Ford F-250 Complaints (1999)

830 consumer complaints on file.

#10378193January 21, 2011
ELECTRICAL SYSTEM
I HAVE A 1999 FORD F-250, SUPER DUTY PICK-UP, WITH A 5.4 V8 ENGINE, WITH ONLY 69,000 MILES. I WAS TRAVELING THROUGH TOWN AT 35 MPH WHEN I HEARD A LOUD POP (GUN SHOT SOUND), FOLLOWED BY POP POP POP POP POP. WHEN I PULLED OVER I DISCOVERED THAT ONE OF MY MICRO-COILS OVER MY SPARK PLUG HAD BROKEN OF THE PLASTIC HOUSING. WHEN I REMOVED THE COIL I FOUND THE PLATINUM SPARK PLUG IN THE COIL BOOT. SPARK PLUG BLOW OUT! NICE!...FORD WANTS $550 TO REPAIR ONE SPARK PLUG AND COIL, AND ALSO CHECK THE REST OF THE PLUGS FOR TIGHTNESS. HELP! *TR
Crash:
No
Fire:
No
Injuries:
0
Deaths:
0
#10376224January 11, 2011
ENGINE AND ENGINE COOLING:ENGINE
DRIVING THE VEHICLE, ENGINE STALLED. UNABLE TO RESTART AS ENGINE HAD SEIZED. UP TO THIS TIME, THE OIL PRESSURE AND WATER TEMPERATURES WERE IN THE NORMAL OPERATING RANGES, AND OIL LEVEL WAS WITHIN RANGE AS WELL. *TR
Crash:
No
Fire:
No
Injuries:
0
Deaths:
0
#10374901January 6, 2011
POWER TRAIN:AUTOMATIC TRANSMISSION
TL*THE CONTACT OWNS A 1999 FORD F250. WHILE DRIVING APPROXIMATELY 40 MPH, THE VEHICLE BEGAN VIBRATING. THE FAILURE WOULD OCCUR WHEN DRIVING AT SPEEDS GREATER THAN 40 MPH. THE FAILURE OCCURRED FOR APPROXIMATELY TWO YEARS. WHILE PARKED, THE CONTACT ALSO NOTICED OIL WAS LEAKING FROM THE VEHICLE. THE CONTACT INSPECTED THE VEHICLE AND NOTICED THE REAR COMB OF THE TRANSMISSION WAS BROKEN. THE VEHICLE WAS NOT TAKEN FOR REPAIRS BUT AN APPOINTMENT WAS MADE. THE APPROXIMATE FAILURE MILEAGE WAS 87,000.
Crash:
No
Fire:
No
Injuries:
0
Deaths:
0
#10373635December 31, 2010
ENGINE AND ENGINE COOLING
I PURCHASED A 1999 FORD F250 SUPER DUTY IN OCTOBER OF 1998 AND AFTER 130,000 MILES THE ENGINE STARTED PUSHING OUT THE SPARK PLUGS RIGHT OUT OF THE ENGINE HEADS. FORD SAID AT THE TIME THAT THE TRUCK WAS OUT OF WARRANTY SO I PURCHASE ANOTHER ENGINE FROM A DISMANTLER AND AFTER 12,000.00 MILES THIS ENGINE DID THE SAME THING BLOWING OUT SPARK PLUGS. *TR
Crash:
No
Fire:
No
Injuries:
0
Deaths:
0
#10370633December 14, 2010
ENGINE AND ENGINE COOLING:ENGINE
1999 FORD F250 ORIGINAL OWNER, 150K MILES MAINTAINED BY FORD DEALER. SPARK PLUGS REPLACED AT 100K MILES PER MAINTENANCE SCHEDULE. #3 BLEW OUT ON 12/10/10. THIS IS A KNOWN ISSUE WITH THE FORD MODULAR ENGINES AND CAUSES DAMAGE TO THE INTERIOR OF THE ENGINE COMPARTMENT AND COMPONENTS IN THE ENGINE BAY. HAS BEEN KNOWN TO START A FIRE. COULD CAUSE SERIOUS INJURY OR DEATH IF SOMEONE WAS LOOKING IN THE ENGINE BAY WHEN A SPARK PLUG BLOWS OUT. NEEDS TO BE ADDRESSED BEFORE SOMEONE IS SERIOUSLY INJURED. *TR
Crash:
No
Fire:
No
Injuries:
0
