Ford Freestar Complaints (2005)

886 consumer complaints on file.

#10423882September 6, 2011
POWER TRAIN
VEHICLE SUDDENLY LOST FORWARD MOTION ON A BUSY STREET WITH NO SHOULDER. COASTED TO STOP WITH ENGINE RUNNING. PUT ON FLASHERS, BUT VEHICLES HAD TO SWERVE TO GO AROUND THE VAN. VEHICLE WOULD NOT MOVE IN DRIVE OR REVERSE. *TR
Crash:
No
Fire:
No
Injuries:
0
Deaths:
0
#10423688September 1, 2011
EQUIPMENT:MECHANICAL:ACCESSORY SCISSOR/SCREW/BOTTLE JACK/LIFT
CPSC# I1180537A. 2005 FORD FREESTAR. CONSUMER STATED HE HAD A FLAT TIRE. WHEN TRYING TO CHANGE HIS TIRE THE JACK CAME APART AND THE CAR CAME DOWN ON HIS ARM. HE BELIEVE THIS IS A POTENTIAL DANGER. *LN... UPDATED 09/15/11 *BF UPDATED 2/28/12 *CN
Crash:
No
Fire:
No
Injuries:
1
Deaths:
0
#10421662August 26, 2011
POWER TRAIN:AUTOMATIC TRANSMISSION
2005 FORD FREESTAR SE HAS APPROX. 70,000 MILES BOUGHT IT FOR A RETAIL OF 9,400 DOLLARS AND 4 MONTHS LATER THE TRANSMISSION GOES OUT (IN MARCH OF 2011). THANK GOD IT MY WIFE AND KID DIDN'T GET INTO A CRASH ON THE HIGHWAY WITH IT. WE JUST RECENTLY TOOK IT BACK TO THE DEALERSHIP TO LOOK AT IT AGAIN BECAUSE IT WON'T RUN IN GEAR AND THEY SAID ITS THE TORQUE CONVERTOR. SO WE TOOK IT BACK TO WHERE WE GOT IT REPAIRED AND THEY SAY THERES WATER IN THE TRANSMISSION. THIS WAS THE WORST 9,400 DOLLARS IVE EVER SPENT! WE HAVENT EVEN HAD THIS CAR FOR 9 MONTHS AND IT BEEN IN THE SHOP 50% OF THE TIME BESIDES THE OUT OF POCKET MONEY COST. HOW CAN FORD SELL SUCH A PIECE OF CRAP? *TT
Crash:
No
Fire:
No
Injuries:
0
Deaths:
0
#10421160August 23, 2011
POWER TRAIN:AUTOMATIC TRANSMISSION
TL* THE CONTACT OWNS A 2005 FORD FREESTAR. THE CONTACT WAS DRIVING 65 MPH WHEN THE VEHICLE STALLED WITHOUT WARNING. THE VEHICLE WAS TAKEN TO THE DEALER WHO DIAGNOSED THAT THE TRANSMISSION WAS DEFECTIVE AND NEEDED TO BE REPLACED. THE MANUFACTURER WAS MADE AWARE OF THE FAILURE WHO DID NOT OFFER ANY ASSISTANCE. THE VEHICLE WAS NOT REPAIRED. THE FAILURE AND CURRENT MILEAGE WAS 86,000.
