GMC Sierra Complaints

15,732 consumer complaints on file.

#11709974January 9, 2026
ENGINE, POWER TRAIN
While traveling down the highway at approximately 60-65mph I pressed the accelerator to change lanes and pass a tractor trailer when it felt like my transmission slipped very abruptly. There was a very noticeable power loss and the truck would not accelerate. Then I noticed a loud knocking noise coming from the engine. No check engine light or any other indications on the dash to let me know there was a problem. I began to try and merge to the right of the highway to get off which was not easy do to the power loss and heavy traffic on the highway at the time. I made it to the right lane to exit the highway and when I slowed down the engine died and I had to coast to a stop luckily on an exit ramp. The truck was towed to a dealership and they state that I will need a new engine. I know this issue is already well documented with the GM 6.2l engines but I is very unsettling that the engine just died on the highway at highway speeds and no indications.
Crash:
No
Fire:
No
Injuries:
0
Deaths:
0
#11709666January 8, 2026
UNKNOWN OR OTHER, AIR BAGS
Our Dash board cracked very badly from the top next to the speaker to the passenger side air bag. We purposely use a dash board cover and never place heavy things on it. This is a safety issue as if getting in an accident wouldn’t be bad enough flying shrapnel would be worse. We just had it fixed at a dealership to the tune of $2500. This is not okay as I see this is a constant problem.
Crash:
No
Fire:
No
Injuries:
0
Deaths:
0
#11709671January 8, 2026
POWER TRAIN
I was driving my vehicle on the highway when the transmission suddenly gave out with no warning whatsoever. When I say gave out, I mean, it just completely stopped working and was unable to go into any gear. I was luckily able to coast over to the median without an accident occurring, but it was not without much concern or worry as traffic moving on the highway is 70 miles an hour plus and quite full of vehicles .I consider myself lucky that I have extensive driving experience and was able to conduct myself calmly under the circumstances. It was a bit tricky, getting situated though under those circumstances. There was no advanced warning in anyway. no engine lights, no sounds ,nothing. This is a well maintained vehicle. All my service is done by the dealership, and I have never been given any indication that there was something wrong. However,After this happened, I have been researching and found that many of these vehicles with this transmission continue to have this problem. This is not normal wear and tear or normal mechanical failure. I have owned many vehicles and never felt as unsafe as I did in that moment, or had a vehicles transmission fail so abruptly.For me, and the research I have done, I can only hypothesize the materials and engineering involved with this transmission are inherently inferior, completely faulty, and a safety risk/hazard to anyone who owns or operates the vehicle. I consider myself lucky to walk away unscathed, other than the economic price that it is going to incur on my finances for repairs.I would hope that it doesn’t take something serious to happen before someone takes action and conducts a recall of this product. From what I have read and what I have experienced, this is truly an unfortunate accident waiting to happen and it appears nothing is being done. I truly hope that you could take a little more look into this matter. Thank you for your time and energy. I have already contacted the manufacturer and felt ignored.
Crash:
No
Fire:
No
Injuries:
0
Deaths:
0
#11709760January 8, 2026
ENGINE
Luckily, truck was sitting in idle waiting on my wife and daughter to leave the store so we could go home. Engine began to run rough, and then died. Would not restart. Had this happened just a few moments later while in traffic, it could have been catastrophic for our family. GM dealership said the engine was nearly locked up and needed a new long block and several other ancillary parts. So far, we have no internal pictures and nothing was harmed externally.
Crash:
No
Fire:
No
Injuries:
0
Deaths:
0
#11709304January 7, 2026
ELECTRICAL SYSTEM
Muti pro tailgate has electric issues due to moisture. Tailgate will open up driving down the road.
Crash:
No
Fire:
No
Injuries:
0
Deaths:
0
#11709335January 7, 2026
POWER TRAIN, ENGINE
I had a lifter fail which is a well known problem for these GM engines. The lifter caused the cam shaft to be damaged because of the lobes being shaved off. Now I’m being told that it will be over $10,000 fix a 3 year old truck.
