Jeep Wrangler Complaints (2005)

650 consumer complaints on file.

#10992191May 30, 2017
FUEL/PROPULSION SYSTEM
WHEN PUTTING GAS INTO THE JEEP, THE NOZZLE DOES NOT AUTOMATICALLY SHUT OFF AND GAS OVERFLOWS OUT OF THE GAS LINE (AT THE POINT WHERE THE CAP GOES ON).
Crash:
No
Fire:
No
Injuries:
0
Deaths:
0
#10969703March 31, 2017
ENGINE
TL* THE CONTACT OWNS A 2005 JEEP WRANGLER. WHILE DRIVING, THE RPMS WOULD NOT INCREASE PAST 3,000 RPMS. THE VEHICLE WAS TAKEN TO THE DEALER WHERE IT WAS DIAGNOSED THAT THE OIL PUMP DRIVE NEEDED TO BE REPLACED. THE VEHICLE WAS REPAIRED, BUT THE FAILURE PERSISTED. THE MANUFACTURER WAS NOTIFIED OF THE FAILURE. THE FAILURE MILEAGE WAS 57,201.
Crash:
No
Fire:
No
Injuries:
0
Deaths:
0
#10953844February 10, 2017
SERVICE BRAKES
WHEN THE EMERGENCY/ PARKING BRAKE IS ON THE CAR WILL STILL ROLL. VERY DANGEROUS FOR ANYONE NEAR IT . CANNOT PARK ON ANY HILL AND MUST ALWAYS PARK ON FLAT SURFACES OR THE JEEP WILL ROLL DOWN THE HILL. THIS IS HOW IT HAS BEEN AN ONGOING PROBLEM SINCE I GOT THE JEEP INTO 2005. ALMOST RAN OVER ONE OF MY KIDS THE OTHER DAY BECAUSE OF THIS.
Crash:
No
Fire:
No
Injuries:
0
Deaths:
0
#10940289January 7, 2017
FUEL/PROPULSION SYSTEM
WHEN FILLING UP THE GAS TANK, GASOLINE ROUTINELY BACK FLOWS AS IT GETS FULL. THIS CAUSES GASOLINE TO SPILL OVER THE FUEL FILLER DOOR AND DOWN THE SIDE OF THE VEHICLE. I HAVE HAD THE VEHICLE FOR THREE YEARS AND SINCE 51K MILES WERE ON IT. THIS ALWAYS HAPPENS WHEN REFUELING.
Crash:
No
Fire:
No
Injuries:
0
Deaths:
0
#10937162December 22, 2016
ENGINE
THIS SPECIFIC PART WAS RECALLED ELEVEN OR SO YEARS AGO. SINCE THAT TIME, THE SAME PART HAS BEEN REPLACED 6 TIMES. ONE TIME REQUIRING A TOTAL ENGINE OVERHAUL. UPON RESEARCHING THIS PART, I HAVE FOUND THAT THERE ARE MANY COMPLAINTS WITH THE FAILURE OF THIS SAME MODEL YEAR OF JEEP WRANGLERS AND THIS PART (OIL PUMP DRIVE). WE HAVE POURED OVER $5000 INTO THIS VEHICLE DUE TO THIS PART AND WE STILL HAVE A VEHICLE THAT DOES NOT RUN. I HAVE CALLED JEEP THREE TIMES NOW AND THEY HAVE NO ADVICE FOR ME OR OFFER OF ASSISTANCE FOR THIS PART. ENGINE LOCKED UP WHILE DRIVING DOWN THE HIGHWAY. *TR
Crash:
No
Fire:
No
Injuries:
0
Deaths:
0
#10936410December 20, 2016
STEERING
THIS IS AN UPDATE TO NHTSA COMPLAINT 10919986 - DEATH WOBBLE, I HAVE REPLACED THE STOCK STEERING DAMPER AND ADDED AN ADDITIONAL STEERING DAMPER FOR THE DRIVER SIDE STEERING ROD. THIS HAS RESOLVED THE REPORTED DEATH WOBBLE WHEN DRIVING OVER 50 MPH. ROD DEFLECTION HAS BEEN PREVENTED BY ADDING THE DRIVER SIDE DAMPER. PLEASE MAKE THIS AVAILABLE AS A SOLUTION. I SEE MANY PEOPLE HAVE SPENT WELL OVER $1,000 FOR NEW SUSPENSION PARTS ETC. THIS IS A $60 STEERING DAMPER SHOCK FIX!! PLEASE PASS ALONG. I SHOCKED THIS IS NOT OBVIOUS AT THE DEALER, THE DRIVER STEERING ROD IS LONG AND WILL HAVE DEFLECTION AT HIGH SPEED/BUMPS, LIKE A TUNING FORK. *TR
