Ford Focus Complaints (2016)

1,195 consumer complaints on file.

#11512437March 17, 2023
ENGINE
The contact owns a 2016 Ford Focus. The contact stated that a large amount of white smoke was coming from the exhaust tip with the check engine warning light illuminated. The vehicle was driven to a dealer where it was diagnosed with a cracked engine block and that the engine needed to be replaced. The manufacturer was also notified of the failure and informed him that there were no recalls on the vehicle. The vehicle had yet to be repaired. The failure mileage was approximately 90,000.
Crash:
No
Fire:
No
Injuries:
0
Deaths:
0
#11512074March 15, 2023
POWER TRAIN
The contact owns a 2016 Ford Focus. The contact stated while driving approximately 30 MPH and depressing the accelerator pedal to accelerate while making a lane change, the vehicle hesitated and then shuddered before responding. The contact stated that the failure was intermittent but had become more constant while driving. The contact stated no warning lights were illuminated. The contact had taken the vehicle to a local dealer, where it was diagnosed and determined that the transmission clutches and seals needed to be replaced. The vehicle had not been repaired. The contact had been advised by the service technician that there had been a TSB: 160109 (Power Train – Clutch Shudder). The contact was advised that her vehicle was not covered by the manufacturer for the repair. The manufacturer had been informed of the failure. The failure mileage was approximately 120,000.
Crash:
No
Fire:
No
Injuries:
0
Deaths:
0
#11511828March 14, 2023
POWER TRAIN:AUTOMATIC TRANSMISSION:CONTROL MODULE (TCM/PCM/TECM), FUEL SYSTEM, GASOLINE
The contact owns a 2016 Ford Focus. The contact stated while driving from a complete stop, the vehicle hesitated to respond. There was no warning light illuminated. The contact stated that the failure reoccurred increasingly. Additionally, the vehicle would sometimes shudder and stall. The contact related the failure to NHTSA Campaign Number: 18V735000 (Fuel System, Gasoline). The vehicle was taken to the dealer and the contact was informed the contact that there was a failure in communication to the powertrain control module (PCM). The vehicle was not repaired. The manufacturer was made aware of the failure and referred the contact to file a complaint with the NHTSA Hotline. The failure mileage was 143,613.
Crash:
No
Fire:
No
Injuries:
0
Deaths:
0
#11511244March 10, 2023
POWER TRAIN:AUTOMATIC TRANSMISSION:CONTROL MODULE (TCM/PCM/TECM)
The contact owns a 2016 Ford Focus. The contact stated that after starting the vehicle, the transmission failed to shift into gear. The vehicle was towed to an independent mechanic, who diagnosed that the TCM needed to be replaced. The vehicle was then towed to the dealer, where the TCM was replaced. The manufacturer was made aware of the failure and advised the contact to file a complaint with the NHTSA Hotline. The failure mileage was approximately 110,000.
Crash:
No
Fire:
No
Injuries:
0
Deaths:
0
#11511049March 9, 2023
POWER TRAIN
The contact owns a 2016 Ford Focus. The contact stated while driving from a complete stop, the vehicle hesitated to respond. There was no warning light illuminated. The contact stated that the failure reoccurred increasingly. The vehicle was taken to an unknown dealer several times; however, the dealer diagnosed that no issues were found and informed the contact that the vehicle was operating as designed. The contact stated that the vehicle had failed to shift into the proper gear and had become undrivable. The manufacturer was notified of the failure and a case was opened. The vehicle was not repaired. The failure mileage was approximately 50,000.
Crash:
No
Fire:
No
Injuries:
0
Deaths:
0
#11511001March 9, 2023
POWER TRAIN
The contact owns a 2016 Ford Focus. The contact stated while driving at various speeds, the vehicle was jerking while accelerating, with the check engine warning light illuminated. The vehicle was initially taken to the dealer to be repaired and the clutch was replaced under warranty. Recently, the contact stated that the failure recurred while driving at various speeds. The vehicle was taken to another dealer where the contact was informed that the clutch needed to be replaced again. The manufacturer was notified of the failure and informed the contact that the vehicle was not under recall or warranty. The vehicle remained in the possession of the dealer and was not repaired. The failure mileage was approximately 66,000.
Crash:
No
Fire:
No
Injuries:
0
Deaths:
0
#11510851March 8, 2023
EQUIPMENT:ELECTRICAL:RADIO/TAPE DECK/CD ETC.
The radio failed and yes it is able to be inspected.Screeches as your driving it comes and goes . Never sure when it will do it scares you . There was no warning on this just started to do it and then radio was no longer working.Radio is no longer working but sound is still coming out unexpectely you never know when it will come on .
