Hyundai Santa Fe Complaints (2017)

972 consumer complaints on file.

#11517839April 19, 2023
ENGINE
I was driving about 20mph down a country road, having just pulled out from the driveway. The car sounded fine, had no trouble accelerating. There were no warning lights on. All of a sudden, the car just died. Everything shut down. The country road was very narrow and there was no shoulder, so all I could do was put on my hazard lights and hope I didn't get hit. The car would not turn back on. I had it towed to a Hyundai dealership and was told that the engine had failed and it would be close to 15-20k to replace it. There was no warning indication that something was wrong with the engine. The car has 108,000 miles on it, but should have lasted longer than this.
Crash:
No
Fire:
No
Injuries:
0
Deaths:
0
#11517762April 18, 2023
ENGINE
Car Mileage approx 81,000 miles at time of incident. All records maintained for 7 years. Driving 70mph on highway. Pull of highway and lose power to engine. Engine has a complete failure. Luckily I was able to pull over to the shoulder, no smoke, oil spill. No check engine light ever came on. Hyundai replaced the engine, costs were approx $19k covered by the warranty. Car was under repair for 5 weeks. Long blocks are no longer available so it was frankensteined with a shortblock. One week after getting car back developed an oil leak. Hyundai will not warranty this issue. Car is in the shop getting repairs. Seeing everyones posts here having the same issue for the same model year I referenced RECALL # 168 which appears to be the same issue in all of these cars but my vin did not fall under its vin range. Good luck out there.
Crash:
No
Fire:
No
Injuries:
0
Deaths:
0
#11517361April 17, 2023
ENGINE
This is second time happening to me. I was driving on us 212west and all of a sudden there was a huge jerk and I lost power. I got almost hit by car behind me. Blinking engine light came on and this is the same thing happened last time with recall 953, knock sensor. I have talked to hyundai customer support. They are playing with peoples life.
Crash:
No
Fire:
No
Injuries:
0
Deaths:
0
#11517504April 17, 2023
STRUCTURE:BODY
While just entering the freeway my hood flew open at approximately 65-70 mph, hit and broke the windshield, causing me to run off the road. The vehicle exhibited no prior indications that the hood could fly up. The vehicle was taken to a Hyundai dealership and we were told that we needed to contact Hyundai Customer Care that the dealership could not do anything until a Claims Manger contacted them. Upon contacting Customer Care a claim number was assigned and the Hyundai claims manger eventually called saying that this defect is not covered under the recall 163 (TSB# 17-01-050 for Secondary Latch Cable) because the manufacture date is 7/30/2016 and the recall dates are 7/12/2012 through 6/27/2016. This is only 33 days after the recall period ended and sounds like the Hyundai factory had an escape of a bad vehicle. I took pictures of the secondary latch cable, it shows corrosion, and uploaded to the Hyundai website at the advice of the Customer Care Representative. After a lengthy period time the Hyundai Clams Manager reported, on a recorded line as he stressed, that his management did not see this as a warranty or goodwill repair and suggested that I make an insurance claim for the repair and for a rental car. My wife, mother in law and children were not physically injured but emotionally rattled. We've had no choice but to drive the vehicle, with the hood secured alternate DIY means, as we awaited disposition by Hyundai. We now have no choice but to arrange both repair and loaner vehicle by ourselves. Again, the vehicle manufacture and recall date range are only 33 days apart - this smells of an escape from the Hyundai manufacturing plant. Also, isn't the purpose of the secondary latch to prevent the hood from flying up if the primary latch fails or is partially / false latched? Please contact me if you need any additional information i.e. Claim number, Claims Manager name, etc.
Crash:
No
Fire:
No
Injuries:
0
Deaths:
0
#11516848April 13, 2023
ENGINE
Engine started losing power with weird noises and after stopping would not start again and was smoking. Dealership said engine has to be replaced. No warning lights came on. Dealership says everything else on the car is working perfectly, just no compression in the engine.
Crash:
No
Fire:
No
Injuries:
0
Deaths:
0
#11516931April 13, 2023
ENGINE
UNKNOWN but it appears the oil is leaking from my car but I am not sure where as there are no puddles and we checked it and dipstick didn't detect anything, 4 quarts were added and it showed it was more than full then after waiting 3 hours for a tow truck to take it to the shop the oil was basically empty per the mechanic and the engine was shot and needs to be replaced but there is no engines available due to engine fires and other scenarios like mine yet an investigation is still going on and I am out a car
Crash:
No
Fire:
No
Injuries:
0
Deaths:
0
#11516659April 12, 2023
SERVICE BRAKES, ENGINE, UNKNOWN OR OTHER
It’s not a accident The car won’t start and brake and wheels keep locking by itself.
