Ford F-250 Complaints (2004)

408 consumer complaints on file.

#10622040August 13, 2014
STRUCTURE:BODY, WHEELS, TIRES
DRIVING ON SH 239 IN REFUGIO COUNTY, TEXAS AT APPROX. 70 MPH BETWEEN TIVOLI, TX AND US HIGHWAY 77 SOUTH. RIGHT FRONT TIRE BLEW OUT WHICH IMMEDIATELY CAUSED THE TRUCK TO VEER OFF THE RIGHT SIDE OF THE HIGHWAY, OVER A METAL CULVERT, GO AIRBORNE THROUGH A BARBED WIRE FENCE AT THE CORNER POSTS, LAND IN A PASTURE AND CONTINUE THROUGH ANOTHER BARBED WIRE FENCE WITH METAL FENCE POSTS. DISTANCE TRAVELED FROM ROAD TO STOPPING POINT APPROXIMATELY 70-75 YARDS. TIRES PURCHASED AT DISCOUNT TIRE, 9/16/2009 TRUCK MILEAGE 68,000, ALL TIRES REPLACED AT THIS TIME WITH LT/265/75R16E1 123R B BF GOODRICH RUGGED TRAIL T/A RBL TIRES. *TR
Crash:
Yes
Fire:
No
Injuries:
0
Deaths:
0
#10618762August 4, 2014
ENGINE AND ENGINE COOLING, FUEL SYSTEM, DIESEL, VEHICLE SPEED CONTROL
ENGINE ACCELERATES SPORADICALLY ON ITS OWN. ENGINE OCCASIONALLY DIES AT STOP LIGHTS. MUST KEEP BRAKE PEDAL FIRMLY PUSHED AT STOP AS ENGINE WILL SUDDENLY ACCELERATE. I HAVE ALREADY REPLACED THE TURBO. THE DEALER SAYS IT COULD BE MANY DIFFERENT THINGS WRONG. THE 2003-2007 DIESELS ARE NOTORIOUS FOR BAD TURBO, FUEL INJECTORS AND A HEAD BOLT PROBLEM THAT REQUIRES REMOVING THE CAB. I PURCHASED THIS TRUCK NEW AND IT NOW HAS 39000 MILES ON IT. THIS IS A SERIOUS SAFETY CONCERN. *TR
Crash:
No
Fire:
No
Injuries:
0
Deaths:
0
#10595396June 1, 2014
SERVICE BRAKES
VEHICLE EXPERIENCED CATASTROPHIC BRAKE FAILURE WHILE MANEUVERING IN DRIVEWAY. REAR STEEL BRAKE LINE FAILED DUE TO INSTALLATION ERROR WHICH CAUSED IT TO WEAR THROUGH ON A FRAME MOUNTED FASTENER. I WAS UNDER THE IMPRESSION THAT VEHICLE BRAKING SYSTEMS WERE "2 CHANNEL" IN THAT IF A CATASTROPHIC FAILURE WAS EXPERIENCED THAT ONLY HALF OF THE SYSTEM WOULD BE AFFECTED. MY EXPERIENCE YESTERDAY HAS CAUSED MUCH CONCERN FOR OTHER OWNERS OF THIS TYPE OF VEHICLE. IN MY OPINION, ALL BRAKE LINES SHOULD BE MANUFACTURED FROM STAINLESS STEEL AS IT APPEARS THE FUEL LINES CURRENTLY ARE. I FEEL THIS IS A SERIOUS DEFICIENCY THAT SHOULD BE ADDRESSED. THANKFULLY, MY EXPERIENCE OCCURRED AT A SLOW RATE OF SPEED. IF IT HAD OCCURRED AT ROAD OR HIGHWAY SPEED, I MAY NOT HAVE BEEN ABLE TO FILE THIS COMPLAINT. *TR
Crash:
No
Fire:
No
Injuries:
0
Deaths:
0
#10592694May 20, 2014
ENGINE, ENGINE AND ENGINE COOLING
TL* THE CONTACT OWNS 2004 FORD F-250 SD. THE CONTACT STATED WHILE DRIVING HER VEHICLE WOULD SHAKE AND STALL. THERE WERE NO WARNING LIGHTS PRESENT HOWEVER, THE VEHICLE WAS TAKEN TO A DEALER WHERE THE TECHNICIAN DIAGNOSED THAT INJECTORS 3,5,6 AND 7, THE EXHAUST BACK PRESSURE SENSOR AND THE FAN CLUTCH NEEDED TO BE REPLACED. THE VEHICLE WAS NOT REPAIRED. THE MANUFACTURER WAS MADE AWARE OF THE FAILURE. THE FAILURE AND CURRENT MILEAGE WERE 144,788.