Crash:
No
Fire:
No
Injuries:
0
Deaths:
0
#11510010March 3, 2023
POWER TRAIN
The contact owns a 2016 Ford Focus. The contact stated while driving 40 MPH, the vehicle started bouncing. Additionally, the vehicle was making abnormal grinding sounds. There was no warning light illuminated. The contact stated that the vehicle was previously repaired in 2018-2019 for the failure. The vehicle was taken to an independent mechanic and the dealer to be diagnosed. The contact was informed that the clutch and PCM needed to be replaced. The vehicle was not repaired. The manufacturer was notified of the failure but offered no assistance. The failure mileage was approximately 100,000.
Crash:
No
Fire:
No
Injuries:
0
Deaths:
0
#11509817March 2, 2023
FUEL SYSTEM, GASOLINE, ENGINE
The contact owns a 2016 Ford Focus. The contact stated that while parked and running the vehicle stalled. The engine warning light was illuminated. The gauges were showing incorrect readings. The contact called the local dealer who informed him that the vehicle was not covered under warranty or recall. The vehicle was not diagnosed or repaired. The contact related the failure to NHTSA Campaign Number: 18V735000 (Fuel System Gasoline). The manufacturer was not contacted. The approximate failure mileage was 109,000.
Crash:
No
Fire:
No
Injuries:
0
Deaths:
0
#11509690March 1, 2023
POWER TRAIN
We purchased a 2016 Ford Focus for our daughters first car. We purchased the car in 2020 used with very low miles. We didn't realize at the time these vehicles had issues with the clutches (but thought it would be OK because after research, we found out the vehicles in the Ford Class Action Lawsuit were model years 2014-2016) and then found out her vehicle build date was just outside of that window by 9 months. But regardless, we had issues from the start with the vehicle shuttering when she accelerated. So we took it in late fall 2020 after we had it a few months and it was a bad clutch. Ford Service replaced the clutch in Dec. 2020 under the Powertrain Warranty coverage. It was better, but within 6 months it started shuttering again, not horrible, but noticable. We took it in for a Check Engine light in Aug. of 2021 and also mentioned to Ford Service that it is already shuttering again. They said it was still safe to drive, but I didn't like that it was already happening when they just replaced the clutch. And if they would've done somethign then, it would've still been within the 5 year powertrain warranty. Then late in 2022 I contacted Ford again because I had driven my daughters car out of town, when it gets heated up from highway driving, it shutters extremely bad when you get back in town and accelerate from a stop. So much so that the whole car shakes and doesn't just accelerate normally at all. We called Ford and they opened a Case #, said we had to get it diagnosed first and yes they said bad clutch again, but now Ford is only offering to cover a portion of the clutch replacement? I was pretty disappointed they wouldn't fully replace. This is 2 years since the last replacement and I wasn't expecting to have any further clutch issues. I honestly don't like my daughter driving it due to this issue. The car is not a healthy running car and takes those extra seconds to get going while the car shakes upon accellerating at a stop light, etc.
Crash:
No
Fire:
No
Injuries:
0
Deaths:
0
#11509589February 28, 2023
STRUCTURE:BODY, FUEL/PROPULSION SYSTEM
While driving on the highway my 2016 ford focus stalled without warning and would not start until after having it towed. When I go to the gas station after filling the gas tank my vehicle is either hard to start or doesn't start until after waiting a while. This happens often. My check engine light stays on and it smells like gas from the outside. The front-end apron of my vehicle has recently fallen off without warning and for no reason. I took my vehicle to San Tan Ford in Gilbert, Arizona where I purchased my 2016 Ford Focus in May of 2016. The technicians' diagnosis was engine light ml on 2pcm code p1450 p0507 fuel tank leaking replace leaking fuel tank and recommend new fuel pump possible damaged from excessive vacuum applied to tank code p1450 replace canister purge valve for code p1450 stuck open & retest. Dealership and Ford Motor Company is refusing to do repairs stating that my VIN number does not have any recalls and refused to check my front-end apron joints for recall 17S03 although my front-end apron has unattached for no reason. the technician also included that the front-end motor mount is collapsed and recommend replacing mount. Water Pump Replacement inspection found leaking recommend replacing water pump. Also, the degas bottle cracked and leaking coolant and Damaged from excessive Vacuum applied to tank The Canister Purge Valve malfunction causing excessive vacuum in the vapor management system. Stuck canister purge valves cause it to stall. If the CPV is replaced, dealers should inspect and replace the carbon canister, fuel tank and fuel delivery module as necessary. Bearing failed as the result of a sudden overload caused by vibration or imbalance compounded by rapid engine acceleration. This overloads the bearing generating a great deal of heat. Amplified through rapid acceleration and high RPM operation.
