Ford F-250 Complaints (2003)

294 consumer complaints on file.

#10513728May 28, 2013
STEERING, SUSPENSION
TL* THE CONTACT OWNS A 2003 FORD F-250 SD. THE CONTACT STATED THAT WHILE DRIVING 70 MPH, THE VEHICLE SHOOK VIOLENTLY. THE VEHICLE WAS TAKEN TO AN INDEPENDENT MECHANIC WHO WAS UNABLE TO DIAGNOSE THE FAILURE. THE MANUFACTURER WAS NOT MADE AWARE OF THE FAILURE. THE VEHICLE WAS NOT REPAIRED. THE VIN WAS NOT AVAILABLE. THE FAILURE MILEAGE WAS 170,000 AND THE CURRENT MILEAGE WAS 228,000. *TR
Crash:
No
Fire:
No
Injuries:
0
Deaths:
0
#10508448April 16, 2013
TIRES, TIRES:TREAD/BELT
TIRE TREAD CAME OFF THE TIRE AT THE STEEL BELTS. *TR
Crash:
No
Fire:
No
Injuries:
0
Deaths:
0
#10502810March 14, 2013
ENGINE
#5 SPARKPLUG SHOT OUT OF THE HEAD WHEN STARTING VEHICLE. *TR
Crash:
No
Fire:
No
Injuries:
0
Deaths:
0
#10482692October 31, 2012
FUEL/PROPULSION SYSTEM
TL* THE CONTACT OWNS A 2003 FORD F250 SD. THE CONTACT STATED THAT WHILE DRIVING UP AN INCLINE APPROXIMATELY 45 MPH, THERE WAS A SUDDEN REDUCTION IN THE ENGINE POWER AND THEN STALLED. THE VEHICLE RESTARTED AFTER NUMEROUS ATTEMPTS. A CHEMICAL BURNING ODOR EMITTED OUTSIDE OF THE VEHICLE. THE FAILURE OCCURRED SPORADICALLY AND WHENEVER THE FUEL TANK LEVEL REGISTERED QUARTER OF A TANK. THE VEHICLE WAS TAKEN TO AN INDEPENDENT MECHANIC WHO STATED THE FUEL TANK LINING WAS SEVERELY DAMAGED AND THE FUEL TANK NEEDED TO BE REPLACED. THE VEHICLE HAD NOT BEEN REPAIRED. THE MANUFACTURER WAS NOT NOTIFIED OF THE PROBLEM. THE APPROXIMATE FAILURE MILEAGE WAS 140,000.
Crash:
No
Fire:
Yes
Injuries:
0
Deaths:
0
#10480130October 15, 2012
FUEL/PROPULSION SYSTEM
TL* THE CONTACT OWNS A 2003 FORD F-250 SD. THE CONTACT STATED THAT WHILE PERFORMING AN OIL CHANGE, HE NOTICED THAT THE FRAME WAS RUSTED SEVERELY.THE CONTACT PERFORMED A THOROUGH INSPECTION OF THE VEHICLE AND ALSO DISCOVERED THAT THE FUEL TANK STRAPS WERE SEVERELY RUSTED. THE FRONT STRAP WAS COMPLETELY DETACHED FROM THE VEHICLE AND THE SECOND STRAP WAS PARTIALLY HANGING FROM THE VEHICLE. THE MANUFACTURER WAS CONTACTED AND ADVISED HIM THAT THE VEHICLE WAS NOT INCLUDED IN NHTSA CAMPAIGN ID NUMBER 11V385000 (FUEL SYSTEM, GASOLINE:STORAGE:TANK ASSEMBLY:MOUNTING). THE VEHICLE WAS NOT REPAIRED. THE FAILURE AND CURRENT MILEAGES WERE APPROXIMATELY 125,000.
