Ford F-250 Complaints (2006)

495 consumer complaints on file.

#10341495July 5, 2010
SERVICE BRAKES, HYDRAULIC
DROVE HOME FROM THE STORE ABOUT 10 MILES RIGHT REAR BRAKE CALIPER FAILED AND SEIZED. WHEN WE GOT HOME SMOKE WAS POURING OUT FROM UNDER THE TRUCK, WHEN WE DISCOVERED IT. BURNED THE PAINT OFF THE BRAKE DUST SHIELD. FORD DEALER SAID IT WAS A DEFECTIVE CALIPER BUT I HAVE TO PAY $750.00? THAT'S NOT RIGHT. AND THEY TELL ME IT HAS HAPPENED TO OTHER FORD TRUCKS? *TR
Crash:
No
Fire:
Yes
Injuries:
0
Deaths:
0
#10340374June 28, 2010
ENGINE AND ENGINE COOLING
TL* THE CONTACT OWNS A 2006 FORD F-250 SUPER DUTY. THE CONTACT STATED THAT SHE HAS BEEN EXPERIENCING RECURRING ENGINE FAILURES IN WHICH THE VEHICLE WILL SPUTTER AND EMIT THICK, WHITE EXHAUST FUMES. IN ADDITION, THE VEHICLE WOULD NO LONGER START. THE CONTACT HAS CLEANED THE EGR VALVES NUMEROUS TIMES BUT TO NO AVAIL. THE DEALER ADVISED REPLACING THE ENGINE. THE VEHICLE WAS NOT REPAIRED. THE FAILURE MILEAGE WAS 200,000 AND THE CURRENT MILEAGE WAS 215,000.
Crash:
No
Fire:
No
Injuries:
0
Deaths:
0
#10339837June 24, 2010
ELECTRICAL SYSTEM
TL* THE CONTACT OWNS A 2006 FORD F250. THE VEHICLE WAS SITTING IDLE WHEN THE CONTACT WENT TO START THE ENGINE. THE GEAR SHIFTER OPENING ERUPTED INTO FLAMES AND SMOKE. THE CONTACT REMOVED THE KEY FROM THE IGNITION AND WAS ABLE TO EXTINGUISH THE SMALL FIRE. A TOW TRUCK COMPANY ARRIVED TO TOW THE VEHICLE AND THE FAILURE RECURRED. THE FIRE WAS EXTINGUISHED A SECOND TIME AND THE VEHICLE WAS TOWED TO THE DEALER. THE DEALER ADVISED THE FAILURE WAS AN ELECTRICAL FAILURE. THE VEHICLE WAS LEFT WITH THE DEALER WHERE THE CONTACT WAS AWAITING UNKNOWN REPAIRS. THE FAILURE AND CURRENT MILEAGES WERE 75,550.
Crash:
No
Fire:
Yes
Injuries:
0
Deaths:
0
#10339848June 24, 2010
POWER TRAIN
TL* THE CONTACT OWNS A 2006 FORD F-250. THE CONTACT STATED WHEN DRIVING OVER AN UNEVEN ROAD SURFACE AT SPEEDS LESS THAN 70 MPH, THE FRONT END WOULD WOBBLE ABNORMALLY. THE DEALER REPLACED THE TRANSMISSION SHIFT AND INSTALLED A DAMPER ON THE FRONT END OF THE VEHICLE. THE FAILURE RECURRED WITHIN FOUR MONTHS. THE VEHICLE WAS NOT DIAGNOSED OR FURTHER REPAIRED. THE FAILURE MILEAGE WAS 17,000 AND THE CURRENT MILEAGE WAS 47,000.