Crash:
No
Fire:
No
Injuries:
0
Deaths:
0
#10586466May 4, 2014
ENGINE
SPARK PLUG NUMBER 3 BLEW OUT OF THE ALUMINUM CYLINDER HEAD. *TR
Crash:
No
Fire:
No
Injuries:
0
Deaths:
0
#10579192April 11, 2014
ENGINE
TL* THE CONTACT OWNS A 2004 FORD F-250 SD. THE CONTACT STATED THAT WHILE DRIVING VARIOUS SPEEDS, THE VEHICLE JERKED VIOLENTLY. THE FAILURE OCCURRED INTERMITTENTLY WHEN THE VEHICLE WAS IDLING OR COMING TO A STOP. ADDITIONALLY, THE ENGINE STALLED BUT WAS ABLE TO RESTART SECONDS LATER. THE VEHICLE WAS TAKEN TO AN AUTHORIZED DEALER AND THEY WERE UNABLE TO LOCATE A PROBLEM. THE MANUFACTURER WAS NOTIFIED OF THE FAILURE. THE APPROXIMATE FAILURE MILEAGE WAS 80,000.
Crash:
No
Fire:
No
Injuries:
0
Deaths:
0
#10574666March 25, 2014
ELECTRICAL SYSTEM
TL* THE CONTACT OWNS A 2004 FORD F-250. THE CONTACT STATED THAT WHILE EXITING A DRIVEWAY, THE VEHICLE STALLED. THE VEHICLE WAS ABLE TO BE RESTARTED AFTER STALLING ON MORE THAN OCCASION. THE VEHICLE WAS TAKEN TO AN AUTHORIZED DEALER, WHO WAS UNABLE TO DIAGNOSE THE FAILURE. THE VEHICLE WAS THEN TAKEN TO AN INDEPENDENT MECHANIC, WHO ALSO WAS UNABLE TO DIAGNOSE THE FAILURE. THE VEHICLE WAS NOT REPAIRED. THE MANUFACTURER WAS NOT NOTIFIED OF THE FAILURE. THE APPROXIMATE FAILURE MILEAGE WAS 15000.