Crash:
No
Fire:
No
Injuries:
0
Deaths:
0
#10419912August 17, 2011
POWER TRAIN:AUTOMATIC TRANSMISSION
I HAVE A 2005 FORD FREESTAR WITH 61000 MILES ON IT AND I HAVE HAD NO PROBLEMS NO SOUNDS NO NOTHING AND TODAY ON MY WAY HOME ON THE HIGHWAY IT JUST STOPPED MOVING LIKE I WAS IN NEUTRAL BUT I WAS IN DRIVE. I HAD TO PULL OVER IMMEDIATELY AS THERE WERE SEVERAL LARGE TRUCKS COMING UP BEHIND ME. I BARELY GOT IT OUT OF THE WAY. I WAS NOT ABLE TO FIND A SPOT TO KIND OF GET OUT OF THE WAY THEN I WOULD NOT BE HERE TODAY. *KB
Crash:
No
Fire:
No
Injuries:
0
Deaths:
0
#10418362August 10, 2011
TRACTION CONTROL SYSTEM
TL* THE CONTACT OWNS A 2005 FORD FREESTAR. THE CONTACT STATED THAT WHILE DRIVING 35 MPH, THE VEHICLE STALLED AND ALL OF LIGHTS ON THE INSTRUMENTAL PANEL ILLUMINATED. THE FAILURE WAS EXPERIENCED SEVERAL TIMES. THE VEHICLE WAS TOWED TO A LOCAL MECHANIC, WHO PERFORMED A DIAGNOSTIC TEST AND LOCATED THE FAILURE AT THE POWER TRAIN CONTROL MODULE. THE POWER TRAIN CONTROL MODULE WAS REPLACED. THE FAILURE MILEAGE WAS 20,000 AND THE CURRENT MILEAGE WAS 23,000. UPDATED 09/21/11*LJ UPDATED 2/23/12 *CN
Crash:
No
Fire:
No
Injuries:
0
Deaths:
0
#10418121August 9, 2011
POWER TRAIN:AUTOMATIC TRANSMISSION
TL* THE CONTACT OWNS A 2005 FORD FREESTAR. THE CONTACT STATED WAS DRIVING 20 MPH WHEN THE VEHICLE STALLED WITHOUT WARNING. THE VEHICLE WAS TOWED TO THE DEALER WHO PERFORMED A DIAGNOSTIC THAT LOCATED THE FAILURE AT THE TRANSMISSION AND ADVISED THE TRANSMISSION BE REPLACED. THE MANUFACTURER WAS CONTACTED AND ADVISED THAT THEY WOULD CONTACT THE DEALER ON THE CONTACT'S BEHALF. THE VEHICLE WAS NOT REPAIRED. THE FAILURE AND CURRENT MILEAGE WAS 93,000.
Crash:
No
Fire:
No
Injuries:
0
Deaths:
0
#10418096August 8, 2011
POWER TRAIN:AUTOMATIC TRANSMISSION
I HAVE THE SAME PROBLEM THAT EVERYONE ELSE IS COMPLAINING ABOUT. DRIVING ALONG AT 30 MPH. ALL OF A SUDDEN COMPLETE POWER LOSS AND REVVING. TOWED THE VEHICLE TO THE MECHANIC AND ALSO STATED I NEEDED A NEW TORQUE CONVERTER. MILEAGE ONLY 66,600. SEEMS TO BE AN ONGOING PROBLEM WITH THIS VEHICLE! *TR
Crash:
No
Fire:
No
Injuries:
0
Deaths:
0
#10417885August 8, 2011
POWER TRAIN:AUTOMATIC TRANSMISSION
2005 FORD FREESTAR 36,000 MILES WAS DRIVING HOME ON SURFACE ROAD ALONG A 2 MILE STRAIGHT AWAY VEHICLE BUCKED, (SURGED AND SLOWED) WHILE DRIVING 40 MILES AN HOUR PUT IT IN NEUTRAL AND REVVED THE ENGINE JUST FINE PUT IT BACK INTO GEAR AND IT DROVE ABOUT ANOTHER MILE DID IT AGAIN... SAME RESPONSE ON MY PART AND WAS ABLE TO LIMP IT BACK TO MY HOUSE WHICH WAS 3 MILES FROM ORIGINAL PLACE OF THE PROBLEM. I PARKED IT AND AFTER A SHORT GOOGLE OF THE PROBLEM FOUND HUNDREDS AFTER HUNDREDS OF PEOPLE WITH THE SAME PROBLEM. I'VE NOT REPAIRED IT YET.PENDING FINDING OUT WHAT MY OPTIONS ARE. *TR
