Ford F-250 Complaints (2001)

508 consumer complaints on file.

#10145690December 20, 2005
STEERING:HYDRAULIC POWER ASSIST:HOSE, PIPING, AND CONNECTIONS
DT: THE CONTACT STATED THE POWER STEERING PULLEY FELL OFF THE ENGINE WHILE DRIVING. THIS CAUSED THE CONTACT TO LOSE CONTROL OF THE VEHICLE AND RESULTED IN LOSS OF POWER STEERING AND BRAKES. UPON INSPECTION, THE PULLEY APPEARED TO BE GLUED ON INSTEAD OF BOLTED. THE CONTACT BELIEVED THERE WAS A DEFECT IN THE WAY THE PULLEY WAS ATTACHED TO THE SHAFT. THERE WERE NO PROBLEM WITH THE STEERING PRIOR TO THIS INCIDENT. HE REPORTED THE INCIDENT TO THE MANUFACTURER. *AK UPDATED 01/11/06. *JB
Crash:
No
Fire:
No
Injuries:
0
Deaths:
0
#10145591December 19, 2005
ENGINE AND ENGINE COOLING:ENGINE:DIESEL
DT: THE CONTACT COMPLAINED ABOUT AN OIL RING FAILURE THE ENGINE WHILE DRIVING. THE ENGINE WAS MAKING A FLUTTERING SOUND, AND THE OIL GAUGE INDICATED A RAPID LOSS OF OIL PRESSURE. HE PULLED THE VEHICLE OVER TO THE SIDE OF THE ROAD. UPON INSPECTING THE VEHICLE, HE DISCOVERED THE OIL RING HAD BLOWN OUT OF THE ENGINE. HE ADDED ENOUGH OIL TO THE ENGINE TO BE ABLE TO DRIVE THE VEHICLE INTO HIS CERTIFIED REPAIR SHOP. REPAIRS WERE MADE TO THE VEHICLE AT THE CONTACT'S EXPENSE. *AK
Crash:
No
Fire:
No
Injuries:
0
Deaths:
0
#10144057November 30, 2005
STEERING:GEAR BOX:SHAFT PITMAN
I WAS DRIVING EAST ON BURKE HILL RD AT APPROX. 35 MPH WHEN THE STEERING WENT ON MY PICK UP TRUCK, THEN I HIT A PINE TREE AND BROKE THE RADIATOR, THE DRIVERS SIDE FRONT QUARTER PANEL WAS FOLDED BACK TO THE DRIVERS DOOR AND I SAW A PIECE OF THE UNDER CARRIAGE HANGING DOWN AND COME TO FIND OUT IT WAS THE SPECTAR ARM BROKE BY THE FRONT TIRE(DRIVERS SIDE), AND WHEN THE GARAGE PICKED THE TRUCK UP IN THE AIR THEY FOUND OUT THE TRANSFER CASE WAS BROKE NEARLY IN HALF. THEY FELT THE CAUSE OF THE ACCIDENT WAS THE BROKEN SPECTAR ARM. *NM
Crash:
Yes
Fire:
No
Injuries:
0
Deaths:
0
#10143405November 21, 2005
SEAT BELTS:FRONT:BUCKLE ASSEMBLY
2001 FORD F250 SUPER DUTY, DRIVER SEAT BELT WILL UNFASTEN AT ANY GIVEN TIME. *NM
Crash:
No
Fire:
No
Injuries:
0
Deaths:
0
#10143238November 19, 2005
ENGINE AND ENGINE COOLING:ENGINE