Deaths:
0
#10368435November 30, 2010
ENGINE AND ENGINE COOLING:ENGINE
AUGUST 2009 MY WIFE WAS DRIVING OUR 1999 F-250 SUPER DUTY WITH 6.8L V-10 AND SHE HEARD A POPPING NOISE COMING FROM UNDER THE HOOD. IT TURNED OUT THAT IT WAS THE 4TH CYLINDER ON PASSENGER SIDE HAVING THE PLUG BLOWN OUT OF THE CYLINDER HEAD. HAD TO HAVE IT TOWED AND FIXED FOR $500.THEY USED A HELICOIL INSTEAD OF REPLACING THE HEADS WHICH IS WHATG FORD RECOMMENDS. OBVIOUSLY LOST THE COIL PACK TOO. I HEARD AFTERWARD THIS IS A COMMON PROBLEM FOR ALL OF THE TRITON MOTORS. I AM NOW WAITING FOR THE NEXT ONE TO GO AND DON'T REALLY TRUST THE VEHICLE FOR LONG TRIPS ANYMORE. THANKFULLY NO FIRE. THIS REPORT IS LISTED LATE AS I JUST CAME ACROSS THIS THREAD. HOPEFULLY FORD WILL BE FORCED TO FIX THESE IN THE FUTURE AS I CANNOT AFFORD TO DO THIS OVER AND OVER AND OVER. *TR
Crash:
No
Fire:
No
Injuries:
0
Deaths:
0
#10365701November 15, 2010
ENGINE AND ENGINE COOLING
MY 1999 FORD F 250HD HAS BLOWN 3 DIFFERENT SPARK PLUGS OUT OF THE HEAD.THE REPAIR COST IS 400.00 EACH AND FORD ACTS LIKE THIS IS NORMAL. THIS IS A MFG. DEFECT THAT FORD WILL NOT ADMIT TO.OUR LOCAL DEALER SAYS THEY CANT COUNT HOW MANY PLUGS THEY HAVE SEEN BLOWN OUT
Crash:
No
Fire:
No
Injuries:
0
Deaths:
0
#10365888November 15, 2010
ENGINE AND ENGINE COOLING:ENGINE
I OWN A 1999 F-250 TRUCK WITH A V-10. RECENTLY RETURNING FROM AN OUT OF TOWN TRIP ONE OF THE SPARK PLUGS BLEW OUT OF THE CYLINDER HEAD WHILE DRIVING ON THE HIGHWAY. IMMEDIATELY LOST POWER AND PULLED ONTO THE SHOULDER. SPEED LIMIT FOR THIS SECTION WAS POSTED FOR 75 MPH. LIMPED THE VEHICLE HOME FOR APPROXIMATELY 25 MILES WITH A STRONG ODOR OF GAS, WAS WORRIED OF POTENTIAL ENGINE FIRE BUT NEEDED TO GET HOME WITH MY TRAVEL TRAILER AND ATV. DID NOT WANT TO LEAVE ALL THIS ON THE SIDE OF THE ROAD. AFTER INTERNET RESEARCH SEAMS THAT THIS IS A COMMON PROBLEM WITH THE FORD TRITON MOTOR DESIGN. POOR ENGINEERING. *TR
Crash:
No
Fire:
No
Injuries:
0
Deaths:
0
#10357489September 25, 2010
ENGINE AND ENGINE COOLING:ENGINE
MY 1999 FORD F-250 SD. BLEW A SPARK PLUG OUT OF THE NUMBER FOUR CYLINDER AND A GASOLINE VAPOR FIRE STARTED. I GOT THE FIRE OUT AND DISCOVERED THE PROBLEM. THE SPARK PLUG WAS LAYING ON TOP OF THE ENGINE WITH APPROXIMATELY FOUR THREADS OF ALUMINUM ATTACHED TO ITS THREADS. HOW CAN FORD HAVE SOOOOO MANY OF THIS EXACT ISSUE AND NOT HAVE A RECALL?PLEASE HELP US!!!!!!!!!!!!!!!!!!!!!!!!!!!!!!! *TR
Crash:
No
Fire:
Yes
Injuries:
0
Deaths:
0
#10351854August 25, 2010
ENGINE AND ENGINE COOLING:ENGINE
