Ford F-350 Service Bulletins (2024)
214 manufacturer communications on file.
- November 7, 2025•Document ID: 11026009OtherELECTRICAL SYSTEM; UNKNOWN OR OTHER; FORWARD COLLISION AVOIDANCE: ADAPTIVE CRUISE CONTROL
- Mfr Comm. #:
- 25L04
- Date Added:
- December 3, 2025
- Manufacturer:
- FORD
SummaryThe affected vehicles were built without the XL Driver Assist Package and the window stickers incorrectly indicated that the vehicles were equipped with the XL Driver Assist Package.
Associated Products (8)Associated Documents - October 29, 2025•Document ID: 11024900Service Bulletin/Repair InstructionsPOWER TRAIN
- Mfr Comm. #:
- SSM 54338
- Date Added:
- November 4, 2025
- Manufacturer:
- FORD
SummarySome 2021-2025 F-150 vehicles equipped with a 5.0L/5.2L engine, 2021-2025 F-Super Duty/F-53 Motorhome/F59 Commercial Stripped Chassis vehicles equipped with a 6.8L/7.3L engine and 2021-2026 E-Series/F-650/F-750 vehicles equipped with a 7.3L engine may exhibit a rattle/scraping noise upon startup that may remain after the engine is running. This may be due to the starter motor drive gear not retracting after starting. To correct this condition, inspect the starter motor drive gear and shaft. If the starter motor drive gear slides back and forth by hand and/or shows signs of scoring or damage, replace the starter motor following Workshop Manual (WSM), Section 303-06 Starting System > Removal and Installation > Starter.
Associated Products (49)2026 Ford E-3502026 Ford E-4502026 Ford F-6502026 Ford F-7502025 Ford E-3502025 Ford E-4502025 Ford F-1502025 Ford F-2502025 Ford F-3502025 Ford F-4502025 Ford F-5502025 Ford F-6502025 Ford F-7502024 Ford E-3502024 Ford E-4502024 Ford F-1502024 Ford F-2502024 Ford F-3502024 Ford F-4502024 Ford F-550+ 29 moreAssociated Documents - October 28, 2025•Document ID: 11024882Service Bulletin/Repair InstructionsELECTRICAL SYSTEM; STEERING; SERVICE BRAKES
- Mfr Comm. #:
- SSM 54333
- Date Added:
- November 4, 2025
- Manufacturer:
- FORD
SummarySome 2023-2025 F-Super Duty vehicles may exhibit a no crank/no start or intermittent no crank/no start with multiple warning indicators and DTC U0100 stored in the anti-lock brake system (ABS), audio front control module (ACM) and power steering control module (PSCM). This may be due to an incorrectly tightened ground 113 (G113). Inspect G113 for proper connection and tighten to 12 Nm (8.9 ft-lb). If the condition remains after tightening G113, perform normal diagnostics outside of this article. Refer to Workshop Manual, Section 303-06 Starting System. For claiming, use causal part 12A581 and labor operations 12650D and 12650D45WR of the Service Labor Time Standards (SLTS) Manual.
Associated Products (12)Associated Documents - October 27, 2025•Document ID: 11024523Service Bulletin/Repair InstructionsPOWER TRAIN; ELECTRICAL SYSTEM
- Mfr Comm. #:
- TSB 25-2515
- Date Added:
- October 28, 2025
- Manufacturer:
- FORD
SummarySome of the vehicles listed in the Model statement above may exhibit an incorrectly illuminated MIL with DTC P0384 stored in the powertrain control module (PCM). This may be due to the calibration in the PCM. This condition does not affect vehicle drivability or durability.
Associated Products (18)Associated Documents - October 24, 2025•Document ID: 11024532Service Bulletin/Repair InstructionsSTRUCTURE:BODY; UNKNOWN OR OTHER
- Mfr Comm. #:
- SSM 54326
- Date Added:
- October 28, 2025
- Manufacturer:
- FORD
SummarySome 2018-2025 F-150 and 2018-2026 F-Super Duty vehicles equipped with a tailgate step may exhibit a step assembly that binds/will not open or opens/pops up while driving. This could be due to an incorrect adjustment of the tailgate step assembly. Before replacing any components for this concern, follow the revised Tailgate Step Adjustment procedure in Workshop Manual (WSM), Section 501-04.
