Ford F-150 Complaints (2001)

1,236 consumer complaints on file.

#10508263April 15, 2013
ELECTRICAL SYSTEM
TL* THE CONTACT OWNS A 2001 FORD F-150. THE CONTACT STATED THAT WHILE PARKED AND OCCUPIED, THE VEHICLE BECAME ENGULFED IN FLAMES. THE FIRE AND POLICE DEPARTMENT REPORTED TO THE SCENE AND FILED A REPORT. THE MANUFACTURER WAS NOT MADE AWARE OF THE FAILURE. THE CAUSE OF THE FIRE WAS UNDETERMINED. THE VEHICLE WAS DESTROYED. THE APPROXIMATE FAILURE MILEAGE WAS 250,000. *TR
Crash:
No
Fire:
Yes
Injuries:
0
Deaths:
0
#10505343April 2, 2013
VEHICLE SPEED CONTROL
TL* THE CONTACT OWNS A 2001 FORD F-150. THE CONTACT STATED THAT WHILE PARKED, THE VEHICLE IGNITED IN FLAMES AND WAS COMPLETELY DESTROYED. THE FIRE DEPARTMENT EXTINGUISHED THE FIRE AND INFORMED THE CONTACT THAT THE FIRE ORIGINATED FROM THE SPEED CONTROL DEACTIVATION SENSOR. THE VEHICLE REMAINED AT THE CONTACT'S RESIDENCE FOR FURTHER INVESTIGATION. THE CONTACT STATED THAT THE FAILURE COINCIDED WITH THE CONSEQUENCE MENTIONED IN NHTSA CAMPAIGN ID NUMBER 05V388000 (VEHICLE SPEED CONTROL), IN WHICH THE CONTACT'S VEHICLE WAS INCLUDED. THE CONTACT HAD NOT RECEIVED THE RECALL REPAIRS AT THE TIME OF THE FAILURE. THE APPROXIMATE FAILURE MILEAGE WAS 130,000.
Crash:
No
Fire:
Yes
Injuries:
0
Deaths:
0
#10504891March 28, 2013
ENGINE
TURNED INTO A GROCERY STORE PARKING LOT AND TRUCK STARTED TO SMOKE. I THOUGHT IT WAS OVER HEATING BUT WHEN I PARKED I GOT OUT AND THE TRUCK STARTED HAVING BLACK SMOKE THEN FLAMES CAME FROM THE DRIVER SIDE OF THE HOOD OVER THE TIRE. I CALLED 911. WHEN THE FIRE TRUCKS ARRIVED THE HOOD WAS IN FLAMES AND THE FRONT OF THE TRUCK WAS BURNED. I AM THE ORIGINAL OWNER OF THE TRUCK AND HAVE TOOK VERY GOOD CARE OF IT. SOMEONE THAT WORKS WITH MY SON HAD AN F150 THAT BURNED 6 MONTHS AGO. AFTER WE LOOKED UP THE INFORMATION ABOUT THIS I FOUND OUT THIS HAS HAPPENED ALOT. I ALSO FOUND A RECALL ON A PART FOR THE CRUISE CONTROL BUT I WAS NEVER INFORMED OF THIS. HOW ARE PEOPLE INFORMED OF RECALLS? I LIVED A THE SAME ADDRESS FOR 7 YEARS AND HAD THE SAME PHONE NUMBER. THE DEALER I BOUGHT THE TRUCK FROM PALMETTO FORD IN CHARLESTON SC HAS BEEN AROUND FOR A LONG TIME. I DON'T UNDERSTAND WHY I WAS NOT INFORMED. IF I HAD NOT GOT OUT I WOULD HAVE BURNED WITH THE TRUCK. IS IT THE OWNER RESPONSIBILITY TO CHECK FOR RECALLS. I WOULD UNDERSTAND IF I WAS NOT THE ORIGINAL OWNER BUT I AM. *TR
Crash:
No
Fire:
Yes
Injuries:
0
Deaths:
0
#10503962March 21, 2013
ENGINE
TL* THE CONTACT OWNS 2001 FORD F150. THE CONTACT STATED THAT WHILE PARKED, THE VEHICLE CAUGHT ON FIRE FROM UNDER THE HOOD AREA AND EXPLODED. AS A RESULT, THE CONTACT'S HOME ALSO CAUGHT ON FIRE FROM THE VEHICLE FIRE. THE FIRE WAS EXTINGUISHED BY THE LOCAL FIRE DEPARTMENT AND A FIRE REPORT WAS FILED. A RESIDENT SUFFERED FRO SMOKE INHALATION. THE VEHICLE WAS NOT INSPECTED AND REMAINED PARKED AT THE CONTACT'S RESIDENCE. THE MANUFACTURER WAS NOT MADE AWARE OF THE FAILURE. THE APPROXIMATE FAILURE AND CURRENT MILEAGE WAS 164,800.