Crash:
No
Fire:
No
Injuries:
0
Deaths:
0
#11508456February 22, 2023
FUEL/PROPULSION SYSTEM, ENGINE, POWER TRAIN
1st Started having issues with advancing, at idle stops,when engaging fuel, it will hesitate and run poorly. after a week, engine light started turning on, and stating that transmission, was running hot, and need it to stop and cool down. after the 2nd time, the vehicle runs rought, and grinding can be heard by shifting gear. An off duty Ford worker, checked vehicle with a computer and stated that the transmission clutch had gone out. checked the internet and stated that Ford Focus from 2012 to 2016 had a recall. yet I enter my vin number and nothing is said. I am currently paying my vehicle and can not drive it, have 3 children, and no money to repair. can you please help.
Crash:
No
Fire:
No
Injuries:
0
Deaths:
0
#11508473February 22, 2023
POWER TRAIN
The contact owns a 2016 Ford Focus. The contact stated that while driving approximately 35 mph, the vehicle stalled. The "vehicle was not in park" warning message was displayed while the contact was in drive. The contact was able to pull over to the nearest parking lot. After a jump start, the vehicle was able to start. They took the vehicle to a certified mechanic who diagnosed that the transmission modular needed to be replaced. The vehicle had not been repaired due to the parts being on backorder. The manufacturer was not made aware of the failure. The approximate failure mileage was 130,500.
Crash:
No
Fire:
No
Injuries:
0
Deaths:
0
#11508598February 22, 2023
POWER TRAIN, ENGINE, UNKNOWN OR OTHER
I have been having problems with ford focus for a long time. I have been told that this is normal. Recently, I had my car fixed by ford. Soon after, I was having problems with car slow start, hesitation and studdering. This is the same problems I was having before. I was told by Ford dealership that it was not the transmission. They told me that it was a crack engine head and purge valve problem. I paid for the fix even though I felt like it should have been covered in a recall. The car is not fix. I have completed 2 surveys with Ford. The department of transportation should investigate ford for its ford focuses.
Crash:
No
Fire:
No
Injuries:
0
Deaths:
0
#11505011February 1, 2023
POWER TRAIN
Transmission slipped occasionally before the TCM finally failed. Unable to repair due to part not being unavailable.
Crash:
No
Fire:
No
Injuries:
0
Deaths:
0
#11504788January 31, 2023
POWER TRAIN
The contact owns a 2016 Ford Focus. The contact stated while at a stop sign and attempting to accelerate, the vehicle started jerking with the check engine warning light illuminated. The vehicle was taken to the dealer for diagnostic tests, and the mechanic stated the vehicle was experiencing the failure listed in NHTSA Campaign Number: 18V845000 (Power Train) however, the VIN was not included in the recall. The vehicle was not repaired. The manufacturer was contacted and confirmed that the vehicle was not included in NHTSA Campaign Number: 18V845000 (Power Train). The contact was informed that the vehicle was previously repaired for the failure under warranty. The failure mileage was 86,403.
Crash:
No
Fire:
No
Injuries:
0
Deaths:
0
#11504421January 30, 2023
POWER TRAIN:AUTOMATIC TRANSMISSION:CONTROL MODULE (TCM/PCM/TECM)
The contact owns a 2016 Ford Focus. The contact stated that while driving at an undisclosed speed, the vehicle lunged forward. Additionally, while driving the vehicle lost motive power and the check engine warning light illuminated. The vehicle was towed to the residence. The vehicle was diagnosed by Auto Zone with transmission control module failure. The vehicle was not diagnosed nor repaired by an independent mechanic or the dealer. The manufacturer was made aware of the failure and referred the contact to file complaint with the NHTSA Hotline. The failure mileage was approximately 103,000.
Crash:
No
Fire:
No
Injuries:
0
Deaths:
0
#11504475January 30, 2023
ELECTRICAL SYSTEM
I am having issue out of my engine harness I have shorts all in my harness and am only at 100k miles.
Crash:
No
Fire:
No
Injuries:
0
Deaths:
0
#11504024January 27, 2023
STEERING, POWER TRAIN
The transmission started failing in 2020 and part of it was repaired on a recall and part we had to pay out of pocket. The entire steering rack failed in July of 2022 requiring replacement. Reports suggest this is a known issue yet Ford offered nothing. Now the transmission is slipping and failing again less than two years since being repaired by Ford. This is a critical safety issue and they can't diagnose the car for 4-6 weeks and are offering no rental assistance for a known factory defect. These cars are dangerous and the fact that Ford won't do anything to jump on the problem when it happens means more liability for the drivers of these vehicles.
Crash:
No
Fire:
No
Injuries:
0
Deaths:
0
#11504084January 27, 2023
POWER TRAIN
TCM failed. Repair under recall warranty. Part indefinitely on backorder.
Crash:
No
Fire:
No
Injuries:
0
Deaths:
0

← Back to Ford Focus