Associated Products (44)2026 Ford F-2502026 Ford F-3502026 Ford F-4502026 Ford F-5502025 Ford F-1502025 Ford F-2502025 Ford F-3502025 Ford F-4502025 Ford F-5502024 Ford F-1502024 Ford F-2502024 Ford F-3502024 Ford F-4502024 Ford F-5502023 Ford F-1502023 Ford F-2502023 Ford F-3502023 Ford F-4502023 Ford F-5502022 Ford F-150+ 24 moreAssociated Documents - October 21, 2025•Document ID: 11024524Service Bulletin/Repair InstructionsSTEERING; POWER TRAIN
- Mfr Comm. #:
- SSM 54311
- Date Added:
- October 28, 2025
- Manufacturer:
- FORD
Summary2023-2026 F-Super Duty vehicles may be equipped from the factory with a power steering system filled with Motorcraft® MERCON® LV Automatic Transmission Fluid XT-10-QLVC or XL-22 high temperature power steering fluid that looks like clear hydraulic fluid. Both fluids are interchangeable in the power steering system when service is required. Workshop Manual, Section 211-02 > Power Steering > Specifications has been updated to provide the correct power steering fluid usage.
Associated Products (16)Associated Documents - October 21, 2025•Document ID: 11024530Service Bulletin/Repair InstructionsELECTRICAL SYSTEM; FUEL/PROPULSION SYSTEM
- Mfr Comm. #:
- SSM 54317
- Date Added:
- October 28, 2025
- Manufacturer:
- FORD
SummarySome 2021-2025 F-150, 2022-2025 Expedition/Navigator, 2023-2025 F-Super Duty, 2024-2025 Ranger and 2026 Transit vehicles may exhibit a discharged battery and/or a no crank/no start condition. The vehicle may also exhibit a clicking noise from the trailer module (TRM) while the vehicle is off. This may be due to software in the TRM.<br /><br />Verify the TRM software part number in the vehicle using Ford diagnosis and repair system (FDRS) to be PC3T-19J297-BF, PC3T-19J297-FF, ML3T-19J297-CD or ML3T-19J297-GD. To confirm a vehicle is equipped with a certain software level, review the software information by hovering over the "Diagnostics" tab in Professional Technician System (PTS) and selecting "Vehicle Software". If one of the listed software part numbers is present, follow the Service Procedure to reprogram the TRM. For vehicles with any other software part number in the TRM, refer to Workshop Manual (WSM), Section 414-01 to continue with normal diagnostics outside of this article. For claiming use causal part 19H332 and labor operation 12651D and 12651D4 of the Service Labor Time Standards (SLTS)
Associated Products (27)2025 Ford Expedition2025 Ford F-1502025 Ford F-2502025 Ford F-3502025 Ford F-4502025 Ford F-5502025 Ford Ranger2025 Lincoln Navigator2024 Ford Expedition2024 Ford F-1502024 Ford F-2502024 Ford F-3502024 Ford F-4502024 Ford F-5502024 Ford Ranger2024 Lincoln Navigator2023 Ford Expedition2023 Ford F-1502023 Ford F-2502023 Ford F-350+ 7 moreAssociated Documents - October 21, 2025•Document ID: 11024526Service Bulletin/Repair InstructionsLANE DEPARTURE: BLIND SPOT DETECTION; ELECTRICAL SYSTEM
- Mfr Comm. #:
- SSM 54313
- Date Added:
- October 28, 2025
- Manufacturer:
- LINCOLN
SummarySome 2020-2025 various Ford and Lincoln vehicles equipped with blind spot information system (BLIS) may experience an inoperative blind spot monitoring with a "Blind Spot System Fault" message displayed in the instrument panel cluster (IPC). This may also be accompanied by diagnostic trouble codes (DTCs) B118C:11 and/or B118C:15 stored in the driver door module (DDM), and/or B118D:11 and/or B118D:15 stored in the passenger door module (PDM). This may be due to the wiring connector from the mirror to the BLIS module. If diagnostics lead to an internal mirror wiring harness fault, a new lower level BLIS light pigtail is now released for service. It is not necessary to replace the exterior mirror assembly. Use part number SC3Z-14A411-B to resolve the concern.
