Ford F-150 Complaints (2006)

585 consumer complaints on file.

#10993883June 8, 2017
SERVICE BRAKES, ENGINE, FUEL/PROPULSION SYSTEM
FORD F150 XLT 2006 SHOULD HAVE A MANDATORY SAFETY RECALL FOR THE FUEL CONTROL MODULE. THIS IS CLEARLY A DESIGN DEFECT AND A MAJOR SAFETY CONCERN. I WAS DRIVING DOWN VT116 (A HILLY, WINDING 2 LANE COUNTRY HIGHWAY WITH NO SHOULDER) IN THE RAIN AT ABOUT 40MPH WHEN MY TRUCK STARTED TO BUCK AND LOSE POWER. THERE WAS NO PLACE TO PULL OVER, SO I PUT MY HAZARDS ON AND TRIED TO LIMP IT TO A SAFE PLACE TO PULL OVER. THE ENGINE STALLED AND I LOST STEERING AND BRAKING POWER ON A CURVE. I APPLIED THE BRAKES MANUALLY AND WRESTLED THE STEERING WHEEL (WHICH NO LONGER HAD ANY POWER ASSIST). WITH MAJOR DIFFICULTY, I WAS ABLE TO BRING THE TRUCK TO A CONTROLLED STOP. I WAS THEN ABLE TO RESTART THE ENGINE, LIMPED ALONG AT 15MPH, BUCKING AND STALLING 3 MORE TIMES BEFORE GETTING TO A SAFE PLACE TO PULL OVER. THIS IS THE SECOND TIME I HAVE HAD MY FCM REPLACED (PRIOR WAS 1/5/2013) AND THE SECOND TIME I ALMOST CRASHED MY TRUCK BECAUSE OF THIS DEFECT. THE PREVIOUS TIME WAS JANUARY 2013 ON A MOUNTAIN ROAD IN WINTER ON SNOW. IF I WAS TOWING MY BOAT ON THE INTERSTATE AND LOST ALL POWER, I WOULD PROBABLY HAVE BEEN KILLED ALONG WITH ANYONE AROUND ME. WHY IS IT A DESIGN DEFECT? BECAUSE THIS ELECTRONIC COMPONENT IS INSTALLED IN A WEATHER-EXPOSED AREA ABOVE THE SPARE TIRE AND IS NOT CORROSION-PROOF. IN ANY RUST BELT STATE (OR A PLACE EXPOSED TO SALT), THE CASE WILL CORRODE, EXPOSING THE CIRCUIT BOARD TO WATER, CAUSING THE UNIT TO FAIL. WHY IS IT A SAFETY CONCERN? BECAUSE WHEN THE FCM FAILS, THE ENGINE WILL STALL, CAUSING A LOSS OF POWER TO THE STEERING AND BRAKING SYSTEMS. NHTSA SHOULD FORCE FORD TO DO A MANDATORY RECALL AND REDESIGN THIS POORLY DESIGNED PART. EVEN THE REPLACEMENT PARTS FAIL AFTER A FEW YEARS. CONSIDERING HOW MANY F150'S ARE ON THE ROAD AND HOW MANY OF THEM CARRY OR TOW HEAVY LOADS, I'D SAY THIS SHOULD BE A TOP PRIORITY FOR BOTH FORD AND NHTSA. RECALL!
Crash:
No
Fire:
No
Injuries:
0
Deaths:
0
#10984888May 11, 2017
AIR BAGS
TL* TAKATA RECALL. THE CONTACT OWNED A 2006 FORD F-150. WHILE DRIVING DURING INCLEMENT WEATHER (DOWNPOUR), THE VEHICLE HYDROPLANED AND FLIPPED OVER SEVERAL TIMES. THE VEHICLE ALSO WENT INTO A DITCH, WHICH IMPACTED THE FRONT AND REAR OF THE VEHICLE. THE STEERING WHEEL BENT IN HALF AND FRACTURED INTO THE ENGINE OFF OF THE MOUNTING BOLTS. NONE OF THE AIR BAGS DEPLOYED. THE CONTACT SUSTAINED BACK PAINS, HEAD INJURY, AND LEG PAINS, WHICH REQUIRED MEDICAL TREATMENT. THE VEHICLE WAS TOWED BY THE INSURANCE COMPANY WHO INDICATED THAT THE VEHICLE WAS DESTROYED. A POLICE REPORT WAS FILED. THE INSURANCE COMPANY PROVIDED NO REASON AS TO WHY THE AIR BAGS FAILED TO DEPLOY. THE DEALER STATED THAT THERE WERE NO AIR BAG RECALLS. THE MANUFACTURER WAS NOTIFIED AFTER THE CRASH HAPPENED TO DETERMINE IF THEY MAY BE ABLE TO INVESTIGATE THE FAILURE. THE FAILURE MILEAGE WAS NOT AVAILABLE.