Crash:
No
Fire:
No
Injuries:
0
Deaths:
0
#10477054September 25, 2012
POWER TRAIN
TL* THE CONTACT OWNS A 2003 FORD F250 SD. THE CONTACT STATED THAT WHILE DRIVING 35 MPH, THE CLUTCH FAILED. UPON FURTHER INSPECTION THE CONTACT NOTICED THAT THE PLASTIC BUSHING HAD FAILED AND THE ROD WAS DETACHED FROM THE CLUTCH. THE CONTACT WENT TO THE DEALER, PURCHASED A NEW BUSHING AND REPAIRED THE VEHICLE HIMSELF. THE RECENT FAILURE WAS THE SECOND CLUTCH FAILURE ON THE VEHICLE. THE VEHICLE WAS REPAIRED. THE FAILURE AND CURRENT MILEAGES WERE 58,000. UPDATED 10/24/12 *CN UPDATED 11/9/2012 *JS
Crash:
No
Fire:
No
Injuries:
0
Deaths:
0
#10464732July 9, 2012
TIRES
TL* THE CONTACT OWNS A 2003 FORD F-250 EQUIPPED WITH DEFINITY TIRES A/T 33 12.5R 16.5. THE CONTACT WAS TRAVELING 65 MPH WHEN THE FRONT PASSENGER SIDE TIRE BLEW OUT. THE FAILURE CAUSED THE FRONT PASSENGER TO RECEIVE INJURIES TO HIS LOWER BACK. THE VEHICLE WAS TOWED A REPAIR SHOP. THE MANUFACTURER WAS CONTACTED. THE VEHICLE WAS REPAIRED AND THE VIN WAS UNKNOWN. THE FAILURE AND CURRENT MILEAGES WERE 144,000. ....UPDATED 08-24-12 *BF THE CONSUMER STATED THE FIRST INCIDENT HAPPENED IN APRIL 2011. IN BOTH CASES, THE TREAD PEELED AWAY FROM THE TIRE. UPDATED 08/29/12
Crash:
No
Fire:
No
Injuries:
1
Deaths:
0
#10461299June 12, 2012
TIRES, TIRES:TREAD/BELT
ON FRIDAY, JUNE 8TH 2012, ON MY 2003 FORD F250, THE FRONT LEFT (DRIVERS SIDE) TIRE TREAD SEPARATED FROM THE REST OF THE TIRE AND CAUSED EXTENSIVE DAMAGE TO MY VEHICLE. THE TIRE IS A DICK CEPEK FUN COUNTRY 2 PURCHASED IN JULY 2007. AT THE TIME OF THE ACCIDENT, THE TIRE HAD 60,000 MILES ON IT AND WAS PROPERLY INFLATED, THERE WAS ADEQUATE TREAD ON IT. MY 15 1/2 YEAR OLD SON, WHO HAS HIS PERMIT, WAS DRIVING AT THE TIME IN HEAVY TRAFFIC, BUT WAS ABLE TO CONTROL THE VEHICLE ENOUGH TO AVOID AN ACCIDENT AND REMOVE THE TRUCK FROM THE ROADWAY; WE WERE TRAVELING AT 50 MPH AT THE TIME. THE TIRE SIZE IS 315/75/16. *TR
Crash:
No
Fire:
No
Injuries:
0
Deaths:
0
#10460796June 6, 2012
FUEL/PROPULSION SYSTEM
TL* THE CONTACT OWNS A 2003 FORD F-250 SUPER DUTY. THE CONTACT WAS TRAVELING 80 MPH WHEN THE SMELL OF FUEL EMITTED FROM THE VEHICLE. THE VEHICLE WAS TAKEN TO A PRIVATE MECHANIC. THE MECHANIC CONFIRMED THAT THE STEEL FUEL LINE WAS CORRODED AND NEEDED TO BE REPLACED. THE MANUFACTURER WAS NOT CONTACTED. THE VEHICLE WAS NOT REPAIRED. THE FAILURE MILEAGE WAS 62,400 AND THE CURRENT MILEAGE WAS 70,780.