Crash:
No
Fire:
No
Injuries:
0
Deaths:
0
#10561561January 26, 2014
ELECTRICAL SYSTEM, ENGINE AND ENGINE COOLING
OUR 2004 F250 DIESEL 4X4 SUPER DUTY WAS PARKED IN THE DRIVEWAY OVERNIGHT, PROPERLY PLUGGED IN DUE TO THE COLD. A NEIGHBOR WOKE US UP TO STATE IT WAS ON FIRE. THE ENTIRE FRONT AND INTERIOR OF THE TRUCK WAS ENGULFED IN FLAMES BEFORE THE FIRE DEPARTMENT ARRIVED. AFTER IT WAS EXTINGUISHED, THE COUNTY FIREMAN POINTED THE BELIEVED THE POINT OF IGNITION APPEARED TO BE AT THE FIREWALL ON THE DRIVERS SIDE DUE TO THE FACT THAT THE MASTER BRAKE CYLINDER & BATTERY WERE DISINTEGRATED. PLUS THE SECONDARY BATTERY & RADIATOR WERE PARTIALLY INTACT WHICH ARE IN THE FRONT. THE FIRE DEPT STATED THAT IF IT HAD BEEN A FRONTAL POINT OF IGNITION DUE TO THE BLOCK HEATER THE RADIATOR & BATTERY ON FRONT PASSENGER SIDE WOULD'VE BURNED FIRST DUE TO ALUMINUM MATERIALS. *TR
Crash:
No
Fire:
Yes
Injuries:
0
Deaths:
0
#10557862December 30, 2013
STEERING, SUSPENSION
FRONT END SHAKES VIOLENTLY AFTER HITTING A ROUGH SPOT ON PAVEMENT AT HIGHWAY SPEED. CONTINUES UNTIL SPEED IS REDUCED TO LESS THAN 50 MPH. THERE ARE SEVERAL OTHER COMPLAINTS ON YOUR DATABASE FOR THE SAME PROBLEM, SO WHY ISN'T SOMETHING BEING DONE ABOUT IT? THIS IS A VERY SERIOUS ISSUE. MY WIFE WOULD NOT HAVE BEEN ABLE TO HANDLE THIS HAPPENING TO HER. THIS HAPPENED ONCE BEFORE ABOUT A YEAR AGO AND I HAD THE TRUCK CHECKED, BUT NOTHING COULD BE FOUND. EVEN THOUGH IT'S TEN YEARS OLD, TRUCK ONLY HAS A LITTLE OVER 24,000 MILES. *TR
Crash:
No
Fire:
No
Injuries:
0
Deaths:
0
#10550934November 5, 2013
FUEL/PROPULSION SYSTEM
TL* THE CONTACT OWNS A 2004 FORD F-250 SD. THE CONTACT STATED THAT WHILE DRIVING 65 MPH, THE CHECK ENGINE WARNING LAMP ILLUMINATED THEN THE VEHICLE STALLED. THE VEHICLE WAS MOVED TO THE SHOULDER WHERE THE CONTACT ATTEMPTED TO RESTART IT BUT TO NO AVAIL. THE VEHICLE WAS ABLE TO BE RESTARTED 30 MINUTES LATER. THE VEHICLE WAS PERSONALLY DIAGNOSED BY THE CONTACT WHO FOUND THAT THE FUEL INJECTION CONTROL MODULE HAD FAILED. THE VEHICLE WAS NOT REPAIRED. THE MANUFACTURER WAS NOTIFIED ABOUT THE ISSUE AND INFORMED THE CONTACT THAT THE VEHICLE WAS NOT INCLUDED IN NHTSA CAMPAIGN NUMBER 05V270000 (ELECTRICAL SYSTEM). THE APPROXIMATE FAILURE MILEAGE WAS 142,200.
