Ford F-250 Complaints (2004)

408 consumer complaints on file.

#10182320February 12, 2007
ELECTRICAL SYSTEM:WIRING, ENGINE AND ENGINE COOLING:ENGINE:DIESEL
TL*- THE CONTACT OWNS A 2004 FORD F-250 SUPER DUTY AND STATED THAT WHILE DRIVING BETWEEN 40-50 MPH, THE VEHICLE STALLED WITHOUT PRIOR WARNING. THE STALLING SEEMED TO OCCUR WHEN THE ENGINE HAD NOT WARMED UP COMPLETELY. HE DID RESEARCH ONLINE AND FELT THAT THIS VEHICLE SHOULD BE COVERED UNDER RECALL NHTSA CAMPAIGN ID NUMBER: 05V270000 CONCERNING ELECTRICAL SYSTEM: WIRING. HE TOOK IT TO THE DEALER, AND THEY STATED THAT THE VEHICLE DID NOT FALL WITHIN THE RECALL DUE TO THE VIN. THE CURRENT AND FAILURE MILEAGE WERE 112000.*AK THE CONSUMER STATED AN ACCIDENT OCCURRED. THE CONSUMER ATTEMPTED TO STOOP THE VEHICLE, BUT THE BRAKES AND STEERING BECAME STIFF. UPDATED 03/07/07. *JB
Crash:
Yes
Fire:
No
Injuries:
0
Deaths:
0
#10174105November 22, 2006
ENGINE AND ENGINE COOLING:ENGINE:DIESEL
1. 2004 F250 6.0 DIESEL EXPERIENCED ENGINE PROBLEMS IN AUG 2004. ENGINE BACKFIRED ON INTERSTATE AND SINCE TIME HAS BEEN WORKED ON MULTIPLE TIMES BY SELLING DEALERSHIP AND FORD ENGINEERS. 2. WHATEVER HAPPENED TO THE ENGINE IN 2004 CAUSED IT TO LOOSE POWER. THE TRUCK HAS BEEN RETURNED TO DEALERSHIP APPROXIMATELY 12 TIMES SINCE THEN WITH A POWER LOSS COMPLAINT THAT HAS YET TO BE FIXED. WHEN PULLING OUT INTO TRAFFIC, THE TRUCK CAN AND FREQUENTLY DOES STALL. LAST MONTH IT STALLED TWICE WHILE ATTEMPTING TO CROSS A SET OF RAILROAD TRACKS. 3. THE DEALERSHIP HAS TRIED MULTIPLE REMEDIES BUT HAS YET TO FIX THE PROBLEM. THE TRUCK HAS BEEN IN THE SHOP SINCE NOV 6TH 2006. THEY CALLED YESTERDAY TO TELL ME IT WAS FIXED. TODAY IS NOV 22, IT IS STILL THERE. IT TEST DROVE IT TODAY AND IT STALLED MULTIPLE TIMES IN THE DEALERSHIP PARKING LOT. I LEFT IT WITH THEM.*JB
Crash:
No
Fire:
No
Injuries:
0
Deaths:
0
#10173834November 20, 2006
FUEL SYSTEM, OTHER:FUEL INJECTION SYSTEM
VEHICLE REQUIRING REPEAT REPAIRS FOR SAME PROBLEM, 3 INJECTORS REPLACED ON SEPARATE OCCASIONS, COMPUTER REPROGRAMMING, EGR VALVE REPLACED. *NM
Crash:
No
Fire:
No
Injuries:
0
Deaths:
0
#10169589September 29, 2006
VEHICLE SPEED CONTROL
DT*: THE CONTACT STATED THE VEHICLE ACCELERATED ON ITS OWN AT VARIOUS SPEEDS INTERMITTENTLY. ALSO, THIS HAD HAPPENED WHILE STOPPED AT A RED LIGHT. THE DEALERSHIP HAD SEEN THE VEHICLE FIVE TIMES. THE FIRST TWO TIMES, THE PROBLEM COULD NOT BE DUPLICATED. THE THIRD TIME, AN UNKNOWN PART WAS REPLACED. THE FOURTH TIME, THE COMPUTER WAS REPROGRAMMED, BUT THE PROBLEM PERSISTED.
