Ford F-150 Complaints (2006)

585 consumer complaints on file.

#10664843December 17, 2014
SEATS
THE SEAT GETS WHOLE BECAUSE OF MEDAL BAR AND NOT ENOUGH CUSHION ON THE SIDE OF IT SO CAUSES IT HOLES. *TR
Crash:
No
Fire:
No
Injuries:
0
Deaths:
0
#10663810December 12, 2014
FUEL/PROPULSION SYSTEM
TL* THE CONTACT OWNS A 2006 FORD F-150. THE CONTACT STATED THAT WHILE DRIVING AT 60 MPH, THE VEHICLE STALLED. THE VEHICLE RESTARTED BUT THE FAILURE RECURRED ON NUMEROUS OCCASIONS. THE VEHICLE WAS TAKEN TO A DEALER FOR DIAGNOSTIC TESTING. THE TECHNICIAN DIAGNOSED THAT THE FUEL PUMP CONTROL MODULE NEEDED TO BE REPLACED. THE VEHICLE WAS REPAIRED. THE MANUFACTURER WAS MADE AWARE OF THE FAILURE. THE FAILURE MILEAGE WAS 87,000. THE VIN WAS UNAVAILABLE.
Crash:
No
Fire:
No
Injuries:
0
Deaths:
0
#10663594December 11, 2014
FUEL/PROPULSION SYSTEM
VEHICLE SUDDENLY STALLED WHILE DRIVING. WAS ABLE TO COAST TO A STOP AND PULLED OVER, BUT WAS STUCK IN A BUSY INTERSECTION FOR 15-20 MINUTES BEFORE THE TRUCK WOULD RESTART. WAS ABLE TO MAKE IT TO A PARKING LOT BEFORE IT STALLED AGAIN. TOWED TO A DEALERSHIP WAS INFORMED IT WAS A CORRODED FUEL CONTROL MODULE. DOING A LITTLE RESEARCH CONFIRMED THIS IS A VERY COMMON PROBLEM AND SHOULD BE ADDRESSED AS A POTENTIALLY DANGEROUS SITUATION COULD EASILY OCCUR. *TR
Crash:
No
Fire:
No
Injuries:
0
Deaths:
0
#10653874November 10, 2014
ENGINE
WHILE DRIVING THE FORD 2006 F150 IT JUST STARTED RUNNING SLUGGISH AND STOPPED. I WAS ABLE TO GET OFF THE SIDE OF THE ROAD. *TR
Crash:
No
Fire:
No
Injuries:
0
Deaths:
0
#10644608October 14, 2014
POWER TRAIN:DRIVELINE:DIFFERENTIAL UNIT
TL* THE CONTACT OWNS A 2006 FORD F-150. WHILE MAKING A TURN AT AN UNKNOWN SPEED, THE VEHICLE BEGAN TO SHAKE VIOLENTLY. THE DEALER STATED THAT THE REAR DIFFERENTIAL FLUID NEEDED TO BE REFILLED. THE FLUID WAS REPLENISHED, BUT THE FAILURE RECURRED. THE VEHICLE WAS TAKEN TO AN INDEPENDENT MECHANIC. THE TECHNICIAN STATED THAT THE REAR DIFFERENTIAL NEEDED TO BE REPLACED. THE VEHICLE WAS NOT REPAIRED. THE MANUFACTURER WAS NOTIFIED. THE APPROXIMATE FAILURE MILEAGE WAS 110,678.
