Hyundai Santa Fe Complaints (2014)

493 consumer complaints on file.

#11643152February 17, 2025
ENGINE
Engine failed mixing oil and coolant
Crash:
No
Fire:
No
Injuries:
0
Deaths:
0
#11631370December 18, 2024
ENGINE
Crack was found in oil pan during regular maintenance. The engine was replaced by Hyundai and now has around 60,000 miles on it. At my expense, the oil plan was replaced.
Crash:
No
Fire:
No
Injuries:
0
Deaths:
0
#11630088December 11, 2024
ENGINE
Check engine light came on and acceleration failed. Hyundai dealership indicated there are no valves in the intake and exhaust ports.
Crash:
No
Fire:
No
Injuries:
0
Deaths:
0
#11630171December 11, 2024
ENGINE
The engine went out while driving on the freeway. All maintenance has always been done and it was burning oil.
Crash:
No
Fire:
No
Injuries:
0
Deaths:
0
#11630007December 10, 2024
STRUCTURE:BODY
Locked the doors normally with the remote. Went into the doctor's office. Returned to the car the driver's door would not unlock. All other doors worked normally. Could not unlock the door with either handle, the switch or the remote. The Dealer says that the door latch mechanism failed in the locked position with the door closed. This would make it very difficult to exit the car in an accident, fire or submersion. The only exit is to crawl over the high mid console and exit through the right front passenger door, this is a very difficult maneuver.
Crash:
No
Fire:
No
Injuries:
0
Deaths:
0
#11629403December 7, 2024
FUEL/PROPULSION SYSTEM
Twice in the last year the high pressure fuel line has cracked while I was driving and started spraying gas all over the engine bay.
Crash:
No
Fire:
No
Injuries:
0
Deaths:
0
#11622994October 31, 2024
ENGINE, POWER TRAIN
The contact owns a 2014 Hyundai Santa Fe. The contact stated that upon starting the vehicle, the vehicle made an abnormal knocking sound. There was no warning light illuminated. Additionally, the contact stated while driving at various speeds and depressing the accelerator pedal, the vehicle sputtered and hesitated while responding. The vehicle was not diagnosed or repaired. The dealer and the manufacturer were not notified of the failure. The failure mileage was approximately 63,547.
Crash:
No
Fire:
No
Injuries:
0
Deaths:
0
#11620890October 20, 2024
UNKNOWN OR OTHER
My drivers side door will not close. Everytime I close it, it doesn’t latch and remains open. There is absolutely no way to close the door. This happen while I was driving my car, the door flew open and when I shut it, it wouldn’t latch.
Crash:
No
Fire:
No
Injuries:
0
Deaths:
0
#11619727October 14, 2024
SERVICE BRAKES
On [XXX}, the abs module failed. I did not know this until it was diagnosed by Pope Automotive, Lubbock, TX on 9/27/24. They discovered there was a recall 205 related to this issue. They started a case with Hyundai in regard to this: #[XXX]. I was in contact with my case worker who told me to have it towed to a Hyundai dealership. I did and it is currently at Gene Messer Hyundai, Lubbock, TX. Messer diagnosed the vehicle and stated the abs module is not related to the recall, because the recall work was done on 2/25/24 in Alabama. I contacted Messer Service Dept and spoke with Victoria. She stated that perhaps only the fuse was replaced, but not the abs. We need a copy of the invoice from Feb 2022, in order to know. I called Carvana, where I purchased the vehicle on [XXX] (only weeks from when the service was done). I was told it has been too long, they don't have the record. Serra Hyundai Trussville, AL said I'd have to get the information from Carvana, they cannot provide it to me. I called Carvana again today. I spoke with a different person and was told it would take 24-48 hours to send me the copy. On this invoice, we will find the abs module was replaced. There is no logical reason for it to go out in just 2.5 years. Perhaps it was a bad part. I feel it is unfair that I am being held responsible for it's replacement. If the abs module was not replaced as part of the 205 recall, I would expect it replaced. There were several model years included in the recall and hundreds of thousands of vehicles affected. There was also a class action lawsuit. There was a period of time where Hyundai parts were not quality or reliable. This has been a very stressful situation requiring many phone calls and research. It should have been a simple solution - replace the defective abs module at no cost to me. I have been without my vehicle now since [XXX]. It is the only transportation for a family of 4. INFORMATION REDACTED PURSUANT TO THE FREEDOM OF INFORMATION ACT (FOIA), 5 U.S.C. 552(B)(6)
Crash:
No
Fire:
No
Injuries:
0
Deaths:
0
#11618527October 7, 2024
ENGINE, POWER TRAIN, VEHICLE SPEED CONTROL
I have been notified that I am in need of a new engine due to possible complete engine failure which is on the near horizon. I have the Lambda II V6 3.3L engine. It is knocking, making noises, hesitates to go, feels like it will stall out at all speeds, and is scaring me terribly. My certified local mechanic replaced a part for failed emissions, which cost almost $900. However the check engine light came back on. They stated I must go to Hyundai because they did not believe they could fix the car as it required a new engine. I took it to my Hyundai dealer, where my contact stated yes it should be covered as it was having the issues as have been identified with this engine. He later came back and stated his managers would not let him put through the claim, and said my estimate was now a whole new timing system at a cost of $4600. My car has less than 83,000 