Crash:
No
Fire:
No
Injuries:
0
Deaths:
0
#10168805September 20, 2006
FUEL SYSTEM, DIESEL
WE HAVE TERRIBLE GAS(DIESEL) MILEAGE WITH OUR TRUCK, CAN YOU HELP? , WE'VE HAD AT LEAST 6 RECALLS ON OUR TRUCK. *JB
Crash:
No
Fire:
No
Injuries:
0
Deaths:
0
#10168190September 13, 2006
POWER TRAIN:DRIVELINE, SUSPENSION, TIRES, SERVICE BRAKES, HYDRAULIC:FOUNDATION COMPONENTS:DISC:ROTOR
DT*: THE CONTACT STATED WHILE TRAVELING 65 MPH, A VIBRATION WAS FELT FROM THE STEERING WHEEL ALONG WITH THE FRONT AND REAR OF THE VEHICLE. THE SERVICE DEALER AND MANUFACTURER REPLACED THE ENTIRE FRONT END, ALL AXLES, ROTORS, RING AND PINION AND WHEEL HUBS, BUT THE VIBRATION CONTINUED. THE MANUFACTURER HAD AN ENGINEER TEST THE VEHICLE AND FOUND THE VIBRATION TO BE WITHIN OPERATING STANDARDS.*AK THE FUEL LIGHT ILLUMINATED, THE CENTER CONSOLE SQUEAKED, THE LOWER BALL JOINTS WERE REPLACED. UPDATED 11/21/06. *JB
Crash:
No
Fire:
No
Injuries:
0
Deaths:
0
#10168199September 13, 2006
ELECTRICAL SYSTEM
THE COMPUTER (PCM) SHUTS THE TRUCK DOWN, KILLS THE ENGINE AND EVERYTHING ASSOCIATED WITH IT (POWER STEERING,BRAKES,ECT.). AT 4735 MILES THE COMPUTER WAS REPROGRAMMED DUE TO TRUCK NOT ABLE TO RUN. AT 51,698 PERFORMED RECALL 05S34 FIC MODULE WIRING HARNESS REPAIR. AT 57,377 MILES THE TRUCK SHUT DOWN TURNING THROUGH AN INTERSECTION LEAVING THE TRUCK IN THE PATH OF TRAFFIC. THE DEALERSHIP WAS UNABLE TO COMMUNICATE WITH THE COMPUTER AT ALL. DEALERSHIP REPLACES AND REPROGRAMS PCM. AT 57,398 MILES THE TRUCK SHUT DOWN AGAIN FULLY LOADED WITH TRAILER RUNNING 65 MPH. BARELY GOT TRUCK TO SIDE OF ROAD AND STOPPED SAFELY DUE TO NO POWER BRAKES OR STEERING. DEALERSHIP REPLACED FUSE BOX ASSY. AT 57,399 MILES THE TRUCK STARTED MISSING, DEALERSHIP REPLACED ENGINE LOOM. AT OR AROUND 89,450 MILES THE TRUCK SHUT DOWN RUNNING 70 MPH ON HIGHWAY WAS ALMOST UNABLE TO SAFELY GET TRUCK TO SIDE OF ROADWAY. DEALERSHIP REPLACED PCM AGAIN AND REPROGRAMMED. TRUCK DID NOT RUN LONG ENOUGH TO GO ON A ROAD TEST BEFORE SHUTTING DOWN AGAIN. DEALERSHIP REPLACED INJECTOR LOOM OF WIRE HARNESS. EACH TIME I WAS TOWED AFTER A SHUT DOWN WE HAD TO MAKE EXTRA ACCOMMODATIONS FOR OUR PETS AND OTHER PASSENGERS WITH US. WE FEEL WE WERE EXTREMELY LUCKY THIS LAST TIME NOT TO HAVE BEEN IN AN ACCIDENT INJURING OTHER PEOPLE AS WELL AS OURSELVES. *NM
Crash:
No
Fire:
No
Injuries:
0
Deaths:
0
#10167379September 5, 2006
POWER TRAIN:TRANSFER CASE (4-WHEEL DRIVE)
DT*: THE CONTACT STATED TWICE THE VEHICLE JUMPED INTO FOUR-WHEEL DRIVE ON ITS OWN CAUSING THE VEHICLE TO LOCK UP. WHEN THIS OCCURRED, THE STEERING WAS VERY DIFFICULT TO PUT INTO GEAR. THE FIRST TIME THIS OCCURRED, THE DEALERSHIP INSTALLED A VACUUM PUMP ASSEMBLY. THE SECOND TIME, THE DEALERSHIP DETERMINED THE MOTOR ON THE TRANSFER CASE NEEDED TO BE REPLACED.
