Ford · Model Report
Showing safety data for the 2004 model year only.
RIDE CONTROL, LLC (RIDE CONTROL) IS RECALLING CERTAIN READYMOUNT ASSEMBLIES, P/N 746641MT AND 746646MT, WITH CORRESPONDING AFTERMARKET CUSTOMER PART NUMBERS: GABRIEL G56944 AND GABRIEL G56945, AND PRIVATELY BRANDED PARTSMASTER WITH PART NUMBERS G68944 AND G68945. THE READYMOUNT ASSEMBLIES WERE SOLD AS AFTERMARKET SERVICE EQUIPMENT FOR USE ON CERTAIN 2000 THROUGH 2005 FORD FOCUS VEHICLES. THESE ASSEMBLIES WERE ASSEMBLED WITH A NUT WITHOUT THE NECESSARY WASHER. THE ABSENCE OF THE WASHER CAN ALLOW THE READYMOUNT ASSEMBLY TO PULL APART THE TOP MOUNT.
DOPE, INC. IS RECALLING 42,540 COMBINATION CORNER AND BUMPER LAMP ASSEMBLIES OF VARIOUS PART NUMBERS SOLD FOR USE AS AFTERMARKET EQUIPMENT FOR VARIOUS PASSENGER VEHICLES. THESE HEADLAMPS FAIL TO CONFORM TO THE REQUIREMENTS OF FEDERAL MOTOR VEHICLE SAFETY STANDARD NO. 108, "LAMPS, REFLECTIVE DEVICES, AND ASSOCIATED EQUIPMENT." THESE LAMPS DO NOT CONTAIN THE REQUIRED AMBER SIDE REFLECTORS.
K2 MOTOR IS RECALLING 1,921 AFTERMARKET HEADLAMPS OF VARIOUS MODELS SOLD FOR USE ON THE ABOVE LISTED VEHICLES. THESE HEADLAMPS ARE MISSING THE AMBER SIDE REFLEX REFLECTOR WHICH FAILS TO CONFORM WITH THE REQUIREMENTS OF FEDERAL MOTOR VEHICLE SAFETY STANDARD NO. 108, "LAMPS, REFLECTIVE DEVICES, AND ASSOCIATED EQUIPMENT."
CERTAIN AFTERMARKET FUEL FILTERS SOLD UNDER THE PUROLATOR BRAND NAME, P/N F65277, SHIPPED FROM JANUARY 16 THROUGH JUNE 2, 2006, FOR USE ON THE ABOVE LISTED PASSENGER VEHICLES. DUE TO INCORRECT DESIGN, THE QUICK CONNECTORS MAY NOT FULLY SEAT WITH THE TUBE INTERFACE, EVEN THOUGH THE PERSON MAKING THE CONNECTION MAY BELIEVE THAT THE QUICK CONNECTOR IS FULLY ATTACHED.
CERTAIN PRO-A MOTORS CORNER LAMPS, TURN SIGNALS, AND HEADLIGHTS SOLD AS REPLACEMENT LAMPS FOR USE ON CERTAIN PASSENGER VEHICLES LISTED ABOVE. SOME COMBINATION LAMPS THAT ARE NOT EQUIPPED WITH AMBER SIDE REFLECTORS FAIL TO CONFORM TO FEDERAL MOTOR VEHICLE SAFETY STANDARD NO. 108, LAMPS, REFLECTIVE DEVICES, AND ASSOCIATED EQUIPMENT.
The contact owns a 2004 Ford Focus. The contact stated while driving on several occasions at various speeds, the check engine warning light illuminated, and the vehicle jerked abnormally. There were three clicks before the vehicle stalled. The vehicle was restarted after approximately 10 minutes. The contact stated that on one occasion while driving at an undisclosed speed, the vehicle stalled nearby train tracks. The contact waited for 10 minutes, restarted the vehicle, and drove the vehicle to safety. The vehicle was then towed to an independent mechanic where a handheld diagnostic test indicated that the PCV valve needed to be replaced. The vehicle was then taken to an independent mechanic where it was diagnosed that an ignition coil needed to be replaced. The vehicle was repaired, but the failure reoccurred approximately a month later. The vehicle was taken to the same independent mechanic where it was diagnosed that the fuel relay fuse needed to be replaced. The vehicle was repaired, but the failure reoccurred approximately three weeks later. The manufacturer was not notified of the failure. The failure mileage was approximately 200,010.
No injuries · No fire · No crash
As I was stopped at red light it stalled as I drove thru. So I pulled over. Got out to open hood. It was smoking.struggled to open hood. Ran around to get towel to smother the fire. But it was too far gone. Man told me just leave it. It was total loss.
2004 ford focus started bucking a few years ago, on occasions only. For months there was no problem and than it would buck. If I shut off the engine and waited a few minutes and started it, it would drive without bucking. Recently, it stalled while driving. Fortunately, I was on a country road and could pull over to safety. Now, on occasion, it wont start. Locks in park. After a while, I can get it out of park and start it. I do not drive it on highways since I am fearful of it shutting off. I have been to three garages for service and they cannot figure it out. I even wrote to the corporate office to ask them to let me know what the problem is. On line many people with 2004 ford focus have the same problem. It isnt just my car. Corporate office answered my letter requesting the vin number on which I gave them. After that, I did not hear from them again. I would think that they would have followed through on this since I told them that it has happened to others with the same vehicle. It stalled again a few days ago as I drove in my driveway. Everytime I try to start it, I hear the clicking sound. I go out once in a while to see if it will start. Sometimes, while in park, it wont start. Another time checking it our, it will start. But, I am not driving it anywhere. I am having it towed to another garage to see if they can figure it out. This car has less than 60,000 miles on it and everything else is good. I have spent a lot of money trying to get this resolved. It has been on diagnostic machines and it doesnt show anything. All I wanted from the corporate office was an engineer to let me know how to fix it. They must have heard the complaints since there are many. A recall wont do me any good since I will be having it looked at again this week. I am doing this for others who have the same problem. However, I would like to know exactly what has caused this.
No injuries · No fire · No crash
I was coming home one night, in my 2004 Ford focus, when another driver comes speeding up behind me. He then proceeds to pass me during a corner, cutting me off. I hit the brakes and lost control. Ended up rolling my vehicle with my 8 month old daughter and i. Back window exploded, and not a single air bags had deployed when I got into my accident.
rear passenger door wont latch shut.Door flies open when making turns
No injuries · No fire · No crash