Crash:
No
Fire:
No
Injuries:
0
Deaths:
0
#10644239October 13, 2014
FUEL/PROPULSION SYSTEM
PART #4L3Z 9D370 A (CONTROL UNIT) THIS IS THE FUEL PUMP DRIVER MODULE ON A 2006 FORD F150 THAT FAILED BECAUSE THE SHELL THAT HOLDS THE MICRO CHIPS RUSTED OUT. THIS SHOULD BE NOTED TO FORD MOTOR COMPANY BECAUSE IS A COMMON PROBLEM IN COLD WEATHER STATES. P.S. REPAIR COST AT FORD DEALERSHIP $458.78. *TR
Crash:
No
Fire:
No
Injuries:
0
Deaths:
0
#10643030October 7, 2014
POWER TRAIN:AUTOMATIC TRANSMISSION
TL* THE CONTACT OWNS A 2006 FORD F-150. THE CONTACT STATED THAT UPON TRAVELING OVER APPROXIMATELY 40 MPH ATTEMPTING TO ACCELERATE, THE VEHICLE HESITATED. THE VEHICLE WAS TAKEN TO AN INDEPENDENT MECHANIC. THE TECHNICIAN DIAGNOSED THAT THE TRANSMISSION NEEDED TO BE REPLACED. THE VEHICLE WAS REPAIRED BUT THE FAILURE RECURRED. THE VEHICLE WAS TAKEN TO AN AUTHORIZED DEALER WHO DIAGNOSED THAT THE SPARK PLUGS NEEDED TO BE REPLACED. THE VEHICLE WAS NOT REPAIRED. THE MANUFACTURER WAS NOTIFIED OF THE FAILURE. THE APPROXIMATE FAILURE MILEAGE WAS 92,000.
Crash:
No
Fire:
No
Injuries:
0
Deaths:
0
#10641346October 3, 2014
STEERING
MY STEERING WHEEL IS STIFF. AND HARD TO TURN THE MECHANIC SAID IT IS A RECALLED RACK AND PINION. *TR
Crash:
No
Fire:
No
Injuries:
0
Deaths:
0
#10637941September 22, 2014
ENGINE
ENGINE HAD BLOWN A PLUG OUT ABOUT 300 MILES AGO ON THE NUMBER 3 WAS REPAIRED WITH REPAIR KIT NEW PLUG AND COIL WAS PUT ON. WAS TRAVELING STARTED UP HILL ENGINE BEGAN TO MISS DROVE 20 MILES TO DESTINATION HAD TRUCK TESTED AT ADVANCE AUTO PARTS READOUT STATED MISFIRE ON CYLINDER 1 AND 3 AND BAD COIL ON 3. REPLACED COIL 3 AGAIN TOOK TO MECHANIC HIS COMPUTER READ OUT WAS NUMBER 8 COIL WAS BAD REPLACED IT ENGINE CONTINUED TO MISS TOOK IT TO THE MECHANIC HE CHANGED ALL THE PLUGS THE 2ND PLUG ON DRIVERS SIDE WAS LOOSE AND READY TO BLOW OUT AND HE TOOK THE NUMBER 3 PLUG OUT THAT HAD BEEN REPLACED PRIOR THE WHOLE BOTTOM OF PLUG WAS MELTED COULD HAVE RESULTED IN A FIRE LOOKED DOWN IN ENGINE WITH CAMERA THE PISTON WAS DESTROYED. THIS PROBLEM IS FROM THE FACTORY INSTALLED PLUG BLOWING OUT AND FRAGMENTS GOING INTO ENGINE. NOW I HAVE TO REPLACE MY ENGINE 2500 OUT OF MY POCKET D/T POOR HEAD DESIGN FORD IS WELL AWARE OF THIS PROBLEM AND REFUSES ANY ASSISTANCE FORD ACTUALLY HAS EXCLUDED BLOWN PLUG REPAIR FROM THEIR WARRANTY. WHEN YOU PURCHASE A NEW VEHICLE YOU EXPECT TO GET MORE THAN 106000 MILES. *TR
Crash:
No
Fire:
No
Injuries:
0
Deaths:
0
#10637355September 18, 2014
TIRES, STEERING
TL* THE CONTACT OWNS A 2006 FORD F-150. WHILE DRIVING APPROXIMATELY 45 MPH, THE STEERING WHEEL SHOOK VIOLENTLY WITHOUT WARNING. THE FAILURE OCCURRED MULTIPLE TIMES. THE VEHICLE WAS TAKEN TO AN INDEPENDENT MECHANIC. THE TECHNICIAN STATED THAT THE TIRES NEEDED TO BE REPLACED AND ALIGNED. THE VEHICLE WAS REPAIRED, BUT THE FAILURE RECURRED. THE MANUFACTURER WAS NOT NOTIFIED OF THE FAILURE. THE APPROXIMATE FAILURE MILEAGE WAS 92,270.