Crash:
Yes
Fire:
No
Injuries:
1
Deaths:
0
#10980370April 25, 2017
SERVICE BRAKES
MY ABS BRAKE SYSTEM FAILED. THE LIGHT FOR ABS CAME ON AND THE BRAKES FAILED TO INGAGE ON A DRY ROAD. I HAD TO VEAR OFF THE ROAD TO AVOID ANOTHER TRUCK MAKING A TURN. THIS HAPPENED AGAIN WITH A CAR INFRONT OF ME, BEFORE I GOT HOME AND PARKED THE TRUCK. THE BRAKES SHUTTER ON PRESSING THEM AND THEN FAIL TO INGAUGE. I HAD THE PROBLEM FIXED IN GOODYEAR AZ AT THE FIRD DEALER FOR OVER 800 DOLLARS AND NOW THE PROBLEM BEGAN AGAIN. I LIVE IN LAKESIDE ARIZONA AND CANT DRIVE THE TRUCK BACK TO THAT DEALER WITHOUT FEAR OF DYING ON THE SIDE OF A CLIFF IR IN A BAD ACCIDENT BECAUSE MY BRAKES FAIL TO STOP THE VEHICLE AND BRAKES ARE NEEDED TO GO THROUGH THE MOUNTSINS TO GET TO THAT DEALER. VERY UPSET THAT I BOUGHT THIS TRUCK FROM CACTUS JACKS IN PHOENIX AZ. 560 DOLLARS A MONTH FOR A TRUCK I CANT DRIVE FOR MY SMALL FARM. I WOULD LIKE TO TRADE IN TBIS TRUCK FOR ONE I CAN TRUST THAT WONT BE THE DEATH OF ME OR MY FAMILY.
Crash:
No
Fire:
No
Injuries:
0
Deaths:
0
#10979677April 20, 2017
ENGINE, SERVICE BRAKES
TL* THE CONTACT OWNS A 2006 FORD F-150. WHILE DRIVING 45 MPH, THE FRONT OF THE VEHICLE SHOOK VIOLENTLY, THE ENGINE NEARLY STALLED AND LOST POWER REPEATEDLY, AND THE CHECK ENGINE INDICATOR ILLUMINATED INTERMITTENTLY. THE VEHICLE ALSO BRAKED INDEPENDENTLY. THE VEHICLE WAS TAKEN TO AN UNCERTIFIED MECHANIC WHO DIAGNOSED THAT THE ENGINE WAS HAVING MULTIPLE MISFIRES, AND DID NOT KNOW HOW TO REPAIR THE VEHICLE. THE CONTACT ALSO CALLED A DEALER WHO WAS EXTREMELY RUDE AND DID NOT ASSIST. THE VEHICLE WAS NOT REPAIRED. THE MANUFACTURER WAS MADE AWARE OF THE FAILURE. THE CONTACT WAS INFORMED THAT THEY WOULD NOT ASSIST BECAUSE THE CLAIMS DEADLINE HAD BEEN MISSED. THE APPROXIMATE FAILURE MILEAGE WAS 128,000.