Crash:
No
Fire:
Yes
Injuries:
1
Deaths:
0
#10503856March 20, 2013
ENGINE, ELECTRICAL SYSTEM
I KEEP HAVING MAJOR ISSUES WITH MY TRUCK EJECTING SPARK PLUGS FROM THE ENGINE WHICH IS BREAKING NOT ONLY MY SPARK PLUGS BUT MY COIL PACK AS WELL. THIS IS REDICULIOUS. THE FIRST TIME I WAS AT A LIGHT AT A DEAD STOP WHEN I HEAR A LOUD BANGING NOISE LIKE SOMETHING EXPLODED THEN MY TRUCK STARTED RUNNING ROUGH AND HAD TO GET IT TOWED. IT STRANDED US 45 MINUTES FROM HOME. THE SECOND TIME WAS TWO DAYS AGO ON MARCH 18 I WAS DRIVING THROUGH A DRIVE THRU AGAIN AT A DEAD STOP AND HEARD A LOUD NOISE AND HAD THE SAME ISSUE. AGAIN MY SPARK PLUG WAS EJECTED AND COIL PACK BROKEN. THE FIRST TIME WAS IN CYLINDER 1 AND WAS REPAIRED THEN ONE MONTH LATER THE NEXT TIME CYLINDER 2 EJECTED. 5 MINUTES AFTER IT WAS REPAIRED AND HAD NEW PLUG AND COIL PACK IT AGAIN EJECTED. IM UPSET BECAUSE I CAN NO LONGER DRIVE MY TRUCK. IF FORD DOESNT FIX THIS I WILLNEVER PURCHASE ANOTHER FORD. NOW IT IS USELESS SITTING IN MY GARAGE TAKIN UP SPACE. *TR
Crash:
No
Fire:
No
Injuries:
0
Deaths:
0
#10496631February 6, 2013
ELECTRICAL SYSTEM
TL* THE CONTACT OWNS A 2001 FORD F-150. THE CONTACT STATED THAT WHILE PARKED, THE VEHICLE BECAME ENGULFED IN FLAMES. THE POLICE AND FIRE DEPARTMENT REPORTED TO THE SCENE AND A REPORT WAS FILED. THE CAUSE OF THE FIRE WAS NOT DETERMINED. THE VEHICLE WAS DESTROYED. THE APPROXIMATE FAILURE MILEAGE WAS 170,000.
Crash:
No
Fire:
Yes
Injuries:
0
Deaths:
0
#10495080January 29, 2013
SEAT BELTS
TL* THE CONTACT OWNS A 2001 FORD F-150. THE CONTACT STATED THAT BOTH THE FRONT DRIVER AND PASSENGER SIDE SEATBELT BUCKLES WOULD UNLATCH INDEPENDENTLY. THE VEHICLE WAS REPAIRED UNDER NHTSA CAMPAIGN ID NUMBER: 01V227001 (SEAT BELTS) IN 2001. THE FAILURE RECURRED RECENTLY. THE VEHICLE WAS NOT REPAIRED. THE MANUFACTURER WAS NOTIFIED OF THE PROBLEM. THE APPROXIMATE FAILURE MILEAGE WAS 96,000.