Crash:
No
Fire:
No
Injuries:
0
Deaths:
0
#10936416December 20, 2016
ENGINE
THIS IS AN UPDATE TO NHTSA COMPLAINT 10919983 - REGARDING CHRYLSER E05 CAMPAIGN CAMSHAFT REPLACEMENT - I STILL NEED A NEW CAMSHAFT BUT HAVE PERFORMED A TEMPORARY FIX IN REPLACING THE OPDA. THE NEW GEAR ON THE OPDA HAS PREVENTED ENOUGH WEAR GAP FOR THE ENGINE TO NOT GO INTO LIMP MODE AND WILL START IMMEDIATELY WHEN TEMPS ARE UNDER 40 DEGREES F. I STILL NEED A NEW CAMSHAFT TO COMPLETE THIS FIX. I MAY TRY THE CHRYSLER CUSTOMER SERVICE TO RESOLVE, BUT THE E05 RECALL DOES NOT COVER MY MANUFACTURE DATE AND THE CAMPAIGN HAS BEEN CLOSED. I AM STUCK WITH A USED LEMON! BUYER BEWARE OF THIS MODEL YEAR, THERE IS A CAMSHAFT GEAR ISSUE THAT WILL PREVENT ENGINE TIMING TO RUN CORRECTLY AND ABILITY TO PASS EMISSIONS! CODES P340 AND P344 PLUS ENGINE WILL NOT REV BEYOND 2500RPM (LIMP MODE) ARE THE TELL TALE SIGNS. A NEW OPDA IS WORTH A TRY TEMPORARY FIX $80. BUT DO NOT BUY THIS YEAR OR 2004, 2006 WITHOUT CHECKING IF CAMSHAFT HAS BEEN REPLACED, OR PLAN ON DOING SOME MAJOR ENGINE WORK/ENGINE REBUILD.
Crash:
No
Fire:
No
Injuries:
0
Deaths:
0
#10923953November 3, 2016
FUEL/PROPULSION SYSTEM
GAS OVERFLOWS AND SPILLS OUT OF VEHICLE WHEN FUELING.
Crash:
No
Fire:
No
Injuries:
0
Deaths:
0
#10919983October 29, 2016
ENGINE
ENGINE CODES P0340 AND P0344 CHRYSLER CAMPAIGN E05 REPLACE OPDA AND CAMSHAFT - MY MANUFACTURE DATE IS JUNE 2005, THERE IS 113K ON THE ENGINE, WHEN THE WEATHER IS COLD (40 F OR BELOW) THE ENGINE HAS LONG START ISSUES, THERE IS PLAY IN THE OPDA ENOUGH TO PUT THE ENGINE IN LIMP MODE NOT REVVING PAST 2500RPM. FOR SURE THIS NEEDS A NEW CAMSHAFT AND NEW OPDA, BOTH GEARS ARE WORN. THE CHRYSLER CAMPAIGN ONLY COVER UP TO A FEB 2005 MANUFACTURE. THIS SHOULD BE CONSIDERED FOR ADDITIONAL MANUFACTURE DATES WITH MULTIPLE COMPLAINTS ON NHTSA ABOUT THIS ISSUE.
Crash:
No
Fire:
No
Injuries:
0
Deaths:
0
#10919986October 29, 2016
STEERING, SUSPENSION
JEEP DEATH WOBBLE - MINE TOO, OVER 50 MPH, RANDOM WOBBLE OTHER TIMES DRIVES SMOOTH, BUMPS DO INITIATE IT NOT ALWAYS THOUGH, READ ALL THE COMPLAINTS ON NHTSA, STABILIZER IS KEY TO RESOLVING THE ISSUE AND STEERING DAMPER. I BELIEVE THIS DESIGN PROMOTES ACCELERATED WEAR OF THESE PARTS WHICH IS WHY THERE ARE REPORTS OF IT COMING BACK AFTER A YEAR OR SO. I'M SURPRISED THERE IS NO DEALER FIX FOR THIS, ADMITTING THE NEED FOR HEAVIER STEERING COMPONENTS. I'LL BE GETTING AFTER MARKET HEAVY DUTY JUST TO DRIVE ON THE STREET. THE FUEL ISSUE IS ANOTHER ONE THAT SHOULD BE RECALLED, HAD TO GO THROUGH 300 PLUS ENTRIES HERE TO FIND ANSWERS TO THE OPDA PROBLEM. MINE HAS NOT STARTED WITH THE FUEL ISSUE BUT AT LEAST I WILL KNOW WHAT IT IS WHEN IT DOES OCCUR.