Crash:
No
Fire:
No
Injuries:
0
Deaths:
0
#10457351May 3, 2012
STEERING
TL* THE CONTACT OWNS A 2003 FORD F-250 SD. THE CONTACT STATED THE STEERING WHEEL WAS LOOSE WHILE DRIVING. THE FAILURE MADE IT VERY DIFFICULT TO CONTROL THE VEHICLE, ESPECIALLY WHEN MAKING A LEFT OR RIGHT TURN. THE DEALER ADVISED THE CONTACT THAT THE FAILURE WAS CAUSED BY THE PITMAN ARM. THE DEALER ALSO STATED THERE WAS A TECHNICAL SERVICE BULLETIN (16515) FOR THE PITMAN ARM AND THERE WAS NO RECALL. THE VIN WAS NOT AVAILABLE. THE FAILURE MILEAGE WAS 85,000 AND THE CURRENT MILEAGE WAS 87,000.
Crash:
No
Fire:
No
Injuries:
0
Deaths:
0
#10448051February 15, 2012
ELECTRICAL SYSTEM
TRUCK COUNT FIRE WHILE NOT IN USE. FIRE UNDER HOOD ON THE DRIVERS SIDE OF THE TRUCK. *TR
Crash:
No
Fire:
Yes
Injuries:
0
Deaths:
0
#10437474November 28, 2011
STRUCTURE:BODY, POWER TRAIN:AUTOMATIC TRANSMISSION
VEHICLE HAS 7.3 LITER DIESEL ENGINE AND THE FORD 4R100 AUTOMATIC TRANSMISSION AND 4 WHEEL DRIVE. TRANSMISSION FAILED AT ABOUT 88,000 MILES DESPITE PROPER SERVICING SINCE NEW. IT WOULD INTERMITTENTLY STOP SHIFTING IN NORMAL USE AND BEGAN TO SLIP BADLY. ONLY SECOND GEAR WAS STILL WORKING WHEN I GOT IT TO THE DEALER THE NEXT DAY. THE TRANSMISSION WAS REPLACED AT MY EXPENSE ($3500+). THE REPLACEMENT TRANSMISSION FAILED IN A SIMILAR WAY AT ABOUT 135,000 MILES DESPITE BEING SERVICED AS REQUIRED BY THE DEALER. THEY ARE UNABLE TO OBTAIN A VALVE BODY FOR THIS TROUBLESOME ASSEMBLY AND IT HAS BEEN AT THE DEALER FOR NEARLY TWO WEEKS. THIS MODEL OF TRANSMISSION IS DEFECTIVE AND DANGEROUS ESPECIALLY IF YOU ARE TOWING AND LOSE ENGINE BRAKING DUE TO THE TRANSMISSION FAILING. FORD NO LONGER USES THIS TRANSMISSION AS IT HAS A HIGH FAILURE RATE. THE BODY HAS RUSTED THROUGH AT ONE OF THE CAB CORNERS AND OVER BOTH REAR WHEEL WELLS. FORD REPAIRED THE RUST THROUGH ONCE UNDER WARRANTY BUT THE RUST THROUGHS CONTINUE AND HAVE A NEGATIVE EFFECT ON THE INTEGRITY OF THE VEHICLE STRUCTURE AND PROTECTION OF IT'S OCCUPANTS IN THE EVENT OF A CRASH. A RUSTED BODY WOULD NOT PROTECT OCCUPANTS AS WELL AS AN AN UNRUSTED ONE. *KB
Crash:
No
Fire:
No
Injuries:
0
Deaths:
0
#10429022October 6, 2011
SERVICE BRAKES, HYDRAULIC
THE REAR BRAKE LINES HAVE RUSTED OUT ON MY 2003 FORD F250 - WE RECEIVED A LETTER FROM THE NTSB ASKING IF OUR BRAKE LINES HAD RUSTED OUT - THEY JUST DID LAST NIGHT AND ALMOST CAUSED AN ACCIDENT. THIS IS INCREDIBLE THAT A 7 1/2 YEAR OLD VEHICLE LOST IT'S BRAKES ALREADY. *TR