Crash:
No
Fire:
No
Injuries:
0
Deaths:
0
#10493172January 16, 2013
FUEL/PROPULSION SYSTEM
TL* THE CONTACT OWNS A 2001 FORD F-150. THE CONTACT STATED THAT THE VEHICLE WAS PREVIOUSLY REPAIRED UNDER THE RECALL ASSOCIATED WITH NHTSA CAMPAIGN ID NUMBER 11V385000 (FUEL SYSTEM, GASOLINE:STORAGE:TANK ASSEMBLY:MOUNTING). THE SAME DAY AS THE REPAIR WAS PERFORMED, THE FUEL TANK BEGAN TO LEAK GASOLINE FUEL. THE FAILURE RECURRED AFTER THE REMEDY REPAIR. THE CONTACT PLANNED TO TAKE THE VEHICLE TO AN AUTHORIZED DEALER FOR FURTHER ASSESSMENT. THE MANUFACTURER WAS NOT NOTIFIED OF THE PROBLEM. THE FAILURE MILEAGE WAS UNAVAILABLE.
Crash:
No
Fire:
No
Injuries:
0
Deaths:
0
#10488933December 16, 2012
STRUCTURE:BODY
AT APPROXIMATELY 50+ MPH THE FRONT OF THE CAR SHAKES. THIS HAS BEEN GOING ON FOR ALMOST OVER AN YEAR. I TOOK IT TO THE DEALERSHIP, SAID NOTHING IS WRONG. IT STARTS TO SHAKE SO BAD THAT YOU HAVE TO LET UP ON THE ACCELERATOR AND ALMOST STOP, BEFORE YOU FEEL SAFE ENOUGH TO CONTINUE ON. SHAKING IS THE WORSE FOR THE FIRST 3 MILES AT THE START OF THE DAY BUT NEVER SEEMS TO COMPLETELY GOES AWAY. *TR
Crash:
No
Fire:
No
Injuries:
0
Deaths:
0
#10487862December 10, 2012
FUEL/PROPULSION SYSTEM
TL* THE CONTACT OWNS A 2001 FORD F-150. THE CONTACT WAS DRIVING APPROXIMATELY 15 MPH AND HEARD A SCRAPING NOISE FROM UNDER THE VEHICLE. THE CONTACT DISCOVERED THAT THE FUEL TANK HAD COMPLETELY DETACHED FROM THE VEHICLE AND BOTH FUEL TANK STRAPS WERE SEVERELY CORRODED. THE VEHICLE WAS TAKEN TO AN INDEPENDENT MECHANIC FOR DIAGNOSIS WHERE THEY ADVISED THAT BOTH STRAPS AND THE FILLER HOSE WERE COMPLETELY CORRODED AND NEEDED TO BE REPLACED. THE VEHICLE WAS REPAIRED AND THE FILLER HOSE WAS BANDAGED. APPROXIMATELY THREE MONTHS LATER THE CONTACT RECEIVED NOTIFICATION OF NHTSA CAMPAIGN ID NUMBER 11V385000 (FUEL SYSTEM, GASOLINE:STORAGE:TANK ASSEMBLY:MOUNTING). THE VEHICLE WAS SERVICED PER THE RECALL AND IMMEDIATELY AFTER, THE CONTACT REFUELED THE VEHICLE, NOTICED GASOLINE LEAKING FROM THE VEHICLE. THE DEALER WAS LATER CONTACTED AND ADVISED HIM THAT THE FUEL TANK WAS FAULTY. THE MANUFACTURER WAS CONTACTED BUT OFFERED NO ASSISTANCE. THE FAILURE MILEAGE WAS APPROXIMATELY 161,344. THE CURRENT MILEAGE WAS APPROXIMATELY 166,000.
Crash:
No
Fire:
No
Injuries:
0
Deaths:
0
#10487346December 4, 2012
SEAT BELTS
TL* THE CONTACT OWNS A 2001 FORD F-150. THE CONTACT STATED THAT THE DRIVER AND PASSENGER SIDE SEAT BELTS WOULD NOT LATCH. THE CONTACT DID NOT TAKE THE VEHICLE TO THE DEALER OR A MECHANIC TO HAVE THE SEAT BELTS INSPECTED. THE CONTACT CALLED THE MANUFACTURER AND FILED A COMPLAINT. THE FAILURE MILEAGE WAS 142,000.