Crash:
No
Fire:
No
Injuries:
0
Deaths:
0
#11709368January 7, 2026
ENGINE AND ENGINE COOLING, VISIBILITY:DEFROSTER/DEFOGGER/HVAC SYSTEM:COMPRESSOR
The contact owns a 2025 GMC Sierra 1500. The contact stated that while driving at 35 MPH, there was an abnormal knocking sound coming from the engine. No warning lights were illuminated. The vehicle was towed to the dealer, where it was diagnosed with a rough idle code, and that the thermostat coolant housing had failed. The contact was provided DTC codes: B1A76 with failure Code 0X15 (pending), P05D, U0075, U0101, U0146, U020C, U0265, U1614, and U1616, and the codes were active. The vehicle was repaired. The contact picked up the vehicle from the dealer after hours, and when the contact started the vehicle, the abnormal knocking sound was still coming from the engine. No warning lights were illuminated. The contact stated that when the A/C was turned off, the abnormal sound ceased. Additionally, the contact performed the oil changes on the vehicle and noticed that the engine was consuming an excessive amount of engine oil. The contact stated that there were no oil stains on the ground. The contact needed to add oil every 800 to 1,000 miles driven. The vehicle was taken to O'Reilly's Chevrolet, located at 6160 E Broadway Blvd, Tucson, AZ, for a diagnostic test, and it was determined that the air compressor had failed. The vehicle was not repaired. The vehicle remained at the dealer pending the repair. The contact stated that when the A/C was activated, the knocking sound in the engine compartment returned. The manufacturer was not made aware of the failure. The failure mileage was approximately 18,000.
Crash:
No
Fire:
No
Injuries:
0
Deaths:
0
#11709456January 7, 2026
STRUCTURE
The contact owns a 2022 GMC Sierra 1500. The vehicle was repaired under NHTSA Campaign Number: 25V060000 (Structure), but the failure occurred. The contact stated that while driving at 65 MPH, the top deflector shield detached from the vehicle. No warning lights were illuminated. The vehicle was not taken to the dealer or an independent mechanic. The vehicle was not repaired. The manufacturer was not notified of the failure. The failure mileage was approximately 13,100.
Crash:
No
Fire:
No
Injuries:
0
Deaths:
0
#11709499January 7, 2026
ENGINE
Complete engine shutdown after multiple issues of truck using 5 quarts of oil in-between oil changes. Engine was rebuilt at dealer at out of pocket cost over 10000
Crash:
No
Fire:
No
Injuries:
0
Deaths:
0
#11709500January 7, 2026
SERVICE BRAKES, ELECTRICAL SYSTEM
Lost brakes and couldn’t stop the truck
Crash:
No
Fire:
No
Injuries:
0
Deaths:
0
#11709032January 6, 2026
ENGINE
Engine failure. 6.2l with AFM system Extreme oil consumption Heavy metal in oil Loud ticking 120789 miles Purchase date 05/29/2025 Madras, Oregon Chevrolet Dealer
Crash:
No
Fire:
No
Injuries:
0
Deaths:
0
#11709134January 6, 2026
ENGINE, POWER TRAIN
My 2020 GMC Sierra with a 5.3L engine and 78,272 miles on the vehicle, experienced damaged lifters which also resulted in a damaged cam shaft. The total repair bill was $9,208.86. While in the GMC dealership for repair, there were 2 other trucks - same model, same year, same engine - in for the same repair. When searching on-line, I found the recall for the GMC 6.2L engine for similar issues. It is my opinion that the 5.3L engine is experiencing the same types of issues. I have driven GMC trucks for almost 40 years and have never experienced these types of issues. I have been told by several people that it is related to the Dynamic Fuel Management system and to fix the problem to disable the system to keep the truck in V8 mode. There are several solutions on line to make this happen. I am no engineer and only provide this as background information. From my perspective, it is clear that GM has a problem (whatever the root cause) with their 5.3L engines.
Crash:
No
Fire:
No
Injuries:
0
Deaths:
0
#11709135January 6, 2026
ENGINE, FUEL SYSTEM, GASOLINE
The contact owns a 2021 GMC Sierra 1500. The contact stated that after driving on a trip, the contact noticed that the vehicle had lost 10 MPG after a software update was performed. The check engine warning light was illuminated. The vehicle was taken to Richardson Chevrolet (3825 S Huron Rd, Standish, MI 48658), who confirmed that the vehicle was working as designed. The check engine warning light was reset. The vehicle was not diagnosed or repaired. The manufacturer was contacted and opened a case, and referred the contact to the NHTSA Hotline for assistance. The failure mileage was approximately 57,000.
