Ford · Model Report
Showing safety data for the 1983 model year only.
CERTAIN FEDERAL-MOGUL AFTERMARKET FUEL PUMPS SOLD UNDER THE BRAND NAMES OF CARTER, ACCUFLOW, NAPA, TRUFLOW, PARTS DEPO, AND PARTS MASTER, SHIPPED BETWEEN AUGUST 2006 AND JULY 2007 FOR USE ON THE VEHICLES LISTED ABOVE. THE FUEL PUMP DIAPHRAGM IN CERTAIN PRODUCTION RUNS MAY HAVE BEEN IMPROPERLY INSTALLED OR INADEQUATELY TESTED WHICH MAY CAUSE THE FUEL PUMP TO LEAK.
EQUIPMENT DESCRIPTION: AFTERMARKET BRAKE ROTORS FOR USE ON CERTAIN FORD AND MAZDA TRUCKS. CRACKED CASTINGS CAUSED CRACKS TO APPEAR ON THE OUTER DIAMETER OF THE ROTOR HAT OR AROUND THE STUD HOLE.
THE FLEXIBLE HOSE CONNECTING THE FUEL PUMP TO THE CARBURETOR FUEL LINE MAY SEPARATE FROM THE FUEL PUMP.
SECONDARY HOOD LATCH COMPONENTS MAY HAVE BEEN IMPROPERLY POSITIONED DURING ASSEMBLY. IF THE HOOD IS NOT CLOSED TIGHTLY, OR IS INADVERTENTLY RELEASED, THE SECONDARY LATCH MAY NOT WORK AND THE HOOD MAY FLY UP WITHOUT PRIOR WARNING.
IF TRUCK IS STRUCK FROM THE SIDE, THE CAP ON THE FUEL TANK COULD BECOME UNSEALED, ALLOWING UNSAFE LEAKAGE OF FUEL. THIS IS A FAILURE TO COMPLY WITH THE REQUIREMENTS OF FEDERAL MOTOR VEHICLE SAFETY STANDARD 301, "FUEL SYSTEM INTEGRITY". LEAKAGE CAN BE CAUSED BY AN ORANGE-COLORED PLASTIC DIESEL FUEL INFORMATION RING WHICH IS FOUND AROUND THE FUEL TANK NECK, OR BY THE TETHER.
WHEN DRIVING THE VEHICLE AT ANY SPEED, THE VEHICLE WOULD STALL. THIS CAUSED THE DRIVER TO DRIFT TO THE SIDE OF THE ROAD. THE CONSUMER HAD THE VEHICLE TOWED TO THE DEALER. THE MECHANIC WAS UNABLE TO DUPLICATE THE PROBLEM. PLEASE PROVIDE ANY FURTHER DETAILS. *JB
No injuries · No fire · No crash
TRANSMISSION WENT OUT DUE TO RUBBER SEALS NOT BEING RELIABLE. FAILURE CAUSED BY THE RUBBER SEAL USED TO HOLD FLUID IN THE TRANSMISSION--IT IS DRY AND CRACKS, ALLOWING FLUID TO LEAK. TRANSMISSION REPAIRED AT OWNER'S COST. *AK *ML
No injuries · No fire · No crash
BOTH FIRES OCCURRED WITHIN THE AIR CONDITIONER EVAPORATOR CORE UPPER HOUSING. BOTH APPEARED TO RESULT FROM THE AIR CONDITIONER BLOWER MOTOR RESISTOR ASSEMBLY IGNITING LEAVES WHICH HAVE BEN SUCKED INTO THE SYSTEM. *AK
BRAKE ROTORS FAILED.
No injuries · No fire · No crash
THERE IS BAD PRIMER ON THE CARS ALL OVER. *AK
No injuries · No fire · No crash