FORD IS RECALLING CERTAIN MODEL YEAR 2007 FORD FIVE HUNDRED AND MERCURY MONTEGO VEHICLES MANUFACTURED FROM SEPTEMBER 5, 2006, THROUGH SEPTEMBER 11, 2006. THE FUEL TANKS MAY NOT HAVE CONSISTENT WELDS BETWEEN THE FUEL TANK AND FUEL FILLER NECK SPUD WHICH CAN AFFECT THE STRENGTH OF THE JOINT. SOME FUEL TANK SPUD WELDS MAY NOT PROVIDE THE EXPECTED STRENGTH IN THE EVENT OF A SEVERE REAR IMPACT TO THE VEHICLE. AN IMPROPER WELD CAN RESULT IN A CRACK IN THE JOINT WHICH COULD ILLUMINATE THE EMISSIONS MALFUNCTION INDICATOR LIGHT, CAUSE A FUEL ODOR, OR ALLOW FUEL TO LEAK OUT.
CERTAIN AFTERMARKET FUEL FILTERS SOLD UNDER THE PUROLATOR BRAND NAME, P/N F65277, SHIPPED FROM JANUARY 16 THROUGH JUNE 2, 2006, FOR USE ON THE ABOVE LISTED PASSENGER VEHICLES. DUE TO INCORRECT DESIGN, THE QUICK CONNECTORS MAY NOT FULLY SEAT WITH THE TUBE INTERFACE, EVEN THOUGH THE PERSON MAKING THE CONNECTION MAY BELIEVE THAT THE QUICK CONNECTOR IS FULLY ATTACHED.
It's starting not going into highway gears (5&6) just revs real high and when it does finally, it kicks really hard. Sounds and feels like it's going to drop out from under the car.
No injuries · No fire · No crash
AFTER DRIVING HALF-HOUR IN HIGH-WAY SOUTHWARD ON I-45 IN THE MORNING. THE CAR CANNOT BE ACCELERATE AT AROUND 40MPH WHEN I RAMP UP TO 288, AND THE AUTO-LOCK LIGHT TURNED RED. SECONDS LATER, IT RECOVERED BACK. 2 MINUTES LATER, IT HAPPENED AGAIN . AND AGAIN . SO I PARKED IT . ~8-HOURS LATER, I STARTED IT AND THE AUTO-LOCK LIGHT RED AGAIN. SECONDS LATER, THE ENGINE STOPPED WHEN I BACK THE CAR. I STEPPED ON GAS-PEDAL WHEN I TRIED 3RD TIME, AND THE CAR MOVED AND THE AUTO-LOCK LIGHT KEPT RED. 10-MINUTS LATER, WHEN I DRIVE ON 288-SOUTH AT ~60MPH, BOTH OF THE REPAIR LIGHT AND ENGINE LIGHT TURNED YELLOW AND THE AUTO-LOCK LIGHT OFF, SECONDS LATER, THE REPAIR LIGHT OFF. THE ENGINE LIGHT KEPT ON. SO I GET DOWN THE HIGHWAY, CANNOT ACCELERATE CAR WITH GAS-PEDAL ON AND CANNOT TURN STERRING WHEEL, THE CAR SLOW DOWN AND STOPPED BY ITSELF. 5-MINUTES LATER, I STARTED IT AGAIN WITH ENGINE LIGHT ON WITH YELLOW, THE CAR MOVED AND 10 MINUTES LATER, I PARKED IT HOME.
No injuries · No fire · No crash
I HAD THIS CAR REPAIRED TWICE AT A PROFESSIONAL MECHANIC SHOP THAT COST ME THOUSANDS OF DOLLARS. EVERY TIME, THE CAR COMES TO STOP OR DIES ON ME. I REPLACED THE FUEL FILTER ONE TIME THAT IS UNDERNEATH THE CAR. NOW THE CAR IS SITTING IN MY GARAGE BECAUSE OF THE FUEL PUMP NOT FUNCTIONING AND DOES NOT MAKE THAT SOUND ANYMORE WHEN YOU TURN THE KEY ON.
IT BEGAN WITH THE 12 VOLT NOT WORKING. PUT IN NEW FUSE IT BLEW. THEN INSTRUMENT PANEL SPEEDOMETER GOES BLACK, IF YOU GOT THE DASH IT COMES BACK ON THE BATTERY GOT COMPLETELY DRAINED BOUGHT A NEW ONE. STILL HAVE A SHORT SOMEWHERE . NOTICED A MILLION OTHER COMPLAINTS THE SAME SHOULD THIS NOT BE INVESTIGATED? A SODERING DEFECT OR ELECTRICAL SHORT DRAINING BATTERY, IT'S OBVIOUSLY A VEHICLE DEFECT. ISN'T FORD A BIG ENOUGH COMPANY TO TAKE CARE OF THIS INSTEAD OF IGNORING IT? THIS IS ON A 2007 FORD 500, LOW MILES. THIS HAPPENS SITTING STILL OR DRIVING.
No injuries · No fire · No crash
CAR IS LEAKING FUEL FROM THE GAS TANK AREA, LOOKS LIKE ITS LEAKING FROM THE FILLER NECK. AT TIMES IT LEAKS A CONSIDERABLE AMOUNT. I'M ALSO HAVING SURGING ISSUES. MAINLY AT LOW SPEEDS. THE VEHICLE HAS ALSO SHUT DOWN IN THE MIDDLE OF TRAFFIC. THESE PROBLEMS TRULY CONCERN ME AND I QUESTION THE SAFETY OF THE VEHICLE AND MY CHILDREN AND MYSELF WHILE IN THIS VEHICLE.
No injuries · No fire · No crash