Crash:
No
Fire:
No
Injuries:
0
Deaths:
0
#10426597September 21, 2011
TIRES
TL* THE CONTACT OWNS A 2003 FORD F250 SD WITH BIG O BIG FOOT HT TIRES, SIZE LT265/75R16, DOT NUMBER: UPW8T264005. THE CONTACT WAS DRIVING 65 MPH WHEN THE VEHICLE STARTED SHAKING ABNORMALLY. THE DEALER ADVISED THAT THREE OF THE TIRES EXHIBITED TREAD SEPARATION AND NEEDED TO BE REPLACED. THE TIRES WERE REPLACED. THE MANUFACTURER WAS NOT NOTIFIED OF THE FAILURE. THE FAILURE MILEAGE OF THE TIRE WAS 948. THE VEHICLE FAILURE MILEAGE WAS 50,988. UPDATED 10/04/11*BF
Crash:
No
Fire:
No
Injuries:
0
Deaths:
0
#10426620September 21, 2011
ELECTRICAL SYSTEM
TL* THE CONTACT OWNS A 2003 FORD F-250. WHILE DRIVING APPROXIMATELY 70 MPH, THE VEHICLE STALLED. THE VEHICLE WAS TOWED TO THE DEALER FOR DIAGNOSTICS WHERE THE TECHNICIAN STATED THAT THE WIRING HARNESS HAD BECOME EXPOSED, CAUSING A SHORT AND BLOWING THE ENGINE FUSE. THE TECHNICIAN ADVISED THAT THE WIRES WOULD HAVE TO BE REPLACED. THE VEHICLE WAS NOT REPAIRED. THE VIN WAS NOT AVAILABLE. THE APPROXIMATE FAILURE MILEAGE WAS 120,000.
Crash:
No
Fire:
No
Injuries:
0
Deaths:
0
#10426540September 20, 2011
ELECTRICAL SYSTEM, POWER TRAIN
TRUCK BEGAN BLOWING FUSE #45, RESULTING IN A LOSS OF INSTRUMENTS AND NO THROTTLE ACTIVATION AVAILABLE. SEEMS TO OCCUR MOST OFTEN WHEN TURNING LEFT, AND/OR WHEN SHIFTING FROM PARK OR REVERSE INTO DRIVE, OR DRIVE INTO REVERSE OR PARK. HAS RESULTED IN A LOSS OF POWER IN ALL OF THE ABOVE SITUATIONS, WITH THE ENGINE ONLY IDLING. IF THIS OCCURS WHILE HEADING UPHILL, VEHICLE WILL NOT MOVE. INTERNET SEARCH REVEALS THIS SEEMS TO BE A FAIRLY COMMON PROBLEM, AND IS DUE TO INSULATION BEING RUBBED OFF PART OF THE WIRING HARNESS THAT RUNS THROUGH THE STEERING COLUMN. SAME RESEARCH INDICATES FORD CHANGED THE ROUTING OF THE WIRING HARNESS IN LATE 2003. I BELIEVE THIS SITUATION SHOULD BE REPAIRED FREE OF CHARGE BY FORD. *TR
Crash:
No
Fire:
No
Injuries:
0
Deaths:
0
#10425995September 19, 2011
ENGINE AND ENGINE COOLING
TL* THE CONTACT OWNS A 2003 FORD F-250 SUPERDUTY. THE CONTACT WAS DRIVING 40 MPH WHEN THE VEHICLE STALLED AND FAILED TO RESTART. THE VEHICLE WAS TOWED TO THE DEALER BUT WAS NOT REPAIRED. THE MANUFACTURER WAS NOT MADE AWARE OF THE FAILURE. THE VEHICLE WAS NOT REPAIRED. THE FAILURE AND CURRENT MILEAGES WERE 108,000.