Crash:
No
Fire:
No
Injuries:
0
Deaths:
0
#11516337April 10, 2023
ENGINE, VEHICLE SPEED CONTROL:ACCELERATOR PEDAL
The contact owns a 2017 Hyundai Santa Fe. The contact stated while driving approximately 30 MPH, the accelerator pedal became inoperable when depressed and the vehicle stalled. The contact stated that a unknown warning light illuminated. The vehicle failed to accelerate and coasted downhill into a parking lot. The vehicle was towed to the local dealer where it was diagnosed and determined that the engine needed to be replaced. The vehicle was not repaired. The manufacturer was contacted but no additional assistance was provided. The failure mileage was approximately 83,000.
Crash:
No
Fire:
No
Injuries:
0
Deaths:
0
#11515766April 6, 2023
ENGINE
Car is properly maintained and serviced. We were driving on Highway and I heard a rattle. I turned down the radio then the speedometer changed from 65MPH to 0. The car was just rolling and lost all power. Then, for the first time ever, the check engine and battery light came on. Lots of smoke from the back and from under hood. They said it threw a rod through the back of the engine, and all the oil leaked out. I had it towed to a dealership
Crash:
No
Fire:
No
Injuries:
0
Deaths:
0
#11515822April 6, 2023
ENGINE
Engine failure while driving the vehicle. My safety along with others on the road was put at risk due to the cars engine failing and making me at risk for someone to hit me. There were no warning or check engine lights on prior to the incident or after.
Crash:
No
Fire:
No
Injuries:
0
Deaths:
0
#11515081April 3, 2023
ENGINE
Two weeks ago, I heard a noise when we started our Santa Fe but the car continued to run and no warning lights were on the dash. The day after I heard the noise, I was driving and the car suddenly stalled - fortunately, I was on a side road but had I been elsewhere I could have easily caused an accident and been a danger to myself and others. I was going 30 MPH and looked down to see my car said 0 MPH so I pulled off the road. My car had no warning lights at all prior to the stalling but once I stalled, the check engine light came on. All my electrical continued to work. We had the car towed to our usual auto mechanic who told us our engine had failed but they believed our issue was under a Hyundai recall. We had our vehicle towed to the closest Hyundai service center, but they denied that our VIN was under the recall despite our car being the exact make, model and month of manufacturing the recall stated. Attempts to speak to Hyundai corporate resulted in the same denials. So now, with no warning, my 6 year old, barely used car has a completely dead engine through no fault of our own. Our car was regularly maintained by our local auto mechanic. Our car is currently sitting at the Hyundai service center after being quoted over $17,000 to replace the engine.
Crash:
No
Fire:
No
Injuries:
0
Deaths:
0
#11514896April 1, 2023
ENGINE
I was driving with my 2 children in the car, and with no warning there was a loud pop noise and lots of smoke came out of the hood I had to pull over as quickly and safely as I could. The car died and would not come back on. Mechanic advised that the rod went through the engine block. I took the car to the dealer after seeing on line that the same year make and model had the same thing happening to the point the cars have caught on fire. I have taken very good care of all of my vehicles she had an oil change every 7k miles on Synthetic oil. I was told the recall was in the 4 cylinder engine and i have the 6 cylinder engine. It is the same exact thing that happened to the 4 cyclinder engine and having all the mechanical reciepts showing that the car was taken care of per service miles.
Crash:
No
Fire:
No
Injuries:
0
Deaths:
0
#11514909April 1, 2023
SERVICE BRAKES
The left rear brake caliper broke off and was hanging next to the wheel. The brake fluid was leaking and had leaked out. it is available for inspection. This occurred while driving home from an errand. Had it occurred earlier on a steep hill down the mountain, the results would have been catastrophic, probably resulting in loss of life. The vehicle has yet to be inspected by the manufacturer but will be soon. No warning lights just noise of caliper banging against car and loss of brakes. Event occurred close to home problem discovered there.
Crash:
No
Fire:
No
Injuries:
0
Deaths:
0
#11514723March 31, 2023
ENGINE, VEHICLE SPEED CONTROL
My engine had been using oil at a very fast rate and I was just told that hyundai consume a lot of oil. I have had this car since 77k miles and have issues ever since I bought it. At first I had issues with it not accelerating on the interstate and then it would randomly stop while I was driving, almost like a car hiccup. I took it to the dealership, and other car shops and no one found anything wrong. Finally two weeks ago, I was on I85 and my car was driving really roughly and idling roughly as well. No lights came on until it started to decelerate on the interstate to 30 miles an hour and I had to pull off to the side of the road. Then a bunch of different lights came on and I turned it off and it wouldn't turn back on. I had it towed to the dealership, and they stated I had a bad engine, and Hyundai may replace it but it will take the shop 4-6 months to even take the engine apart to see whats happening. I'm out of a car for at least 4 months probably more, and there is nothing I can do. The mechanic is thinking there is an issue with the bearing.