Crash:
No
Fire:
No
Injuries:
0
Deaths:
0
#10967978March 23, 2017
AIR BAGS
TL* THE CONTACT OWNS A 2006 FORD F-150. THE CONTACT STATED THAT WHILE ATTEMPTING TO START THE VEHICLE, THE AIR BAG WARNING LIGHT ILLUMINATED. THE WARNING LIGHT FLICKERED INTERMITTENTLY AND THEN REMAINED ILLUMINATED. THE VEHICLE WAS NOT TAKEN TO A DEALER OR INDEPENDENT MECHANIC. THE VEHICLE WAS NOT DIAGNOSED OR REPAIRED. THE MANUFACTURER WAS NOT MADE AWARE OF THE FAILURE. THE APPROXIMATE FAILURE MILEAGE WAS 63,000.
Crash:
No
Fire:
No
Injuries:
0
Deaths:
0
#10948553January 30, 2017
FUEL/PROPULSION SYSTEM, FUEL SYSTEM, GASOLINE:DELIVERY:FUEL PUMP
FUEL PUMP CONTROL MODULE CORROSION CAUSING ENGINE TO STALL AND NOT RESTART WHILE DRIVING ON SECONDARY ROAD. *TR
Crash:
No
Fire:
No
Injuries:
0
Deaths:
0
#10937998December 28, 2016
TRACTION CONTROL SYSTEM
TL* THE CONTACT OWNED A 2006 FORD F-150. WHILE DRIVING APPROXIMATELY 5 TO 6 MPH AND TURNING LEFT, THE VEHICLE SLID ON WET PAVEMENT AND CRASHED INTO A WALL. THE AIR BAGS DID NOT DEPLOY. A POLICE REPORT WAS FILED. THE CONTACT WAS INJURED AND REQUIRED MEDICAL ATTENTION. THE VEHICLE WAS DESTROYED AND TOWED. THE MANUFACTURER WAS NOT NOTIFIED. THE APPROXIMATE FAILURE MILEAGE WAS 110,000.
Crash:
Yes
Fire:
No
Injuries:
1
Deaths:
0
#10937392December 25, 2016
SERVICE BRAKES, ENGINE, STEERING
WAS DRIVING MY 2006 F-150 OVER A MOUNTAIN PASS IN CANADA. THERE WAS COMPACT SNOW AND ICE ON THE ROADWAY AND I WAS TRAVELING WITH OTHER VEHICLES AROUND ME AT APPROXIMATELY 40 MPH. THE VEHICLES AHEAD OF ME BEGAN TO BRAKE, I AS WELL TRIED TO BRAKE ONLY TO FIND MY TRUCK HAD LOST POWER AND WAS NO LONGER RUNNING. I HAD LOST POWER TO MY BRAKES AND STEERING. THIS CAUSED MY TRUCK TO BEGIN SLIDING ON THE SNOW AND ICE AND I WAS UNABLE TO CONTROL MY VEHICLE. THE CARS AROUND ME WERE SLOWING AND STOPPING AND I COULD NOT. I BEGAN TO FISH TAIL IN BOTH DIRECTIONS WHILE TRYING DESPERATELY TO CONTROL MY TRUCK WITH NO BRAKES OR POWER STEERING, I EVENTUALLY DID A COMPLETE 360 DEGREE SPIN AND SOMEHOW MANAGED TO GET THE TRUCK UNDER CONTROL WITH OUT ROLLING OVER AND INTO THE DITCH OR SMASHING INTO THE OTHER VEHICLES AROUND ME. WHEN I CAME TO A STOP MY TRUCK WAS NOT RUNNING AND THE DASH LIGHTS WERE ON. I PLACED THE TRANSMISSION INTO DRIVE AND RESTARTED THE TRUCK WITHOUT ISSUE AND CONTINUED ON WITHOUT ISSUE. THIS IS THE SECOND TIME THIS HAS HAPPENED WITH THIS TRUCK, THE FIRST TIME I WAS ON A RESIDENTIAL STREET AND I WAS ABLE TO JUST COAST TO A STOP AND RESTARTED THE TRUCK. THIS LAST INCIDENT ON THE MOUNTAIN PASS HAS CONFIRMED TO ME THAT I WILL NOT OWN ANOTHER FORD AS I HAVE RESEARCHED THIS PROBLEM TO FIND THAT THIS IS A COMMON ISSUE WITH FORD TRUCKS. I AM CERTAIN THIS HAS CAUSED MAJOR ACCIDENTS IF NOT DEATHS AND THE FACT THERE ARE NO ERROR CODES LEFT BEHIND FROM THE EVENTS TO VERIFY THIS HAS HAPPENED WE MAY NEVER KNOW. THE FACT IT HAS HAPPENED TO ME TWICE AND ONCE ONLY A MIRACLE A SERIOUS ACCIDENT DIDN'T OCCUR I AM DONE WITH THE FORD MOTOR COMPANY. *TR
Crash:
No
Fire:
No
Injuries:
0
Deaths:
0
#10934613December 12, 2016
AIR BAGS, STRUCTURE:BODY, ELECTRICAL SYSTEM
TL* THE CONTACT OWNS A 2006 FORD F-150. AFTER TAKING THE VEHICLE TO A DRIVE THRU CAR WASH SERVICE, WATER ENTERED THE PASSENGER SIDE. THE INTERIOR OF THE PASSENGER SIDE BECAME WET AND THE AIR BAG WARNING INDICATOR ILLUMINATED INTERMITTENTLY. THE VEHICLE WAS NOT DIAGNOSED OR REPAIRED. THE MANUFACTURER WAS NOTIFIED OF THE FAILURE. THE APPROXIMATE FAILURE MILEAGE WAS 98,000.