Crash:
No
Fire:
No
Injuries:
0
Deaths:
0
#10548656October 21, 2013
TIRES, TIRES:TREAD/BELT
A MONTH AGO I HAD A BRIDGESTONE A/T REVO SEPARATE AND MANAGED TO GET IT REPLACED BEFORE IT BLEW. THIS PAST FRIDAY I WAS TOWING A TRAILER AND HAD ANOTHER SEPARATE AND BEFORE I COULD GET STOPPED IT BLEW OUT ALSO. FORTUNATELY IT WAS ON THE BACK AND I MANAGED TO GET THE TRUCK AND TRAILER STOPPED SAFELY. NOT SURE I COULD HAVE DONE THIS HAD IT BEEN ON THE FRONT. TIRES WERE AIRED PROPERLY THAT MORNING ALSO. RIPPED MY RIGHT REAR FENDER UP ALSO. TWO OF THE SAME TIRES PURCHASED AT THE SAME TIME SEPARATED WITHIN A MONTH OF EACH OTHER. *TR
Crash:
No
Fire:
No
Injuries:
0
Deaths:
0
#10544941September 23, 2013
ENGINE
WHILE ON A RECENT TRIP PULLING OUR 5TH WHEEL TRAVEL TRAILER WE NOTICED ON SEVERAL OCCASIONS THE SMELL OF ANTI-FREEZE WHILE UNDER ACCELERATION(UP HILLS, HIGHWAY MERGING). ONCE AT THE CAMPGROUND WE MADE A VISUAL CHECK FOR ANY LEAKS AND NONE WERE FOUND, BUT THE COOLANT RESERVOIR WAS AT THE MIN MARK. I FILLED TO MAX. ON THE RETURN TRIP SAME THING HAPPENED. ONCE HOME I CHECKED FOR LEAKS AND NONE WERE FOUND BUT COOLANT WAS BACK TO MIN MARK. AT NO TIME DURING THE TRIP DID THE TRUCK OVERHEAT OR RUN ANY DIFFERENTLY THAN NORMAL. I MADE AN APPOINTMENT AT OUR LOCAL FORD DEALERSHIP AND AFTER THEY INSPECTED I WAS TOLD THAT THE TURBO HAD GONE SOUTH CAUSING AN OVER BOOST CONDITION THAT THEN ENTERED INTO THE COMBUSTION CHAMBER AND CAUSED THE HEAD GASKETS TO FAIL. THEN I WAS TOLD THAT AS THE HEAD GASKETS HAD FAILED PRESSURE FROM THE COMBUSTION CHAMBER HAD ENTERED INTO THE COOLANT SYSTEM BOOSTING PRESSURE BEYOND WHAT THE PRESSURE RELIEF CAP WAS RATED FOR ON THE DEGAS(OVER FLOW) BOTTLE AND SPEWED ANTI FREEZE OUT OF THE BOTTLE, WHICH IS WHAT WE WERE SMELLING. THE COST FOR REPAIRS AND PARTS ARE ESTIMATED AT 7,000.00 DOLLARS FOR A TRUCK THAT HAS LITTLE OVER 58,000 MILES ON IT. A CALL TO FORD CUSTOMER SERVICE(CHRIS) AND A FOLLOW UP CALL FROM HIS SUPERVISOR AT MY REQUEST, HAS NETTED US NOTHING AS FORDS STANCE ON THIS IS "THERE IS NOTHING THAT FORD WILL OR CAN DO". AFTER SOME RESEARCH I SEE THAT I AM NOT THE ONLY CONSUMER BEING ASKED TO BEAR THE BRUNT OF FORDS MISTAKES. APPARENTLY EVERY ITEM THAT I WAS TOLD THAT NEEDED TO BE REPLACED IS A PART THAT A MULTITUDE OF CONSUMERS ARE HAVING ISSUES WITH. THIS IS UNACCEPTABLE. THEY KNOW THEY HAVE AN ISSUE YET THEY DO NOTHING, AND NO ONE IS HOLDING THEM ACCOUNTABLE. IF I WANTED TO SELL MY TRUCK AFTER IT IS REPAIRED I'D BE LUCKY TO RECOUP ANYTHING AS THIS ISSUE HAS GROWN SO LARGE THAT EVERYONE IS SELLING AND THE VALUE HAS DROPPED.