Crash:
No
Fire:
No
Injuries:
0
Deaths:
0
#10166106August 21, 2006
ENGINE AND ENGINE COOLING:ENGINE:DIESEL, VEHICLE SPEED CONTROL
F250 DIESEL ENGINE HAS UNCOMMANDED THROTTLE ADVANCE. IN TRAFFIC ENVIRONMENT, I NEED TO KEEP A LARGE INTERVAL IN CASE TRUCK DECIDES TO ADVANCE THROTTLE ON ITS OWN. THIS SITUATION RULES OUT PARKING IN THE GARAGE. TRUCK WAS PURCHASED NEW FROM FORD, HAS BEEN IN SHOP 6 TIMES FOR SAME PROBLEM. *JB
Crash:
No
Fire:
No
Injuries:
0
Deaths:
0
#10166156August 21, 2006
ELECTRICAL SYSTEM:WIRING
DT*: THE CONTACT STATED THE VEHICLE HAD THE SAME PROBLEMS AS DEFINED IN NHTSA RECALL #05V270000, BUT THE MANUFACTURER STATED THE VEHICLE WAS NOT INCLUDED IN THE RECALL DUE TO THE VIN. THE VEHICLE LOST POWER AND DID NOT ACCELERATE ON TWO DIFFERENT OCCASIONS. THE SECOND OCCASION THE VEHICLE STALLED AND WAS NOT ABLE TO BE RESTARTED. THE SERVICE DEALER COULD NOT LOCATE THE PROBLEM.
Crash:
No
Fire:
No
Injuries:
0
Deaths:
0
#10163958July 31, 2006
ENGINE AND ENGINE COOLING
DT*: THE CONTACT STATED WHILE DRIVING 35MPH OR LESS, THE ENGINE REVS FOLLOWED BY A SUDDEN DECREASE. THE VEHICLE WAS INSPECTED BY A DEALER WHO PERFORMED A DIAGNOSTIC TEST WHICH PRODUCED NO FAILURE CODES. THE SERVICE DEPARTMENT WAS UNABLE TO DUPLICATE THE PROBLEM.
Crash:
No
Fire:
No
Injuries:
0
Deaths:
0
#10162819July 19, 2006
ENGINE AND ENGINE COOLING:ENGINE, EQUIPMENT:ELECTRICAL
I OWN A 2004 F-250 POWER STROKE DIESEL MY TRUCK HAS STALLED NUMEROUS TIMES THAT HAVE LEFT ME IN VERY DANGEROUS SITUATIONS SUCH AS ON FREEWAYS, WHERE HIGHWAY PATROL OFFICERS HAD ESCORT ME TO THE SHOULDER OF THE FREEWAY. THE DEALER HAS REPLACED NUMEROUS PARTS ON MY VEHICLE EVEN BEFORE I HAD THE PROBLEM OF MY TRUCK STALLING. THEY HAD REPLACED ALL THE RECALL PARTS WHICH WAS SAID TO HAVE CAUSED THE STALLING OF THE POWER STROKE MODELS. AROUND 20,00 MILES AFTER I HAD BOUGHT MY TRUCK IT WOULD STALL WITHOUT WARNING. UP TO THIS DAY IT HAS STALLED A TOTAL OF ABOUT 12 TIMES. SOME TIMES IT WOULD START AND STALL AGAIN AND AT TIMES IT WOULD NOT START AT ALL AND HAD TO BE TOWED TO THE DEALER. IT HAS BEEN TO THE DEALER 5 TIMES FOR THEM TO FIX IT AND EVERY TIME THEY SAID THAT THEY HAD CORRECTED THE PROBLEM. THEY HAVE GIVEN ME FLIGHT DATA RECORDERS TO RECORD THE PROBLEMS AS IT STALLS. THE PROBLEM WAS RECORDED AND THEY STILL COULDN'T FIGURE OUT THE PROBLEM. THE LAST TIME MY VEHICLE STALLED WAS ON THE 6TH OF JULY ME AND MY FAMILY WERE ON A VACATION TO YOSEMITE TOWING A TRAVEL TRAILER WHEN MY TRUCK STALLED ON A TWO LANE HIGHWAY WITH NO SHOULDER SO I WAS STALLED DANGEROUSLY CLOSE TO OPPOSING TRAFFIC WHEN AN ON COMING VEHICLE SLAMMED INTO MY MIRROR AND BROKE IT. IT COULD HAVE BEEN ALOT WORSE IN SENSE THAT MY FAMILY'S LIVES COULD HAVE BEEN IN DANGER. I DON'T KNOW WHAT TO DO. ALL THE SHOP FOREMAN WHICH I DEAL WITH AT THE DEALER TELLS ME TO JUST BRING MY VEHICLE BACK TO THE DEALER AND THEY WILL FIX THE PROBLEM. BUT THEY HAVE YET TO FIX THIS PROBLEM. I AM FED UP WITH THIS PROBLEM. *NM