Crash:
No
Fire:
No
Injuries:
0
Deaths:
0
#10417895August 8, 2011
POWER TRAIN:AUTOMATIC TRANSMISSION
HAVE A 2005 FORD FREESTAR WITH 64000 MILES ON IT. WHILE DRIVING DOWN A HIGHWAY WITH MY HUSBAND AND 5 CHILDREN IN THE CAR, IT JUST REVVED UP WITHOUT WARNING AND STARTED TO SLOW DOWN. NO DRIVE, REVERSE, LOW... NOTHING. THE TRANSMISSION JUST TOOK A VACATION. LUCKY AAA WAS CLOSE BY AND GOT THE CAR TOWED TO OUR HOME AND OUR FAMILY HOME SAFE. THE NEXT MORNING WE DECIDED TO GO OUT AND TRY TO START IT AGAIN AND SEE IF ANYTHING CHANGED. NOW THE CAR NOT ONLY HAS NO TRANSMISSION BUT THE CAR WONT EVEN TURN OVER. EVERYTHING ELSE WORKS. ITS NOT THE BATTERY, WHICH IS NEW. HAVE HAD REGULAR MAINTENANCE ON IT AND NOT HAD MANY PROBLEMS UNTIL NOW,. HAVE A CALL INTO FORD RIGHT NOW WAITING FOR A TECH TO CALL ME BACK WITH OPTIONS. SEEING SO MANY PEOPLE WITH THE EXACT SAME ISSUE , SEEMS TO ME FORD SHOULD BE TAKING CARE OF THIS ISSUE. *TR
Crash:
No
Fire:
No
Injuries:
0
Deaths:
0
#10417128August 4, 2011
POWER TRAIN:AUTOMATIC TRANSMISSION
THE TRANSMISSION IN MY 2005 FORD FREESTAR STOPPED WORKING WITHOUT WRINGING OR PRIOR INDICATION THAT SOMETHING WAS WRONG. MY WIFE BACKED OUT OF THE DRIVE AND THEN PUT THE VAN IN DRIVE AND IT WOULD NOT MOVE FORWARD. ALSO TRIED REVERSE AND IT NO LONGER WORKS EITHER. THIS NEEDS TO BE A RECALL BASED ON WHAT I AM REVIEWING ON SEVERAL WEB SITES. THIS TYPE OF REPAIR (THAT COULD HAVE BEEN AVOIDED WITH A BETTER DESIGN) IS COSTING APPROXIMATELY $2500 FOR EACH VEHICLE - WITH SOME OWNERS EXPERIENCING THIS ISSUE MULTIPLE TIMES! *TR
Crash:
No
Fire:
No
Injuries:
0
Deaths:
0
#10416608August 1, 2011
POWER TRAIN:AUTOMATIC TRANSMISSION, ENGINE AND ENGINE COOLING:COOLING SYSTEM, TIRES
I HAD TAKEN MY 2005 FORD FREESTAR VAN TO BE CHECKED FOR A PROBLEM WITH THE TRANSMISSION BECAUSE IT WASN'T SHIFTING PROPERLY. THEN LATER I HAD TAKEN IT TO A FORD DEALER FOR THE CHECK ENGINE LIGHT TO BE DIAGNOSED - THEY CLAIMED THAT IT COULDN'T BE DIAGNOSED BECAUSE IT DIDN'T WRITE THE CODE PROPERLY. TRANSMISSION STILL NOT SHIFTING PROPERLY. A MONTH LATER THE TRANSAXLE LIGHT CAME ON, THE ENGINE WASN'T RUNNING PROPERLY AND IN THE RAIN THE CHECK ENGINE LIGHT WOULD BLINK ON AND OFF. I TOOK IT TO A TRANSMISSION SPECIALIST WHO ACTUALLY TOOK THE TIME WITH THE VAN TO DIAGNOSE IT. HE HAD TO LET THE ENGINE WARM UP LONG ENOUGH FOR THE LIGHTS TO START COMING ON. THEN HE DIAGNOSED THE PROBLEM TO BE THE 2ND