Crash:
No
Fire:
No
Injuries:
0
Deaths:
0
#10544959September 23, 2013
ENGINE
TL* THE CONTACT OWNS A 2004 FORD F-250 TDI. THE CONTACT STATED THAT WHILE DRIVING 55 MPH, WHITE SMOKE STARTED TO EMIT OUT OF THE EXHAUST PIPE. THE VEHICLE WAS TAKEN TO THE DEALER. THE TECHNICIAN DIAGNOSED THAT THE VEHICLE HAD BLOWN A HEAD GASKET. AS A RESULT, THE COOLER, EGR, AND HEAD GASKET NEEDED TO BE REPLACED. THE MANUFACTURER WAS MADE AWARE OF THE FAILURE. THE VEHICLE WAS REPAIRED. THE FAILURE MILEAGE WAS 75,961 AND THE CURRENT MILEAGE WAS 76,000. UPDATED 11/19/13*CN UPDATED 12/2/2013 *JS
Crash:
No
Fire:
No
Injuries:
0
Deaths:
0
#10543979September 17, 2013
FUEL/PROPULSION SYSTEM
TL* THE CONTACT OWNS A 2004 FORD F-250 TDI. THE CONTACT STATED THAT WHILE DRIVING 10 MPH UPHILL AND TOWING A BOAT, THE VEHICLE STALLED WITHOUT WARNING. THE VEHICLE WAS TAKEN TO THE DEALER. THE TECHNICIAN WAS UNABLE TO DIAGNOSE THE FAILURE BUT STATED THAT HE FOUND PERMATEX GASKET MATERIAL IN THE FUEL SYSTEM, CAUSING THE INJECTOR O-RING TO BLOW. THE MANUFACTURER WAS NOT MADE AWARE OF THE FAILURE. THE VEHICLE WAS NOT REPAIRED. THE FAILURE MILEAGE WAS 140,000 AND THE CURRENT MILEAGE WAS 1637,000.
Crash:
No
Fire:
No
Injuries:
0
Deaths:
0
#10524540July 12, 2013
ENGINE
TL* THE CONTACT OWNS A 2004 FORD F-250 SD. THE CONTACT STATED THAT WHILE DRIVING IN REVERSE AT APPROXIMATELY 2 MPH, SMOKE EMITTED FROM UNDER THE HOOD. THE ENGINE WAS TURNED OFF AND THE DRIVER INSPECTED UNDER THE HOOD AREA, WHERE HE NOTICED OIL SPRAYING OUT OF THE DIP STICK TUBE. A LARGE AMOUNT OF SMOKE WAS PRESENT HOWEVER, A FIRE DID NOT ERUPT. THE CONTACT PLANNED TO TAKE THE VEHICLE TO THE DEALER FOR DIAGNOSIS. THE MANUFACTURER WAS NOTIFIED OF THE DEFECT. THE APPROXIMATE FAILURE MILEAGE WAS 58,000. UPDATED 9/12/13*CN THE DIP STICK TUBE WAS COMPLETELY RUSTED. UPDATED 10/22/13
Crash:
No
Fire:
No
Injuries:
0
Deaths:
0
#10523485July 6, 2013
ENGINE, POWER TRAIN
FORD F SERIES AND SUPER DUTY PICKUPS WITH 5.4 ENGINES. MY 2004 FORD F-250 HAS AN ISSUE WITH LEAKING EXHAUST MANIFOLDS. WHEN LOOKING INTO THIS FURTHER WHILE GETTING PRICING, I FOUND OUT THAT THIS WAS NOT AN ISOLATED ISSUE AND THAT IT WAS A COMMON OCCURRENCE DUE TO A MISTAKE IN MATERIAL USED FOR THE EXHAUST MANIFOLD BOLTS. SO COMMON THAT AFTERMARKET SUPPLIERS ARE MAKING REPLACEMENT KITS FOR THE PROBLEM. THE EXHAUST MANIFOLD ATTACHING STUDS WERE MADE OUT OF A METAL THAT QUICKLY RUSTS OUT CAUSING THE FAILURE. AFTER THE FAILURE, I BEGAN TO NOTICE EXHAUST GASES ENTERING THE CAB OF THE VEHICLE THROUGH THE CLIMATE CONTROL, WHICH ITS FRESH AIR INTAKE IS IN THE GENERAL DIRECTION OF THE EXHAUST MANIFOLD. I ALSO QUESTION THE EMISSIONS STANDARDS BECAUSE OF THE EXHAUST LEAK NOT TO MENTION THE POTENTIAL FIRE RISK FROM HEATED GASES AND FLAMES ENTERING THE ENGINE COMPARTMENT. *TR