MY 1999 FORD F-250 V-10 SUPER DUTY WITH 42, 960 MILES BLEW THE SPARK PLUG OUT OF NUMBER 8 CYLINDER. I WAS DRIVING DOWN THE HIGHWAY, APPROXIMATELY 15 MILES FROM A MAJOR CITY, WHEN IT SHOT OUT THE PLUG. I WAS ABLE TO LIMP INTO TOWN AND FIND A MECHANIC THAT WOULD WORK ON A SUNDAY NIGHT. HE HAD TO DRILL OUT THE PLUG HOLE, TAP AND INSTALL A STEEL INSERT, THEN REPLACE THE PLUG AND COIL PACK. IT WAS A $500.00 REPAIR. THIS IS A WELL KNOWN ISSUE WITH 1999 THROUGH 2002 FORD TRITON V-8 AND V-10 ENGINES. A SIMPLE WEB SEARCH REVEALS HOW PREVALENT IT IS, AND THE AMOUNT OF COMPLAINTS DOCUMENTED ON THE NHTSA WEB SITE CONFIRMS THAT FACT. NHTSA NEEDS TO FORCE FORD TO RECALL THEIR DEFECTIVE CYLINDER HEADS BEFORE SOMEONE IS SERIOUSLY INJURED BY THIS DESIGN FLAW. *TR
Crash:
No
Fire:
No
Injuries:
0
Deaths:
0
#10345995July 28, 2010
SUSPENSION:FRONT
TODAY TOOK THE FORD 1999, 250 SD CREW-CAB TO MY MECHANIC, A FUNNY NOISE, LIKE METAL TO METAL IN THE FRONT AREA OF THE SUSPENSION...SOMETIME NOT ALL THE TIME, TECH DOES NOT KNOWS WHAT IT IS, GUESSED IS RELATED TO THE LEAF SPRING WORNOUT BUSHINGS...PLUS SWAY BARS END TIPS...TOLD ME THAT FEW PARTS HAD TO BE CHANGED..AND EVEN SO, HE DID NOT ASSURED ME THAT THE NOISE WILL DISAPPEARED.... IT'S BEEN A VERY GOOD TRUCK, ONLY OIL, BRAKES, BATTERIES, ETC. WHAT A DILEMMA ??? *TR
Crash:
No
Fire:
No
Injuries:
0
Deaths:
0
#10331905May 24, 2010
ENGINE AND ENGINE COOLING:ENGINE
I OWN A 1999 FORD F-250. THE TRUCK HAS HAD 3 SPARK PLUGS BLOW OUT OF THE ENGINE SPONTANEOUSLY WHILE I WAS DRIVING AT APPROXIMATELY 60MPH EACH TIME. THE TRUCK HAS RECEIVED PROPER MAINTENANCE. I AM FINALLY REPORTING IT AFTER I STARTED TO RESEARCH AND FOUND OUT THAT THIS IS A WELL KNOWN FORD DEFECT THAT THEY WILL NOT ADMIT TO. THE ENGINE IN QUESTION IS A 5.4L V-8. *TR
Crash:
No
Fire:
No
Injuries:
0
Deaths:
0
#10326002April 16, 2010
VEHICLE SPEED CONTROL
PURCHASED A 1999 FORD F250 SUPER DUTY FEBRUARY,2009. IN SEPTEMBER 2009, RECEIVED A LETTER FROM FORD INFORMING OF A RECALL TO THE SPEED CONTROL (05S28). ON OCTOBER 6,2009, TOOK THE TRUCK TO NEAREST FORD DEALER WHICH HAD PERFORMED THE NECESSARY PART TO PREVENT THE TRUCK FROM IGNITING A FIRE. ON OCTOBER 17,2009 WHILE THE TRUCK WAS PARKED IN OUR DRIVEWAY, IT CAUGHT FIRE. WE LEARNED FROM A NEIGHBOR: THEY PULLED IN THEIR HOUSE AND SEEN SMOKE COMING FROM THE TRUCK UNDER THE HOOD. THEY RAN OVER AND GRABBED THE WATER HOSE AND TRIED TO OPEN THE DOOR, IT WAS LOCKED. THEY CALLED THE LOCAL FIRE DEPT. AND THE FIRE STARTED.THE TRUCK'S ENGINE STARTED UP, THE HEADLIGHTS CAME ON AND THE WIPERS STARTED GOING BACK AND FORTH. MY NEIGHBOR LOOKED IN THE WINDOW AND SEEN THERE WAS NO KEYS IN THE IGNITION. THE FIREMEN ARRIVED AND FORCE AND FORCED THE HOOD UP AND PUT OUT THE FIRE. IT WAS A TOTAL LOSS. WE CONTACTED THE LOCAL DEALERSHIP WHERE THE RECALLED PART WAS REPLACED AND TOLD US TO CONTACT FORD MOTOR COMPANY. WE DID, THEY SENT US A LETTER OF NEEDED INFORMATION FROM US. WHEN SUBMITTED ALL INFORMATION AND IN DECEMBER 2009 GOT A REPLY THEY WERE UNABLE TO ASSOCIATE WITH US ON OUR DAMAGE. *TR