Crash:
No
Fire:
No
Injuries:
0
Deaths:
0
#10336815June 17, 2010
SUSPENSION:FRONT:STABILIZER BAR
TL* THE CONTACT OWNS A 2006 FORD F-250 SUPER DUTY. THE CONTACT STATED THERE WAS A FAILURE IN THE FRONT SUSPENSION STABILIZER. THE DEALER REPLACED THE SINGLE STABILIZER WITH A DUAL STABILIZER BUT THE VEHICLE WOULD NOT PASS STATE INSPECTION. THE MANUFACTURER WOULD NOT PROVIDE ANY ASSISTANCE. THE VEHICLE WAS NOT REPAIRED. THE CURRENT MILEAGE WAS 98,212 AND THE FAILURE MILEAGE WAS 600. UPDATED 10/27/10. *LJ
Crash:
No
Fire:
No
Injuries:
0
Deaths:
0
#10333888May 30, 2010
TRACTION CONTROL SYSTEM, SERVICE BRAKES, HYDRAULIC
I OWN A FORD SUPER DUTY F 250 2006 WAS BOUGHT 03-18-10 .APROX 2 1/2 MONTHS THE TRUCK VIOLENTLY SHAKES AND LOSES CONTROL WHEN HITTING THE SMALLEST BUMP IF EXCEEDING 45 KLM OUR HIGHER. IF YOU APPLY YOUR BRAKES WHILE THIS HAPPENS THE BACK END WILL 360 THIS IS A DEATH TRAP. THIS HAS HAPPENED ABOUT 15 TIMES BUT IT COULD OF BEEN MORE I ONLY DRIVE VERY SLOW AND IN THE SLOW LANE SO IF IT HAPPENS I CAN PULL OVER. I HAVE HAD EVERYTHING REPAIRED ON THIS TRUCK I REPLACED ALL THE HEAVY DUTY SHOCKS THE TIE RODS THE STEERING DAMPER THE ALIGNMENT THE PRESSURE IN MY TIRES AND EVEN THE BRAKES, AT FIRST I THOUGHT THE GARAGE JUST WANTED MY MONEY BUT ONCE SEARCHING ON THE INTERNET I FOUND MANY OTHERS WITH THE EXACT SAME PROBLEMS NO ONE HAS FOUND A SOLUTION TO THE PROBLEMS AND MY OWN MECHANIC SAYS HE HAS EXHAUSTED ALL AVENUES WITH THIS TRUCK. MY BIGGEST FEAR IS SOMEONE WILL HAVE TO DIE TO MAKE FORD UNDERSTAND THERE IS A DEFECT WITH THIS TRUCK AND I DON'T WANT IT TO BE ME. I HAVE NOT DRIVEN THIS TRUCK IN THE WINTER AS OF YET AND CAN TELL YOU WITH EXPERIENCE IF THE TRUCK SHAKES VIOLENTLY AND I HAVE A HAD A TOUGH TIME CONTROLLING IT IN THE SUMMER IMAGINE THE WINTER. SOMEONE NEEDS TO TAKE THIS SERIOUS. JUST TELL ME HOW TO FIX IT AT LEAST I CAN MAKE IT SAFE. *TR
Crash:
No
Fire:
No
Injuries:
0
Deaths:
0
#10332479May 27, 2010
ENGINE AND ENGINE COOLING
DURING REPLACEMENT OF SPARKPLUGS IN A 2006 FORD F-250, 5 PLUGS HAD TO BE BORED OUT DUE THE PLUGS DISINTEGRATING UPON ATTEMPTS TO REMOVE THEM. THE REPAIR COSTS ARE $600-800 TO REMOVE THE REMAINDER OF THE PLUGS AND INSTALL NEW PLUGS. WHEN THE FORD SERVICE REPRESENTATIVE WAS ASKED WHAT CAUSED THIS PROBLEM AND IF IT WOULD OCCUR AGAIN THE FOLLOWING ANSWER