GEAR IN THE TRANSMISSION. ONCE THE TRANSMISSION WAS REMOVED HE SAID THAT IT COULDN'T BE FIXED SO I HAD TO INSTALL A NEW TRANSMISSION - $2700 LATER AND HAD TO BORROW A VEHICLE FROM FAMILY TO GO ON VACATION. I ALSO HAD TO REPLACE THE AIR COMPRESSOR FOR THE AIR CONDITIONER - $500 LATER BUT NOW IT SEEMS TO BE GIVING ME PROBLEMS AGAIN. I HAVE HAD NUMEROUS ISSUES WITH THE TIRES - THEY DON'T HOLD AIR BECAUSE OF THE RIMS THAT DON'T ALLOW THEM TO PROPERLY SEAL. I HAD THE DEALER PUT ON THE LAST SET OF TIRES AND TOLD THEM TO FIX THE ISSUE - SO FAR I HAVEN'T HAD AN ISSUE. BUT FOR 60000 MILES I HAVE HAD ISSUES. *KB
Crash:
No
Fire:
No
Injuries:
0
Deaths:
0
#10416321July 30, 2011
POWER TRAIN:AUTOMATIC TRANSMISSION
TRANS WENT OUT 10/09 WITH 69613 ML. HAD IT REPAIRED. SAID IT HAD SOMETHING TO DO WITH THE TORQUE CONVERTER. ON 2/11, 88K ML ON VAN, 18K ML ON REBUILT TRANS, IT WENT OUT AGAIN. I WAS LUCKY, BOTH TIMES IT QUIT WHEN MY WIFE WAS IN THE DRIVE WAY SO NO ONE WAS HURT. I HAVEN'T HAD IT REPAIRED AS YET, STILL DECIDING IF IT IS WORTH HAVING IT REPAIRED A 2ND TIME IF IT IS NOT GOING TO BE SAFE/DEPENDABLE. NOW I HERE THE CASE IS CLOSED! THE SUBJECT VEHICLES SUFFERED FROM A DESIGN ISSUE WHEREBY WATER COULD RUN DOWN ONTO THE COWLING AND THEN DRIP ON THE (PCM), WHICH COULD BE MANIFESTED IN A VARIETY OF SYMPTOMS. IN ADDITION TO CAUSING AN ENGINE TO STALL, IT COULD ALSO CAUSE THE TRANS TO SHIFT POORLY, HAVE ERRATIC POWER, AN INABILITY TO SHIFT THE VEHICLE INTO EITHER FORWARD OR REVERSE, AND CAUSE HIGHER IDLE RPM IN PARK. DURING THIS INVESTIGATION ODI WAS CONCERNED WITH THE EFFECT OF THE ENGINE STALLING OR A DRASTIC AND SUDDEN LOSS OF POWER EITHER OF WHICH MAY CREATE A SAFETY RISK. IN REVIEWING THE ACTUAL NUMBER OF THESE TYPES OF INCIDENTS, COLLECTIVELY REFERRED TO HERE AS ENGINE STALLS, THE NUMBER WAS FOUND TO BE BELOW WHAT WOULD BE CONSIDERED A DEFECT TREND. ACCORDINGLY THIS INVESTIGATION IS CLOSED. THE CLOSING OF THIS INVESTIGATION DOES NOT CONSTITUTE A FINDING BY NHTSA THAT A SAFETY-RELATED DEFECT DOES NOT EXIST. THE AGENCY WILL CONTINUE TO MONITOR COMPLAINTS AND OTHER INFORMATION RELATING TO THE ALLEGED DEFECT IN THE SUBJECT VEHICLES AND TAKE FURTHER ACTION IN THE FUTURE IF WARRANTED. EDT YOU MEAN TO TELL ME NHTSA DOESN'T FIND A DRASTIC AND SUDDEN LOSS OF THE TRANS TO CREATE A SAFETY RISK. DRIVING ON THE INTERSTATE OR PULLING INTO A BUSY INTERSECTION AND THE TRANS SUDDENLY QUITS, NO WAY TO MOVE OUT OF HARMS WAY. THERE ARE OVER 1500 MESSAGES ON EDMUNDS.COM , TELLING THE SAME STORY, BUT THAT'S NOT BEING LOOKED INTO. I SINCERELY HOPE THE AGENCY WILL CONTINUE TO MONITOR COMPLAINTS AND INFORMATION RELATING TO THE DEFECT AND TAKE FURTHER ACTION IN THE FUTURE BECAUSE IT IS WARRANTED. *TR
