Ford F-250 Complaints (2005)

439 consumer complaints on file.

#10583873April 21, 2014
ENGINE
CRANK, NOT START. HIGH PRESSURE OIL SYSTEM LEAK. PUMP FITTING LEAKING AND IPR DAMAGED. REMOVED AND REPLACED HP OIL PUMP, QUICK CONNECT AND IPR. COST $1380.29 AFTER ONLY 705 MILES, MORE REPAIRS NEEDED, OF COURSE NOT COVERED BY WARRANTY AGAIN. WHY ISN'T SOMETHING BEING DONE TO FORCE FORD TO PAY FOR REPAIRS TO THIS JUNK THEY PUT TOGETHER? WORK DONE BY LEGACY FORD. *TR
Crash:
No
Fire:
No
Injuries:
0
Deaths:
0
#10583891April 21, 2014
ENGINE, ENGINE AND ENGINE COOLING
LOSING WATER AND OIL FROM EXHAUST, WHITE SMOKE. VEHICLE LOSING COOLANT FROM EXHAUST PIPE. HARD START. ACTS LIKE HIGH PRESSURE OIL, BLOWS LOTS OF WHITE SMOKE OUT OF EXHAUST. INSTALLED IDS/ COMPUTER AND INSTALLED COOLANT PRESSURE GAUGE IN LINE ON COOLING SYSTEM. MONITORED ECT/EOT AND COOLANT PRESSURE.. GOT VEHICLE TO NORMAL OPERATING TEMP. ECT/EOT WERE AT 15 DEGREES DIFFERENCE WHICH IS MAXIMUM ALLOWANCE FOR OIL COOLER TEMP.FORD RECOMMENDS IT BE REPLACED WHEN IT REACHES 15 DEGREE DIFFERENCE. ALSO RECOMMEND REPLACE EGR COOLER WITH OIL COOLER AS A SET. PERFORM TSB 09-08-3, TEST DEGASS BOTTLE-OK. EGR TEST ON VEHICLE PASSED, INSTALLED PRESSURE GAUGE. ROAD TEST FOR HEAD GASKETS - 21 PSI IN COOLING SYSTEM FAILED. PERFORMED TURBO OVER BOOST - TEST PASSED. FAILED ITEMS: HEAD GASKETS, OIL COOLER. WHEN TEARING APART NEED CHECK CONCERN WITH HIGH PRESSURE OIL SYSTEM. ESTIMATE TO REPAIR AROUND $7000 WHICH NEITHER FORD NOR DEALER, LEGACY FORD, WILL COVER UNDER WARRANTY. WHAT IS THE WARRANTY FOR IF NOT TO REPAIR FORD'S JUNK? SO NOW AN EXPENSIVE TRUCK SITS UNUSABLE BECAUSE OF FORD AND THEY HAVE LOST A LONG TIME BELIEVER IN FORD VEHICLES, THIS IS MY LAST FORD. *TR
Crash:
No
Fire:
No
Injuries:
0
Deaths:
0
#10583648April 19, 2014
ENGINE
HARD TO START. REPLACE BRACELET KIT. UNDER WARRANTY BY FORD OF WALLA WALLA. GOOD COMPANY. REPLACED BY LEGACY. NO MORE WARRANTY WHEN DEALERS CHANGE?. *TR
Crash:
No
Fire:
No
Injuries:
0
Deaths:
0
#10583652April 19, 2014
ENGINE
CHECK GAUGE LIGHT CAME ON. TEMPERATURE GAUGE ALMOST TO TOP. TOWED FROM ONTARIO, OR., TO BAKER, OR. FOR REPAIRS. REPLACED COOLANT CAP, STILL NOT RIGHT. SAND DEGAS BOTTLE AND RETEST, STILL FAILED. REMOVE TURBO ASSEMBLY AND INTAKE. PRESSURE TEST. EGR COOLER FAILS. REPLACE EGR COOLER AND INSTALL INTAKE. DISASSEMBLE TURBO AND INSPECT. CARBONED UP. REPLACED CENTER ROTATING ASSEMBLY AND UNISON RING. REASSEMBLED AND TRIED TO START. STATIC LOCKED. REMOVED ALL GLOW PLUGS, CRANK ENGINE TO CLEAR ALL CYLINDERS AND REINSTALL GLOW PLUGS. HAD TO CLEAR CARBON FROM INTAKE AND REPLACE EGR VALVE, RUN EGR TEST AFTER FULLY WARMED UP, EGR SYSTEM PASSED. CODES PO404, P0405, P115A AND U0100. DONE UNDER WARRANTY BY GENTRY FORD. THIS DEALER GIVES VERY DETAILED REPORT, BE NICE IF THEY ALL DID. *TR
Crash:
No
Fire:
No
Injuries:
0
Deaths:
0
#10583335April 17, 2014
ELECTRICAL SYSTEM, ENGINE
TL* THE CONTACT OWNS A 2005 FORD F250. THE CONTACT STATED THAT THE VEHICLE WAS HESITANT UPON START-UP. THE FAILURE WAS RECURRING. THE STARTER WOULD TURN OVER BUT THE ENGINE WOULD NOT ENGAGE. THE BATTERY WAS REPLACED TWICE BUT TO NO AVAIL. ADDITIONALLY, BLACK SMOKE WAS EMITTING FROM THE VEHICLE AND THE VEHICLE WOULD STALL SPORADICALLY. THE VEHICLE WAS TO BE INSPECTED, DIAGNOSED AND REPAIRED. THE MANUFACTURER WAS NOTIFIED OF THE FAILURE. THE APPROXIMATE FAILURE MILEAGE WAS 109000.