Crash:
No
Fire:
No
Injuries:
0
Deaths:
0
#10919720October 27, 2016
STEERING
JEEP HAS SEVERE DEATH WOBBLE WHEN TRAVELING @60 MPH. FRONT WHEELS WILL START TO VIBRATE VIOLENTLY AT THIS SPEED AND SEEMS TO START WHEN HITTING A BUMP OR IMPERFECTION IN ROAD SURFACE. REQUIRED ACTION IS TO APPLY BRAKES UNTIL SHAKING STOPS WHICH COULD INVOLVE A DECREASE IN SPEED OF 15 MPH OR MORE CREATING A DANGEROUS SITUATION ESPECIALLY IN HEAVY TRAFFIC. I HAVE HAD VEHICLE INSPECTED AT THREE SHOPS WITH NO WORN COMPONENTS FOUND. HAD AN ALIGNMENT PERFORMED TIRES BALANCED TRACK BAR MOUNT REPLACED CONTROL ARM MOUNT REINFORCED REPLACED STEERING STABILIZER REPLACED TIE ROD END REPLACED SWAY BAR LINKS AND STILL PROBLEM IS NO BETTER. JEEP ONLY HAS 49,000 MILES SO NOTHING IS REALLY WORN TOO BAD. THIS PROBLEM STARTED ROUGHLY 10,000 MILES AGO AND I AM NOT SURE WHAT TO DO NEXT OTHER THAN REPLACING EVERY STEERING AND SUSPENSION COMPONENT AT A COST OF PROBABLY A COST OF THOUSANDS OF DOLLARS. FROM WHAT I HAVE READ THIS IS A COMMON PROBLEM WITH THE COIL SPRUNG JEEPS WITH A TRACK BAR WHICH SEEMS TO BE A DESIGN FLAW. JUST WANT TO ADD THE VEHICLE IS A SAFETY HAZARD DUE TO THE FACT YOU NEVER KNOW WHEN THE WOBBLE WILL START AND IF YOU ARE IN HEAVY TRAFFIC AND ALL OF A SUDDEN YOU HAVE TO SLAM ON THE BRAKES TO REGAIN CONTROL OF YOUR VEHICLE IT COULD BE A VERY DANGEROUS SITUATION. CHRYSLER/JEEP NEEDS TO REMEDY THIS ENGINEERING FLAW NOT EXPECT CONSUMERS TO FOOT THE BILL.
Crash:
No
Fire:
No
Injuries:
0
Deaths:
0
#10913847October 4, 2016
FUEL/PROPULSION SYSTEM
WHEN HAVING TO FILL UP ON GAS IT IS OVERFLOWING. EVEN IF YOU SET THE CONTROL ON THE PUMP, WHEN YOU PULL OUT THE NOZZLE, GAS IS SPILLING ALL OVER THE JEEP, FLOOR AND HAS EVEN HAS SPILLED ALL OVER MYSELF. THIS FULL TANK NEEDS TO BE RECALLED FOR THE SAFETY OF ALL CONSUMERS.
Crash:
No
Fire:
No
Injuries:
0
Deaths:
0
#10904484September 7, 2016
AIR BAGS, WHEELS
TL* THE CONTACT OWNED A 2005 JEEP WRANGLER. WHILE DRIVING VARIOUS SPEEDS, THE FRONT DRIVER SIDE WHEEL FRACTURED AND THE DRIVER LOST CONTROL OF THE VEHICLE. THE DRIVER CRASHED INTO A CULVERT. THE VEHICLE ROLLED OVER AND LANDED ON ITS ROOF IN A DITCH. THE DRIVER SIDE AIR BAGS DID NOT DEPLOY. A POLICE REPORT WAS FILED. THE DRIVER SUSTAINED FATAL INJURIES TO THE HEAD. THE PASSENGER WAS ALSO FATALLY INJURED. THE MANUFACTURER WAS NOT NOTIFIED OF THE FAILURE. THE VEHICLE WAS DESTROYED AND TOWED. THE VIN AND FAILURE MILEAGE WERE NOT AVAILABLE. ...UPDATED 10/19/16 *BF .. ..UPDATED 03/31/17 *BF ...UPDATED 04/11/17 *BF UPDATED 08/08/2017*JS UPDATED 09/19/2017*JS *TR
Crash:
Yes
Fire:
No
Injuries:
2
Deaths:
2
#10874959June 18, 2016
FUEL/PROPULSION SYSTEM
AS THE FUEL TANK IS BEING FILLED WITH FUEL AND THE FUEL PUMP CUTS OFF WHEN THE TANK IS FULL, THE TANK ALLOWS A SIGNIFICANT AMOUNT OF FUEL TO BE "BURPED" OUT OF THE FUEL FILLER ONTO THE VEHICLE, GROUND, AND THE PERSON FILLING THE VEHICLE. THIS OCCURS EVERY TIME THE TANK IS FILLED AT EVERY FUEL DEPOT.