I OWN A FORD F 250 SUPER DUTY PICKUP WITH THE 5.4L MOTOR AND WHILE DRIVING, THE SPARK PLUG ON THE PASSENGER SIDE, #3, BLEW OUT OF THE SOCKET AREA. I WAS FORCED TO HAVE A FORD DEALERSHIP REPAIR THE PROBLEM AND NOW HAVE HAD A SECOND, FOLLOW UP INCIDENT, WITH THE SAME CYLINDER, RESULTING FROM THE ORIGINAL REPAIR. I UNDERSTAND THAT THIS HAS BEEN AN ONGOING PROBLEM WITH THESE MOTORS (AMONG OTHER CHRONIC PROBLEMS) AND NOTICED THAT CALIFORNIA IS NOW PAVING THEY WAY TO SOME SORT OF COMPENSATION. THE DEALER EVEN TOLD ME THAT THIS HAS HAPPENED IN OTHER TRUCKS. AFTER RESEARCHING THE ISSUE, I HAVE FOUND THAT IT IS FAIRLY WIDESPREAD. I WOULD LIKE TO BE INCLUDED IN ANY ACTION ON BEHALF OF VEHICLE OWNERS THAT WOULD ELIMINATE THE ISSUE AND REFUND MONIES SPENT ON REPAIRS. *JB
Crash:
No
Fire:
No
Injuries:
0
Deaths:
0
#10142742November 15, 2005
VEHICLE SPEED CONTROL:CRUISE CONTROL
CONSUMER OWNS 2001 F250 SUPER DUTY WHICH FIRE STARTED UNDER HOOD ON DRIVER'S SIDE. FIRE INVESTIGATOR'S OPINION WAS FAULTY CRUISE CONTROL SWITCH. VEHICLE IS TOTAL LOSS AND FIRE DAMAGE TO BUILDING. *JB
Crash:
No
Fire:
Yes
Injuries:
0
Deaths:
0
#10141301October 31, 2005
ENGINE AND ENGINE COOLING
DT: THE CONSUMER STATED THAT THE MOTOR STALLED WITHOUT WARNING WHILE DRIVING. THERE WAS A COMPLETE POWER FAILURE. THE CONSUMER CONTACTED THE MANUFACTURER AND WAS TOLD THAT THIS PROBLEM WAS NOT COVERED UNDER WARRANTY. THE FIRST TIME THE VEHICLE WAS TAKEN TO DEALERSHIP, THE CAM SENSOR WAS REPLACED. THE VEHICLE ONLY HAD 44, 000 MILES ON IT. THE SECOND TIME THIS HAPPENED, THE VEHICLE HAD 88, 000 MILES. THE CAM SENSOR WAS REPLACED AGAIN. *AK (12/08/05) THE CONSUMER STATED THAT THIS VEHICLE IS DRIVEN DAILY TOWING OVER 14K LBS. THE DEALER IS AWARE OF THIS PROBLEM. *SC
Crash:
No
Fire:
No
Injuries:
0
Deaths:
0
#10140400October 20, 2005
ENGINE AND ENGINE COOLING:ENGINE
FORD NEEDS TO DO A RECALL ON THE CAM POSITION SENSOR. IF THIS PART FAILS ON THE SUPER DUTY DIESEL AT HIGHWAYS SPEEDS, A CRASH COULD OCCUR RESULTING IN SERIOUS INJURY OR DEATH TO THE OCCUPANTS OF THE VEHICLE OR ANY OTHER VEHICLE THAT THE SUPER DUTY MAY COME IN CONTACT WITH. I WAS DRIVING AT 75 MPH WHEN THE ENGINE SUDDENLY DIED DUE TO CPS FAILURE. THE TRUCK SLOWED SO FAST I ALMOST HIT THE WINDSHIELD. THE ENGINE WOULDN'T RESTART. OTHER MOTORIST SAW ME IN TROUBLE AND LET ME PULL TO THE RIGHT SHOULDER. STEERING THE TRUCK REQUIRED "SUPERMAN" STRENGTH. I SCRAPPED MY TRUCK AGAINST THE GUARD RAIL. FORTUNATELY I WASN'T TOWING 6,000 LB LIKE I NORMALLY DO AT THAT TIME. NOW I KEEP A SPARE CPS AND A 10 MM SOCKET IN MY TRUCK.