WAS PROVIDED. DURING PRODUCT ASSEMBLY AT THE FACTORY , NO LUBRICANT WAS PLACED ON THE SPARKPLUG THREADS IN "SOME MODELS", CAUSING THE BASE TO WELD ITSELF TO THE ENGINE. THIS CAUSED WHAT SHOULD BE A $300 REPAIR TO MORE THAN DOUBLE IN COST. FORD SHOULD HAVE TO BEAR REPAIR COSTS TO BORE OUT THE PLUGS, NOT THE CAR OWNER. THIS PROBLEM IS WIDELY KNOWN, BUT THE CONSUMER HAS NO COURSE OF ACTION EXCEPT A COSTLY LEGAL REMEDY. I WILL NO LONGER PURCHASE FORD PRODUCTS BASED ON MY RECENT PROBLEMS WITH THEIR PRODUCTS. *TR
Crash:
No
Fire:
No
Injuries:
0
Deaths:
0
#10332063May 24, 2010
STEERING
THE VEHICLE SHIMMIES WHEN I HIT ANY SIZE BUMP ON THE ROAD. IT IS VERY VIOLENT AND HAS CAUSED ME TO MOVE ACROSS LINES IN THE ROAD. *TR
Crash:
No
Fire:
No
Injuries:
0
Deaths:
0
#10331252May 19, 2010
SERVICE BRAKES, HYDRAULIC:FOUNDATION COMPONENTS:DISC:CALIPER
TL*THE CONTACT OWNS A 2006 FORD F-250 EXTENDED CAB. WHILE CHANGING THE BRAKES, THE CALIPER PISTON THE DRIVER SIDE CRUMBLED, THE FRONT PASSENGER SIDE CALIPER PISTON WAS LOCKED. THE CONTACT TOOK THE VEHICLE TO AN AUTHORIZED DEALERSHIP WHERE HE WAS INFORMED THAT THE CALIPER WAS LOCKED, FROZEN OR BUSTED. THE CURRENT AND FAILURE MILEAGES WERE APPROXIMATELY 60,000.
Crash:
No
Fire:
No
Injuries:
0
Deaths:
0
#10330653May 16, 2010
SUSPENSION:FRONT
2006 FORD F250 FRONT END SHAKE OUT OF CONTROL HAS NOTHING TO DO WITH TIRE PRESSURE. WHO IS PAYING YOU OFF TO MAKE UP THIS STUFF. THIS IS A VERY DANGEROUS DEFECT THAT YOU AND FORD NEED TO DO SOMETHING ABOUT. *TR
Crash:
No
Fire:
No
Injuries:
0
Deaths:
0
#10330519May 14, 2010
ENGINE AND ENGINE COOLING:COOLING SYSTEM
THE EGR VALVE IS A DEFECTIVE PART ON MY 06 SUPER-DUTY IT HAS OVER HEATED ON ME THE LAST TWO TIMES I TOOK MY RV OUT ,AFTER CHECKING OUT AFTER MARKET PARTS STORES I SEE THEY HAVE ONE AVAILABLE THAT KEEPS IT RUNNING COOL. AFTER DOING MORE RESEARCH ITS A WELL KNOWN FACT THAT ITS A DEFECTIVE PART ALONG WITH THE WEAK HEAD BOLTS. I ALSO HEARD THAT LAST YEAR IN 2009 THAT FORD STARTED REPAIRING THE EGR ON VEHICLES THAT WERE BROUGHT IN THAT HAVE FACTORY WARRANTY ON THEM. MY QUESTION IS WHY NO RECALLS HAVE BEEN ISSUED ! ! ! ! *TR
Crash:
No
Fire:
No
Injuries:
0
Deaths:
0
#10328683May 3, 2010
STEERING, SUSPENSION:FRONT
