Hyundai Santa Fe Complaints (2017)

972 consumer complaints on file.

#11513552March 24, 2023
ENGINE
Engine is using a quart of oil every thousand miles.
Crash:
No
Fire:
No
Injuries:
0
Deaths:
0
#11513362March 23, 2023
ENGINE
Was driving 55 mph and engine went into limp mode on busy road almost creating a tear end collision with multiple vehicles traveling at high rate of speed. Cam shaft bolt har sheared off cracking the fuel cover resulting in loss of engine oil. Told this was not covered under warranty but fixable. So fixed that along with front and rear brakes for a total bill of over 3k. Less than 500 miles Later my 21 year old son was driving - engine started clanking loudly the he lost acceleration while traveling a proximate ally 49 mph in heavy traffic. Car needed to be towed and am not being told the engine is blown.
Crash:
No
Fire:
No
Injuries:
0
Deaths:
0
#11512805March 20, 2023
ENGINE
Engine had a massive Engine failure with 90k miles on it. Engine was well maintained when failure happened. Engine shut down and left wife and I on side of the road. Had to towed to dealership and dealership said its an engine failure.
Crash:
No
Fire:
No
Injuries:
0
Deaths:
0
#11512865March 20, 2023
STRUCTURE:BODY:HATCHBACK/LIFTGATE
The contact owns a 2017 Hyundai Santa Fe. The contact stated while she was parked in her driveway, she was at the back of the vehicle and had lifted the lift gate to place items in the back when the lift gate inadvertently came down on the contact's neck. The contact was trapped by the liftgate and struggled to pull her head out. The contact had hurt her neck in the process of freeing herself and had set up an appointment with a doctor. The contact stated no warning lights or chimes were heard or noticed. The contact had not taken the vehicle to a dealer or independent mechanic. The vehicle had not been diagnosed or repaired. The manufacturer had not been informed of the failure. The failure mileage was approximately 80,000.
Crash:
No
Fire:
No
Injuries:
1
Deaths:
0
#11511230March 10, 2023
ENGINE
Vehicle started flashing oil light during turns or bumps. The vehicle was not at mileage for oil change, but brought it in anyway. Turned out the oil was being burned at an access rate which was luckily caught before there was no oil in the vehicle. Vehicle is regularly maintained with documentation to prove. Followed protocols through hyundai by performing an oil consumption test and a combustion engine clean out. Hyundai service coordinator said my engine needs to be replaced but hyundai corporate declined the coverage. Even though many of these vehicles are having this exact same problem. He acknowledged this is a problem with their vehicles and stated they see at least 4 of these a day in their service shop. They told me that I did nothing wrong; that their engines are defective. The only thing he could do is help me price out a new engine. My Santa Fe sport was seen for this problem starting at 70,357miles. Previous oil change was at 66869.
Crash:
No
Fire:
No
Injuries:
0
Deaths:
0
#11511091March 9, 2023
ENGINE, STEERING, SUSPENSION
The engine throttles while accelerating and leaks oil and a burning smell comes from under the hood. the smell passes through the air vents and fills the car. I am afraid it might catch fire under the hood. The suspension makes noise and can also feel on the steering wheel. I will appreciate the company if they take safety measures in fixing this issue.
Crash:
No
Fire:
No
Injuries:
0
Deaths:
0
#11510583March 7, 2023
ENGINE
While driving at approx. 65 mph on Friday, March 3, 2023 my Hyundai Sanat Fe completely loss power. It dramatically loss steering and brake pedal feel. The vehicle needed to be towed to the closest service station. The engine shows no signs of oil leaks or any other physical issues.
Crash:
No
Fire:
No
Injuries:
0
Deaths:
0
#11509795March 2, 2023
ENGINE
I bought a 2017 Hyundai Sante Fe Limited trim with the 3.3 L 6 cylinder on Nov 2, 2022. The car was running perfect until Feb 28, 2023, when while driving the engine started knocking and the check engine light came on. This happened instantly. I had it towed to a mechanic where it was discovered that the oil pan and oil filter were covered in metal shavings. The engine failed at 97,000 miles. The code that is being read is “P0014 Exhuast Camshaft position timing - over advanced. This is the same exact thing that is happening with earlier and Hyundai and Kia engines, but there aren’t any recalls, campaigns, or class action law suits open for my specific vehicle, so the Hyundai dealership that I am bought it from are pretty much telling me too bad too sad, you didn’t buy the extended warranty. Hyundai has a significantly documented issues that are exactly the same problems and seem to only be addressing the older vehicles with the same exact issues. This is almost criminal of Hyundai, because even though corporate and their dealerships are aware of these issues and acting like they are sympathizing, they are offering absolutely no help to their customers for their faulty engines.
