Hyundai Santa Fe Complaints (2017)

972 consumer complaints on file.

#11434327September 25, 2021
ENGINE
Even though my check engine light wasn’t on my vehicle began to stall while I was merging on a major highway. A mile later the car began to smoke from behind made a weird noise and it completely stopped. Me and my 7 yr old stayed stranded on the shoulder of a highway while semis whizzed by at 80 mph. Called roadside assistance but no longer covered so couldn’t be helped while me and my families life was in danger. Case manager at the national office rude unsympathetic and hung up on me. My car is still with the dealer even though it is under warranty and has been with the dealer since September 8,2021 every time I call they give me the run around as I pay $1200 for a rental because they refuse to provide me with one.
Crash:
No
Fire:
No
Injuries:
0
Deaths:
0
#11434003September 23, 2021
ENGINE
The contact owns a 2017 Hyundai Santa Fe. The contact stated while driving 50 MPH, the vehicle loss power. The vehicle was towed to an independent mechanic where it was diagnosed that the engine had seized. The vehicle was towed to the dealer where they confirmed the diagnosis. The vehicle was not repaired. The manufacturer was notified of the failure. The approximate failure mileage was 80,000.
Crash:
No
Fire:
No
Injuries:
0
Deaths:
0
#11433028September 15, 2021
ENGINE
The contact owns a 2017 Hyundai Santa Fe. The contact stated that while operating the vehicle, a knocking noise was present coming from the engine compartment. The vehicle was taken to the local dealer who diagnosed that the engine bearings had failed, and metal particles were discovered in the engine. The contact was informed that the engine needed to be replaced. The vehicle was not repaired. The manufacturer was notified of the failure and the contact was informed that the vehicle was included in NHTSA Campaign Number: 17V578000 (Engine and Engine Cooling). The contact indicated that the vehicle had experienced the failure listed in the recall. The failure mileage was 74,400.
Crash:
No
Fire:
No
Injuries:
0
Deaths:
0
#11431773September 5, 2021
ENGINE
The engine warning light came on and Oil leak from engine, I have taken the vehicle to the dealership and they thought it was an oil cap plug not put in correctly, they put it back in back in July 2021. But oil leak still happen and the engine warning light keeps turn on. Every day i have to check oil level to make sure it not go below the minimum and I keep on adding oil. I have go to the dealership and they unable to help me. I made repair issues know to them, and schedule several appointments and they keep cancel it, they say at this time they do not take any serious engine issues. The last appointment was made on August for September 4, and the Huyndai auto repair center cancel the day before, say that i have to find other repair shop to work on my engine problem. My car buy in October 2016, and currently sit at under 41,000 miles. The Engine warning light came up back in June 2021.
Crash:
No
Fire:
No
Injuries:
0
Deaths:
0
#11431571September 3, 2021
ENGINE
The engine in our 2017 Hyundai Santa Fe SE 3.3L V6 has always had problems with lag/ hesitation when accelerating from a stop from the very beginning of ownership (first owner). This was always dismissed by Hyundai's mechanics as not actually existing, although it did lag constantly. I know many other have reported similar issues so, I include this only that it could potentially be an early sign of a manufacturers defect leading to larger problems later? Now, we regularly change the oil in our Santa Fe and have never seen a single warning light outside of tire pressure warnings. But on 7/29/21, with our vehicle just out of warranty at 112k miles, while accelerating to freeway speed from an on ramp at 60 mph multiple warning lights came and at the same time there was a very large bang from the engine and a large amount of smoke came from under the hood, enough to seriously affect the vision of drivers behind me. There was a very rapid lose of speed and I also observed things falling from the vehicle in the rearview. I luckily managed the vehicle to the shoulder and quickly got out. I thought vehicle was on fire, it may have been, the smoke kept up for 5-10 minutes. At this point the car would not start or run and a large pool of oil and or coolant formed underneath. It was towed to a Hyundai dealer and the prognosis was a broken connecting rod that had blew a large maybe 5" diameter hole through the bottom of the engine. And now, despite providing proof of recent oil changes, Hyundai has dismissed any manufacturing issues from causing the issue and sighting the problem was from lack of maintenance because of sludge in the engine. Although to my understanding sludge can also be produced rapidly when contaminants, like coolant, from bad valves or head gaskets, enter the oil. When I asked about this the technician literally just didn't answer. So, now we currently owe $7k on a vehicle needing repairs at the quoted price of $8-$14k and Hyundai has closed our case.