OVER THE PAST 9 MONTHS I HAVE NOTICED A FRONT END/STEERING WHEEL VIBRATION AT HIGHWAY SPEEDS IN MY 2006 FORD F250. AT FIRST, THE VIBRATION WOULD GO AWAY IF I ACCELERATED THROUGH IT OR SLOWED DOWN. IT HAS WORSENED TO THE POINT WHERE IT HAS CAUSED ME TO PARTIALLY LOSE CONTROL OF THE TRUCK. I FIRST BOUGHT FOUR NEW TIRES. I THEN HAD THE LARGE RETAIL CHAIN WHERE I PURCHASED THE NEW TIRES ROTATE AND BALANCE THE THEM MULTIPLE TIMES WITH NO IMPROVEMENT. THEY SUGGESTED TAKING THE TRUCK TO THE DEALERSHIP TO HAVE IT CHECKED. I HAVE SINCE HAD THE TRUCK INTO THE DEALERSHIP MULTIPLE TIMES (BALANCING AND ROTATING, STEERING DAMPENER, AND CARRIER BEARING). *TR
Crash:
No
Fire:
No
Injuries:
0
Deaths:
0
#10326393April 19, 2010
SUSPENSION, STEERING
2006 FORD F-250 SUPER DUTY GAS 5.4L V8 I WAS ON THE HIGHWAY DRIVING AROUND 70 WHEN I HIT A POT HOLE THE STEERING WHEEL JERKED LIKE NORMAL BUT THEN ALL OF A SUDDEN THE TRUCK STARTED TO SHAKE VIOLENTLY. I STARTED TO SLOW DOWN AS FAST AS POSSIBLE, I THOUGHT I HAD A FLAT. I WAS BARELY ABLE TO GET OFF THE ROAD WITH OUT CAUSING AN ACCIDENT. I SPENT ABOUT AN HOUR TRYING TO FIGURE OUT WHAT HAPPENED. WITH NO FINDINGS I STARTED TO DRIVE HOME VERY SLOWLY AFRAID TO GO OVER 50. I TYPED IN GOOGLE.COM FORD F250 SHAKING AND WAS AMAZED THAT THERE WAS A MAJOR PROBLEM OUT THERE AND FORD IS DOING NOTHING ABOUT IT. I JUST CALLED FORD MOTOR COMPANY AND WAS GIVEN A CASE NUMBER. ALL THE DEALERSHIP BLAME IT ON TIRE PRESSURE. AND MOST OF THEM STATE THAT THE PRESSURE NEEDS TO BE GREATER THEN LISTED ON THE DOOR OF THE TRUCK. I AM TRULY AMAZED I WAS NOT HURT OR EVEN MORE AMAZED OF THE QUICK THINKING OF THE DRIVERS AROUND ME, GOING FROM 70 PLUS TO ABOUT 30 IN A FEW SECONDS. FROM WHAT I AM READING THE HAVE BEEN ARTICLES IN A FEW MAJOR MAGAZINES AND TV SHOWS REGARDING THIS ISSUE. I AM NOW GOING TO INCREASE MY TIRE PRESSURE AND SEE IF THAT CURES THE PROBLEM, IF NOT I AM GOING TO BE FORCED TO BUY AFTER MARKET PARTS TO FIX THE PROBLEM, COSTING $ 1,000 MIN. I DON'T MIND THE PRICE FOR THE SAFETY OF MY WIFE AND PASSENGERS. BUT I WOULD THINK THAT FORD MOTOR COMPANY WOULD STAND BEHIND THERE PRODUCT. ON THIS DAY IT HAPPENED 2 TIMES ON A 100 MILE TRIP, I AM NOW DEATHLY AFRAID TO DRIVE IT ON THE HIGHWAY, OR EVEN TAKE A PASSENGER WITH ME, OTHER THEN THAT HAPPENING AT HIGHWAY SPEEDS, THE VEHICLE HANDLES GREAT AND NO PROBLEMS. *TR
Crash:
No
Fire:
No
Injuries:
0
Deaths:
0
#10326448April 19, 2010