Crash:
No
Fire:
No
Injuries:
0
Deaths:
0
#11709155January 6, 2026
ENGINE
There is a Service Bulletin on the Engine Oil Cooler line failure. It leaks or becomes detached form the crimp joint. Mine is leaking from the crimp joint and GMC says my VIN is not covered under this bulletin. N192220080 if this is a known issue on these vehicles why am I having to cover the costs for replacing a known faulty part. GMC said I could bring it in and have them perform the repair at my cost. The nearest service department is 100 miles away. I have it at a local mechanic that says it will cost anywhere from $1300 to $1500 to perform the repair.
Crash:
No
Fire:
No
Injuries:
0
Deaths:
0
#11709159January 6, 2026
EXTERIOR LIGHTING
My right headlamp/ turn signal assembly began flashing at random intervals. The high beam would come on and off randomly. The entire assembly would randomly flash along with the turn signal. The headlamp would go on and off randomly. This included switching between setting. High beam, low beam, daytime running light, and completely off with no warning. This causes blinding conditions for oncoming drivers, loss of visibility for driver, and loss of visibility during inclement weather due to high beam coming on and off, then entire unit turning off. As of right now, the vehicle is undrivable due to incorrect lighting, and flashing lights.
Crash:
No
Fire:
No
Injuries:
0
Deaths:
0
#11709235January 6, 2026
ENGINE
My engine started making a clicking noise like a playing card in a bicycle spokes. Was able to drive and make it to dealership and they determined that my engine crankshaft had to much end play and they needed to replace the engine. They had my truck approximately 2 weeks, did not provide me a loaner, nor any reimbursement for being without my truck during this time. My truck was still under the factory bumper to bumper warranty at the time.
Crash:
No
Fire:
No
Injuries:
0
Deaths:
0
#11709276January 6, 2026
ENGINE
Complete engine failure with no warning on major road in heavy traffic. Very dangerous situation to pull off safely. Vehicle was towed to dealer and confirmed engine is seized. Unknown cause at this time. Transmission has had valve body replaced prior to engine failure. Transmission still has shudder after valve body replacement and prior to engine failure.
Crash:
No
Fire:
No
Injuries:
0
Deaths:
0
#11708721January 5, 2026
VISIBILITY/WIPER
If truck has a “dusting of snow” on it, blower motor for defrost and heat retracts to absolute “low” setting to supposedly protect the blower motor. Have been caught driving in snow, and defrost couldn’t keep up with keeping windshield defrosted due to this behavior. Had to pull over on expressway to clean vents on the cowl from snow in order for the defrost to work properly. According to GM, this is normal behavior. In fact this is extremely dangerous and should be investigated and a recall to repair should be made. Having to pull over to remove snow from the cowl, open the hood to clear the other vents is not safe.
Crash:
No
Fire:
No
Injuries:
0
Deaths:
0
#11708817January 5, 2026
ENGINE
5.3L V8 L84 Engine, 101,300 2nd owner Slowed down for traffic and was accelerating back to 80 when sudden loss of engine power coinciding with cylinder failure happened. Dealership determined lifter was collapsed. Lifter 1 failure at interstate speeds. Collapsed lifter caused damage to camshaft required both components to be replaced.
Crash:
No
Fire:
No
Injuries:
0
Deaths:
0
#11708994January 5, 2026
ENGINE
3.0 Duramax Engine Failure - 2026 GMC Sierra 1500 Denali Ultimate at just 6,755 miles and only 77 days of ownership. Within the first few thousand miles, the truck intermittently had warnings appear of “reduced acceleration, drive with care”. The truck would limit its ability to maintain speed. When it occurred during highway driving, it was particularly dangerous. The check engine light would also come on. After parking the vehicle for a bit and restarting it, things returned to normal. At the dealership, we reported the issue and leaned the computer reveled a P06DD code which required them to check the crankshaft for excessive play. Our truck was out of specification requiring complete engine replacement at just 6,755 miles. “Service Bulletin 25-NA-307 which states this code may set due to thrust bearing failure. following 25-NA-307 checked crankshaft end play and got a reading of 0.3400 in. the maximum spec is 0.0124 in.“ GM and Laura Buick GMC should not have sold this truck to us without inspecting it for this known issue. This extensive repair required complete removal of the cab from the chassis.
Crash:
No
Fire:
No
Injuries:
0
Deaths:
0

← Back to GMC Sierra