Crash:
Yes
Fire:
No
Injuries:
0
Deaths:
0
#10140063October 18, 2005
TIRES:TREAD/BELT
THREADS ON THE REAR COOPER TIRE OF MY PICKUP TRUCK CAME OFF THE TIRE WHILE DRIVING ON THE EXPRESSWAY. THE THREADS SCATTERED ALL OVER THE ROAD AND THE CARS AND TRUCK IN BACK OF ME HAD TO SLOW DOWN TO AVOID THE DEBRIS. THE COMPLETE SIDE OF MY PICKUP HAD TO BE REPLACED. THIS " LOAD RANGE E "TIRE STILL HAD ALL OF THE AIR IN IT WHEN I CHANGED IT. I SENT THE TIRE BACK TO COOPER TIRE COMPANY AT THEIR EXPENSE ALONG WITH PICTURES OF THE DAMAGE TO MY TRUCK. COOPER INSPECTED THE TIRE AND DETERMINED THE AIR PRESSURE HAD BEEN LOW, APPARENTLY FOR SOME TIME, AND DENIED MY CLAIM. THIS LOAD RANGE E TIRE HAS A MAXIMUM INFLATION OF 80 PSI. THE FIRESTONE / BRIDGESTONE - FORD COURT CASE APPARENTLY HAS GIVEN TIRE MANUFACTURERS A GREEN LIGHT TO MANUFACTURE DEFECTIVE TIRES AND ANY PROBLEMS ASSOCIATED WITH THESE TIRES ARE BLAMED ON THE CONSUMER NOT KEEPING THE TIRE PRESSURE AT MAXIMUM PSI.*JB
Crash:
No
Fire:
No
Injuries:
0
Deaths:
0
#10138755October 5, 2005
ENGINE AND ENGINE COOLING:ENGINE
WHILE DRIVING HOME WITH 4 KIDS IN OUR FAMILY F250 FORD PICK UP TRUCK A LOUD NOISE, WHICH SOUNDED LIKE GUNFIRE, CAME FROM THE TRUCK. I STOPPED AS FAST AS I COULD AND HAD ALL OF MY KIDS RUN FOR SAFETY. I CALLED MY BROTHER N LAW AND WAS SCREAMING HYSTERICALLY THAT I THOUGHT SOMEONE HAD BEEN SHOOTING AT ME. HE STARTED LAUGHING AT ME AND WAS QUITE FAMILIAR WITH WHAT WAS GOING ON BECAUSE THIS WAS A COMMON THING WITH FORD. THE SPARK PLUG ACTUALLY BLEW OUT OF THE HEAD. I CONTACTED FORD AND THEY JUST BRUSHED ME OFF, THIS IS A VERY SERIOUS PROBLEM THAT SPARK PLUG COULD OF CAME THROUGH THE WINDSHIELD AND KILLED ONE OF MY KIDS SOMETHING NEEDS TO BE DONE. *JB
Crash:
No
Fire:
No
Injuries:
0
Deaths:
0
#10137633September 26, 2005
TIRES:TREAD/BELT
1. DRIVING 60 MPH DOWN HIGHWAY 290E NEAR ELGIN, REAR PASSENGER TIRE TREAD CAME FLYING OFF. 2. TIRE DENTED PANEL, SCRATCHED CHROME AND DID OTHER DAMAGE TO TRUCK. 3. I HAVE PERSONALLY PURCHASED 4 NEW TIRES BUT HAVE KEPT THE DAMAGED TIRE AND THE OLD TIRES.*JB
Crash:
No
Fire:
No
Injuries:
0
Deaths:
0
#10137409September 23, 2005
TIRES:TREAD/BELT