Crash:
No
Fire:
No
Injuries:
0
Deaths:
0
#10424752September 12, 2011
ENGINE AND ENGINE COOLING
TL* THE CONTACT OWNS A 2003 FORD F-250. WHILE DRIVING 55 MPH, THE CONTACT HEARD A LOUD THUMP AND BEGAN TO SMELL GASOLINE FUMES ENTERING THE VEHICLE. THE VEHICLE WAS TAKEN TO A PRIVATE MECHANIC WHO DIAGNOSED THE VEHICLE WITH A BLOWN SPARK PLUG. THE DEALER WAS UNAWARE OF THE FAILURE AND ADVISED HIM TO BRING THE VEHICLE IN FOR DIAGNOSTIC TESTING. THE MANUFACTURER WAS AWARE OF THE FAILURE. NO REPAIRS WERE PERFORMED. THE CURRENT AND FAILURE MILEAGES WERE 75,000.
Crash:
No
Fire:
No
Injuries:
0
Deaths:
0
#10415022July 25, 2011
TIRES:TREAD/BELT
TL* THE CONTACT OWNS A 2003 FORD F-250 EQUIPPED WITH COOPER DISCOVERER ATR (LT265/75/R16 DOT3DW8) TIRES. WHILE DRIVING APPROXIMATELY 50 MPH THE CONTACT NOTICED THE STEERING WHEEL WAS FEELING AWKWARD. THE CONTACT STOPPED THE VEHICLE ON THE SHOULDER OF THE ROAD AND NOTICED THE TREAD SEPARATION ON THE FRONT DRIVER AND PASSENGER SIDE TIRES. THE VEHICLE WAS TAKEN TO A TIRE SHOP WHERE THE TECHNICIANS STATED THE TIRE NEEDED TO BE REPLACED DUE TO TREAD SEPARATION. THE FRONT DRIVER AND PASSENGER SIDE TIRES WERE REPLACED. THE TREAD ON THE REAR DRIVER AND PASSENGERS SIDE TIRES ALSO SEPARATED CAUSING DAMAGE TO THE WHEEL WELL AND FENDER. THE REAR TIRES WERE NOT REPLACED. THE VEHICLE WAS NOT REPAIRED. THE VIN WAS NOT AVAILABLE. THE APPROXIMATE FAILURE MILEAGE WAS 60,000. UPDATED 8/29/11 *CN THE CONSUMER STATED THE OTHER THREE TIRES WERE INSPECTED AND FOUND TO BE OK. ABOUT THREE MONTHS LATER, THE DRIVER REAR TIRE SEPARATED CAUSING $3,000 DAMAGE TO THE TRUCK. THE CONSUMER IS USING THE SPARE TIRE AND WAITING FOR A DECISION FROM COOPER TIRES. UPDATED 09/21/11
Crash:
No
Fire:
No
Injuries:
0
Deaths:
0
#10410853July 7, 2011
STRUCTURE
TL* THE CONTACT OWNS A 2003 FORD F-250. THE CONTACT STATED THE SEAM THAT HOLDS THE ROOF IN PLACE FRACTURED FROM THE FRONT OF THE VEHICLE TO THE REAR. THE VEHICLE WAS INSPECTED BY A DEALER WHO ADVISED HIM THAT THEY WERE AWARE OF THE FAILURE AND THAT HE WOULD NEED TO HAVE THE SEAL GRIND OUT AND REPLACED. THE VEHICLE WAS NOT REPAIRED. THE MANUFACTURER WAS NOTIFIED AND OFFERED NO ASSISTANCE. THE FAILURE MILEAGE WAS APPROXIMATELY 90,000. IN 2 HOURS I LOCATED 12 ADDITIONAL FORD VEHICLES AT DEALERSHIPS WITH THE SAME PROBLEM. 2006 AND OLDER VEHICLES INCLUDING MY OWN 2005 FREESTAR. I BELIEVE IF INVOLVED IN AN ACCIDENT THE ROOF WILL DISLODGE CAUSING THE OCCUPANTS TO BE EJECTED. THE MANUFACTURE WAS CONTACTED THEY ARE AWARE AND REFUSED TO ASSIST. UPDATED 10/18/2011 *LN *TR
Crash:
No
Fire:
No
Injuries:
0
Deaths:
0

← Back to Ford F-250