Hyundai Motor America (Hyundai) is recalling certain 2017-2018 Ioniq HEV and Ionic PHV vehicles previously recalled under recall number 18V-704. The Power Relay Assembly (PRA) located underneath the rear seat may overheat.
Hyundai Motor America (Hyundai) is recalling certain 2017-2019 Ioniq electric vehicles. An unstable electrical ground may cause the vehicle to enter a fail-safe mode with reduced acceleration and power. In certain conditions while in fail-safe mode, the vehicle may accelerate after the gas pedal is released.
Hyundai Motor America (Hyundai) is recalling certain 2017-2018 Hyundai Ioniq Hybrid and 2018 Ioniq Plug-In Hybrid vehicles. The Main Relay within the Power Relay Assembly (PRA) may have inadequate connections between its contacts, causing increased electrical resistance.
Hyundai Motor America (Hyundai) is recalling certain 2017 Hyundai Ioniq Hybrid vehicles. The Hydraulic Clutch Actuator (HCA) inner oil seal may leak, allowing oil to accumulate in the cap area, possibly resulting in an electrical short.
Hyundai Motor Company (Hyundai) is recalling certain 2017 Ioniq Electric Vehicles. Manufacturing defects within the Electronic Power Control Unit (EPCU) may allow coolant to contact the unit's circuit board.
After the Dealership, Michigan City Hyundai (MCH), performed part of the needed repairs, I became aware of what could/would have been a fire hazard (as evidenced by brownish/black heat spots, on the metal cover of the hybrid battery, under the rear seat. To maintain its recall-denial, MCH blames the hybrid starter generator (HSG) for the damage to the hybrid battery. The noted heat-spots prove otherwise - the power relay assembly (the subject of one of the recalls related to my car), and its malfunction and consequent generation of excessive heat, is what caused severe damage to the hybrid battery. The other failed component (hybrid system generator - HSG) is directly related to the hybrid clutch actuator (HCA), which is the subject of the 2nd recall affecting my car. The malfunction of the HCA is what damaged the HSG. The NHTSA database shows no open recall affecting my car VIN, is because dealer IL093 (who sold me the car around April 2025), logged both recall remedies as applied in Hyundai's internal database. The selling dealer (IL093), which claims to have completed the Power Relay Assembly and Hydraulic Clutch Actuator recalls on my vehicle, was under the ownership of Leader Automotive Group during the timeline of the alleged repairs and my April 2025 purchase. Leader Automotive Group was sued and penalized $20 million by the FTC and the State of Illinois for systematic consumer fraud, deceptive practices, and concealing voided manufacturer warranties. Because the physical components have now suffered the exact catastrophic failures these recalls were designed to prevent, there is a high probability that dealer IL093 fraudulently logged these recall remedies as completed without physically performing the work. I request that the NHTSA Office of Defects Investigation immediately audit IL093's repair logs for this VIN in light of the FTC enforcement action.
No injuries · No fire · No crash
I was driving my two young daughters (ages [XXX] and [XXX]) to school, in clear conditions, when we suddenly heard a static-like noise. Instantly, the car's check engine light and check EV battery light came on, and I realized I could no longer accelerate. I immediately pulled off to a safe shoulder and turned the car off and then back on. The car would not move. I exited the vehicle and THANKFULLY left my car door open. I walked around the vehicle and immediately called my husband for help. Within seconds, my [XXX] daughter, who was sitting directly behind me in the rear driver's seat, told me she saw smoke. I went to open her door and realized it was locked. My key fob and door lock would not unlock her door. I reached through my seat to open her door and instantly saw the smoke coming from a vent just to the left of her legs. I unbuckled her and pulled her out, and climbed through the vehicle to get my [XXX] unbuckled and safely out of the vehicle. I cannot stress enough how grateful I am that my car door was left open because I don't believe I would have been able to break the glass to get my daughters out. The could have easily died. Within a minute of the smoke starting from my daughter's vent, the flames began from the same vent. I got both daughters away from the vehicle asap. While trying to grab what I could from the vehicle, my fires on my right hand were caught in the fire. The vehicle became fully engulfed in fire and was a total loss. Two volunteer fire departments responded. I have both the fire incident report as well as the police incident report. The police report only mentioned one daughter but witnesses can attest that I had to get BOTH daughters out. Following the incident, I went to the doctor to receive care for my burns and received a chest x-ray due to smoke inhalation. My [XXX] daughter has been traumatized and keeps thinking something is wrong with her. She told me her bottom felt very warm just before I pulled her out. INFORMATION REDACTED PURSUANT TO THE FREEDOM OF INFORMA
The vehicle has suffered a catastrophic failure of the hybrid drive motor rotor, transmission, and engine clutch, resulting in a $14,993 repair quote. This is a direct consequence of a failed remedy for NHTSA Recall 18V260 (Hyundai Campaign 176).In February 2020, a dealer performed an 'inspection/cap' remedy under Campaign 176. However, this did not permanently fix the manufacturing burrs on the hydraulic clutch actuator housing. Over time, the inner oil seals degraded exactly as warned in the original defect report. Hydraulic fluid leaked into the electric stepper motor, causing an electrical short circuit that destroyed the entire hybrid powertrain. The vehicle lost propulsion and threw a severe Hybrid Warning Light on the dashboard. This represents a complete failure of a mandated safety recall remedy, introducing an active electrical short circuit and a severe vehicle fire hazard.
No injuries · No fire · No crash
The contact owns a 2017 Hyundai Ioniq Hybrid. The contact stated that the vehicle failed to start with several unknown warning lights illuminated. Additionally, the message "Starting Engine to Avoid Battery Discharge" was displayed. The vehicle was later towed to the local dealer who diagnosed that the 12-volt lithium battery had melted and expanded and needed to be replaced, along with the power relay assembly and fuse. The vehicle was not repaired. The manufacturer was contacted. The contacted stated that the vehicle was previously serviced and inspected under NHTSA Campaign Numbers: 22V459000 (HYBRID PROPULSION SYSTEM) and 18V704000 (HYBRID PROPULSION SYSTEM). The contact stated that the vehicle had experienced the failure listed in the recalls. The failure mileage was 135,262.
No injuries · No fire · No crash
January 2022. The car was brought to dealership because the transmission was slipping in 3rd gear. Service light was on. On my way the problem fixed itself. I explained that it happened only in the extreme cold here in michigan. They documented for warranty. Said it may be due to clutch overheating on slippery roads. IT WAS NOT. The cars was not used for 2 winters as we were in Florida. Dec. 2025 it happened again and expressed my concerns that if this happened in traffic it could be dangerous. Both the dealership and Hyundai washed there hands of it even though I was assured that it would be covered and addressed it it happened again. The service light came on but the problem fixed itself . I do not believe this is a mechanical issue, it sure would have failed by now. Software/electronic.
No injuries · No fire · No crash