Associated Products (102)2025 Ford Bronco2025 Ford Bronco Sport2025 Ford Escape2025 Ford Expedition2025 Ford Explorer2025 Ford F-1502025 Ford F-2502025 Ford F-3502025 Ford F-4502025 Ford F-5502025 Ford Mustang2025 Ford Mustang Mach-E2025 Ford Transit2025 Lincoln Aviator2025 Lincoln Corsair2025 Lincoln Navigator2024 Ford Bronco2024 Ford Bronco Sport2024 Ford Edge2024 Ford Escape+ 82 moreAssociated Documents - October 4, 2025•Document ID: 11024026Service Bulletin/Repair InstructionsVISIBILITY/WIPER
- Mfr Comm. #:
- SSM 54270
- Date Added:
- October 8, 2025
- Manufacturer:
- FORD
SummarySome 2024-2025 F-150/F-Super Duty vehicles may exhibit an inoperative front passenger window when operated from the driver master window control switch with diagnostic trouble code (DTC) U2013:23 stored in the driver door module (DDM). This may be due to software in the driver door module (DDM). Inform customers that engineering is currently working on a solution for this condition and will be released via a software update delivered over-the-air (OTA) expected in March 2026. Software will update automatically if vehicle connectivity is enabled in the vehicles settings. Schedule a service visit for customers who have disabled vehicle connectivity or who report that they did not receive the update in March 2026. Monitor Professional Technician System (PTS) for additional information.
Associated Products (10)Associated Documents - October 4, 2025•Document ID: 11024021Service Bulletin/Repair InstructionsENGINE
- Mfr Comm. #:
- SSM 54269
- Date Added:
- October 8, 2025
- Manufacturer:
- FORD
SummarySome 2021-2025 Expedition/Navigator/F-150/F-Super Duty/F-53 Motorhome/F59 Commercial Stripped Chassis/F-650/F-750/Transit vehicles equipped with a 2.7L,3.5L EcoBoost (non-hybrid), 3.5L Cyclone, 6.8L or 7.3L engine, may exhibit a rattle/scraping noise from the bellhousing area on start-up. Workshop Manual (WSM), Section 303-00 Engine System - General Information > Diagnosis and Testing and 303-06 > Starting System has been updated. Additionally, WSM, Section 303-01 > Removal and Installation > Engine to Transmission Spacer Plate has been added to address this condition. Refer to the revised WSM sections for normal diagnosis.
Associated Products (51)2025 Ford Expedition2025 Ford F-1502025 Ford F-2502025 Ford F-3502025 Ford F-4502025 Ford F-5502025 Ford F-6502025 Ford F-7502025 Ford Transit2025 Lincoln Navigator2024 Ford Expedition2024 Ford F-1502024 Ford F-2502024 Ford F-3502024 Ford F-4502024 Ford F-5502024 Ford F-6502024 Ford F-7502024 Ford Transit2024 Lincoln Navigator+ 31 moreAssociated Documents - October 1, 2025•Document ID: 11024199Service Bulletin/Repair InstructionsUNKNOWN OR OTHER; STRUCTURE:BODY
- Mfr Comm. #:
- TSB 25-2466
- Date Added:
- October 9, 2025
- Manufacturer:
- FORD
SummarySome of the vehicles listed in the Model statement above may exhibit a headliner rattle or sagging condition around the roof opening panel. This may be due to the adhesive separating from the headliner substrate.