Crash:
No
Fire:
Yes
Injuries:
0
Deaths:
0
#10574696March 25, 2014
STEERING
STOPPED AT A STOP SIGN, ACCELERATED TO MAKE LEFT TURN,HIT EITHER A BUMP OR PATCH OF SAND WHEN STEERING TOOK TO LEFT THEN RIGHT AND COULD NOT GET BACK. HIT A GUARDRAIL AND LANDED IN DITCH. MY TRUCK IS TOTALED BUT LUCKILY I WAS NOT SEVERELY INJURED. *TR
Crash:
Yes
Fire:
No
Injuries:
1
Deaths:
0
#10573490March 19, 2014
STRUCTURE:BODY, SERVICE BRAKES
TL* THE CONTACT OWNS A 2005 FORD F250. THE CONTACT STATED THAT THE BRAKES WOULD NOT FULLY ENGAGE WITHOUT ABRUPT FORCE BEING APPLIED AND THE WHEELS WOULD CONTINUE TO ROLL AS IF THE ACCELERATOR WAS APPLIED. THE VEHICLE HAD BEEN TAKEN TO AN INDEPENDENT MECHANIC FOR ROUTINE SERVICE. ADDITIONALLY, THERE WAS RUST AND CORROSION ON THE BEAMS FOR THE TRUCK BEDDING WHICH EXHIBITED AN ABNORMAL NOISE.THE VEHICLE WAS NOT INCLUDED IN NHTSA CAMPAIGN ID NUMBER:06E087000 (SERVICE BRAKES, AIR). THE MANUFACTURER WAS NOT NOTIFIED OF THE FAILURE. THE APPROXIMATE FAILURE MILEAGE WAS 5000.
Crash:
No
Fire:
No
Injuries:
0
Deaths:
0
#10567363March 4, 2014
SUSPENSION
WHEN EVER THE TRUCK GOES OVER SOMETHING LIKE AN BULGED EXPANSION JOINT OR A POT HOLE WITH SPEED IN EXCESS OF 40-45, IT WILL REACT VIOLENTLY. OFTEN THE VEHICLE WILL MOVE OVER A FOOT OR TWO(DEPENDING ON THE SPEED OF THE TRUCK) IN THE LANE OF TRAFFIC. THE BOUNCING/SHAKING OF THE FRONT WHEELS IS OVER IN SEVERAL SECONDS, BUT IS SEVERE NONE THE LESS. IF YOU HIT A BUMP ON A CURVE, THE VEHICLE WILL ALMOST GO OFF THE ROAD. THIS HAS HAPPENED ENOUGH TIMES OVER THE YEARS THAT I ATTEMPTED EVASIVE ACTION/SLOW WAY DOWN WHEN I SEE I'M ABOUT TO STRIKE SOMETHING THAT WILL SET THE SUSPENSION INTO BOUNCE MODE. MANY, MANY, MANY FORD SUPER DUTY OWNERS HAVE COMPLAINED ABOUT THIS ISSUE AND ALL FORD CAN SAY IS THAT IT'S THE OWNERS FAULT FOR NOT KEEPING THE TIRES AIRED PROPERLY. I DARE YOU TO COME DRIVE MY TRUCK!!!!!!!!! YES, I HAVE CHANGED THE OEM SHOCKS TO BILSTENS FOR THE F250 APPLICATIONS AND HAVE INSTALLED A STIFFER STEERING STABILIZER SHOCK. HAVE ALSO EXPERIMENTED WITH VARIOUS AIR PRESSURE SETTINGS. NOTHING MADE ANY DIFFERENCE. TRUCK STILL HAS STOCK SUSPENSION SPRINGS.