Crash:
No
Fire:
No
Injuries:
0
Deaths:
0
#11509426February 28, 2023
ENGINE
On the incident date listed, we were driving in Denison, Texas, going southbound on US Hwy 75. Traveling at 70mph, the vehicle started to have a loss of power and the vehicle started to shake, as if we were traveling on uneven pavement. Thankfully, we were able to pull to the side of the road to avoid being struck by traffic following behind us. Approximately 7 miles ahead, road construction is being performed, and there is no shoulder. If this incident would have happened in this area, we would certainly have been killed, because there was no place to move the vehicle. After having the vehicle towed to the dealership, the engine no longer had fire in the first and third cylinders. This was due to no oil in the engine. An oil change had been performed on the car on 11/19/2022, at 115,323 miles. So we had traveled 1205 miles since the oil change. When the oil was checked, no oil showed on the dipstick and there were only 2 quarts of oil in the reservoir. 5 quarts of oil had to be put into the engine to attempt to start the vehicle. After doing research on an issue we did not know existed prior to purchase, Hyundai has shown to have an unusual instance of burning oil in their engines. Leaking is not a sign of trouble, or we would have seen this and had it addressed. We are outside of the warranty by 16k miles and the dealership is unwilling to work with us. We believe this should be brought to the NHTSA's attention, to prevent a potentially deadly incident from happening in the near future.
Crash:
No
Fire:
No
Injuries:
0
Deaths:
0
#11509452February 28, 2023
ENGINE
Our 2017 Hyundai Santa Fe was driving perfect up until an engine light came on last week. During which the vehicle began sounding like a diesel engine idling rough. Using an inexpensive code reader I connected to the vehicle OBDII port and the code related to an crankshaft position error (i don't recall the actual code set). I brought the vehicle into the dealership for a routine oil change and check why the engine light came on. After the oil change had started the dealer brought me into the garage to show me excessive amounts of metal pieces caught within the oil filter making the vehicle inoperable. They mentioned something must have failed within the engine and the engine chewed it to pieces causing the rough idle. They also mentioned they're surprised the vehicle was still working and it was just a matter of time before the engine failed. The dealer explained it would take 9 months to repair due to the 50 other vehicles ahead of me all needing engines and only 1 technician on their staff qualified to replace engines. I researched online for "2017 hyundai santa fe engine failure" and a recall showed up sounding very similar to my issue (Recall No. 17V578000); however, my vehicle VIN number was not included.
Crash:
No
Fire:
No
Injuries:
0
Deaths:
0
#11509621February 28, 2023
ENGINE
All of sudden check engine came on along with engine oil and battery on dashboard and couldn’t go over 55 MPH on highway and car has been burning oil the past couple months and was told it wasn’t an issue until engine failed on my husband on the way home.
Crash:
No
Fire:
No
Injuries:
0
Deaths:
0
#11509168February 26, 2023
VISIBILITY:SUN/MOON ROOF ASSEMBLY
The panoramic sunroof on our 2017 Hyundai Santa Fe unexpectedly and without warning, exploded during a leisurely drive through our town this morning. At a speed not exceeding 40 mph, we were suddenly met with a loud, gunshot like sound that instantly frightened us. We immediately put our hazards on and pulled off to the side of the road to find that the sunroof had completely shattered. Thank goodness we had just closed the sun shade or else our three year old and family pet would have been covered in glass shards, shards that would have most definitely caused serious injuries had that sun shade not been closed. We were on a paved road where no other vehicles were present, leaving no chance for a rock or any sort of debris to have impacted the vehicle. There has been no prior glass work done on the sunroof and we have not experienced any sort of major temperature differential in our area recently. There were no chips or hairline cracks present prior to this incident. We have contacted our insurance company but are waiting to file a claim until we reach out to the dealership (it is currently a Sunday and all dealerships are closed here). Had we been on a major highway or road, this could have most definitely caused an accident as the noise was incredibly loud and shocking. Again, what is most concerning is the fact that had we not just closed the sun shade, our toddler could have been seriously injured by the glass shards.
Crash:
No
Fire:
No
Injuries:
0
Deaths:
0
#11508838February 24, 2023
SERVICE BRAKES, FORWARD COLLISION AVOIDANCE: AUTOMATIC EMERGENCY BRAKING, FORWARD COLLISION AVOIDANCE: WARNINGS
My lane departure and collision warning did not work when I crashed into a car head on and totallled my vehicle. I had not yet received my recall maintenance, nor did I know about both recalls. Only the first. Not only that but lane assist did not work and the airbag did not go off. Despite totaling the car, how did they not go off?????