Crash:
No
Fire:
Yes
Injuries:
0
Deaths:
0
#11431383September 1, 2021
ENGINE
The engine lite came on, there was a lost of acceleration, the vehicle stalled when slowing down for a stop light or stop sign, There was a ping noise evident with the engine. I didnt trust the vehicle had it towed to the mechanic. The mechanic noted you have only two quarts of oil in the engine. This mechanic performed all routine maintenance, rotations, oil changes, checking fluids etc. There were no signs of oil leaks and or burning of oil with the exhaust. I then sent the car to the dealership for their own review. They confirmed the engine failure and the ping noise was the rod due to lack of oil. The dealership files a claim with Hyundai #PA102790, the claim was denied and still has not provided a reason for the oil loss which was the reason for the failure of the engine. There were no indicator lights noting low oil pressure or the engine is overheating, the engine lite came on in the morning and just like in A MANNER OF COUPLE OF HRS the engine started the symptoms noted above. The dealer ship gave Hyundai's complaint line, but after reading the problems associated with the Engines with the sante fe what is the point to call them?
Crash:
No
Fire:
No
Injuries:
0
Deaths:
0
#11430321August 24, 2021
ENGINE
Engine made a loud pinging noise. No warning lights appeared. I had it towed to dealer and they said that metal shavings were in the oil and the engine is shot and needs to be replaced. Car had 95,400 miles. Hyundai denied warranty because I was second owner after ignoring me for approximately one month and they never did reply to me directly, only to the dealer. How can so many Hyundai engines not last for over 100,000 miles?
Crash:
No
Fire:
No
Injuries:
0
Deaths:
0
#11430153August 23, 2021
ENGINE
Took 2017 Sante Fe to dealer for a oil change and to look into an intermittent hard shift from a stop. During test drive dealer stated car engine warning light came on and vehicle stalled, mechanic was able to steer vehicle to side of road, vehicle would not restart, after several hours they informed me that engine had seized and would need to be replaced.
Crash:
No
Fire:
No
Injuries:
0
Deaths:
0
#11430041August 22, 2021
UNKNOWN OR OTHER
As I was driving on the freeway, I heard something that sounded like a bomb go off overhead. I safely pulled over and discovered that my panoramic sunroof had exploded. There were no other vehicles nearby that could have kicked up anything, especially because it was directly overhead. Thankfully I had the interior closed, but if it had been opened myself along with my 4 passengers (three who are young children) would have been covered in glass shards not to mention I could have ran into the wall or something else. Upon investigation, this is a known issue with Hyundai sunroofs. I have not yet been able to have anyone inspect it since it is Sunday. There were no warnings at all that this was going to happen.
Crash:
No
Fire:
No
Injuries:
0
Deaths:
0
#11426116July 23, 2021
VISIBILITY/WIPER
We were driving on a highway at normal highway speeds around 10:15pm. There was some light rain and some lightning in the area. Out of nowhere our panoramic sunroof on our 2017 Hyundai Santa Fe just exploded. There were no cars/trucks in front of us that kicked up any debris that could have caused this. It just shattered and the sound was deafening, it sounded like an explosion and for a quick second I thought we were getting shot at until I observed that no other glass in the car was broken so at that point I knew it was the panoramic sunroof.