Crash:
No
Fire:
No
Injuries:
0
Deaths:
0
#10561613January 27, 2014
ENGINE
TL* THE CONTACT OWNS A 2005 FORD F-250. WHILE DRIVING 55 MPH, THE CONTACT STATED THAT THE VEHICLE POWERED OFF WITHOUT WARNING. THE CONTACT RESTARTED THE VEHICLE AND IT PERFORMED NORMALLY THEN POWERED OFF AGAIN. THE VEHICLE WAS NOT TAKEN TO A DEALER FOR DIAGNOSTIC TESTING. THE VEHICLE WAS NOT REPAIRED. THE VIN WAS UNAVAILABLE. THE APPROXIMATE FAILURE MILEAGE WAS 100,000.
Crash:
No
Fire:
No
Injuries:
0
Deaths:
0
#10557937December 31, 2013
ENGINE
TL* THE CONTACT OWNS A 2005 FORD F-250 SD. THE CONTACT STATED THAT WHILE DRIVING APPROXIMATELY 40 MPH, THE VEHICLE STALLED WITHOUT WARNING. THE VEHICLE WAS TOWED TO AN INDEPENDENT MECHANIC BUT HAD NOT BEEN DIAGNOSED OR REPAIRED. THE MANUFACTURER WAS MADE AWARE OF THE PROBLEM. THE APPROXIMATE FAILURE MILEAGE WAS 160,000.
Crash:
No
Fire:
No
Injuries:
0
Deaths:
0
#10557215December 25, 2013
SUSPENSION, STEERING
I WAS DRIVING DOWN A MAIN ST, GOING ABOUT 35 MPH...WHEN I HIT A BUMP THE TRUCK WOULD SHAKE VIOLENTLY AND THE STEERING WHEEL WAS ALSO SHAKING VIOLENTLY , I HAD IT DIAGNOSED AS THE DRAG LINK BALL JOINT AND AN UPPER BALL JOINT BOTH ON THE PASSENGER SIDE FRONT...I GOT A LETTER IN THE MAIL FROM FORD JUST YESTERDAY ABOUT THE SHIMMY/SHAKING ISSUE, THE LETTER STATES THAT IT IS DUE TO TIRE PRESSURE IN WHICH I BELIEVE TO BE VERY WRONG!! *TR
Crash:
No
Fire:
No
Injuries:
0
Deaths:
0
#10557180December 24, 2013
STEERING, SUSPENSION
SEVERE STEERING SHAKE AND FRONT SHIMMY AFTER GOING OVER ROUGHNESS IN ROAD. VEHICLE HAD TO BE SLOWED TO ALMOST REST TO STOP SHIMMY. HAS HAPPENED MULTIPLE TIMES. *TR
Crash:
No
Fire:
No
Injuries:
0
Deaths:
0
#10545735September 27, 2013
ENGINE
TL* THE CONTACT OWNS A 2005 FORD F-250. THE CONTACT STATED THAT WHILE TRAVELING APPROXIMATELY 20 MPH, THE VEHICLE SUDDENLY STALLED AND FAILED TO RESTART. THE VEHICLE WAS NOT DIAGNOSED OR REPAIRED. THE MANUFACTURER WAS CONTACTED ABOUT THE FAILURE. THE FAILURE MILEAGE WAS 39,000. UPDATED 12/4/13*CN THE CONSUMER STATED THE FAILURE WAS DUE TO A MANUFACTURING DEFECT. THE EGR AND COOLERS FAILED DUE TO CLOGGING AND EXCESSIVE HEAT.