Crash:
Yes
Fire:
No
Injuries:
1
Deaths:
0
#11508904February 24, 2023
ENGINE
Driving car when suddenly all the dash lights came on and car started sputtering. Pulled over to side of road where car completely died. Could not restart with jump. Towed to mechanic where he informed me the engine appears to be ruined. Maintain regular oil changes since purchasing car in 2020.
Crash:
No
Fire:
No
Injuries:
0
Deaths:
0
#11508827February 23, 2023
ENGINE
The engine seized while driving. It will be available to inspect if requested. No warning signs whatsoever. Not a light on the dash. 117,xxx or so miles on it. We were driving in the left lane on the interstate when it happened. No noise, just completely shut off. In ST. Louis traffic. We couldn’t get to the right side so it was extremely dangerous. I’m unsure if this is a common issue or not. The vehicle has only had diagnostics so far, no further inspections. I was due for an oil change that week, there were zero warnings signs that I noticed but I’m not a mechanic. No lights prior to incident, but when it occurred the following lights came on: key undetected light, oil pressure light, engine malfunction light, power steering light, battery light, and I believe there was one more unknown light. My vehicle engine just shut off completely and wouldn’t restart.
Crash:
No
Fire:
No
Injuries:
0
Deaths:
0
#11508368February 21, 2023
ENGINE, POWER TRAIN
We were traveling down the road 12/08/22 and a clanging noise started. we were only a few miles from the Hyundai place in Orlando so we drove there. They put us in a rental and said most likely it threw a rod and would need the Engine replaced. It had about 95500 miles on it. Universal Hyundai called and said Hyuandi would replace the engine as goodwill with a rebuilt engine and It will cost me 1300.00. after 65 days in the shop they said I can pick it up. Drove it 11 miles and it broke down again. got it towed back to Universal Hyundai. They said it was the start and alternator and it will cost me 2000.00. My car is 4.5 hours away from where I live. The month before I had to have both sensor assy- oxygen replaced, they changed me for that also. In February of 2022 the Catiliyst Convertor was replaced, which was covered under warranty. I maintained my oil changes.
Crash:
No
Fire:
No
Injuries:
0
Deaths:
0
#11506729February 11, 2023
ENGINE
My family was driving down a busy state road at around 45 mph when the engine stalled. Seconds before the engine stalled the check engine light came on leaving no time to react.There were no other warning lights to indicate a problem leading up to the incident. Thankfully with what control we had left of the vehicle we were able to maneuver into a shopping center. Though we were able to stop safely we found ourselves facing the wrong direction in the shopping center right of way. The police arrived to direct traffic in the area around our vehicle as we waited for the tow truck causing major congestion leading out into the main road. The car was towed to the Hyundai dealership for inspection. They diagnosed the problem as a rod bearing failure in the engine. At only 65,000 miles this type of engine failure without any warning from the cars systems is unacceptable and dangerous.
Crash:
No
Fire:
No
Injuries:
0
Deaths:
0
#11506694February 10, 2023
ENGINE
Oil consumption bulletin, piston slap, engine failure causing vehicle to shift into limp mode while driving at 70 miles per hour.
Crash:
No
Fire:
No
Injuries:
0
Deaths:
0
#11505554February 4, 2023
ENGINE
The car lost all power in he middle of a busy 4 lane highway. Was able to coast to the shoulder. Engine light came on had car towed to mechanic. I then took car to Hyundai an they told me it had to do with update. Got car back an less the 6 hours later the car went into limp mode not exceeding 2000 rpm. Took the car back an now they are claiming the piston has dug into cylinder wall an need new engine.
Crash:
No
Fire:
No
Injuries:
0
Deaths:
0
#11505378February 3, 2023
ENGINE
On 11-12-22 my Sante Fe stuttered and came to a stop on a busy highway. On inspection we found there was no oil in the engine, there was no crack in the oil pan and otherwise no way for the oil to leak out. We did all the maintenance on schedule according the Hyundai's recommendations. My two young kids, my husband and I were stranded on the side of the highway for hours until we could get the car towed to the nearest dealership. Clearly, an engine seizing on the highway is very scary and unsafe. Hyundai is aware of the excessive oil consumption and did not inform consumers, putting lives at risk. The car is sitting dead in a dealership and in the mean time has been vandalized, the steering column was busted and the lift gate was disabled. The vehicle has been inspected by the dealership and an insurance rep is scheduled to inspect it for the damage from the break-in. Insurance has already said the engine is our problem because it wasn't caused by an accident but by manufacturer defect. There was no warning that the engine was consuming excessive oil, it just seized. Hyundai is requesting a tear down of the engine so they can determine if the engine will be covered. I fear they will find a way to not cover a new engine, when it was clearly a manufacturing defect. My families lives were at risk because of Hyundai's disregard for their customers.
Crash:
No
Fire:
No
Injuries:
0
Deaths:
0

← Back to Hyundai Santa Fe