Crash:
No
Fire:
No
Injuries:
0
Deaths:
0
#10637048September 17, 2014
ENGINE
VEHICLE STARTED MISSING AND BUCKING. BROUGHT INTO MECHANIC AND WAS TOLD THIS IS A VERY COMMON PROBLEM WITH TRITON 5.4L ENGINE. NEEDS SPARK PLUG CHANGE AND CHANCES ARE THEY WILL BREAK OFF IN ENGINE WHILE CHANGING (WHICH 5 OUT OF 8 DID). TOTAL COST A SHAMEFUL $800 (ESTIMATE WAS BETWEEN $600-$1200). MECHANIC PULLED OUT MANY PRIOR INVOICES FROM OWNERS WITH THE EXACT SAME ISSUE. THE SPARK PLUGS IN THESE ENGINES SHOULD BE RECALLED. *TR
Crash:
No
Fire:
No
Injuries:
0
Deaths:
0
#10631076September 5, 2014
ELECTRICAL SYSTEM
THE ELECTRIC WINDOWS AND DOOR LOCKS AND MIRROR ADJUSTMENTS ALL STOPPED WORKING ON MY 2006 F150. AFTER DOING SOME LOOKING I FOUND THAT THE WIRE HARNESS THAT RUNS TO THE DOOR HAS MOST OF THE WIRES BROKEN OR BREAKING IN HALF THUS LEAVING BARE WIRES EXPOSED AND A POSSIBLE FIRE HAZARD THE WAY IT LOOKS TO ME. *TR
Crash:
No
Fire:
No
Injuries:
0
Deaths:
0
#10629943September 1, 2014
ENGINE, ELECTRICAL SYSTEM, UNKNOWN OR OTHER
WENT TO STOP FOR TRAFFIC LIGHT APPLIED THE BRAKES AND VEHICLE TOOK OFF///////SLAMMED ON BRAKES TO TRY TO STOP AND SLAMMED IN PARK .CAME WITH IN INCHES OF CRASHING INTO CAR IN FRONT OF ME. TODAY IS SEPT.1ST HAVE NOT DRIVEN TRUCK AGAIN////// CALL FORD CORP. THEY WILL NOT PAY TO CHECK OUT TRUCK. AT 3100 MILES HAD TO REPLACE TIRES. ORIG. HAD DRY ROT,,,,,, *TR
Crash:
No
Fire:
No
Injuries:
0
Deaths:
0
#10629110August 28, 2014
VEHICLE SPEED CONTROL
TL* THE CONTACT OWNS A 2006 FORD F-150. WHILE APPROACHING A TRAFFIC LIGHT, THE VEHICLE SUDDENLY ACCELERATED WITHOUT WARNING. THE CONTACT APPLIED EXCESSIVE FORCE TO THE BRAKE PEDAL, BUT IT FAILED TO STOP THE VEHICLE. THE CONTACT HAD TO RAPIDLY SHIFT THE GEAR INTO PARK IN ORDER TO STOP THE ENGINE FROM REVVING. THE FAILURE OCCURRED MULTIPLE TIMES. THE VEHICLE WAS TAKEN TO THE DEALER FOR DIAGNOSTIC TESTING, BUT THE CAUSE OF THE FAILURE COULD NOT BE DETERMINED. THE VEHICLE WAS NOT REPAIRED AND THE MANUFACTURER WAS NOTIFIED. THE APPROXIMATE FAILURE MILEAGE WAS 3,200.