Crash:
No
Fire:
No
Injuries:
0
Deaths:
0
#10544279September 18, 2013
ENGINE
TL* THE CONTACT OWNS A 2005 FORD F-250 SD. THE CONTACT STATED THAT WHILE DRIVING 55 MPH, THE TEMPERATURE WARNING LIGHT ILLUMINATED. THE CONTACT NOTICED THAT THE VEHICLE WAS OVERHEATED AND PULLED THE VEHICLE OVER TO LET IT COOL DOWN. THE VEHICLE WAS TAKEN TO THE DEALER FOR INSPECTION WHERE THEY STATED THAT THE IGR VALVE NEEDED TO BE REPLACED. THE VEHICLE WAS NOT REPAIRED. THE MANUFACTURER WAS NOTIFIED OF THE FAILURE. THE FAILURE MILEAGE WAS 115,500.
Crash:
No
Fire:
No
Injuries:
0
Deaths:
0
#10522391June 29, 2013
SERVICE BRAKES
THIS IS THE THIRD TIME I HAVE ENCOUNTERED THIS PROBLEM, AND REPORTED THIS PROBLEM AS WELL. . BROUGHT TO FORD DEALERSHIP AND TOLD THEY DID NOT FIND ANYTHING WRONG WITH THE VEHICLE. IT CONTINUED TO HAPPEN. I BROUGHT THE TRUCK TO AN INDEPENDENT REPAIR SHOP WHO KNEW RIGHT AWAY THAT THE CALIPERS WERE SEIZED.. I PAID APPROXIMATELY $1100.00 FOR THAT BRAKE JOB AND TOLD THAT FORD WOULD NOT WARRANTY THE PARTS IT WAS BEYOND THE WARRANTY. I WAS TOLD THERE WAS A RE-DESIGN OF THE BRAKE SHOES. THEY REPLACED ONE REAR ROTORS, "FREED UP" ONE REAR CALIPER. I DID ADVISE DRIVERS FRONT WAS SEIZING UP AT ONE POINT AS WELL. I WAS PROVIDED THE REAR ROTORS AND SHOES. THE SHOES WERE WELL WITHIN USABLE RANGE WHICH WAS NOTED BY MYSELF, ALSO A DIESEL MECHANIC AND A INDEPENDENT AUTO REPAIR SHOP. THE DAY I PICKED UP THE VEHICLE I WAS DRIVING HOME LOST ALL BRAKES. I HAD IT TOWED AT MY OWN EXPENSE THEN THEY DISCOVERED THE OTHER REAR CALIPER HAD IN FACT SEIZED LIKE I HAD TOLD THEM THEY REPLACED IT COST ME FOR THE REPAIR.THIS YEAR MAY 2013 WAS AGAIN NOTICED SMELL OF THE BRAKES BURNING, ALONG WITH FAMILIAR BOUNCING. ONLY THIS TIME I DROVE 8 MILES WHEN HEAVY SMOKE WAS COMING FROM FRONT WHEEL WHAT I TOLD THEM LAST TIME AND THEY DIDN'T FIX IT BACK TO THE DEALERSHIP IT WENT. ALTHOUGH THEY FIXED THE PROBLEM IT COST ME THE FEE FOR THE SERVICE. I PAID THE OUTRAGEOUS PRICE OF $2400.00 IN 2011 FOR THE EXTENDED WARRANTY KNOWING THIS TRUCK WOULD BE COSTING FAR MORE THAN THAT IN FUTURE. THE MYSTERY VIBRATION SOME EXPERIENCE THAT CANT BE "REPEATED" AT THE DEALERSHIP OTHER THAN THE CRAP OF TIRE INFLATION OR "ROAD FORCE BALANCING" WHICH THERE IS NO TIRE SHOP WITHIN 50 MILES OF ME THAT HAS EVER HEARD OF SUCH A THING IS MOST LIKELY THE BRAKES. *TR
Crash:
No
Fire:
No
Injuries:
0
Deaths:
0
#10504963March 29, 2013
STRUCTURE:BODY, SERVICE BRAKES, SUSPENSION
