CERTAIN MOTORCYCLES EQUIPPED WITH COMBINED-BRAKE SYSTEMS HAVE A PROPORTIONING CONTROL VALVE (PCV) THAT MECHANICALLY PROPORTIONS BRAKE FORCE WHEN THE REAR BRAKE IS APPLIED. A SEAL IN SOME PCVS IS IMPROPERLY SHAPED, AND BRAKE FLUID LEAKAGE MAY OCCUR.
ON CERTAIN MOTORCYCLES, THE MAIN WIRE HARNESS HAS A GROUND DISTRIBUTION CONNECTOR THAT IS INCORRECTLY ASSEMBLED. SOME ELECTRICAL CIRCUITS MAY OVERHEAT AND SHORT, INCLUDING THE FUEL PUMP.
ON CERTAIN MOTORCYCLES, THE ROUTING OF SOME WIRE HARNESSES MAY ALLOW A CONNECTOR TO CONTACT AND CHAFE AGAINST THE FUEL TANK.
REAR WHEEL BEARING FAILURE: THE DRIVEN FLANGE BEARINGS WHICH TOGETHER MAKE UP THE RIGHT SIDE REAR WHEEL BEARING FAILED AT LOW MILEAGE. THESE TWO BEARINGS FAILED AT 21,000 MILES, AND WERE DISCOVERED AT A ROUTINE TIRE CHANGE. OTHERS HAVE REPORTED SIMILAR AND NEAR CATASTROPHIC BEARING FAILURES AT SIMILAR MILEAGES . SEE HTTP://GROUPS.MSN.COM/ST1300US AND WWW.ST-OWNERS.COM/FORUMS WHEEL BEARINGS CAN BE EXPECTED TO LAST FOR THE LIFE OF THE VEHICLE, BEARING UNUSUAL STRESSES. THESE BEARINGS WERE APPARENTLY SUB STANDARD IN QUALITY AND/OR DESIGN AND SHOULD BE EXAMINED AND REPLACED IMMEDIATELY. CONSEQUENCES OF WHEEL BEARING FAILURE COULD RANGE FROM SIMPLE DISABLEMENT TO SERIOUS CRASHES.*AK
No injuries · No fire · No crash
CONSUMER CONTACTED THE DEALER TO HAVE RECALLS REPAIRS PERFORMED ON HIS 2003 HONDA ST1300 AND WAS INSTRUCTED TO BRING IT BACK AT THE END OF THE SUMMER TO HAVE THE WORK PERFORMED BECAUSE THEY WERE BUSY. *MR RECALL CAMPAIGN#'S 04V549000 AND 05V010000. *SC *JB
No injuries · No fire · No crash
CONSUMER RECEIVED RECALL 04V549000 AND THREE CONSUMER SERVICE AWARENESS CAMPAIGNS. NO PARTS FOR THE RECALL WIRE HARNESS HAVE BEEN MADE AVAILABLE.*AK
No injuries · No fire · No crash
RECALL CAMPAIGN. 2003 HONDA ST 1300 MOTORCYCLE, STALLS ON THE INTERSTATE. *BF THE CONSUMER HAD BEEN TRYING TO GET HIS MOTORCYCLE REPAIRED EVER SINCE HE RECEIVED THE RECALL LETTER IN THE MAIL ON DEC 20,2004. THE CONSUMER WAS ALREADY HAVING PROBLEMS WITH THE MOTORCYCLE, BUT THE PROBLEM WAS SPORADIC. EVERYTIME THE CONSUMER CONTACTED THE DEALER, HE WAS TOLD THE PARTS WERE NOT IN UNTIL FINALLY ON FEB 7 2005, THE BIKE FINALLY STOPPED. RECALL#04V549000 *JB *SC
No injuries · No fire · No crash
I WAS AT MY HONDA MOTORCYCLE DEALER TODAY FOR THE THIRD TIME. THE DEALER IS OCALA MOTOR SPORTS IN OCALA, FLORIDA. THEY STATED THAT PARTS ARE STILL UNAVAILABLE FOR THE FIRST RECALL ON MY MOTORCYCLE. THE DATE OF THE FIRST RECALL WAS NOV. 19, 2004. IT WAS NHTSA CAMPAIGN ID # 04V549000. THERE HAVE BEEN TWO SUBSEQUENT RECALLS SINCE THEN MAKING IT A TOTAL OF THREE RECALLS, THE LATTER TWO BEING 04V568000 & 05V010000. I THINK THAT THREE MONTHS IS A TOTALLY UNREASONABLE TIME FRAME TO EVEN RESPOND TO THE FIRST RECALL. WHEN YOU PAY OVER $13,000.00 FOR A MOTORCYCLE, YOU DON'T EXPECT IT TO BE PARKED FOR 3 MONTHS.
No injuries · No fire · No crash