Crash:
Yes
Fire:
No
Injuries:
0
Deaths:
0
#10162799July 18, 2006
VEHICLE SPEED CONTROL
MY 2004 FORD 250 4 X 4 IS SURGING (TAKING OFF) WHEN I AM NOT ACCELERATING THE ENGINE. IT DOES THIS AT VARIOUS SPEEDS. THE DEALERSHIP HAS TRIED SEVERAL FIXES AND EVEN CALLED THEIR OWN HOTLINE. NOTHING IS WORKING TO FIX THE PROBLEM. I AM AT TIMES SITTING A RED SIGNAL LIGHT ANT THE TRUCK WANTS TO TAKE OFF. MY FOOT WAS FIRMLY SUPPRESSED UPON THE BRAKE PEDAL. I TRAVEL DOWN A RESIDENTIAL STREET, GOING AT SPEEDS BETWEEN 25 AND 40 MILES PER HOUR, AND MY TRUCK SURGES FORWARD AS THOUGH I DEPRESSED THE ACCELERATOR. I DID NOT DEPRESSED THE ACCELERATOR. I CAN BE GOING SPEEDS BETWEEN 25 AND 75 MILES PER HOUR ON THE HIGHWAY, WHETHER IN STOP AND GO OR CONTINUOUS SPEED, AND THE TRUCK SURGES WITHOUT THE COMMAND OF MY FOOT ON THE ACCELERATOR. THE RPM NEEDLE JUMPS SUDDENLY AS WELL WHEN THIS OCCURS. IF I AM REPEATING MYSELF, IT IS BECAUSE I AM VERY CONCERN FOR MY SAFETY AS WELL AS ANY PASSENGERS AND THE OTHER DRIVERS ON THE ROAD WITH ME WHEN THIS PROBLEM OCCURS. I HAVE GONE TO VARIOUS WEBSITE FORUMS AND I AM SEEING OTHER OWNERS COMPLAIN OF THE SAME THING, BUT FORD IS NOT FIXING THE SAFETY ISSUE. *NM
Crash:
No
Fire:
No
Injuries:
0
Deaths:
0
#10161165June 30, 2006
FUEL SYSTEM, DIESEL, EQUIPMENT:MECHANICAL
MY 2004 FORD F250 SUPER DUTY DIESEL HAD ITS TURBO REPLACED IN MAY 2005-IT HAS BEEN IN AND OUT OF THE DEALERSHIP'S GARAGE ON AND OFF FOR THE LAST YEAR, STALLING OUT AT VARIOUS SPEEDS, WE CAN NOT TOW ANYTHING WITH OUT IT BLOWING BLACK SMOKE AND CUTTING OUT. I AM 1000 MILES FROM THE INITIAL WARRANTY THE MECHANIC'S HAVE NOT FIXED THE PROBLEM I LOCATED A NHTSA RECALL WHICH DESCRIBES THE PROBLEM TO THE TEE. FORD MOTOR COMPANY REPRESENTATIVES TOLD ME THAT MY VEHICLE'S VIN WASN'T INCLUDED IN THE RECALL SO I HAVE TO PAY OUT OF MY POCKET FOR THE CORRECTION. EVEN THOUGH I AM STILL UNDER WARRANTY, AND THE CONSEQUENCES OF SUMMARY STATES: IF THE ENGINE STALLS, A CRASH COULD OCCUR. WHICH COULD ENDANGER MY FAMILY AND POSSIBLY SOMEONE ELSE. *NM
Crash:
No
Fire:
No
Injuries:
0
Deaths:
0
#10158389May 16, 2006
ENGINE AND ENGINE COOLING:ENGINE
2004 F 250 ENGINE LIGHT ILLUMINATED , ENGINE SURGED AND RAN ROUGH. *TS THE VEHICLE ALSO STALLED. THE DEALER ATTEMPTED TO RESOLVE THE PROBLEM BUT EACH TIME THE PROBLEM RECURRED. *NM
Crash:
No
Fire:
No
Injuries:
0
Deaths:
0
#10155424April 16, 2006
ENGINE AND ENGINE COOLING:ENGINE:DIESEL
