Ford · Model Report
Showing safety data for the 1994 model year only.
FORD IS RECALLING MODEL YEARS 1995-2003 WINDSTAR, 2000-2003 EXCURSION DIESEL, 1993-1997 AND 1999-2003 F-250 SD THROUGH F-550 SD DIESEL, 1992-2003 E-150 THROUGH E-550, 1995-2002 EXPLORER, 1997 AND 2002 MERCURY MOUNTAINEER, 1995-1997 AND 2001-2003 RANGER, AND 1994 F53 VEHICLES EQUIPPED WITH THE TEXAS INSTRUMENTS SPEED CONTROL DEACTIVATION SWITCH (SCDS). THE SCDS MAY LEAK INTERNALLY AND THEN OVERHEAT, SMOKE, OR BURN.
ON CERTAIN TRUCKS EQUIPPED WITH SPEED CONTROL, GASOLINE OR NATURAL GAS ENGINES, THE SPEED CONTROL DEACTIVATION SWITCH MAY OVERHEAT.
CERTAIN CK MOTORSPORTS COMBINATION HEADLIGHTS, CLEAR CORNER, BUMPER, AND SIDE MARKER LIGHTS SOLD AS REPLACEMENT LAMPS FOR USE ON THE PASSENGER VEHICLES LISTED ABOVE. SOME COMBINATION LAMPS THAT ARE NOT EQUIPPED WITH AMBER SIDE REFLECTORS FAIL TO CONFORM TO FEDERAL MOTOR VEHICLE SAFETY STANDARD NO. 108, LAMPS, REFLECTIVE DEVICES, AND ASSOCIATED EQUIPMENT.
ON CERTAIN PICKUP TRUCKS AND SPORT UTILITY VEHICLES EQUIPPED WITH SPEED CONTROL, THE SPEED CONTROL DEACTIVATION SWITCH MAY OVERHEAT, SMOKE, OR BURN.
THIS IS NOT A SAFETY RECALL IN ACCORDANCE WITH THE SAFETY ACT. HOWEVER, IT IS DEEMED A SAFETY IMPROVEMENT CAMPAIGN BY THE AGENCY. EQUIPMENT DESCRIPTION: FORD IS REPLACING ALL FIRESTONE WILDERNESS AT 15, 16, AND 17 INCH TIRES MOUNTED ON FORD TRUCKS AND SUVS. FORD REPORTS TREAD SEPARATION CAN OCCUR DUE TO A COMBINATION OF THE SENSITIVITY OF THE TIRE DESIGN TO STRESS, AGING, AND MANUFACTURING DIFFERENCES BETWEEN PLANTS. FORD IS REPLACING THESE TIRES TO PREVENT POSSIBLE PREMATURE TIRE FAILURE. VEHICLE DESCRIPTION: THE VEHICLES LISTED BELOW MAY HAVE BEEN ORIGINALLY EQUIPPED WITH FIRESTONE WILDERNESS AT TIRES OR MAY HAVE HAD WILDERNESS AT TIRES INSTALLED DURING THE FIRESTONE RECALL LAUNCHED IN AUGUST 2000. CERTAIN 1991 THROUGHT 2002 FORD EXPLORER CERTAIN 2001 THROUGHT 2002 EXPLORER SPORT, AND SPORT TRAC CERTAIN 1997 THROUGH 2002 MERCURY MOUNTAINEER CERTAIN 1991 THROUGH 2001 RANGER CERTAIN 1999 THROUGH 2001 EXPEDITION CERTAIN 1991 THROUGH 1994, AND 1997 MODEL YEAR F-SERIES CERTAIN 1991 THROUGH 1994 BRONCO NOTE: BOTH ORIGINAL EQUIPMENT AND REPLACEMENT TIRES ARE AFFECTED.
ENGINE SHUTS DOWN WITHOUT WARNING AT SPEEDS 50 TO 70 MPH AND WON'T RESTART SOMETIMES. IT MIGHT RESTART AFTER AN HOUR AND RUN FOR ABOUT 10 TO 15 MINUTES AND STOP AGAIN AND WON'T START AGAIN TILL NEXT MORNING. IS INTERMITTENTLY AND RANDOMLY STOPPING DEAD, LIKE TURNING OFF THE KEY. MECHANIC CANNOT MAKE IT HAPPEN IN SHOP!
No injuries · No fire · No crash
DIMMER SWITCH SHUTS OFF ALL THE LIGHTS AT NIGHT WHEN I DRIVE AT NIGHT
No injuries · No fire · No crash
TL* THE CONTACT OWNS A 1994 FORD F-250 EQUIPPED WITH DOMINATOR SPORT ATZ TIRES, SIZE: LT265/75R16. WHILE DRIVING 35 MPH, THE CONTACT FELT A VIBRATION IN THE FRONT PASSENGER SIDE TIRE. THE TIRE WAS ROCKING FROM SIDE TO SIDE. IN ADDITION, THE CONTACT STATED THAT THE BELT WAS SEPARATED FROM THE FRONT PASSENGER SIDE TIRE. THE VEHICLE WAS NOT TAKEN TO THE DEALER. THE VEHICLE WAS NOT DIAGNOSED OR REPAIRED. THE MANUFACTURER WAS NOTIFIED OF THE FAILURE AND REFERRED THE CONTACT TO NHTSA. THE APPROXIMATE VEHICLE FAILURE MILEAGE WAS 265,000 AND THE TIRE FAILURE MILEAGE WAS 185.
No injuries · No fire · No crash
TL* THE CONTACT OWNS A 1994 FORD F-250. THE CONTACT STATED THAT WHILE DRIVING AT VARIOUS SPEEDS, THE FRONT FUEL TANK WOULD EXTRACT FUEL FROM THE REAR FUEL TANK CAUSING THE FUEL TO LEAK OUT THE FRONT FUEL TANK. THE VEHICLE WAS NOT DIAGNOSED OR REPAIRED. THE MANUFACTURER HAD BEEN NOTIFIED. THE APPROXIMATE FAILURE MILEAGE WAS 63,000.
No injuries · No fire · No crash
TL* THE CONTACT OWNS A 1994 FORD F-250. THE CONTACT STATED THE FUEL PRESSURE REGULATOR HAS WORN OUT AND CAUSE FUEL TO LEAK IN ONE OF THE DUAL FUEL TANKS. THE FUEL LEAKAGE IN THE PRESENCE OF AN IGNITION SOURCE COULD RESULT IN A VEHICLE FIRE. THE CONTACT NOTICE A RECALL FOR THE PREVIOUS YEAR MODEL REGARDING THE FUEL SYSTEM, GASOLINE:STORAGE:TANK ASSEMBLY (00V424000). HE HAD NOT CALLED THE MANUFACTURER TO SEE IF HIS VEHICLE IS INCLUDED IN THIS RECALL. THE CONTACT STATED THE VEHICLE CAN CAUSE A FIRE WHILE DRIVING. THE FAILURE MILEAGE WAS 79,000.
No injuries · No fire · No crash