INCIDENT I WAS ON A TRIP TO POINT REYES THIS LAST WEEKEND. ON THE WAY HOME I HAD A FRONT TIRE DELAMINATE WHILE I WAS TOWING MY 27 FOOT TRAVEL TRAILER. FORTUNATELY NO ONE INJURED AND I WAS ABLE TO EXIT THE FREEWAY SAFELY. THE TIRE DID NOT DEFLATE UNTIL AFTER IT WAS REMOVED. THE VEHICLE SUSTAIN ABOUT $2,000 IN DAMAGE. I HAVE APPROXIMATELY FORTY SIX THOUSAND MILES ON THE TIRES. WHEN LOOKING AT PICTURES OF THE TIRES OF THE FIRESTONE/FORD RECALL THIS TIRE COULD LOOKS BE ONES OF THE TIRES IN THE PHOTOS. 2001 F250 CREW CAB 4X4 SHORT WHEEL BASE STOCK TIRE I BOUGHT THE TRUCK IN OCTOBER OF 2000 NEW WITH THESE TIRES ON IT. NOMAD 27?? APPROXIMATELY 7700 LBS DRY ABOUT TWO WEEKS AGO I HAD A LADY IN A SMALL HONDA CIVIC WITH HER SMALL CHILDREN RUN A RED LIGHT IN FRONT OF ME. I WAS GOING ABOUT 45 MILES PER HOUR. I ALMOST T BONED HER, I WAS FORTUNATELY ABLE TO SWERVE INTO ON COMING TRAFFIC (CARS WERE IN THE SLOW LANE) I SWERVE AGAIN AND MADE AN UNEXPECTED LEFT TURN. I HAD THE TRUCK LOCKUP AS HARD COULD TO STOP, I WAS SURPRISED AS WAS WIFE THAT WE DID NOT HIT THE CAR. AFTER THAT THE FRONT END FELT OFF, I THOUGHT THE ALIGNMENT WAS OFF. I WAS PLANNING ON PUTTING THE TRUCK IN THE SHOP FOR IT'S 45K CHECKUP AFTER OUR LAST PLANNED CAMPING TRIP OF THE YEAR. ON THE TRIP I FELT THE ALIGNMENT JUST DID NOT FEEL RIGHT. ON THE WAY HOME ON BLACK POINT TURN OFF HWY 37& HWY 80 ON RAMP WE HAD A SMALL CAR CUT IN FRONT OF US LAST MINUTE TO GET ON THE FREEWAY WE HAD TO LOCK UP THE RIG, MISSED REAR ENDING HIM BY ABOUT 3??. THE TIRE GAVE WAY ABOUT APPROXIMATELY 5-10 MILES DOWN THE ROAD. THE REASON FOR MY EMAIL IS IF THESE TIRE ARE ALSO DEFECTIVE, WE DID NOT GET HURT BUT I DO NOT WANT TO SEE ANY ONE ELSE GET HURT. THANKS,
Crash:
No
Fire:
No
Injuries:
0
Deaths:
0
#10136038September 9, 2005
TIRES
SUBJECT OF COMPLAINT: GOODYEAR, TRAIL MARK M&S LT235/85R16 12/1160, DOT PJCR C9KV 0703. MILEAGE ON TIRE AT TIME OF BLOWOUT: 37580.4; MIN TREAD DEPTH: 3/8"; EVEN WEAR; NO SIDEWALL DAMAGE PRIOR TO BLOWOUT; INFLATED TO DEALER SPEC (CHECKED INFLATION THAT AM). VEHICLE: FORD F250 LONG BED, SUPER DUTY TRUCK. TIRE PURCHASED AT AND INSTALLED BY FORD DEALERSHIP. INCIDENT: PASSENGER REAR TIRE BLOW OUT RENDERED TIRE INTO 3 INDEPENDENT PARTS: INSIDE AND OUTSIDE RIMS AND TREAD. DRIVING UPHILL PULLING SMALL, DUAL-AXLE ALPACA TRAILER (EMPTY) AT 55 MPH AT APPROXIMATELY 3 PM PDT; MAINTAINED VEHICLE CONTROL, PULLED TO SIDE OF I-80 JUST WEST OF RENO, NV. CALIFORNIA HIGHWAY PATROL RESPONDED WITH ROADSIDE ASSISTANCE. REPLACED REMAINING TIRES WITH TOYO COMMERCIAL TIRES, NOT TAKING ANY MORE CHANCES WITH GOODYEAR OR FORD DEALERSHIP.*JB
Crash:
No
Fire:
No
Injuries:
0
Deaths:
0
#10130864August 26, 2005
SERVICE BRAKES, HYDRAULIC:ANTILOCK/TRACTION CONTROL/ELECTRONIC LIMITED SLIP, AIR BAGS:FRONTAL, FUEL SYSTEM, GASOLINE:DELIVERY:HOSES, LINES/PIPING, AND FITTINGS