miles on it. My previous Hyundai is still running at 200,000 miles, so yes, I take good care of my vehicles. This is an early equipment failure on the part of Hyundai and Kia that they are now owning up to. I drive on busy 4 lane local roads, and I am afraid of this engine failure. Also, when I did take my Hyundai into the dealership, they did not have the ABS part needed for the recall. I was told it would be in within a couple of days. I have not been contacted back by them if it is in and to schedule me an appt. This is a huge failure in itself! I did make a claim to Hyundai Customer Care, that stated it was out of warranty. Today, I have my car at a 3rd automotive mechanic in the area to get a 3rd opinion. He has a minor timing issue code P0018 that emissions still kicked out once I finally got it passed. I am waiting to hear what he has to say regarding my engine with no beforehand knowledge of what I know so far. If my car catches fire or breaks down or seizes up on a busy road, I don't think that will go safely at all. I am very concerned for my safety and that of others.
Crash:
No
Fire:
No
Injuries:
0
Deaths:
0
#11618243October 5, 2024
ENGINE, FUEL/PROPULSION SYSTEM, POWER TRAIN
My 2014 Hyundai Sonata is subject to the recall campaign for the 2.0L and 2.4L Gasoline Direct Injection (GDI) engines. Since June 24, 2024, the vehicle has exhibited multiple issues: 1. Check Engine Light: The check engine light is continuously on and blinking, signaling that the vehicle is unsafe to drive. Diagnostic codes retrieved include P0140 (O2 Circuit), P0172 (System Too Rich), and P0126 (Knock Sensor Circuit). While the P0126 code pertains to the knock sensor, there has been no definitive diagnosis to determine if the issue is isolated to the sensor or indicative of a deeper engine problem. 2. Engine Power Issue: The car experiences jolts and kicks back during acceleration, along with intermittent lack of power. Furthermore, an independent mechanic performed some tests on the engine, determining that it runs too rich. After the second white smoke through exhaust incident, the vehicle struggles, and often does not reach, 60 MPH; aligning with "Reduced power and/or hesitation" (case #2) in the recall campaign. 3. Exhaust Smoke: On two separate occasions, within a month, white smoke has been observed exiting the exhaust. Engine oil has been below 3/5 empty each time. No oil leak found; must be exiting through exhaust. Despite qualifying for the recall, the Hyundai Colorado Springs dealer has refused to inspect or replace the engine as required. These ongoing issues pose significant safety risks, including the potential for unexpected engine failure and loss of power while driving.
Crash:
No
Fire:
No
Injuries:
0
Deaths:
0
#11615061September 17, 2024
ENGINE
On [XXX] I was driving down a busy 4-lane in Los Angeles and my engine suddenly died. There were no warning signs like indicator lights or warning noises. It was traumatic and frightening and I thought I was going to be struck by a car or truck. I had little control over the car-it would not accelerate to get out of the road lane. I was coasting, stopped half toward the side of the road but still sticking out in the road lane and was terrified I'd get hit by another vehicle from my back driver's corner. Cars and trucks that were traveling at normal speed were trying to avoid a collision with me and swerving around me, putting myself and others at risk for serious injury or death. I had had all the systems updated 2 years ago at a HMA, Hyundai dealership as I was directed, which included the KSDS (Knock Sensor Detection System). Dealer said it was to warn me of possible engine noise and issues. I never got any warning. I was NEVER told by anyone including Hyundai or any regulatory agency that the engine could suddenly fail as I'm driving the car OR I WOULD NOT HAVE BEEN DRIVING IT! There were never any warnings at that time or any time that anything was wrong with the vehicle. The car was towed to a Hyundai dealership and they diagnosed the problem on 8/28/2024 as a failed engine bearings clearance test at 63Kmiles. I kept all maintenance records, all done timely and properly with full synthetic oil. The components were assessed by the Hyundai dealership in communication and with guidance through HMA, Hyundai Technical /Techline confirmed failed engine bearings clearance test. My engine was not making any noises beforehand at all, and no engine warning light or sounds gave any warnings to be cautious or do anything other than drive normally. I was told I need an engine replacement. A Prior Approval for the engine replacement was started on 8/28/24 and sent to HMA, Hyundai. 9/17/2024, I still don't have engine replacement, dealer refuses to give records. INFORMATION REDACTED PURSUANT TO THE FREEDOM OF INFORM
Crash:
No
Fire:
No
Injuries:
0
Deaths:
0
#11613852September 10, 2024
ENGINE
Engine was replaced in Feb. 2020 as part of the 162 engine recall. Car engine completely shuts down while driving and cannot be restarted for 20 or so minutes. This leaves me stuck in traffic with no ability to move the car. The new engine only has 40,000 miles on it. Dealership first said it was an issue with the engine and valves but when I wanted them to pay, they said the car is fine and passes all inspections. The check oil light and engine light come on when the engine stops, but they are not on prior to the engine stalling. I have made three visits regarding this - 1 to my personal mechanic and two to the Hyundai dealership. I filmed a video of the stall but it is too long to upload.
