Hyundai Santa Fe Complaints (2005)

216 consumer complaints on file.

#10554266December 1, 2013
POWER TRAIN, FUEL SYSTEM, GASOLINE, ELECTRICAL SYSTEM, ENGINE
STARTED ENGINE. PLACED THE AUTOMATIC TRANSMISSION SELECTION INTO REVERSE. THE ENGINE IMMEDIATELY HAD AN UNINTENDED ACCELERATION TO PERHAPS 2500 RPM. OPERATOR IMMEDIATELY APPLIED VERY HEAVY PRESSURE ON THE BRAKE PEDAL TO STOP ANY REAR DIRECTION MOVEMENT. OPERATOR IMMEDIATELY MOVED THE SHIFT LEVER BACK TO THE PARK POSITION, SHUT OFF THE IGNITION AND RESTARTED THE VEHICLE. AFTER RESTARTING, EVERYTHING WAS BACK TO NORMAL. THIS HAD ALSO OCCURRED ONE OTHER TIME IN SEPTEMBER, 2013 UNDER THE SAME CIRCUMSTANCES. OPERATOR INITIALLY ASSUMED THAT PERHAPS HIS FOOT HAD MOVED TO THE RIGHT AND WAS DEPRESSING BOTH THE ACCELERATOR AND THE BRAKE AT THE SAME TIME, BUT WHEN ATTEMPTING TO SEE IF THIS COULD BE DONE, OPERATOR COULD NOT REPLICATE. IT IS ASSUMED THE THROTTLE SENSOR LOCATOR MAY BE FAULTY. VERY DISTURBING WHEN THIS HAPPENS AND COULD EASILY RESULT IN PROPERTY OR PERSONAL DAMAGE.. *TR
Crash:
No
Fire:
No
Injuries:
0
Deaths:
0
#10552964November 19, 2013
FUEL SYSTEM, GASOLINE
TL* THE CONTACT OWNS A 2005 HYUNDAI SANTA FE. THE CONTACT STATED THAT WHILE DRIVING 55 MPH, HE SMELLED GASOLINE. THE CONTACT DISCOVERED THAT FUEL WAS LEAKING FROM UNDER THE VEHICLE. THE CONTACT TOOK THE VEHICLE TO THE DEALER, WHO REPLACED THE FUEL TANK DUE TO EXCESSIVE CORROSION. THE CONTACT INFORMED THE MANUFACTURER OF THE PROBLEM. THE FAILURE MILEAGE WAS 76,264. UPDATED 12/20/13*CN
Crash:
No
Fire:
No
Injuries:
0
Deaths:
0
#10551615November 9, 2013
AIR BAGS
ME AND MY 5 MONTH OLD SON GOT INTO AN ACCIDENT IN OUR 2005 SANTA FE...FRONT END COLLISION. THE OTHER VEHICLE IS TOTALED AND MY AIR BAGS NEVER DEPLOYED WHEN THEY DEFINITELY SHOULD HAVE. I SMASH MY HEAD DUE TO THE AIR BAGS NOT DEPLOYING BUT EVERYONE ELSE WAS SAFE!! *TR
Crash:
Yes
Fire:
No
Injuries:
0
Deaths:
0
#10545690September 27, 2013
SEAT BELTS, AIR BAGS, SEATS
THE AIRBAG LIGHT IS ON WHICH WAS DIAGNOSED BY THE DEALER THAT I WOULD HAVE TO REPLACE THE DRIVER SEAT BELT, AND COMPUTER PARTS IN ORDER TO RESET THE AIRBAG LIGHT. THE AIRBAG LIGHT IS ALWAYS ON AND EVENTHOUGH I WEAR MY SEAT BELT THE SYMBOL AND BEEPING NOISE COMES ON STATING I DO NOT HAVE MY SEATBELT ON. THE COST TO FIX THIS PROBLEM IS OVER $500.00. ALSO, THE DRIVER SEAT BELTS HAVE WORN AWAY WHICH HAS DAMAGED MY CLOTHING. *TR
Crash:
No
Fire:
No
Injuries:
0
Deaths:
0
#10526286July 23, 2013
AIR BAGS
THE RED AIRBAG LIGHT BEGAN TO INTERMITTENTLY TURN ON/OFF FOR NO APPARENT REASON. WHEN AN OCCUPANT IS IN THE FRONT SEAT, THE LIGHT IS GENERALLY OFF, BUT IF THE OCCUPANT MOVES OR CHANGES HIS/HER POSITION IN THE FRONT SEAT, THE LIGHT WOULD ACTIVATE AGAIN, IF ONLY FOR A FEW SECONDS. THE AIRBAG LIGHT IS NOW ON AT ALL TIMES AND WILL NOT SHUT OFF. *TR
Crash:
No
Fire:
No
Injuries:
0
Deaths:
0
#10524970July 15, 2013
AIR BAGS, SEAT BELTS
