERVICE BRAKES
The vehicle (2025 Kia Carnival Hybrid) has suffered from a systemic parasitic 12V battery drain since the first month of ownership. The first occurrence was July 20, 2025, requiring a jump-start from Kia Roadside Assistance. On 02/26/2026, the vehicle was presented at Moritz Kia Alliance for the same issue. The dealer diagnosed the 12V battery as defective (Code R04) and replaced it under warranty. However, the defect persisted. On 03/10/2026, only 12 days later, the vehicle suffered another total electrical failure. I had to utilize Kia Roadside Assistance for a jump-start and drive the vehicle directly to the dealer without turning the engine off to ensure it could be serviced. This marked the second official repair attempt for this recurring defect. The vehicle has remained in dealer possession since March 10 (21 consecutive days). On March 11, only one day after drop-off, the Service Director threatened that the vehicle would be "impounded" after 60 days, despite the vehicle being the subject of an active Texas DMV Lemon Law Case (#26-0012638.CAF). On March 26, a critical safety failure occurred: during a start-up attempt, the Integrated Power Brake (IPB) system malfunctioned, causing the brake pedal to pulsate and physically "kick back" with significant force against my foot. I have serious concerns that this braking failure could occur while in motion, posing an unreasonable risk of high-speed collision, serious injury, or death. No root-cause diagnosis has been made. Furthermore, the main fuse box cover was left off during service, exposing critical electrical components. The vehicle is available for inspection.
Crash:
No
Fire:
No
Injuries:
0
Deaths:
0
#11727626March 28, 2026
ENGINE, POWER TRAIN
"Continuous engine oil leak for 12 months. After 4 failed repair attempts, the dealer used liquid sealer instead of a gasket. This is a deceptive repair that creates a severe fire hazard. The leak is still active today, March 2026."
Crash:
No
Fire:
No
Injuries:
0
Deaths:
0
#11727093March 25, 2026
UNKNOWN OR OTHER
The horn stops working when it’s cold and the horn installed does not match the amperage need for the vehicle. It has failed multiple times. I rarely use my horn. It failed for the first time around 20,000 miles. Separately, I have an oil leak that is also covered under warranty. This car has been serviced countless times and it has been in the shop for three weeks.
Crash:
No
Fire:
No
Injuries:
0
Deaths:
0
#11726814March 24, 2026
UNKNOWN OR OTHER
Air conditioning has never worked. It was purchased in the winter. As weather warmed, we noticed the air conditioning was never cold. Dropped it off at the dealership. Their first comment before looking at the vehicle was that a rock probably hit it and broke the air conditioning. After inspection they said it was a rock so it isn’t a warranty item. Seems suspicious. Possibly warranty fraud to try to get money from a consumer for a covered defect. If that’s the first thing they suggested was wrong, how often is this happening and is it fraud or a design defect.
Crash:
No
Fire:
No
Injuries:
0
Deaths:
0
#11726379March 23, 2026
POWER TRAIN, ENGINE
When accelerating, the car feels stuck to gear up. After 2 seconds of loud revving, it would switch and have a prominent jerk motion that it finally switched gears. There have been times the car wouldn't go past 30 mph, stuck at the gear making a loud noise. This is dangerous! There's absolutely no way I can get on the freeway never getting past 30ish mph. I checked recalls for this vehicle and there isn't any. No warning lights in the dash.
Crash:
No
Fire:
No
Injuries:
0
Deaths:
0
#11724831March 17, 2026
UNKNOWN OR OTHER, ELECTRICAL SYSTEM
Driver side passenger back sliding door will not open or close properly. Door will jam and make a loud noise or will not open when trying to open. Took it the dealership 4 times they replaced the motor but the issue continues.
Crash:
No
Fire:
No
Injuries:
0
Deaths:
0

← Back to Kia Carnival