DT: ABS BRAKES, AIR BAGS, AND FUEL SYSTEM FAILED. AT 4700 MILES THEY REPLACED THE ENTIRE BRAKE SYSTEM. HAD IT A MECHANIC SHOP AND DISCOVERED IT WAS THE ABS. WHILE GOING 55 MPH AND MAKING A LEFT HAND TURN KEPT PUSHING THE BRAKES AND NOTHING HAPPENED CAUSING A WRECK. KEPT TAKING VEHICLE TO FORD, THEY COULD NOT FIND ANYTHING WRONG. UPON IMPACT, AIR BAGS ALSO DID NOT DEPLOY. ALSO, FUEL LINES SHUT OFF. THIS HAPPENED ON MARCH 15, 2002. *AK *NM
Crash:
Yes
Fire:
No
Injuries:
4
Deaths:
0
#10133710August 22, 2005
UNKNOWN OR OTHER
MY HUSBAND AND I HAVE A FORD F250 TRUCK. IT'S A 2001 WHICH WE PURCHASE IN 3/2002. MY HUSBAND WAS DRIVING THE TRUCK WHEN HE HEARD A BANG THEN THE TRUCK DIED. WE HAD THE TRUCK TOWED TO A LOCAL AUTO REPAIR SHOP. THE REPAIR SHOP STATED THAT THEY WOULD NOT TOUCH THE TRUCK BECAUSE THE SPARK PLUG BLEW OUT CAUSING THE HEAD TO BLOW. THEY STATED THAT THIS IS AN ONGOING THING WITH FORD TRUCKS AND FORD WILL NOT ADMIT THAT THEY HAVE AN ENGINEERING PROBLEM WITH THE MOTOR. I BROUGHT THIS MATTER TO THE DEALERSHIP AND THE FORD CUSTOMER SERVICE DEPARTMENTS ATTENTION. NEITHER ONE OF THEM WOULD ASSIST ME. THEY STATED THAT WE WOULD BE RESPONSIBLE FOR THE REPAIRS. AFTER THESE PHONE CALLS I CALL A FEW OTHER AUTO REPAIR SHOPS. THEY ALSO STATED THAT THAT WAS UNUSUAL THAT A SPARK PLUG WOULD BACK OUT AND EVEN IF THE SPARK PLUG DID BACK OUT THAT IT WAS UNUSUAL THAT IT WOULD BLOW THE HEAD GASKET. AT THIS POINT WE HAVE TO PAY FOR THE REPAIRS WHICH IS 3,500.00. I WOULD LIKE THIS MATTER LOOKED INTO.
Crash:
No
Fire:
No
Injuries:
0
Deaths:
0
#10132934August 15, 2005
VEHICLE SPEED CONTROL:CRUISE CONTROL
ELECTRICAL FIRE RESULTED IN TOTAL LOSS. *NM
Crash:
No
Fire:
Yes
Injuries:
0
Deaths:
0
#10133472August 12, 2005
TIRES
THE CONSUMER DEVELOPED PROBLEMS WITH THE FIRESTONE STEELTEX RADIAL TIRES ON HIS 2001 FORD F250.***NO ANSWER REQUIRED***. *MR ON TWO SEPERATE OCCASIONS THE FRONT AND REAR LEFT TIRE HAD COME APART WHILE THE VEHICLE WAS IN MOTION. *SC
Crash:
No
Fire:
No
Injuries:
0
Deaths:
0
#10132666August 12, 2005
ENGINE AND ENGINE COOLING:EXHAUST SYSTEM:MANIFOLD/HEADER/MUFFLER/TAIL PIPE
I PURCHASED A NEW FORD F250 SUPER DUTY TRUCK IN MAY, 2001. I ALMOST IMMEDIATELY SMELLED EXHAUST FUMES COMING FROM UNDERNEATH THE FRONT OF THE TRUCK- FUMES WHICH SMELL MUCH LIKE THAT OF A LAWN MOWER. THE EXHAUST COMING FROM THE END OF THE TAILPIPE DID NOT HAVE THIS SMELL. AFTER 6 MONTHS, I BROUGHT THE TRUCK BACK TO THE SERVICE DEPARTMENT IN MY PLACE OF PURCHASE, BILL MARSH FORD IN NEWTOWN, PA. THE