AIR BAGS, EQUIPMENT:MECHANICAL:WINCH
THIS WAS A SINGLE VEHICLE CRASH INVOLVING A 2006 FORD F-250 EXTENDED CAB 4X4 PICKUP ON A COUNTY MAINTAINED GRAVEL SURFACED ROAD. UPON LEAVING THE ROADWAY THE FRONT OF THE VEHICLE STRUCK A TREE HEAD ON, JUST TO THE RIGHT SIDE OF CENTER. THERE WERE NO PASSENGERS, JUST THE OPERATOR IN THE VEHICLE. THE ESTIMATED SPEED WAS 30-35 MPH. THE AIRBAG DID NOT DEPLOY. THE DRIVER WAS TREATED AT A MEDICAL FACILITY AND RELEASED. *TR
Crash:
Yes
Fire:
No
Injuries:
1
Deaths:
0
#10326010April 16, 2010
SUSPENSION:FRONT
MY FORD F250 4X4 TRUCK HAS A SEVERE SHIMMY OF THE FRONT WHEELS WHICH CAN OCCUR WHEN DRIVING AROUND 55-60 MILES PER HOUR. IN ORDER TO CALM THE SHIMMY OR OSCILLATION, I HAVE TO SLOW DOWN AT LEAST 10 MILES PER HOUR. THIS HAS HAPPENED ON SEVERAL TIMES, BOTH WHEN TOWING A 5TH WHEEL AND WITHOUT THE 5TH WHEEL. HOWEVER, IT IS MORE PRONE TO OCCURRING WHEN DOWNING THE 5TH WHEEL. I TOOK MY TRUCK INTO THE FORD DEALER TO INSPECT THE SUSPENSION AND ADJUST THE TIRE PRESSURE, BUT THEY SAID IT WAS ALL FINE. I HAD AN OCCURRENCE OF THIS SHIMMY WITHIN 3 DAYS FROM TAKING IT FROM THE DEALER. I HAVE SEEN THERE HAS BEEN SOME REPORT ON THIS TYPE OF BEHAVIOR, AND FORD HAS STATED IT IS A TIRE INFLATION PROBLEM, BUT AFTER TAKING IT INTO THE FORD DEALER AND THEM CHECKING IT OUT AND THEN IT HAPPENING, I THINK IT IS SOMETHING MORE SERIOUS. *TR
Crash:
No
Fire:
No
Injuries:
0
Deaths:
0
#10325735April 14, 2010
SUSPENSION:FRONT
I PURCHASED A 2006 FORD F250 EXTENDED CAB DIESEL TRUCK APPROXIMATELY EIGHTEEN MONTHS AGO. I HAD THE TRUCK INSPECTED BY THE LOCAL FORD DEALERSHIP AND WAS TOLD THAT THE TRUCK WOULD QUALIFY AS A CERTIFIED PRE OWNED VEHICLE. I ALSO PURCHASED THE PREMIER LEVEL EXTENDED WARRANTY OFFERED BY FORD. SHORTLY AFTER MY PURCHASE I NOTICED A SIGNIFICANT FROM WENT SHIMMY THAT WAS FELT IN THE STEERING WHEEL. FORD DEALERSHIP REPLACED TRACK BAR. TRUCK WAS ALIGNED AND TIRES ROTATED. SINCE THAT TIME I HAVE EXPERIENCED WHAT CAN ONLY BE DESCRIBED AS A VIOLENT FRONT END WOBBLE THAT IS PRECIPITATED BY RUNNING OVER ANY SIGNIFICANT ROAD IMPERFECTION AT ANY SPEED BETWEEN 35 AND 45 MPH. THE WOBBLE BECOMES SO SEVERE THAT CONTROLLING THE VEHICLE BECOMES NEARLY IMPOSSIBLE UNLESS THE SPEED IS REDUCED TO APPROXIMATELY 25MPH, AT WHICH TIME THE WOBBLE STOPS. I HAVE EXPERIENCED THIS ON AT