Crash:
No
Fire:
No
Injuries:
0
Deaths:
0
#10416310July 29, 2011
POWER TRAIN:AUTOMATIC TRANSMISSION
I HAVE 05 FORD FREESTAR WITH ONLY 66K MILES, AND TRANSMISSION FAILED. I HAD 6 KIDS WITH ME GOING CAMPING. OUR PLAN FAILED BECAUSE OF THIS I HAVE TO TOW IT ABOUT 600 MILES. I DON'T DRIVE IT SINCE THAN BECAUSE IT IS TO EXPENSIVE TO REPAIR. WILL NEVER BUY FOUND ON ROAD DEAD AGAIN. *TR
Crash:
No
Fire:
No
Injuries:
0
Deaths:
0
#10415317July 27, 2011
POWER TRAIN:AUTOMATIC TRANSMISSION
COMPLETE LOSS OF MOVEMENT POWER ON I-85 S ABOUT 20 MILES NORTH OF ATLANTA, GA. HAD VEHICLE TOWED TO MALL OF GEORGIA FORD IN SUGAR HILL, GA. DIAGNOSED AS COMPLETE TRANSMISSION FAILURE. NO INJURY OR ACCIDENT CAUSED BY FAILURE. I UNDERSTAND THIS IS A COMMON FAILURE FOR FREESTARS IN MODEL YEARS 2004 AND 2005. *TR
Crash:
No
Fire:
No
Injuries:
0
Deaths:
0
#10415270July 26, 2011
POWER TRAIN:AUTOMATIC TRANSMISSION
I WAS DRIVING ON THE FREEWAY AT NIGHT IN HEAVY TRAFFIC WHEN MY CAR SUDDENLY LOST POWER. I WAS ABLE TO COAST TO THE SHOULDER BEFORE IT LOST POWER COMPLETELY. THE ENGINE WAS STILL RUNNING, BUT WHEN I PUT IT IN DRIVE NOTHING HAPPENED. NO ENGINE LIGHTS CAME ON BEFORE THIS HAPPENED. ABOUT A WEEK AGO, I NOTICED THE WINDSHIELD WIPER FLUID WASN'T WORKING AND REFILLED IT. IT WORKED ONE TIME. WHEN I TRIED TO USE IT YESTERDAY, IT ONLY WORKED IN THE BACK AND NOT IN THE FRONT. I HAD IT TOWED TO A TRANSMISSION DEALER AND THEY ARE LOOKING AT IT NOW. *TR
Crash:
No
Fire:
No
Injuries:
0
Deaths:
0
#10414992July 25, 2011
ELECTRICAL SYSTEM, POWER TRAIN
MY 2005 FORD FREESTAR HAS STOP DRIVING.IT STARTS BUT WHEN I SHIFT INTO GEARS THE CAR DOES NOTHING. IT WON'T DRIVE OR GO IN REVERSE. I HAD A MECHANIC LOOK AT IT AND THEY SAID WATER GOT INTO THE PCM. AND WOULD COST ABOUT $1200 TO FIX.I HAVE NOTICE MANY OTHER 2005 FORD FREESTARS WITH THE SAME PROBLEM. MANY HAVE REPAIRED THE PROBLEM OUT OF POCKET BECAUSE FORD WON'T PAY FOR THE PROBLEM.WE DIDN'T DESIGN THE VECHILE SO WHY IS IT WE HAVE TO PAY FOR THE PROBLEM.I WAS LUCKY THAT I WAS PULLING INTO MY HOUSE WHEN MY CAR CUT OFF.BUT MANY OTHER STORIES WITH THE SAME WATER ON THE PCM PROBLEM HAVE BEEN ON HIGHWAYS OR BUSY STREETS WHEN THEIR CAR DIES SO IS FORD WAITING FOR SOMEONE OR A GROUP OF PEOPLE TO DIE IN ORDER TO RECALL THIS PROBLEM AND TAKE RESPOSIBILITY AND REPAIR IT SO THE CONSUMER DON'T HAVE TO PAY WITH THIER MONEY OR THIER LIVES.I SWEAR HAD I KNOWN THAT FORD HAS IGNORED SERIOUS LIFETHREATING PROBLEM LIKE THE WATER ON THE PCM OR TRANSMISSION PROBLEM I WOULD HAVE NEVER GOTTEN A VAN FROM FORD OR ANY VEHICLE FROM THEM. FORD CLEARLY STANDS FOR FOUND ON ROAD DEAD AND SOON ITS NOT GOING TO BE JUST THE VEHICLE BUT SOMEONE LIFE AS WELL IF THEY DRIVE A FORD.AND FORD DOESN'T GIVE A CRAP. *TR