Crash:
No
Fire:
No
Injuries:
0
Deaths:
0
#10522838July 2, 2013
ENGINE
TL* THE CONTACT OWNS A 2004 FORD F-20. THE CONTACT STATED THAT THERE WAS A RECURRING FAILURE WITH THE EGR VALVE COOLER. THE TURBO ENGINE ALSO FAILED AND AS A RESULT, CAUSED DAMAGE TO THE ENGINE HEADS WHICH RESULTED IN A STALLING FAILURE. IN ADDITION, THE FUEL LEVEL GAUGE WOULD NOT PROVIDE ACCURATE FUEL LEVEL READINGS. THE FAILURE WAS REPORTED TO THE MANUFACTURER. THE VEHICLE WAS NOT REPAIRED. THE FAILURE MILEAGE WAS 1,500 AND THE CURRENT MILEAGE WAS 43,322. *TR
Crash:
No
Fire:
No
Injuries:
0
Deaths:
0
#10522716July 1, 2013
TIRES, TIRES:SIDEWALL
SUBJECT: DEVELOP A NOTICEABLE BLISTER ON THE SIDEWALL, WHICH MAY EVENTUALLY RESULT IN TIRE AIR PRESSURE LOSS ALL 4 KUMHO ROAD VENTURE AT-KL78 HAVE LARGE BLISTERS ON SIDE WALLS. YOU CAN PUSH THE BLISTERS IN WITH YOUR FINGERS. THEY LOOK TO BE READY TO POP. I CHECKED THE RECALL LIST AND FIND THE LATEST TIRE RECALLS FROM THE NATIONAL HIGHWAY TRAFFIC SAFETY ADMINISTRATION AND MY TIRES ARE PART OF THE RECALL. I DID NOT RECEIVE ANY NOTIFICATION AND WOULD ASK FOR YOU TO SEND ME A RECALL REPLACEMENT AUTHORIZATION FOR MY TIRES. *TR
Crash:
No
Fire:
No
Injuries:
0
Deaths:
0
#10522247June 28, 2013
SERVICE BRAKES, STRUCTURE:BODY
TL* THE CONTACT OWNS A 2004 FORD F-250. THE CONTACT STATED THAT THE BRAKES FAILED. AFTER INSPECTING THE VEHICLE, THE CONTACT DISCOVERED THAT THE FRAME RAIL AND UNDERCARRIAGE WERE COMPLETELY RUSTED. IN ADDITION, THE EXHAUST MANIFOLD WAS CORRODED AND THERE WERE FUMES ENTERING THE CABIN OF THE VEHICLE. THE REAR PLATES FOR THE PARKING AND EMERGENCY BRAKES WERE ALSO COMPLETELY RUSTED. THE VEHICLE WAS NOT TAKEN TO THE DEALER FOR INSPECTION OR REPAIRS. THE MANUFACTURE WAS MADE AWARE OF THE FAILURE. THERE WERE NO RECALLS FOR THE VEHICLE. THE FAILURE AND THE CURRENT MILEAGE WAS 59,000. *TR
Crash:
No
Fire:
No
Injuries:
0
Deaths:
0
#10520534June 18, 2013
TIRES
YOKOHAMA GEOLANDER A/T-S LT315/75R16 CRACKING AND SEPARATION OF TIRE TREAD AROUND ENTIRE CIRCUMFERENCE OF TIRES. ALL 4 TIRES PURCHASED 6/7/07 HAD 50% TREADWEAR AND 52K MILES. THESE WERE NOT DRY ROT CRACKS. YOKOHAMA CREATED CASE# AND ISSUED A 50% CREDIT TOWARDS 4 NEW TIRES AT DISCOUNT TIRE. I HAVE PICTURES OF THE DAMAGED TIRES. *TR
Crash:
No
Fire:
No
Injuries:
0
Deaths:
0

← Back to Ford F-250