Crash:
No
Fire:
No
Injuries:
0
Deaths:
0
#10482233October 25, 2012
FUEL/PROPULSION SYSTEM
THIS IS REGARDING THE RECALL FOR THE STRAPS HOLDING THE GAS TANK ON THE FORD F150 . FORD REPLACED THE STRAPS IN FEB. OF 2012, BUT NEVER SAID ANYTHING ABOUT THE CORROSION ON THE GAS TANK THAT WAS CAUSED FROM THE FAULTY STRAPS.. A FEW MONTHS AFTER THE REPAIR THE GAS TANK STARTED TO LEAK DUE TO THE RUST WHERE THE STRAPS WERE. I BROUGHT THE VEHICLE BACK TO MY FORD DEALERSHIP AND THEY TOLD ME THAT THE GAS TANK WAS NOT WARRANTEED UNDER THE RECALL. THIS IS RATHER CONFUSING. IF THE FAULTY STRAPS WHICH FORD AGREED TO REPLACE CAUSED THE GAS TANK TO RUST AND LEAK, WHY WOULD THIS NOT BE INCLUDED IN THE RECALL?? THE FAULTY STRAPS CAUSED THE CORROSION OF THE GAS TANK. THIS IS CLEARLY EXPLAINED IN THE NHTSA WEBSITE. I WAS FORCED TO ACCEPT AFTERMARKET PARTS IN ORDER TO AVOID THE FULL PRICE OF APPROXIMATELY $2,000 FOR REPAIR. IT IS OBVIOUS THAT I AM NOT THE ONLY FORD 150 OWNER WHO HAS BEEN FORCED TO REPLACE THEIR CORRODED GAS TANK DUE TO DEFECTIVE STRAPS ON FORD'S PART. WE ALL KNOW A LEAKY GAS TANK IS THE RECIPE FOR DISASTER - DEATH. MY FINAL COST WAS $540 - ONLY BECAUSE I AGREED TO USE AFTERMARKET PARTS. THIS ENTIRE SITUATION IS A DISGRACE. I AM CONSIDERING BRINGING THIS MATTER TO THE ATTENTION OF THE MEDIA. SHAME ON FORD. *TR
Crash:
No
Fire:
No
Injuries:
0
Deaths:
0
#10480794October 17, 2012
SERVICE BRAKES
TRUCK STARTING PULLING BADLY TO RIGHT, LOSS OF POWER, SPEED AND SMOKE COMING FROM THE RIGHT FRONT WHEEL. RIM, CALIPER WERE SMOKING , HAD TO POUR WATER ON TO WHEEL TO KEEP FROM BURNING. AFTER TOWED TO SERVICE CENTER WAS TOLD THIS IS A COMMON PROBLEM WITH THE FORD TRUCKS THAT THE SLIDE PIN ON THE CALIPER CAN SEIZE AND LOCK THE BRAKE IN ACTIVE POSITION PREVENTING IT FROM RELEASING FROM THE ROTOR CAUSING THE EXTREME HEAT AND BURNING THE BRAKE BAD AND SEALS IN THE CALIPER. I WAS LUCKY IT DIDN'T HAPPEN AT 70 MPH AND LOCK THE WHEELCAUSING ME TO LOSE CONTROL. I VE ALSO LOOKED AT THE REPORTS ON THE INTERNET AND SEE WHERE OTHERS HAVE REPORTED THIS IN BLOG BUT NOW TO SAFETY COMMISSION. *TR
Crash:
No
Fire:
No
Injuries:
0
Deaths:
0
#10480700October 16, 2012
FUEL SYSTEM, GASOLINE:STORAGE:TANK ASSEMBLY:MOUNTING
TL* THE CONTACT OWNS A 2001 FORD F-150. THE CONTACT STATED THAT THE FUEL TANK HAD RUSTED AND STARTED TO LEAK. THE VEHICLE WAS TAKEN TO THE DEALER FOR REPAIRS UNDER NHTSA CAMPAIGN ID NUMBER: 11V385000 (FUEL SYSTEM, GASOLINE: STORAGE: TANK ASSEMBLY: MOUNTING). THE CONTACT MENTIONED THAT ALTHOUGH THE TANK WAS LEAKING AT THE TIME OF THE REPLACEMENT OF THE STRAPS THE MANUFACTURER REFUSE TO COVER THE FUEL TANK REPLACEMENT SINCE IT WAS NOT INCLUDED IN THE RECALL. THE VEHICLE WAS NOT REPAIRED. THE FAILURE AND CURRENT MILEAGE WAS 140,000. UPDATED 02/20/13*LJ