TL* THE CONTACT OWNS A 2005 HYUNDAI SANTA FE. THE CONTACT STATED THAT THE OCCUPANT RESTRAINT SYSTEM FAILED. THE CONTACT TOOK THE VEHICLE TO THE DEALER AND WAS TOLD THAT THE SENSOR OF THE SEAT BELT THAT CONNECTED TO THE AIR BAG HAD FAILED. THE CONTACT ASKED IF THE FAILURE WAS THE SAME AS THAT LISTED IN NHTSA CAMPAIGN ID NUMBER: 05V450000 (AIR BAGS). THE CONTACT WAS TOLD THAT ALTHOUGH THE FAILURES WERE THE SAME, THE VEHICLE WAS NOT INCLUDED IN THE RECALL CAMPAIGN. THE FAILURE MILEAGE WAS UNKNOWN, BUT THE CURRENT MILEAGE WAS 95,000. *TR
Crash:
No
Fire:
No
Injuries:
0
Deaths:
0
#10520331June 17, 2013
SUSPENSION
DRIVING DOWN THE HIGHWAY A LOUD BANG WAS HEARD. DISCOVERED THE DRIVER FRONT COIL SPRING HAD BROKEN. FORTUNATELY NO DAMAGE TO THE TIRE. I AM SURPRISED BY THE AMOUNT OF SIMILAR FAILURES REPORTED. THIS CERTAINLY COULD HAVE BEEN MUCH WORSE. I AM A BIT CONCERNED THAT HAS NOT BEEN INVESTIGATED! *TR
Crash:
No
Fire:
No
Injuries:
0
Deaths:
0
#10512220May 15, 2013
AIR BAGS
TL* THE CONTACT OWNS A 2005 HYUNDAI SANTA FE. THE CONTACT STATED THAT THE AIR BAG WARNING LAMP ILLUMINATED. THE VEHICLE WAS TAKEN TO THE DEALER. THE TECHNICIAN DIAGNOSED THAT THE OCS SENSOR ON THE PASSENGER'S SIDE WAS DEFECTIVE AND NEEDED TO BE REPLACED. THE MANUFACTURER WAS MADE AWARE OF THE FAILURE. THE VEHICLE WAS NOT REPAIRED. THE FAILURE MILEAGE WAS 47,300 AND THE CURRENT MILEAGE WAS 47,411. *TR UPDATED 07/16/13*LJ
Crash:
No
Fire:
No
Injuries:
0
Deaths:
0
#10509062April 22, 2013
ENGINE
WHEN I'M STARTING UP FROM A STOPPED POSITION, THE CAR JERKS FORWARD AS IF I HAVE "FLOORED IT." I AM A REALTOR AND DRIVE 100'S OF MILES A WEEK. THIS HAPPENS AT LEAST TWICE A DAY, ON AVERAGE. *TR
Crash:
No
Fire:
No
Injuries:
0
Deaths:
0
#10508781April 19, 2013
SUSPENSION, SERVICE BRAKES, HYDRAULIC
DRIVING HOME FROM WORK, ON A MAJOR LOCAL INTERSTATE, MY CHECK BRAKE LIGHT APPEARED ON MY DASHBOARD. I PRESSED THE BRAKE PEDAL TO SLOW THE CAR DOWN, BUT FOUND OUT THAT THE BRAKE PEDAL HAD GONE SOFT AND I ENDED UP HAVING TO PUSH THE PEDAL ALL THE WAY TO THE FLOORBOARD TO GET ANY RESISTANCE. I MANAGED TO DRIVE IT TO THE HYUNDAI DEALERSHIP A MILE AWAY WHERE THEY REALIZED THAT THE BRAKE FLUID WAS EMPTY DUE TO A RUPTURED SEAL IN THE BRAKE CALIBER ON THE PASSENGER SIDE. UPON FURTHER INSPECTION, THEY FOUND THAT BOTH FRONT SUSPENSION COIL SPRINGS WERE DAMAGED. THE PASSENGER SIDE COIL HAD LITERALLY SNAPPED IN HALF AND THE DRIVER'S SIDE COIL WAS DISLOCATED AND BROKEN. MY CAR HAD JUST BEEN IN THE SAME DEALERSHIP ONE WEEK PRIOR HAVING A NEW TRANSMISSION INSTALLED IN IT (UNDER WARRANTY). AS NO LOUD BANG OR NOISE OCCURRED AS WITH THE MANY OTHERS THAT HAVE HAD THIS HAPPEN TO THEM, I CAN ONLY ASSUME THE COILS BROKE OR SHIFTED DURING THE TRANSMISSION REPLACEMENT WHEN THE WEIGHT OF THE CAR WAS ON THE LIFT, AND NOT ON THE SUSPENSION. THE GROSS NEGLIGENCE THAT NEITHER OF THESE COILS WERE FOUND BROKEN AT THAT TIME HAS ME INCENSED. THE FACT THAT