Crash:
No
Fire:
No
Injuries:
0
Deaths:
0
#11607969August 12, 2024
SERVICE BRAKES, AIR:ANTILOCK:MODULATOR
See attached document for complaint
Crash:
No
Fire:
No
Injuries:
0
Deaths:
0
#11607113August 7, 2024
ENGINE
vehicle was driving then all of a sudden there was an excessive amount of white smoke coming out of exhaust Engine was making a clicking sound before like a card in spokes on a bike and has been excessively consuming oil recently Auto shop discovered that a piston came loose and was rattling around the engine until it eventually shot through the engine
Crash:
No
Fire:
No
Injuries:
0
Deaths:
0
#11604688July 26, 2024
ENGINE
This past Tuesday, July 23, 2024, I started to drive out of my driveway and I heard a very loud knocking noise coming from under the hood. Upon driving the car less than 100 feet the car lost power. It was extremely difficult to get the car back to my driveway. The car was completely impossible to drive and control of my Santa Fe Limited was lost. I had a tow company tow my Santa Fe to the place where I got normal routine service done. Both the tow truck driver and the owner of the auto service business stated the failure was a broken connecting rod or something very similar in the engine. The result was the engine is not able to be repaired and would need to be replaced by a new engine. I purchased the Santa Fe Limited new on May 17, 2024 and I am the only owner. It currently has 72,600 miles on it. I performed all service requirements and changed oil and filter every 5000 miles. Also had my tires rotated and balanced every 5000 miles.
Crash:
No
Fire:
No
Injuries:
0
Deaths:
0
#11603507July 20, 2024
UNKNOWN OR OTHER, STRUCTURE:BODY
Drive side door latch does not open from inside or out. Even after removing inner door panel and manually pulling latch cables the latch remains in the locked position. This is an obvious and major safety issue where the driver is unavailable to exit the vehicle. Other years were recalled for this issue however my 2014 model is not on the recall list for some reason. Even though the very same safety issue with door latch occurs.
Crash:
No
Fire:
No
Injuries:
0
Deaths:
0
#11603404July 19, 2024
ELECTRICAL SYSTEM, UNKNOWN OR OTHER
I took my vehicle in for recall and they replaced the fuse box. Starting that day, the auxiliary power outlet in the rear (trunk) started to short out my pump that I have used many times while blowing up lake tubing equipment. Also since then my trunk has been randomly opening on its own (mostly while I’m asleep). It is happening about every 3 days. There is nothing in the way of the latch or the door and it is closed and locked before I walk away. Started happening 6/29 and the recall replacement was on 6/27
Crash:
No
Fire:
No
Injuries:
0
Deaths:
0
#11603450July 19, 2024
UNKNOWN OR OTHER
A/c works but will not cool checked for leak none can be located- Frion added will not work
Crash:
No
Fire:
No
Injuries:
0
Deaths:
0
#11601984July 14, 2024
FORWARD COLLISION AVOIDANCE: AUTOMATIC EMERGENCY BRAKING
Recently, three different lights went on in my car. When looking it up online I found recall number 251 from Hyundai and it matches the lights and issues my car is facing. However, when looking it up via my VIN there are no open recalls.
Crash:
No
Fire:
No
Injuries:
0
Deaths:
0

← Back to Hyundai Santa Fe