Crash:
No
Fire:
No
Injuries:
0
Deaths:
0
#10862847May 3, 2016
ELECTRONIC STABILITY CONTROL (ESC), VEHICLE SPEED CONTROL, STEERING
'DEATH WOBBLE" THE JEEP SHAKES UNCONTROLLABLY BETWEEN 50 AND 55 MPH MAKING SPEED AND STEERING VERY HARD TO CONTROL. NO ONE SEEMS TO KNOW WHAT CAUSES IT. BEEN TO MANY JEEP MECHANICS.
Crash:
No
Fire:
No
Injuries:
0
Deaths:
0
#10855093April 12, 2016
FUEL/PROPULSION SYSTEM
WHEN FILLING FUEL TANK, FUEL COMES OUT WITHOUT WARNING AND SPILLS ALL OVER THE GROUND AND THE VEHICLE. WHEN ADJACENT TO A HOT BRAKE CALIPER, THIS COULD CREATE A FIRE HAZARD. ABOUT A PINT OF FUEL IS SPILLED WITH EVERY FILL-UP. IF THE OPERATOR TRIES TO LISTEN FOR THE FUEL TO COME UP THE FILLER TO STOP, THERE IS A SPLASH AND EYE HAZARD.
Crash:
No
Fire:
No
Injuries:
0
Deaths:
0
#10855084April 12, 2016
ENGINE
WAS CROSSING A BUSY 4-LANE ST RT WHEN THE THROTTLE CABLE CAME APART AND PROPULSION WAS LOST. NEARLY GOT T-BONED BY ONCOMING TRAFFIC. A MULTI-CAR PILEUP WAS NARROWLY AVERTED. VEHICLE HAS ONLY 85,000 MILES. THROTTLE CABLE FRAYED JUST INSIDE THE FIREWALL IN THE PASSENGER COMPARTMENT. IT HAS NO HISTORY OF ACCIDENTS OR REPAIRS ON THIS ASSEMBLY. NO WARNING. VERY SCARY EXPERIENCE. STRANDED IN THE MIDDLE OF THE ROAD, PERPENDICULAR TO TRAFFIC.
Crash:
No
Fire:
No
Injuries:
0
Deaths:
0
#10854233April 7, 2016
FUEL/PROPULSION SYSTEM
ALSO FUEL TANK OVERFLOW SHUTOFF VALVE DOES NOT WORK. WHEN FILLING UP GAS TANK, FUEL OVERFLOWS ON CAR AND PERSON PUMPING GAS EVERY TIME THE TANK IS FILLED. MULTIPLE YEARS OF JEEP WRANGLERS WERE RECALLED, INCLUDING MANY 05'S FOR THIS SAME PROBLEM.
Crash:
No
Fire:
No
Injuries:
0
Deaths:
0
#10854232April 7, 2016
POWER TRAIN
VEHICLE WILL NOT SHIFT INTO 3RD GEAR. THIS STARTED WHILE DRIVING THE VEHICLE IN TOWN AND NOW ONLY RUNS IN 1ST AND 2ND GEAR. DIAGNOSTIC CODE P0765 (SHIFT SOLENOID D) IS THE ONLY CODE SHOWING. OTHER (03-05) JEEPS WERE RECALLED FOR THE SAME PROBLEM.
Crash:
No
Fire:
No
Injuries:
0
Deaths:
0
#10852031March 28, 2016
FUEL/PROPULSION SYSTEM
TL* THE CONTACT OWNS A 2005 JEEP WRANGLER. WHILE PUMPING FUEL INTO THE VEHICLE, FUEL SPEWED OUT. THE FAILURE RECURRED NUMEROUS TIMES. THE VEHICLE WAS TAKEN TO A DEALER WHERE IT WAS DIAGNOSED THAT THE ROLLOVER CHECK VALVE NEEDED TO BE REPLACED. THE VEHICLE WAS NOT REPAIRED. THE MANUFACTURER WAS NOTIFIED OF THE FAILURE. THE APPROXIMATE FAILURE MILEAGE WAS 54,000. THE VIN WAS UNKNOWN.
Crash:
No
Fire:
No
Injuries:
0
Deaths:
0

← Back to Jeep Wrangler