A SOLID STEEL COIL THAT TAKES 4,000LBS TO COMPRESS CAN BREAK IN HALF LIKE THAT IS DISTURBING. I ASSUME THAT WITHOUT THE SUSPENSION, DUE TO THE BROKEN COILS, THE BRAKES SUFFERED DAMAGE AND THE ABOVE INCIDENT OCCURRED. I WAS VERY LUCKY INDEED THAT NOTHING WORSE HAPPENED, BUT AS THIS IS A RECURRENT ISSUE WITH THE HYUNDAI COIL SUSPENSION AND IT SHOULD BE ADDRESSED THROUGH A RECALL. PICTURES ARE AVAILABLE OF THE DAMAGE, AS ARE THE SUSPENSION COILS (WE SAVED EVERYTHING). *TR
Crash:
No
Fire:
No
Injuries:
0
Deaths:
0
#10500947March 1, 2013
VEHICLE SPEED CONTROL, AIR BAGS, ENGINE, STRUCTURE:BODY
MY MOMS SANTA FE HAS SPED OUT OF CONTROL SEVERAL TIMES IN THE LAST THREE MONTHS. THE LAST INCIDENT CAUSED INJURIES BECAUSE THE AIR BAG FAILED TO DEPLOY. THE FIRST INCIDENT WAS IN A PARKING LOT WHERE THE CAR HAD UNINTENDED ACCELERATION AND CRASHED INTO SEVERAL CARS. SECOND INCIDENT WAS ON THE ROAD WHERE CAR SPED UP AND SHE TURNED IT OFF. THE THIRD WAS BACKING OUT OF A SHOPPING CENTER PARKING LOT WHERE THE CAR RAPIDLY ACCELERATED IN REVERSE HITTING A CAR AND THEN TRIED TO PUT IN NEUTRAL BUT WENT INTO DRIVE INSTEAD. SHE HIT A POST AND THE FRONT END WRAPPED AROUND THE POST BUT AIR BAG DID NOT DEPLOY CAUSING INJURY. STATE FARM AND MANY ATTORNEYS WON'T TOUCH THIS CASE BECAUSE OF THE COSTS INVOLVED TO SUE SUCH A LARGE CORPORATION. *TR
Crash:
Yes
Fire:
No
Injuries:
1
Deaths:
0
#10499592February 21, 2013
SUSPENSION
FRONT DRIVER SIDE COIL SPRING SNAPPED DAMAGING FRONT STRUT. THERE HAVE BEEN NUMEROUS SIMILAR COMPLAINTS OF PREMATURE UNEXPECTED BREAKAGE THAT HAS RESULTED IN SUDDEN TIRE PUNCTURE WHEN THE SPRING HITS THE TIRE. THIS IS A VERY SERIOUS LIFE THREATENING FLAW. HYUNDAI HAS NOT INITIATED A RECALL BUT SHOULD. I WAS VERY LUCKY THAT THIS FAILURE OCCURRED AT A LOW SPEED. *TR
Crash:
No
Fire:
No
Injuries:
0
Deaths:
0
#10498255February 15, 2013
SERVICE BRAKES
TL* THE CONTACT OWNS A 2005 HYUNDAI SANTA FE. THE CONTACT STATED THAT THE BRAKE WARNING LIGHT ILLUMINATED ON THE INSTRUMENT PANEL. THE CONTACT WAS PREVIOUSLY INVOLVED IN A CRASH THAT WAS UNRELATED TO THE BRAKING SYSTEM HOWEVER, AFTER THE VEHICLE WAS REPAIRED FOLLOWING THE CRASH, THE CONTACT WAS ADVISED THAT THE BRAKES NEEDED TO BE ADJUSTED BECAUSE AFTER BLEEDING THE BRAKES, THE BRAKE PEDAL ABNORMALLY TRAVELED TO THE FLOORBOARD. THE CONTACT WAS OT AWARE OF THE EXACT REPAIR NEEDED TO CORRECT THE FAILURE. THE VEHICLE WAS NOT REPAIRED. THE VIN WAS NOT AVAILABLE. THE FAILURE AND THE CURRENT MILEAGE WAS 48,000. ## VIN FAILED ##
Crash:
No
Fire:
No
Injuries:
0
Deaths:
0
#10492501January 8, 2013
SUSPENSION
STARTED VEHICLE, PLACED IN REVERSE, SUSPENSION COIL ON FRONT DRIVERS SIDE BROKE, PUNCTURED NEW TIRE, AND BROKE STRUT. HAVE RESEARCHED ONLINE AND FOUND THIS TO BE HAPPENING ACROSS THE COUNTRY WITH THE 2005 SANTA FE. UNFORTUNATELY, IT'S NOT BEING REPORTED TO THE RIGHT PLACE. THIS COULD BE A DEADLY SITUATION IF HAPPENS WHILE DRIVING.