Crash:
No
Fire:
No
Injuries:
0
Deaths:
0
#10415017July 25, 2011
POWER TRAIN:AUTOMATIC TRANSMISSION
MOVING ON INTERSTATE AT 65 MPH IN HIGH GEAR. TRANSMISSION SUDDENLY FAILS WITHOUT WARNING RESULTING IN SUDDEN COMPLETE LOSS OF POWER. TACHOMETER RISES TO 6000 RPM'S. ABLE TO PULL ONTO SHOULDER. TRANSMISSION REPAIRED AT FORD DEALER FOR $3400. *TR
Crash:
No
Fire:
No
Injuries:
0
Deaths:
0
#10415040July 25, 2011
POWER TRAIN:AUTOMATIC TRANSMISSION
LAST SATURDAY, JULY 23, 2011, MY HUSBAND WAS DRIVING OUR 2005 FORD FREESTAR (JUST OVER 86,000 MILES) IN REVERSE. HE STOPPED, PUT IT INTO DRIVE AND IT WOULD NOT GO INTO GEAR. NOT REVERSE, NOT DRIVE, NOT FIRST OR THIRD--NOTHING. FORTUNATELY HE WAS ABLE TO GET IT PUSHED INTO A PARKING STALL AND OUT OF THE ROAD. UPON LOOKING ONLINE TO FIND OUT INFORMATION REGARDING A TRANSMISSION WARRANTY, HE DISCOVERED THAT MANY, MANY OTHER PEOPLE HAVE HAD THIS SAME PROBLEM WITH '04 AND '05 FREESTARS AND THAT FORD'S ONLY RESPONSE IS TO REPLACE THE DEFECTIVE PART WITH ANOTHER SAME, DEFECTIVE PART. WE WERE NOT HURT IN ANY WAY, BUT IT WON'T BE LONG BEFORE SOMEONE IS ON A FREEWAY OR IN AN INTERSECTION AND IS INVOLVED IN A SERIOUS--MAYBE EVEN FATAL--ACCIDENT BECAUSE THEIR TRANSMISSION IS SUDDENLY NO LONGER FUNCTIONAL. FORD NEEDS TO RECOGNIZE THIS OVERSIGHT AND RECALL ALL '04 AND '05 FORD FREESTARS. WE HAVE NOT BEEN ABLE TO GET THE VEHICLE TO A MECHANIC AS OF YET, BUT WILL BE DOING SO THIS WEEK. COST OF REPAIR: UNKNOWN. *TR
Crash:
No
Fire:
No
Injuries:
0
Deaths:
0
#10415036July 25, 2011
POWER TRAIN:AUTOMATIC TRANSMISSION
TL* THE CONTACT OWNS A 2005 FORD FREESTAR. WHILE DRIVING 65 MPH, THE CONTACT STATED THE RPMS WOULD INCREASE AND SHIFT INTO NEUTRAL AND SLOWLY DECREASE. THE DEALER WAS NOT NOTIFIED OF THE FAILURE. THE MANUFACTURER WAS CONTACTED, BUT DENIED ANY ASSISTANCE TO THE VEHICLE FAILURE. A LOCAL MECHANIC DIAGNOSED A TRANSMISSION FAILURE. THE VEHICLE WAS IN THE PROCESS OF BEING REPAIRED. THE FAILURE AND CURRENT MILEAGE WAS 66,300 UPDATED 08/31/11 *BF THE CONSUMER STATED THE ENGINE REVVED UP AND THEN THE VEHICLE SLIPPED OUT OF GEAR AND THE VEHICLE LOST ALL POWER TO GO FORWARD. THERE WAS NO WARNING OF ANY KIND THAT SOMETHING WAS WRONG. UPDATED 09/0/11
Crash:
No
Fire:
No
Injuries:
0
Deaths:
0

← Back to Ford Freestar