F250 6.0 POWERSTROKE STALLS, MISSES, AND LOSES ALL POWER. FORD DEALER HAS NO IDEA OF WHAT COULD BE CAUSING PROBLEM. HAVE BEEN UNABLE TO REPAIR. CHANGED EGR VALVE AND A COUPLE OF OTHER SENSORS. NO CHANGE. *NM
Crash:
No
Fire:
No
Injuries:
0
Deaths:
0
#10155369April 14, 2006
ENGINE AND ENGINE COOLING:ENGINE:DIESEL
PURCHASED NEW 2004 F250 6.0L TURBO DIESEL. SINCE PURCHASE, HAVE REPEATEDLY EXPERIENCED INTERMITTENT SURGING, STUMBLING, & STALLING. HAVE RETURNED VEHICLE NUMEROUS TIME WITH NO TROUBLE FOUND. SUBSEQUENT RECALL CAME OUT AND WAS PERFORMED IN SEPTEMBER 2005. INTENT OF RECALL WAS TO ADDRESS STATED PROBLEMS. STARTED EXPERIENCING PROBLEM AGAIN IN FEBRUARY OF 2006. SHOP VISIT ON 12 APRIL 2006 REVEALED EGR?? PROBLEM, AND WAS REPLACED. PROBLEMS REAPPEARED THE NEXT MORNING. WILL TAKE TO THE SHOP FOR ANOTHER ROUND!! *NM
Crash:
No
Fire:
No
Injuries:
0
Deaths:
0
#10155275April 13, 2006
STRUCTURE:BODY:TAILGATE:HINGE AND ATTACHMENTS
DT*: THE CONTACT STATED WHILE LEANING ON THE TAILGATE TO RAISE THE CAP DOOR, THE TAILGATE CAME OPEN. THE TRUCK WAS PARKED ON AN INCLINE AND THE LUMBER IN THE TRUCK CAME CRASHING OUT ONTO THE CONSUMER'S RIGHT FOOT SPRAINING IT. PRIOR TO THE FAILURE THE TAILGATE MADE RATTLING SOUNDS WHILE DRIVING AT ANY SPEED. THE POLICE WERE NOT CONTACTED AND THE MANUFACTURER HAS NOT BEEN ALERTED. UPDATED 5/10/2006 - *NM
Crash:
No
Fire:
No
Injuries:
1
Deaths:
0
#10154739April 6, 2006
STEERING
WHEN PULLING THE TRUCK FORWARD AFTER BACKING UP, THERE IS A POPPING NOISE COMING FROM THE LEFT FRONT STEERING MECHANISM AS I DRIVE FORWARD. I HAVE TAKEN THE TRUCK TO FORD SERVICE ON MULTIPLE OCCASIONS AND THEY INDICATED THAT NO PROBLEM EXISTED. I CALLED THE FORD MOTOR COMPANY IN DEARBORN MICHIGAN FOR HELP, BUT THEY INDICATED THE NOISE WAS NORMAL AND NO OTHER COMPLAINTS HAD BEEN FILED. I WOULD LIKE SOMEONE TO LOOK INTO THIS AS I FEEL IT IS A STEERING COMPONENT ISSUE AND A POSSIBLE SAFETY ITEM. THE POPPING NOISE IS TRANSMITTED AND MANIFESTS THROUGH THE STEERING WHEEL, AND AS AN EXPERIENCED PROFESSIONAL TRUCK DRIVER I UNDERSTAND THAT THIS CANNOT BE A NORMAL SITUATION AS FORD WOULD LIKE ME TO BELIEVE. *NM
Crash:
No
Fire:
No
Injuries:
0
Deaths:
0
#10153578March 24, 2006
POWER TRAIN:AUTOMATIC TRANSMISSION
WHILE ACCELERATING FROM A TRAFFIC LIGHT, THE TRANSMISSION BEGAN SHIFTING WILDLY. PULLED OVER, RESTARTED AND TRANSMISSION BEGAN SHIFTING UP AND DOWN AGAIN WITH A SERIOUS LOSS OF POWER. VEHICLE WAS LIMPED UNDER ITS OWN POWER BACK TO THE DEALER WITH THE TRANSMISSION ACTING AS IF IT WOULD FAIL AT ANY TIME. DEALER FOUND AND REPLACED A SOLENOID AND WIRING HARNESS SHORTING TO THE TRANSMISSION PAN. *JB
Crash:
No
Fire:
No
Injuries:
0
Deaths:
0

← Back to Ford F-250