Ford Motor Company (Ford) is recalling certain 2018-2022 Transit Connect, 2019-2020 MKZ, MKX, Edge, Continental, F-150, Nautilus, Fusion, 2019-2023 Ranger, Mustang, 2020-2021 EcoSport, Expedition, Navigator, 2020-2022 Escape, F-250 SD, Corsair, 2020-2023 Aviator, Transit, 2020-2024 Explorer, 2021-2024 Bronco Sport, and 2022-2024 Maverick vehicles. A software error may cause the rearview camera to display a blank image, or the image may remain on the display after the backing event has ended.
Ford Motor Company (Ford) is recalling certain 2019-2020 Transit Connect vehicles previously repaired incorrectly under recall number 20V-636. The powertrain control module (PCM) software has fail-safe temperature threshold values higher than intended for the engine. This may delay engine cooling and result in engine overheating.
Ford Motor Company (Ford) is recalling certain 2017-2019 Transit Connect vehicles. An improper bond may exist between the panoramic roof and the vehicle body, which can result in the panel detaching from the vehicle.
Ford Motor Company (Ford) is recalling certain 2013-2019 Escape, 2013-2018 C-Max, 2013-2016 Fusion, 2013-2021 Transit Connect, and 2015-2018 Edge vehicles. The bushing that attaches the shifter cable to the transmission may degrade or detach.
Ford Motor Company (Ford) is recalling certain 2013-2021 Transit Connect vehicles equipped with 2.5L engines. The bushing that attaches the shifter cable to the transmission may degrade or detach.
Right front brake caliper locked on without warning ( or warning lights). Overheated brake components and tire, necessitating replacement of brake rotor, pads, fluid, tire valve stem. Pedal went to floor, luckily on level ground. Loss of braking and control. Replacement parts failed within 200 miles.Independent Repair shop traced problerm to failure of ABS module, as right front AND left rear brakes not releasing fully. Part Number: KV6Z2B373A. No warning lamps present.
No injuries · No fire · No crash
Since I’ve bought it at 48,000 miles the van has always had hard engagements on 1 gear and 2nd. I knew the transmission was bad a week after I bought it at the ford dealership. All they did under their limited warranty was a transmission flush. Now it has 70,000 and the torque converter is toast now. I was on the interstate going 70mph. Let off the gas and a huge aggressive deceleration happened and I almost lost control. It is constant issue now when going over 70mph. Took it to ford, no transmission codes so they didn’t try fix it or find anything wrong. Noticing high rpms trying to get up to speed. Torque converter is clearly slipping.
No injuries · No fire · No crash
Description of Defect: When the vehicle is shifted into reverse, the rearview camera display freezes for several seconds before going black. This malfunction creates a direct and serious safety hazard — during the period the display is frozen, the image shown does not reflect actual real-time conditions behind the vehicle. Any pedestrian, child, or object that moves into the path of the vehicle after the display freezes will not be visible to the driver. This significantly increases the risk of a backover collision. Dealership Inspection Outcome: I brought the vehicle to an authorized Ford dealership for diagnosis. Upon inspection, the technician was unable to detect the diagnostic trouble code associated with Recall 25S89, and as a result, the vehicle was deemed to have passed inspection. However, the malfunction continues to occur. The failure to trigger the recall code does not resolve the underlying issue — the camera display still freezes and blacks out during reverse operation, leaving the driver without a functioning rearview safety system. Safety Concern: A rearview camera is a federally mandated safety feature. A display that intermittently freezes and then goes dark is functionally equivalent to having no camera at all during those critical moments. This is not a minor inconvenience — it is a safety system failure that puts pedestrians and other individuals behind the vehicle at risk every time the vehicle is put in reverse. Requested Action: I am requesting that NHTSA investigate whether Recall 25S89 adequately captures all failure modes associated with this defect, and whether vehicles that present with this symptom but do not trigger the associated diagnostic code are being improperly cleared at dealerships. A remedy should be identified and applied to all affected vehicles regardless of whether the recall code is detected during inspection.
No injuries · No fire · No crash
The vehicle has only been driven for 24K miles and there was an issue with the ABS Hydraulic Control Unit (HCU) and the recommendation is for it to be completely replaced. Seems ridiculous if the ABS Hydralic Control Unit is meant to last 100k-200k miles.
No injuries · No fire · No crash
While traveling on the freeway after approximately 45 minutes of driving at 65 mph, the car suddenly felt like it was down shifting causing it to slow substantially. When I tried to accelerate to avoid cars behind me from hitting me, the car prevented me from speeding up for approximately five seconds. RPM is over 5000 b4 it allowed speed up. This happened on two separate occasions,. The car would not start after the second trip and was towed to a Ford dealer for repair. I was told I needed a new alternator and battery and what I experienced on the freeway was the alternator impacting the transmission. I picked up what I thought was a repaired vehicle, traveled to one of the same places I had gone previously and approximately 45 minutes into my drive, the same event took place with the car. Slowing severely and not allowing me to accelerate to return to freeway speed for approximately five seconds. It was taken back for repairs shortly thereafter. I was told it wasn't the transmission. It was a sensor in the brake system that causes the brakes to be applied just enough to create friction that heats up two of the wheels to such a high temp., the brake pads melted onto the rotors. The master cylinder, pads, rotors, sensors all needed replacement. The car is a 2019, purchased new, out of warranty with only 26,000 miles. Ford has offered to pay part of the repairs but expects me to pay the other portion. This car has been well cared for. Nothing I have done while driving it has caused their sensor to create such a dangerous situation on the freeway. It also started happening before it was driven to the dealership by refusing to move for five seconds every time the car came to a stop. I have read other accounts of the same situation happening to people who own the same model and year. This is a dangerous situation created by Ford's faulty equipment. The car is at Ford dealership waiting to be repaired for the 2nd time.
No injuries · No fire · No crash