Crash:
No
Fire:
No
Injuries:
0
Deaths:
0
#10625815August 17, 2014
ENGINE
ENGINE STARTED MAKING A LOUD NOISE UPON INSPECTION OF ENGINE FOUND THAT THE BACK SPARK PLUG ON PASSENGER SIDE HAD BLOWN OUT FROM HEAD AND OF COURSE STRIPPED THE TREADS FROM THE HEAD THE SPARK PLUGS ARE THE ONES THAT CAME FROM FACTORY THEY HAVE NEVER BEEN REMOVED OR REPLACED VEHICLE WAS PURCHASED NEW AFTER REVIEWING INFORMATION ON THE INTERNET THIS SEEMS TO BE A MAJOR PROBLEM WITH FORDS 4.6 AND 5.4 ENGINE AS WELL AS RESULTING IN FIRES AND CONSIDERING FORD MAKES A REPAIR KIT. IF THIS HAS EFFECTED THIS MANY VEHICLE SHOULDN'T FORD FOOT THE BILL. *TR
Crash:
No
Fire:
No
Injuries:
0
Deaths:
0
#10622576August 15, 2014
STRUCTURE:BODY, SERVICE BRAKES, VEHICLE SPEED CONTROL
GAS AND BRAKE PEDAL ARE TOO CLOSE TOGETHER. YOU COULD STILL BE GIVING IT GAS WHILE YOU ARE PUSHING ON THE BRAKES. I SEE HUNDREDS OF COMPLAINTS ABOUT THIS ONLINE.I WAS PULLING INTO A PARKING SPOT WHEN I THOUGHT I WAS APPLYING THE BRAKES THE OTHER HALF OF MY FOOT WAS ON THE GAS CAUSING ME TO JUMP THE CURB AND CRASH INTO A WALL. *TR
Crash:
Yes
Fire:
No
Injuries:
0
Deaths:
0
#10618695August 4, 2014
ENGINE
TL* THE CONTACT OWNS A 2006 FORD F-150. THE CONTACT STATED THAT WHILE DRIVING UPHILL, THERE WAS A ENGINE MISFIRE. THE VEHICLE WAS TAKEN TO A DEALER WHERE THE VEHICLE WAS REPAIRED. THE FAILURE RECURRED. THE MANUFACTURER WAS NOT MADE AWARE OF THE FAILURE. THE FAILURE MILEAGE WAS 50,000.
Crash:
No
Fire:
No
Injuries:
0
Deaths:
0
#10617765July 30, 2014
FUEL SYSTEM, GASOLINE
TRUCK STUTTERED & STALLED, WOULD NOT RESTART. TOWED FORD TO DEALER. FAILURE CAUSED BY CORRODED, CRACKED FUEL PUMP MODULE. THE MODULE BODY IS MADE OF AN ALLOY METAL MATERIAL, AND THE MODULE IS BOLTED DIRECTLY TO THE STEEL FRAME NEAR THE GAS TANK, MOISTURE AND DIS-SIMILAR METALS (ELECTROLYSIS) CAUSED RAPID DETERIORATION OF MODULE BODY. THIS POOR DESIGN CAUSES THE VEHICLE TO SHUT DOWN AT ANY SPEED/SITUATION, LOSS OF POWER STEERING & BRAKES WOULD OCCUR. RESULT COULD BE DEATH OF OCCUPANTS OR THOSE PERSONS AROUND TRUCK WHEN ENGINE SHUT DOWN OCCURS *TR
Crash:
No
Fire:
No
Injuries:
0
Deaths:
0
#10615804July 23, 2014
SERVICE BRAKES