Crash:
No
Fire:
No
Injuries:
0
Deaths:
0
#10929707December 3, 2016
ENGINE
I WAS DRIVING ON THE ROAD WHEN THE "ENGINE FAILSAFE WARNING' LIGHT CAME ON. THE ENTIRE ENGINE SHUT DOWN. NO POWER AT ALL. VERY HARD TO STOP AND STEER. I NEARLY GOT INTO AN ACCIDENT. ANOTHER TIME I WAS ENTERING PARKING LOT WHEN IT HAPPENED. I HAD THE THROTTLE BODY REPLACED TO FIX THE PROBLEM. BUT SHUTTING OFF THE ENGINE ON A WARNING WHILE DRIVING IS VERY DANGEROUS. SOME INTERNET RESEARCH INDICATES THIS IS NOT A LONE OCCURRENCE.
Crash:
No
Fire:
No
Injuries:
0
Deaths:
0
#10917391October 19, 2016
ENGINE, VEHICLE SPEED CONTROL
TL* THE CONTACT OWNS A 2006 FORD F-150. THE CONTACT STATED THAT THE VEHICLE WOULD SHOOK WHENEVER THE VEHICLE WAS IDLING. THE SHAKING INCREASED DURING ACCELERATION. THE CONTACT TOOK THE VEHICLE TO A DEALER WHO WAS UNABLE TO IDENTIFY THE CAUSE OF THE FAILURE, BUT INFORMED THE CONTACT THAT THE SHAKING WAS A COMMON ISSUE WITH THE YEAR, MAKE, AND MODEL. THE VEHICLE WAS NOT REPAIRED AND THE FAILURE RECURRED. THE MANUFACTURER WAS NOT MADE AWARE OF THE FAILURE. THE APPROXIMATE FAILURE MILEAGE WAS 111,000.
Crash:
No
Fire:
No
Injuries:
0
Deaths:
0
#10915674October 12, 2016
ENGINE
TOOK TRUCK IN FOR ROUTINE 100,000 MAINTENANCE AND TUNE UP. SPARK PLUG STUCK IN THE CYLINDER HEAD AND ENDED UP GETTING CHARGED $3,500 FOR THE REPAIR. I AM READING ONLINE OF HOW WIDESPREAD THIS PROBLEM IS AND FORD SHOULD RECALL THESE SPARK PLUGS AND TAKE CARE OF THEIR CUSTOMERS. I WILL NEVER PURCHASE ANOTHER FORD IN MY LIFETIME IF THEY DON'T DO SOMETHING ABOUT THIS.
Crash:
No
Fire:
No
Injuries:
0
Deaths:
0
#10910800September 30, 2016
ENGINE
TL* THE CONTACT OWNS A 2006 FORD F-150. WHILE DRIVING 8 MPH, THE VEHICLE STALLED WITHOUT WARNING AFTER A SHARP RIGHT TURN. THE CHECK ENGINE INDICATOR ILLUMINATED. THE VEHICLE WAS TAKEN TO BE REPAIRED, BUT THE ISSUE RECURRED. THE MANUFACTURER WAS MADE AWARE OF THE ISSUE. THE FAILURE MILEAGE WAS 158,818.