SHOP FOREMAN DENIED SMELLING ANY FUMES AND, WITHOUT HAVING LOOKED UNDERNEATH AT THE EXHAUST SYSTEM, STATED THAT THERE WAS NOTHING WRONG WITH MY TRUCK. A YEAR LATER I RETURNED FOR THE SAME PROBLEM. I HAD HIM DOCUMENT THIS VISIT, BUT NOT THE FIRST ONE. THEIR CONSENSUS REMAINED THE SAME. FOR THE FIRST TIME THE OTHER DAY, I CRAWLED UNDER MY TRUCK WHILE IT WAS RUNNING, SEEKING AN EXHAUST LEAK. AND THAT'S EXACTLY WHAT I FOUND. RECENTLY, MY TRUCK'S WARRANTY HAS EXPIRED AND I STILL HAVE THIS PROBLEM. TODAY, BILL MARSH FORD SERVICE HAS LOOKED AT THE PROBLEM BASED ON WHAT I FOUND. I NOW HAVE AN APPOINTMENT WITH THEM TO HAVE THE DEFECTIVE PART OF THE EXHAUST SYSTEM REPLACED. WHILE IT IS ONE THING TO HAVE TO PAY FOR SOMETHING THAT THEY COULD HAVE FIXED WHEN IT WAS NEW, OR THAT SHOULD HAVE BEEN PUT TOGETHER RIGHT AND TESTED AT THE FACTORY, I HAVE A BIGGER CONCERN. I FEEL THIS IS A SAFETY HAZARD, SINCE THE EXHAUST FUMES COME INTO THE TRUCK THROUGH OPEN WINDOWS AND THE VENTS. IT IS ALSO AN ENVIRONMENTAL ISSUE SINCE THE LEAK IS IN FRONT OF THE CATALYTIC CONVERTER. I CANNOT SEE HOW I WAS ALLOWED TO DRIVE UNDER THESE CONDITIONS AFTER I REPORTED SMELLING THE FUMES, OR HOW THE TRUCK WAS EVEN ALLOWED TO PASS INSPECTION IF THE EXHAUST SYSTEM WAS COMPLETELY CHECKED. NOW THAT I HAVE IDENTIFIED THE SOURCE OF THE PROBLEM WHICH HAS PLAGUED MY TRUCK FROM DAY ONE, AND THE SERVICE DEPARTMENT HAS ADMITTED THAT THERE IS A CORRECTABLE PROBLEM, I WISH TO PURSUE ANY FURTHER ACTION NECESSARY FOR SUCH A CASE. THANK YOU! *JB
Crash:
No
Fire:
No
Injuries:
0
Deaths:
0
#10132297August 10, 2005
POWER TRAIN:AUTOMATIC TRANSMISSION:LEVER AND LINKAGE:COLUMN SHIFT
I STOPPED TO GRAB A BITE TO EAT AND THE TRUCK WOULD NOT SHIFT INTO PARK. I HAD TO TURN OFF THE ENGINE IN GEAR AND SET THE PARKING BRAKE. WHEN I GOT BACK, I COULD HARDLY GET THE TRUCK BACK INTO NEUTRAL TO START THE VEHICLE. IT WAS ALSO HARD TO FIND GEARS TO DRIVE BACK TO WORK. WE DROPPED THE TRUCK BY THE FORD DEALER AND THEY REPLACED THE SHIFT SHAFT TUBE, 2 BUSHINGS AND THE SHIFTER CABLE ASSEMBLY. IT SEEMS TO WORK FINE NOW. *JB
Crash:
No
Fire:
No
Injuries:
0
Deaths:
0
#10130726July 31, 2005
ENGINE AND ENGINE COOLING:COOLING SYSTEM:HOSES/LINES/PIPING/FITTINGS
SAW ANTI-FREEZE LEAKING,TOOK VEHICLE, WHICH IS A 2001 FORD F250 SD, TO THE DEALER. HAD PRESSURE TEST DONE OF COOLING SYSTEM,FOUND WAS A BROKEN HOSE CLAMP,DEALER CHANGED ALL FOUR HOSE CLAMPS. VEHICLE HAS 22,000 MILES. *NM
Crash:
No
Fire:
No
Injuries:
0
Deaths:
0

← Back to Ford F-250