LEAST TEN DIFFERENT OCCASIONS AND I AM CERTAIN THAT IF MY WIFE OR TEENAGE DAUGHTER HAD BEEN DRIVING THE TRUCK THEY WOULD HAVE BEEN INVOLVED IN A SERIOUS COLLISION. I AM IN RECEIPT OF ALETTER FROM FORD MOTOR CO. ADVISING ME OF OTHER COMPLAINTS RELATIVE TO THIS WOBBLE AND ADVISING ME THAT I SHOULD SCRUPULOUSLY MONITOR MY TIRE PRESSURE. I HAVE DONE AS FORD RECOMMENDED, BUT DESPITE THIS I HAVE CONTINUED TO EXPERIENCE THE WOBBLE. I HAVE RESEARCHED THIS PROBLEM ON THE INTERNET AND FOUND NUMEROUS OTHER CONSUMERS COMPLAINING OF THE SAME ISSUE. CURRENTLY MY TRUCK IS SCHEDULED TO RETURN TO THE DEALERSHIP IN A FEW DAYS AND THE SERVICE WRITER ADVISES ME THAT I MAY BE ELIGIBLE FOR A MODIFIED STEERING DAMPENER THAT IS THE RECOMMENDED FACTORY REPAIR AND MAY CORRECT THE PROBLEM. *TR
Crash:
No
Fire:
No
Injuries:
0
Deaths:
0
#10325110April 12, 2010
STRUCTURE:BODY
TL*THE CONTACT OWNS A 2006 FORD F-250. THE CONTACT WAS DRIVING APPROXIMATELY 65 MPH WHEN THE TRUCK BED CRACKED WITHOUT WARNING. THE VEHICLE WAS TAKEN TO AN AUTHORIZED DEALER. THE VEHICLE HAD NOT BEEN REPAIRED AT THE TIME OF THE COMPLAINT. THE FAILURE MILEAGE WAS 117,000. THE CURRENT MILEAGE WAS 121,000. UPDATED 06/25/10. *LJ UPDATED 06/29/10
Crash:
No
Fire:
No
Injuries:
0
Deaths:
0
#10324810April 10, 2010
STEERING
MY SON WAS DRIVING HIS 2006 FORD F 250 TRUCK WHEN THE STEERING LINKAGE BROKE AND HE LOST ALL ABILITY TO STEER HIS TRUCK. HE CRASHED INTO A PIECE OF EQUIPMENT. *TR
Crash:
Yes
Fire:
No
Injuries:
0
Deaths:
0
#10324141April 7, 2010
SUSPENSION:FRONT, STEERING
VIOLENT FRONT END SHAKE AT ALMOST ANY SPEED AFTER HITTING POTHOLE OR EVEN DIPS IN ROADS. WORSE WITH SPEED. OCCURS ALL THE TIME. DANGEROUS ABOVE 45 MPH. *TR
Crash:
No
Fire:
No
Injuries:
0
Deaths:
0
#10323451April 2, 2010
SERVICE BRAKES, HYDRAULIC, SUSPENSION:FRONT
TL* THE CONTACT OWNS A 2006 FORD F-250 SUPERDUTY. WHILE DRIVING AT APPROXIMATELY 50 MPH ON AN UNEVEN ROAD, THE STEERING WHEEL BEGAN SHAKING. THE CONTACT WAS ALSO UNABLE TO SLOW THE VEHICLE DOWN SINCE WHEN THE BRAKE PEDAL WAS DEPRESSED, IT WOULD RELEASE. THE VEHICLE WAS TAKEN TO AN AUTHORIZED DEALERSHIP BUT NO REPAIRS WERE PERFORMED WHEN THE COMPLAINT WAS FILED. THE FAILURE MILEAGE WAS APPROXIMATELY 38,000. THE CURRENT MILEAGE WAS APPROXIMATELY 97,000.
Crash:
No
Fire:
No
Injuries:
0
Deaths:
0

← Back to Ford F-250