Crash:
No
Fire:
No
Injuries:
0
Deaths:
0
#10490271December 27, 2012
SERVICE BRAKES
BOTH FRONT AND REAR BRAKES HAVE BEEN REPAIRED WITHIN LAST 6 OR 7 MONTHS; HOWEVER, FRONT BRAKES PULSATE (LIKE ABS IS ENGAGING) WHEN BRAKING AT LOW SPEEDS FOR THE PAST SEVERAL MONTHS EVEN BEFORE AND AFTER BRAKE REPAIRS. ON DEC 21, 2012, I DROPPED OFF MY GRANDSON AT SCHOOL AND WENT TO PARK ON A STREET NEXT TO THE SCHOOL. THE FRONT BRAKES PULSATED WHEN BRAKING TO PARK (ABOUT 4 MILES PER HOUR) AND THEN THE BRAKE PEDAL WENT ALL THE WAY TO THE FLOOR AND I LOST ALL BRAKING POWER -- COASTED TO A STOP (ABOUT 10 FEET). I SUSPECT THE ABS CONTROL MODULE IS BAD FOR SOME OF THE 2005 MODELS. THE 2003 AND 2004 YEAR MODEL ABS CONTROL MODULES HAVE BEEN RECALLED BUT APPARENTLY NOT FOR THE 2005 MODEL YEARS. *TR
Crash:
No
Fire:
No
Injuries:
0
Deaths:
0
#10482310October 26, 2012
VEHICLE SPEED CONTROL
TL*THE CONTACT OWNS A 2005 HYUNDAI SANTA FE. THE CONTACT STATED THAT WHILE SITTING AT A TRAFFIC LIGHT, THE VEHICLE ACCELERATED INDEPENDENTLY. THE CONTACT SHIFTED THE VEHICLE INTO PARK AND THE VEHICLE STOPPED. THE VEHICLE WAS NOT TAKEN TO THE DEALER FOR INSPECTION. THE VEHICLE WAS NOT REPAIRED. THE MANUFACTURER WAS NOT NOTIFIED. THE FAILURE MILEAGE WAS 30,000.