Crash:
No
Fire:
No
Injuries:
0
Deaths:
0
#10480190October 15, 2012
STRUCTURE:FRAME AND MEMBERS:UNDERBODY SHIELDS
THE FRAME IS STARTING TO RUST OUT ON MY 2001 F150. WHY IS THEIR NOT A RECALL. I KNOW THAT I CAN,T BE THE ONLY ONE WITH THIS PROBLEM. TOYOTA IS REPLACING SOME OF THEIR FRAME THAT ARE RUSTING OUT. *TR
Crash:
No
Fire:
No
Injuries:
0
Deaths:
0
#10477414September 28, 2012
SEATS
TL* THE CONTACT OWNS A 2001 FORD F150. THE CONTACT STATED THAT THE VEHICLE WAS NOT EQUIPPED WITH BRACKETS OR A LATCH SYSTEM IN THE REAR SEAT IN ORDER TO SECURE A CHILD SEAT. THE MANUFACTURER WAS MADE AWARE OF THE FAILURE. THE VEHICLE WAS NOT REPAIRED. THE VIN WAS NOT AVAILABLE. THE FAILURE AND THE CURRENT MILEAGE WAS 140,000.
Crash:
No
Fire:
No
Injuries:
0
Deaths:
0
#10476766September 22, 2012
STRUCTURE:BODY, ELECTRICAL SYSTEM
CAR WAS SITTING IN DRIVEWAY FOR AROUND 30 -45 MINUTES THEN JUST SET FIRE. *TR
Crash:
No
Fire:
Yes
Injuries:
0
Deaths:
0
#10473685September 4, 2012
ELECTRICAL SYSTEM, EXTERIOR LIGHTING
REAR LIGHTS, INCLUDING BRAKE, TURN SIGNALS, AND HAZARD LIGHTS QUIT WORKING. THIS ISSUE CAN BE FOUND ON MANY ONLINE FORD F-150 FORUMS. THE STEERING COLUMN WIRING IS TOO SHORT, AND BREAKAGE IN THE WIRE, OR CONNECTORS CAN OCCUR WITH THE TILT STEERING MECHANISM. THE TILT STEERING MECHANISM AND SHORT WIRING HAS CAUSED THE CONNECTION TO BREAK INSIDE THE STEERING COLUMN TRIM ON OUR VEHICLE, WHICH CAUSED THE LIGHTS TO STOP FUNCTIONING PROPERLY. I INSPECTED THE PROBLEM, AND FOUND THE CONNECTOR CAN MOVE FREELY. I FEEL THIS IS AN ISSUE SINCE I AM ABLE TO LOCATE MANY OTHERS THAT HAVE HAD THE SAME ISSUE FROM 1997 UP TO 2001 FORD F-150S. *TR
Crash:
No
Fire:
No
Injuries:
0
Deaths:
0
#10473231August 31, 2012
STRUCTURE:FRAME AND MEMBERS:UNDERBODY SHIELDS, SUSPENSION, WHEELS
ITS NOT WHAT HAPPENED ITS WHAT MAY HAPPEN SOON THE RUST IS SO BAD IN THE REAR I CANT EVEN PUT A TRAILER HITCH ON AND THE REAR SHACKLES THAT HOLD THE LEAF SPRINGS ON ARE ABOUT TO BREAK OFF THERES SO MUCH RUST IM VERY CONCERNED. *TR
Crash:
No
Fire:
No
Injuries:
0
Deaths:
0
#10468426July 31, 2012
STRUCTURE:BODY
THE RADIATOR SUPPORT BRACKET BENEATH THE RADIATOR RUSTED THROUGH LEAVING THE RADIATOR WITH VIRTUALLY NO SUPPORT. THE SUPPORT BRACKET HAD TO BE REPLACED AND WELDED IN PLACE... *TR
Crash:
No
Fire:
No
Injuries:
0
Deaths:
0

← Back to Ford F-150