Crash:
No
Fire:
No
Injuries:
0
Deaths:
0
#11424803July 14, 2021
ENGINE
Broken cam shaft lifter arm caused engine to stall and break down
Crash:
No
Fire:
No
Injuries:
0
Deaths:
0
#11423948July 8, 2021
ENGINE
The contact owns a 2017 Hyundai Santa Fe. The contact stated while his wife was driving and approaching a red traffic light, the light turned green and the driver depressed the accelerator pedal and the vehicle started shaking abnormally and loss motive power, and stalled without warning. The driver attempted to restart the vehicle, but the vehicle would not restart. The contact arrived at the scene and attempted to jump-start the vehicle however, the vehicle failed to start up. The contact had the vehicle towed to a local dealer who inspected the vehicle and diagnosed the failure as bearing failure which caused the shaking and stalling of the vehicle. The vehicle was not repaired due to the cost of the repair. The manufacturer was made aware of the failure. The failure mileage was approximately 79,000.
Crash:
No
Fire:
No
Injuries:
0
Deaths:
0
#11423230July 2, 2021
UNKNOWN OR OTHER
Location: Apartment complex , driveway This morning I went to drop off my son at my parents place and when I made a U turn to turn around, the car accelerated on it’s own, I stepped on the brakes and it was too late, I hit the neighbors car on the corner and my right tire was on top of the sidewalk. Keep in mind the speed limit in the apartment complex is 5mph. I was going at 6mph and when the car accelerated it felt like if it was going 20mph! I bought my car last year on August 2020, since then my car has been giving signs of hesitations on the acceleration but never would of thought my car would actually drive off on its own. I have a 1yr old son and after this accident happen I don’t feel safe driving my car at all or even trust it at this point, I don’t want to be driving and it happens again and it could be worse.
Crash:
Yes
Fire:
No
Injuries:
0
Deaths:
0
#11421282June 17, 2021
POWER TRAIN
The contact owns a 2017 Hyundai Santa Fe Sport. The contact stated while driving at an undisclosed speed, the accelerator pedal was depressed but the vehicle stalled with no warning lights illuminated. The contact also stated that the vehicle had been stalling from the time of purchase when making a right or left turn. The vehicle was taken to the dealer but was not diagnosed nor repaired. The manufacturer was not made aware of the failure. The approximate failure mileage was 18,000.
Crash:
No
Fire:
No
Injuries:
0
Deaths:
0
#11419748June 5, 2021
ENGINE, POWER TRAIN
The engine is consuming oil. After 1500 miles since my last oil change the oil DOES NOT show up on the oil stick. I have bought 3 brand new Hyundai Santa Fe's and 1 used Sonata, and NEVER had problems, except for my 2017 Santa Fe Sport, which I purchased at Dondelinger Hyundai in Baxter, Minnesota. I have also had to replace the backup camera. I have been to this dealer 4 times with no resolve! Please help!!
Crash:
No
Fire:
No
Injuries:
0
Deaths:
0
#11419067May 30, 2021
ELECTRICAL SYSTEM, ENGINE, FUEL/PROPULSION SYSTEM
Smelled smoke at a stop light. Continued when light turned green. Pulled over about 30 car lengths later because smoke was coming in the vents. Jumped out of car and ran. Within 2 minutes, entire front engine was completely engulfed in flames. No indicator light came on before. Car was driving perfect.
Crash:
No
Fire:
Yes
Injuries:
0
Deaths:
0
#11418439May 25, 2021
SEATS, ENGINE
The contact owns a 2017 Hyundai Santa Fe. The contact stated while driving at various speeds, the check engine warning light illuminated and the vehicle shifted into limp mode, causing the speed to be reduced to 20 mph. The vehicle was taken to the local dealer who was unable to duplicate the failure. The mechanic was unable to retrieve a fault code. Additionally, while driving at speeds above 60 mph, the 2nd-row captain seats shook and vibrated abnormally. The cause of the failure was not yet determined. The manufacturer was notified of the failure. The approximate failure mileage was 40,000.
Crash:
No
Fire:
No
Injuries:
0
Deaths:
0
#11415031May 3, 2021
ENGINE
VEHICLE BEGAN BURNING THROUGH 3-4 QUARTZ OF OIL EVERY 1,000 MILES AFTER VEHICLE GOT CLOSE TO 75K MILES. WHEN THE ISSUE FIRST BEGAN, THE CAUSE WAS UNKNOWN. AFTER RUNNING MULTIPLE OIL CONSUMPTION TESTS, IT IS NOW BELIEVED TO BE AN ENGINE DEFICIENCY.