Crash:
No
Fire:
No
Injuries:
0
Deaths:
0
#10473699September 4, 2012
AIR BAGS
TL* THE CONTACT OWNS A 2005 HYUNDAI SANTA FE. THE CONTACT STATED THAT WHILE PARKED THE AIR BAG WARNING LIGHT ILLUMINATED ON THE INSTRUMENT PANEL. THE CONTACT INSPECTED THE VEHICLE. THE CONTACT STATED THAT THE DRIVERS SIDE AIR BAG SWITCH WAS DEFECTIVE AND NEEDED TO BE REPLACED. THE VIN WAS NOT AVAILABLE. THE VEHICLE WAS NOT REPAIRED. THE APPROXIMATE FAILURE MILEAGE WAS 24,000. UPDATED 10/31/12 *CN UPDATED 11/08/2012 *JS
Crash:
No
Fire:
No
Injuries:
0
Deaths:
0
#10471962August 22, 2012
AIR BAGS
THERE IS A RED LIGHT FOR THE AIRBAG. I CALLED HYUNDAI DEALER. THEY ADVISED IT IS PROBABLY A SENSOR. I AM CONCERNED THE AIRBAG COULD DEPLOY BUT THEY "DO NOT THINK" THAT WILL HAPPEN. IT MAY BE EXPENSIVE TO FIX DEPENDING IF THIS IS A SENSOR IN THE SEAT BELT OR STEERING WHEEL. THEY ADVISED THERE IS NO CURRENT RECALL SO I WOULD HAVE TO PAY FOR THIS TO BE FIXED. I BELIEVE THIS IS POTENTIALLY DANGEROUS. OTHER YEARS OF THIS MODEL VEHICLE HAD SAME PROBLEM. *TR
Crash:
No
Fire:
No
Injuries:
0
Deaths:
0
#10469434August 6, 2012
AIR BAGS, SEAT BELTS
WE OWN A 2005 SANTA FE BY HYUNDAI. WE HAVE BEEN READING BLOGS ABOUT THE AIR BAG LIGHT BEING ILLUMINATED AS A RESULT OF THE SEAT BELT SENSOR GOING BAD ON THESE VEHICLES AND NOT DEPLOYING IN THE CASE OF AN ACCIDENT. OURS IS NOW DEMONSTRATING THIS. THE RED AIR BAG LIGHT WILL REMAIN ILLUMINATED AND THE ISSUE AFTER BEING RUN THROUGH A DIAGNOSTIC AT A LOCAL DEALERSHIP WAS AS EXPECTED TIED TO A SEAT BELT SENSOR ISSUE. I KNOW THAT THERE ARE MORE OF THESE ISSUES AND SOME HAVE ACTUALLY WON CASES DEALING ON AN INDIVIDUAL LEVEL WITH HYUNDAI OF AMERICA WHICH IS WHAT WE INTEND TO DO, BUT IF THIS IS SUCH A RAMPANT ISSUE, THERE SHOULD BE A FURTHER INVESTIGATION DONE AND A VOLUNTARY RECALL ON THEIR PART TO ASSURE THAT THE AIR BAGS ARE DEPLOYABLE AT ALL TIMES AND NOT JUST WHILE THE CAR IS UNDER WARRANTY. *TR
Crash:
No
Fire:
No
Injuries:
0
Deaths:
0
#10468754August 1, 2012
VEHICLE SPEED CONTROL, AIR BAGS
MY MOTHER DIED IN A VEHICLE ACCIDENT WITH NO OTHER VEHICLES INVOLVED. HER SANTA FE WENT THROUGH A "T" INTERSECTION WITHOUT STOPPING CROSSING HIGHWAY, WENT AIRBORNE OVER HILLSIDE AND STRUCK A TREE. SEVERED SPINE, CHEST TRAUMA AND SHATTERED ANKLE. THERE ARE NO SKIDS MARKS AT THE SCENE AIRBAGS WERE DEPLOY BUT WHEN? STEERING COLUMN IS CRUSHED IN AND STEERING WHEEL WAS BENT INWARD. THE ROAD SHE WAS ON IS A RESIDENTIAL SIDE STREET. THERE IS A 100 FEET DOWNGRADE BUT STRAIGHT AS YOU APPROACH THE STOP SIGN. THE "T" INTERSECTION IS A TWO LANE NOT WELL TRAVELED ROAD. SHE DROVE THIS ROAD MANY TIMES BEFORE. WHAT MAKES A VEHICLE TRAVEL AT A HIGH RATE OF SPEED IN A 100 FEET STRAIGHT AWAY, GO THROUGH A STOP SIGN GET AIRBORNE AFTER CROSSING HIGHWAY? ACCELERATION STICKING? WHY IS THERE SO MUCH DAMAGE TO STEERING COLUMN IF AIRBAG WENT OFF? COULD THE ACCELERATOR GET STUCK AND MY MOTHER PANIC AND TRIED TO STOP CAR BY STEPPING ON BRAKES MAKING A PANIC DECISION, NOT KNOWING TO TAKE VEHICLE OUT OF GEAR OR TURNING VEHICLE OFF? WAS THERE ENOUGH TIME. I LOST MY MOTHER AND AFTER READING ALL THE PROBLEMS, I THINK THESE AND ALL HYUNDAI VEHICLES SHOULD BE LOOKED AT! *TR
Crash:
Yes
Fire:
No
Injuries:
0
Deaths:
1

← Back to Hyundai Santa Fe