I NOTICED THAT WHEN I HIT A BUMP THE BED OF MY TRUCK BOUNCES ABOUT TWO INCHES, WHEN I LOOKED UNDER THE TRUCK I NOTICED ALL THE SUPPORTS UNDER THE BED WERE COMPLETELY ROTTED. I HAVE ALSO HAD PROBLEMS WITH MY BRAKES. IN LESS THAN 90,000 MILES I'VE REPLACED THREE BRAKE CALIPERS, TWO ROTORS, TWO SETS OF BRAKES, AND THE LAST TIME I HAD IT SERVICED THE BACKING PLATES WERE SO ROTTED THAT THE EMERGENCY BRAKE WOULDN'T WORK AND COULDN'T BE REPLACED WITHOUT ALSO REPLACING THE BACKING PLATES. I HAVE BEEN DRIVING FOR 50 YEARS AND HAVE NEVER EXPERIENCED THIS MUCH ROT. I FEEL THAT THE STRUCTURAL DAMAGE SHOULDN'T HAPPEN THIS SOON, AND FEEL THAT I SHOULDN'T BE RESPONSIBLE FOR THE COST TO REPAIR IT. *TR
Crash:
No
Fire:
No
Injuries:
0
Deaths:
0
#10504964March 29, 2013
WHEELS
TL* THE CONTACT OWNS A 2005 FORD F-250 SD HARLEY DAVIDSON EDITION MOTORCYCLE. THE CONTACT STATED THAT THE FRONT DRIVER SIDE WHEEL WAS CRACKED ON THE OUTER RIM. THE CONTACT STATED THAT HE HAD EXPERIENCED THE FAILURE PREVIOUSLY AND THE WHEEL WOULD CAUSE THE TIRE TO LOSE PRESSURE. THE CONTACT HAD TO REMOVE THE WHEEL AND REPLACE IT WITH THE SPARE TIRE. THE CONTACT CALLED THE MANUFACTURER NUT WAS PROVIDED WITH NO ASSISTANCE. THE FAILURE MILEAGE WAS 48,000.
Crash:
No
Fire:
No
Injuries:
0
Deaths:
0
#10503450March 18, 2013
SERVICE BRAKES, STEERING, SUSPENSION
THIS IS THE FIRST OF FOUR TIMES THAT I HAVE HAD TO HAVE BRAKE WORK DONE ON MY TRUCK. THREE OF THE TIMES I WAS TOLD THAT THE CALIPERS HAD FROZEN AND SO CALIPERS PADS AND (EXCEPT THIS LAST TIME) ROTORS HAD TO BE REPLACED. THIS IS ABSURD FOR A TRUCK WITH LESS THAN 45,000 MILES. UNDERSTAND THIS IS EXPENSIVE!! HAVE NEVER HAD ANYTHING LIKE THIS ON ANY OTHER VEHICLE. ALSO, I HAVE EXPERIENCED THE OFT TALKED ABOUT "DEATH WOBBLE" A FEW TIMES ON THE HIGHWAY. WAS REAR BRAKES IN 2010' FRONTS IN 2011' NOW REARS AGAIN IN 2013. *TR
Crash:
No
Fire:
No
Injuries:
0
Deaths:
0
#10499966February 25, 2013
ELECTRICAL SYSTEM
FAILURE TO START, NO WARNING, NO CODES , TURNS OVER BUT NO FURTHER INFO. SENT TO THE DEALER FOR EVAL, FUEL INJECTOR CONTROL MODULE (FICM). FAILURE , AFTER REPLACING OF THE WIRELESS FOOT ASSEMBLY PEDAL 2 WEEKS AGO. JUST ANOTHER ONGOING ISSUE RELATED TO THIS 6.0 , WHICH PRIOR STALLS WITHOUT WARNING , REFUSE TO RUN WITHOUT MISHAPS FOR PERIOD OF TIME FORD SHOULD BE RESPONSIBLE TO FIX OR REPLACE THIS VEHICLE. *TR
Crash:
No
Fire:
No
Injuries:
0
Deaths:
0
#10495353January 31, 2013
STEERING:LINKAGES:TIE ROD ASSEMBLY
TL* THE CONTACT OWNS A 2005 FORD F-250. THE CONTACT STATED THAT WHILE DRIVING 55 TO 60 MPH, A POT HOLE WAS HIT AND CAUSED THE VEHICLE TO SHIMMY AND SHAKE OUT OF CONTROL. THE BRAKE WAS ENGAGED WHILE AT HIGHWAY SPEEDS TO BRING THE VEHICLE UNDER CONTROL. THE DEALER ADVISED THAT THE TIE RODS FAILED. THE MANUFACTURER WAS MADE AWARE OF THE FAILURE. THE VEHICLE WAS NOT REPAIRED. THE FAILURE AND CURRENT MILEAGE WAS 97,000.
Crash:
No
Fire:
No
Injuries:
0
Deaths:
0

← Back to Ford F-250