AS A PART OF REGULAR MAINTENANCE I ALWAYS HAVE WELL IN ADVANCE PERFORMED SCHEDULED MAINTENANCE ON MY 06 F-150.ON AUG 23 2013 I HAD MY ROTORS AND BRAKE PADS ALL REPLACED AS WELL AS HAVING A HI PRESSURE BRAKE FLUID CHANGE PERFORMED AS PART OF THIS AS SUGGESTED BY THE BILL CURRIE FORD DEALERSHIP IN TAMPA. THE TRUCK HAD 83,996 MILES ON IT AT THIS TIME OF SERVICE. THE TRUCK WAS RARELY DRIVEN AFTER THAT AND USED ONLY ON SHORT TRIPS.OF 10-20 MILES OR LESS AFTER HAVING THE BRAKES SERVICED. FRIDAY JULY 18TH 2014..THE TUCK HAD ONLY APPROX. 2000 ADDITIONAL MILES ON IT AFTER THE BRAKES WERE SERVICED AT BILL CURRIE FORD.I AND A FRIEND WERE DRIVING TO PICKUP A WASHING MACHINE ABOUT 30 MILES AWAY. WITHOUT WARNING. UPON RETURNING THE RIGHT WHEEL BEGAN PULLING TO THE RIGHT AND SMOKE AND A RUBBER AND PLASTIC SMELL ACCOMPANIED BY SMOKE STARTING RISING FROM THE RIGHT WHEEL WELL WHICH WAS SCOTCHING HOT. THE HEAT WAS SO INTENSE THAT WHEN WE STOPPED THE PLASTIC WHEEL COVER FELL OFF BECAUSE ITS WAS MELTED.IT WAS TAKEN TO THE DEALERSHIP WERE THE ORIGINAL WORK WAS PERFORMED. I WAS INFORMED IT WAS THE CALIPER,THAT IT HAD SEIZED AND THAT AFTER ALREADY HAVING REPLACED THE FRONT ROTOR SEVERAL THOUSAND MILES BEFORE//THE RIGHT ROTOR AND CALIPER AND BRAKE LINE WOULD NOW HAVE TO BE REPLACED AGAIN..BECAUSE THEY SAID.."WE CAN'T TELL WHEN A CALIPER WILL FAIL". NOW IT HAS COST ME $2,300,00 TO GET MY BRAKES DONE..WHEN INITIALLY THEY WERE STILL IN SAFE LIMITS.WE WERE LUCKY THIS DIDN'T CAUSE A FIRE OR CAUSE THE TIRE TO BLOW OUT WHILE ON THE HIGHWAY. *TR
Crash:
No
Fire:
No
Injuries:
0
Deaths:
0
#10610729July 15, 2014
FUEL/PROPULSION SYSTEM
UPON ATTEMPTING TO START MY 2006 FORD F150 SUPER CREW CAB VEHICLE (5.4L), THE ENGINE WILL ATTEMPT TO CRANK OVER BUT WILL NOT TURN ON. UPON FURTHER DIAGNOSIS, IT WAS DETERMINED THAT THE FUEL PUMP MODULE IS NOT WORKING. IT BECAME COMPLETELY RUSTY AND EXHIBITS HOLES THROUGHOUT THE SURFACE OF THE MODULE. THIS APPEARS TO BE AN EXTREMELY COMMON PROBLEM THAT FORD IS VERY WELL AWARE OF AND HAS NOT ADDRESSED THE PROBLEM. I THINK A CIVIL CLASS ACTION LAWSUIT SHOULD HELP THEM WITH THEM MAKE THE RIGHT DECISION TO REPAIR THE MODULE AT NO COST TO THE CONSUMER. THIS IS AN EXTREMELY FRUSTRATING ISSUE THAT FORD HAS KNOWN ABOUT FOR SEVERAL YEARS. UPON SPEAKING WITH FORD DIRECTLY, I WAS ADVISED THAT THEIR HAS BEEN RECALLS FOR THAT EXACT PART BUT NOT FOR THE 2006 FORD F150. COMPLETELY UNACCEPTABLE AND INEXCUSABLE. THIS WILL BE MY LAST FORD PURCHASE. I'VE BEEN A FORD MAN ALL MY LIFE. NOT ANYMORE.... *TR
Crash:
No
Fire:
No
Injuries:
0
Deaths:
0

← Back to Ford F-150