Crash:
No
Fire:
No
Injuries:
0
Deaths:
0
#11414251April 28, 2021
ENGINE
CAR STARTED TO WHINE WHEN STARTED, THEN I WAS AT ABOUT 30 MPH IT MADE A HIGH PING NOISE LIKE SOMETHING FELL OUT AND THE CAR SHUT OFF, NEVER STARTED AGAIN, MECHANIC SAID ENGINE BLOWN
Crash:
No
Fire:
No
Injuries:
0
Deaths:
0
#11413155April 21, 2021
ENGINE
LET ME SAY MY HYUNDAI SANTA FE LIMITED ULTIMATE 3.3L AWD IS A VERY GOOD AND RELIABLE VEHICLE NEVER HAD ANY ISSUES OR PROBLEMS. ALWAYS KEPT IT MAINTAINED. WELL ABOUT A MONTH AGO I HAPPEN TO START MY HYUNDAI WITH THE DOOR OPEN AND I HEARD A SOUND JUST FOR A FEW SECONDS. THE SOUND OF A ENGINE LOW ON OIL WHAT COULD NOT BELIEVE IT, IT CAN'T BE. SO I CHECKED IT AND SURE ENOUGH IT NEEDED OIL, DUMBFOUNDED NO OIL PUDDLES ANYWHERE ON THE GROUND I WAS KINDA IN SHOCK THIS HAS NEVER HAPPENED DIDN'T NEED TO WORRY ABOUT THAT ITS NEVER LEAKED OIL AND NONE OF THE GENTLEMEN THAT CHANGES THE OIL NEVER SAID ANYTHING OIL ABOUT THE OIL BEING LOW OR OIL ON THE ENGINE. SO I FOUND OUT WHAT KINDA OF OIL IT TOOK AND PUT ABOUT 3 1/2 QUARTERS. OK ALL BETTER BUT STILL WONDERING HOW THAT HAPPEND JUST RECENTLY HAD THE OIL CHANGED. WELL THE NEXT MORNING I HAD TO DRIVE TO SAN DIEGO FROM LONG BEACH CHECKED OIL OK NO PROBLEM ALL GOOD. SO IM ON THE FREEWAY DRIVING THROU OCEANSIDE CAMP PENDLETON AND WAS GETTING HUNGRY SO THE FIRST EXIT AFTER DRIVING THROUGH OCEANSIDE I WAS GOING TO STOP AND GET SOMETHING MIND YOU NO LIGHTS NO SMELLS NO SMOKE. SO I STARTED TO EXIT STILL EVERYTHING JUST FINE AND WHEN I SLOWED DOWN COMING TO THE LIGHT THE ENGINE STALLED AGAIN NO SMOKE NO LIGHTS NO SMELLS. I WAS VERY SUPRISED I TRIED TO START IT AND NOTHING TRIED AGAIN AND NOTHING. SO I CALLED AAA THEY LOOKED AT IT AND DIDN'T SEE ANYTHING WRONG BUT WOULD NOT START. SO I HAD THEM TAKE IT ON A FLAT BED TO HYUNDAI HARBOR OFF OF CHERRY WHERE IT SITS NOW. THEY LOOKED AT IT AND SAID THE ENGINE HAS SEIZED UP IT WILL NOT ROTATE. TOOK OIL PAN OFF AND FOUND METAL PIECES AND SAID THE BEARINGS WENT BAD IN TURN BURNING UP THE OIL AND SEIZED THE ENGINE. THAT PRETTY MUCH IT SO IS THEIR ANYTHING THAT CAN BE DONE TO HELP ME. I STILL OWE AROUND $19,000 ON IT AND DONT KNOW WHAT TO DO I'M GLAD I FOUND THAT LITTLE ARTICLE BECAUSE I NEED HELP.
Crash:
No
Fire:
No
Injuries:
0
Deaths:
0

← Back to Hyundai Santa Fe