Crash:
No
Fire:
Yes
Injuries:
0
Deaths:
0
#10314902February 27, 2010
ENGINE AND ENGINE COOLING:ENGINE
SPARK PLUG BLOWS OUT OF CYLINDER HEAD AND TAKES COIL PACK WITH IT. *TR
Crash:
No
Fire:
No
Injuries:
0
Deaths:
0
#10312344February 20, 2010
VEHICLE SPEED CONTROL
ON THURSDAY EVENING FEBRUARY 18, 2010 AT APPROXIMATELY 9:45 PM MY WIFE NOTICED WHEN SHE TOOK OUR DOG OUT IN OUR FRONT YARD THAT OUR 1999 FORD F250 LARIET 7.3 LITER DIESEL WAS ON FIRE. I HAD CONNECTED THE FACTORY INSTALLED BLOCK HEATER TO A 120V EXTENSION CORD AT AROUND 9:00 PM THAT SAME EVENING, AS USUALLY DONE IN THE EVENINGS WHEN IT WILL BE DRIVEN THE NEXT DAY. AMBIENT TEMPERATURE WAS APPROXIMATELY 25 DEGREES F. THE TRUCK HAS FACTORY INSTALLED CRUISE CONTROL, AND WAS BROUGHT IN TO A FORD DEALER IN AROUND JULY 2009 AS REQUIRED BY A FORD RECALL NOTICE ABOUT CRUISE CONTROLS. THE SERVICE DEPARTMENT OF THE DEALERSHIP SAID THE CRUISE CONTROL WAS NOT DEFECTIVE. BASED UPON THE FIRE, I BELIEVE FORD'S TEST PROCEDURES TO ASSESS THE SAFE OPERATION OF THE CRUISE CONTROL SWITCH AS TO CORROSION/ELECTRICAL RESISTANCE, AND EXCESSIVE HEAT GENERATION, IS IN ADEQUATE BECAUSE IT PROBABLY DOES NOT MEASURE CONDUCTIVITY, AND SWITCH ASSEMBLY TEMPERATURE. THE BETTENDORF, IOWA FIRE DEPARTMENT RESPONDED, AND EXTINGUISHED THE FIRE WITHIN FIVE MINUTES ONCE THEY HAD THE HOSES, PRY BARS, AND HYDRAULIC JAWS IN PLACE. THE SCOTT COUNTY SHERIFF DEPARTMENT ALSO RESPONDED. OUR INSURANCE COMPANY SAID THE TRUCK IS TOTALED, AND AWAITING MY DECISION REGARDING SALVAGE. I WILL CONTACT AN ATTORNEY (HE WAS IN COURT) MONDAY FEBRUARY 22, 2010 REGARDING WHAT I BELIEVE THAT THE CAUSE OF THE FIRE WAS THE CRUISE CONTROL SWITCH, PROBABLY MANUFACTURED BY TEXAS INSTRUMENTS. THE TRUCK HAS NOT BEEN MOVED AWAITING DIRECTIONS FROM THE ATTORNEY. *TR
Crash:
No
Fire:
Yes
Injuries:
0
Deaths:
0
#10310990February 16, 2010
TIRES, TIRES:TREAD/BELT
TL* THE CONTACT OWNS A 1999 FORD F250 SUPER DUTY. WHEN HE TOOK THE VEHICLE TO INDEPENDENT MECHANIC FOR ROUTINE MAINTENANCE HE NOTICED THAT ALL FOUR TIRES WERE BALD AND HAD NOT THREAD. THE TIRES WERE MANUFACTURED BY GENERAL TIRE, LINE GENERAL GRABER AT2, SIZE LT245-75R16 LOAD EASE, DOT P5111UU. HE CONTACTED THE MANUFACTURER. THE MANUFACTURER STATED HE SHOULD FILE A COMPLAINT THEN THEY WILL REPLACED THE TIRE, OR GIVE HIM HIS MONEY BACK. THE VEHICLE CURRENT AND FAILURE MILEAGE WERE 240,000.