Crash:
No
Fire:
No
Injuries:
0
Deaths:
0
#11514757March 31, 2023
ENGINE
Car lost power, and engine has catastrophic failure. Needs new engine, has 74k miles on it!
Crash:
No
Fire:
No
Injuries:
0
Deaths:
0
#11514179March 28, 2023
ENGINE, POWER TRAIN
1. Over several documented and undocumented times since July 2021, this vehicle has consistently lost >1 quart of oil every 1k miles. 2. This issue has been confirmed by the dealerships involved several times. 3. It is identified as the Theta engine failure. It began in 2012-13 and has been a constant for Hyundai and Kia models for 7 years. 4. There were no warnings from the initial ignition vehicles system check or at any time while operating this vehicle. Even when the engine loss was measured at about 4 qts. 5. This vehicle has been through 2 complete "oil consumption" programs that measure the oil loss during three consecutive 1K mile periods. Also it has had 2 "combustion cleanings" after which a follow up 1k mile oil check found that it still lost >1 qt of oil. 6. The failure of this engine is always a concern. I have personal and anecdotal testimony of what can happen with the failure of this engine. My wife and I are both in our 70's. We are also helping our 26 year old grandson with various transportation requirements. He has spastic dysplasia cerebral palsy and is unable to walk without a cane or walker. Longer distances require a wheelchair. We cannot push that wheelchair, we cannot carry him. We are in trouble if this engine fails and we are miles from home. Also, the vehicle under went the required ECM UPDATE as required by the NHTSA at 39843 miles on January 11, 2019. This update required the installation of a module that would decrease the RPM'S of the engine if there was a failure. There are horror stories on various FB Group pages about the terror of being on a 70 mph road, in the middle lane, when the engine fails and goes immediately to 35 mph. I have a personal friend who experienced that on I-95 in Maryland and was petrified. 6. Finally, after speaking with various Hyundai Service employees, I feel that I was mistreated after the first process. When my SUV lost >1 qt after 1K miles after the cleaning, I should have gotten a new engine.
Crash:
No
Fire:
No
Injuries:
0
Deaths:
0
#11513898March 27, 2023
ENGINE
The vehicle lost power. When we looked under the hood there was oil all over and all oil had leaked. There is a small hole in the side of the engine block.
Crash:
No
Fire:
No
Injuries:
0
Deaths:
0
#11513968March 27, 2023
ENGINE AND ENGINE COOLING
The contact owns a 2017 Hyundai Santa Fe. The contact stated that while driving at an undisclosed speed, the vehicle stalled. The check engine and oil pressure warning lights were illuminated. Additionally, the vehicle experienced rough idle. The contact related the failure to NHTSA Campaign Number: 17V578000 (Engine And Engine Cooling), however, the VIN was not included in the recall. The dealer was not notified of the failure. The vehicle was not diagnosed nor repaired. The manufacturer was not made aware of the failure. The failure mileage was approximately 162,000.
Crash:
No
Fire:
No
Injuries:
0
Deaths:
0
#11514040March 27, 2023
ENGINE
Engine started making a loud ticking sound about a year ago. No check engine lights and no oil lights. Brought it into Liberty Hyundai in Ramsey, NJ. They flushed the system for $200 and said there was nothing else that had to be done. Then Jan 2023 oil warning light comes on. Checked oil and it was full. Brought it to Paramus, NJ Hyundai and they replaced the oil sensor for $1600. Still said everything was okay. Car is still not sounding right with 74,0000 miles.
Crash:
No
Fire:
No
Injuries:
0
Deaths:
0
#11513731March 25, 2023
ENGINE
My 2017 Santa Fe SE Ultimate AWD was scheduled for an oil change and yearly NC State inspection and I scheduled that with the local dealer that I use regularly for servicing my Hyundai. On the way to the Hyundai dealership, Johnson Hyundai of Apex, I felt that the engine was making a strange knocking sound when accelerating and seems to have lost power. So I mentioned that to the dealer servicing technician Jeremy and he told me that he too noticed the knocking sound and that they will let me know what is going on. I got my complementary ride back home and in few hours got a call from dealership that I have a blown engine and that they will try and contact Hyundai to see if they will replace the engine. Few day later they called me that Hyundai was going to only pay 90% of the nearly $20000 cost and that I’ll be paying the balance. I insisted full payment but they declined and I am still fighting them to pay for my rental coverage. There were no sign of engine problem or service lights and my suv has been regularly serviced by Hyundai from day one. They need to cover the total cost of the engine as I see there are many other owners that are in the same boat.
Crash:
No
Fire:
No
Injuries:
0
Deaths:
0

← Back to Hyundai Santa Fe