Associated Products (39)2025 Ford F-1502025 Ford F-2502025 Ford F-3502025 Ford F-4502025 Ford F-5502024 Ford Edge2024 Ford Expedition2024 Ford F-1502024 Ford F-2502024 Ford F-3502024 Ford F-4502024 Ford F-5502024 Lincoln Navigator2023 Ford Edge2023 Ford Expedition2023 Ford F-1502023 Ford F-2502023 Ford F-3502023 Ford F-4502023 Ford F-550+ 19 moreAssociated Documents - September 26, 2025•Document ID: 11023567Service Bulletin/Repair InstructionsELECTRICAL SYSTEM; SERVICE BRAKES
- Mfr Comm. #:
- SSM 54250
- Date Added:
- October 2, 2025
- Manufacturer:
- FORD
SummarySome 2024-2025 Escape Hybrid/Maverick Hybrid/Nautilus Hybrid/F-150 non-Lightning/F-Super Duty/Bronco and 2025 Expedition/Navigator/Ranger vehicles where customers have installed an aftermarket supplemental braking system may experience a discharged 12-volt battery after recreational towing. This may be due to the supplemental braking system keeping the vehicle awake during brake applications. Advise customers that while recreational towing the vehicle with a supplemental braking system installed, it is recommended to use a 12-volt battery charger connected to a power source external to the vehicle being towed. The Owners Manual is in process of being updated with this information.
Associated Products (22)2025 Ford Bronco2025 Ford Escape2025 Ford Expedition2025 Ford F-1502025 Ford F-2502025 Ford F-3502025 Ford F-4502025 Ford F-5502025 Ford Maverick2025 Ford Ranger2025 Lincoln Nautilus2025 Lincoln Navigator2024 Ford Bronco2024 Ford Escape2024 Ford F-1502024 Ford F-2502024 Ford F-3502024 Ford F-4502024 Ford F-5502024 Ford Maverick+ 2 moreAssociated Documents - September 24, 2025•Document ID: 11023547Service Bulletin/Repair InstructionsPOWER TRAIN
- Mfr Comm. #:
- TSB 25-2423
- Date Added:
- October 2, 2025
- Manufacturer:
- LINCOLN
SummarySome of the vehicles listed in the Model statement above may exhibit at least one of the following conditions: - No upshift past second gear - Unable to achieve third gear ratio - Illuminated malfunction indicator lamp (MIL) with DTCs P0757 and P2701 This may be due to a damaged one-way clutch (OWC).
Associated Products (18)Associated Documents - September 19, 2025•Document ID: 11023302Service Bulletin/Repair InstructionsVISIBILITY/WIPER; ELECTRICAL SYSTEM
- Mfr Comm. #:
- TSB 25-2448
- Date Added:
- September 23, 2025
- Manufacturer:
- FORD
SummaryThis article supersedes TSB 25-2201 to update the vehicles affected. Some of the vehicles listed in the Model statement above equipped with one-touch up/down front windows may exhibit a window not responding to one-touch controls, not opening all the way and/or bouncing back when using the one-touch close function. This may be due to a calibration parameter in the driver door module (DDM) and/or passenger door module (PDM).
Associated Products (13)Associated Documents - September 17, 2025•Document ID: 11023296Service Bulletin/Repair InstructionsPOWER TRAIN
- Mfr Comm. #:
- TSB 25-2412
- Date Added:
- September 23, 2025
- Manufacturer:
- FORD
SummarySome of the vehicles listed in the Model statement above may exhibit an incorrectly illuminated malfunction indicator lamp (MIL) with cylinder injection pulse offset DTCs P2B11, P2B13, P2B15, P2B17, P2B19, P2B1B, P2B1D, and/or P2B1F stored in the powertrain control module (PCM). The vehicle may also exhibit a slight running rough condition at idle. This may be due to incorrect learned values in the PCM from operating the vehicle at altitudes greater than 2500 feet (762 meters) above sea level. This condition does not affect vehicle drivability or durability.
Associated Products (12)Associated Documents - September 16, 2025•Document ID: 11023294Service Bulletin/Repair InstructionsVISIBILITY/WIPER; ELECTRICAL SYSTEM
- Mfr Comm. #:
- SSM 54223
- Date Added:
- September 23, 2025
- Manufacturer:
- FORD
SummarySome 2024-2025 F-150/F-Super Duty vehicles may exhibit an inoperative front passenger window when operated from the driver master window control switch with diagnostic trouble code (DTC) U2013:23 stored in the driver door module (DDM). This may be due to the software level of the DDM. To correct this condition, reprogram the DDM using the latest software level of the Ford Diagnosis and Repair System (FDRS) scan tool. For claiming, use causal part 14B291 and labor operations 12651D and 12651D4.