Crash:
No
Fire:
No
Injuries:
0
Deaths:
0
#10303633February 1, 2010
PARKING BRAKE:CONVENTIONAL:MECHANICAL:LINKAGE AND CABLE
TL*THE CONTACT OWNS A 1990 FORD F250 SUPER DUTY TRUCK(NA). WHILE THE VEHICLE WAS PARKED HE ATTEMPTED TO APPLY THE PARKING BRAKE AND IT FAILED. HE TOOK THE VEHICLE TO THE DEALER WHO STATED THAT THE FRONT PARKING BRAKE CABLE BROKE. HE EXPERIENCED THE IDENTICAL FAILURE IN 2001 AND THE CABLE WAS REPAIRED UNDER THE WARRANTY; HOWEVER; THE MANUFACTURER CONFIRMED THAT HIS VIN IS NOT RELATED TO RECALL 02V068000 PARKING BRAKE, CONVENTIONAL MECHANICAL LINKAGE AND CABLE. THE CURRENT AND THE FAILURE MILEAGE WERE 152,000.
Crash:
No
Fire:
No
Injuries:
0
Deaths:
0
#10299586January 13, 2010
ELECTRONIC STABILITY CONTROL (ESC)
SPARK PLUG THREAD DEFECT IN #2 CYLINDER CAUSING LOW COMPRESSION AND POSSIBLE BENT VALVE DAMAGED BY PLUG DEBRIS. THE CYLINDER WILL NEED TO BE REMOVED TO CORRECT PROBLEM. THIS IS A KNOWN CONDITION WITH FORD AND THE 5.4 TYPE ENGINE AND THEY IGNORE THERE RESPONSIBILITY COMPLETELY. THE REPAIR IS AT A COST OF ABOUT TWO THOUSAND DOLLARS AND THEY SHOULD TAKE SOME ALLOWANCE TO CUSTOMERS THAT OWN THERE PRODUCT. POOR QUALITY AND DESIGN WILL ONLY CONTINUE TO REDUCE AMERICAN CONFIDENCE IN THE AUTO INDUSTRY. *TR
Crash:
No
Fire:
No
Injuries:
0
Deaths:
0
#10299053January 11, 2010
PARKING BRAKE
TL*THE CONTACT OWNS A 1999 FORD F250 WITH A MANUAL TRANSMISSION. HE STATED THAT HE WAS HAVING ISSUES WITH THE PARKING BRAKE. WITH THE ENGINE STARTED AND IN THE PARK POSITION THE VEHICLE ROLLED OUT OF THE DRIVEWAY WHILE THE EMERGENCY BRAKE WAS ENGAGED. THIS OCCURRED TWICE WITHIN TWO MONTHS. THE MANUFACTURER WAS CONTACTED AND STATED THAT THERE WERE NO RECALLS AND HAD NOT RECEIVED ANY COMPLAINTS PERTAINING TO THE FAILURE. NO REPAIRS WERE MADE TO DATE. THE CONTACT WAS UTILIZING A LARGE PIECE OF CONCRETE UNDER HIS WHEELS TO KEEP THE VEHICLE FROM ROLLING AWAY. THE FAILURE AND CURRENT MILEAGES WERE 223,000. UPDATED 02/1710 *BF UPDATED 02/19/10*JB
Crash:
No
Fire:
No
Injuries:
0
Deaths:
0
#10298273January 5, 2010
POWER TRAIN:AXLE HUBS
TL*THE CONTACT OWNS A 1999 FORD F-250. THE CONTACT STATED THAT THE LOCKOUT HUB WAS BROKEN AND IT CAUSED THE 4 WHEEL DRIVE TO DISENGAGE. THE LOCKOUT HUBS WERE REPLACED FOUR TIMES. THE MANUFACTURER STATED THAT THERE WAS NOTHING THAT THEY COULD DO SINCE THE WARRANTY EXPIRED. THE CONTACT WOULD LIKE FOR THE MANUFACTURER TO ASSUME THE REPAIR COST SINCE AN AUTHORIZED MECHANIC CONFIRMED THAT THIS FAILURE IS COMMON FOR HIS YEAR, MAKE AND MODEL VEHICLE. THE FAILURE MILEAGE WAS 30,000.
Crash:
No
Fire:
No
Injuries:
0
Deaths:
0

← Back to Ford F-250