Associated Products (10)Associated Documents - September 12, 2025•Document ID: 11023203Service Bulletin/Repair InstructionsFUEL/PROPULSION SYSTEM
- Mfr Comm. #:
- SSM 54215
- Date Added:
- September 18, 2025
- Manufacturer:
- FORD
SummarySome 2019-2026 F-Super Duty vehicles equipped with a 6.7L engine may require various repairs and/or maintenance to the fuel system where quick release couplings are utilized, such as the secondary fuel filter. The Workshop Manual (WSM), Section 310-00 > General Procedures > Quick Release Coupling has been updated to include videos and instructions of proper disconnect/connect steps involving the Type 27 quick release couplings.
Associated Products (32)2026 Ford F-2502026 Ford F-3502026 Ford F-4502026 Ford F-5502025 Ford F-2502025 Ford F-3502025 Ford F-4502025 Ford F-5502024 Ford F-2502024 Ford F-3502024 Ford F-4502024 Ford F-5502023 Ford F-2502023 Ford F-3502023 Ford F-4502023 Ford F-5502022 Ford F-2502022 Ford F-3502022 Ford F-4502022 Ford F-550+ 12 moreAssociated Documents - September 10, 2025•Document ID: 11023139Service Bulletin/Repair InstructionsPOWER TRAIN; ENGINE
- Mfr Comm. #:
- TSB 25-2420
- Date Added:
- September 16, 2025
- Manufacturer:
- FORD
SummarySome of the vehicles listed in the Model statement above built with minor feature code AAZNQ or AAZNS (gross vehicle weight rating ÝGVWR¨ 9,900 lb. or 10,000 lb. pounds) may exhibit an incorrectly illuminated malfunction indicator lamp (MIL) with diagnostic trouble code (DTC) P20EE stored in the powertrain control module (PCM). This may be due to the calibration in the PCM. This condition does not affect vehicle drivability or durability. To confirm a vehicle is built with a certain minor feature code, review the build information by double-clicking the vehicle identification number (VIN) in the upper left corner in the Professional Technician System (PTS).
Associated Products (8)Associated Documents - September 4, 2025•Document ID: 11022906OtherVISIBILITY/WIPER
- Mfr Comm. #:
- SSM 54193
- Date Added:
- September 8, 2025
- Manufacturer:
- FORD
SummarySome 2024-2025 Mustang Mach-E/F-150/F-Super Duty vehicles equipped with 360 degree camera may exhibit a distorted or blurry 360 degree camera image in the center display screen but the rear view camera image is operating correctly. To restore the 360 degree camera image, download and run the "IPMA - Reset the Image Processing Module A (IPMA) Calibration Data" application using the Ford Diagnosis and Repair System (FDRS) scan tool. Then download and run the "IPMA - 360 Degree View Camera Alignment" application. Inform customers that they can continue to drive the vehicle and engineering is currently working on a software solution for this condition that is expected by the end of 2025. Replacement or reprogramming of the IPMA will not resolve this condition. Monitor Professional Technician System (PTS) for additional information and schedule service appointments for customers once the repair becomes available.
Associated Products (12)Associated Documents - August 27, 2025•Document ID: 11022272Service Bulletin/Repair InstructionsELECTRICAL SYSTEM
- Mfr Comm. #:
- SSM 54173
- Date Added:
- September 2, 2025
- Manufacturer:
- FORD
SummarySome 2023-2025 F-Super Duty vehicles may exhibit a no crank/no start or intermittent no crank/no start with multiple warning indicators and DTC U0100 stored in the anti-lock brake system (ABS), audio front control module (ACM) and power steering control module (PSCM). This may be due to an incorrectly tightened ground 113 (G113). Inspect G113 for proper connection and tighten to 12 Nm (8.9 ft-lb). If the condition remains after tightening G113, continue with normal diagnostics. Refer to Workshop Manual, Section 303-06 Starting System outside of this article. For claiming, use causal part 12A581 and labor operations 12650D and 12650D45WD.
Associated Products (12)Associated Documents