Crash:
No
Fire:
No
Injuries:
0
Deaths:
0
#10909520September 25, 2016
STRUCTURE:BODY, ENGINE, STEERING
POWER STEERING HOSE RUST AND LEAKING-TRANSMISSION HOSES RUSTED AND LEAKING - SPARK PLUG BREAKING OFF WHEN HAVING THEM REPLACED
Crash:
No
Fire:
No
Injuries:
0
Deaths:
0
#10908094September 20, 2016
SERVICE BRAKES
WAS SITTING AT A RESTAURANT DRIVE THRU WITH FOOT ON THE BRAKE WHEN THE BRAKE PEDAL SUDDENLY WENT TO THE FLOOR AND THE TRUCK STARTED MOVING. I WAS ABLE TO GET THE VEHICLE HOME AND BACK TO THE FORD DEALERSHIP THE NEXT MORNING VERY CAREFULLY AND BY PUMPING THE BRAKES TO GET THE VEHICLE TO STOP. WAS TOLD THAT THE BRAKE LINE HAD RUPTURED. LUCKILY, I WAS NOT TOWING MY 6000 POUND BOAT OR GOING DOWNHILL AT THE TIME OF THE FAILURE. I ASKED IF THIS WAS COMMON SINCE BRAKE LINES ARE NOT AN ITEM THAT ARE ROUTINELY INSPECTED OR REPLACED ON A NORMAL 17 POINT INSPECTION. I WAS TOLD THAT IT WAS UNCOMMON. I GOOGLED THE PROBLEM AND DISCOVERED THAT SEVERAL OTHER FORD F150 OWNERS OF VARIOUS MODEL YEARS HAD EXPERIENCED THE SAME ISSUE. LUCKILY, THERE HAVE BEEN NO REPORTS OF DEATHS OR SEVERE INJURY, BUT I AM REPORTING THIS TO HOPEFULLY PREVENT A DEATH FROM OCCURRING.
Crash:
No
Fire:
No
Injuries:
0
Deaths:
0
#10888942July 27, 2016
ENGINE
VEHICLE JERKED WHEN DRIVING DOWN HIGHWAY WHEN YOU REACH 45 TO 50 MPH. I WOULD LET OFF GAS AND THEN GIVE IT GAS AGAIN AND IT WOULD NOT JERK. CHECK ENGINE LIGHT APPEARED SO I TOOK IT TO FORD DEALERSHIP AND THEY RUN A CHECK . TOLD ME I NEED ANOTHER MOTOR. THIS TRUCK HAS 154000MILES. IT HAS NOT OVERHEATED.
Crash:
No
Fire:
No
Injuries:
0
Deaths:
0
#10885909July 19, 2016
SUSPENSION
I JUST HAD MY TRUCK SERVICED AT SAYVILLE FORD & THEY FOUND TWO BROKEN FRONT SPRINGS. THE TRUCK HAS 142000 MILES. I CANT FIND ANY RECALL INFO ON NHTSA. CAN YOU ADVISE ME IF THIS IS A CURRENT PROBLEM BEING INVESTIGATED?
Crash:
No
Fire:
No
Injuries:
0
Deaths:
0
#10884754July 14, 2016
ELECTRICAL SYSTEM
TL* THE CONTACT OWNS A 2006 FORD F-150. WHILE DRIVING 15 MPH, THE VEHICLE MADE A LOUD POPPING NOISE AND THE INSTRUMENT PANEL BECAME INOPERABLE. IN ADDITION, THE REAR WINDOWS AND POWER LOCKS FAILED TO OPERATE AND THE VEHICLE STALLED. THE VEHICLE WAS NOT DIAGNOSED OR REPAIRED. THE MANUFACTURER WAS NOT MADE AWARE OF THE FAILURES. THE FAILURE MILEAGE WAS 150,000.
Crash:
No
Fire:
No
Injuries:
0
Deaths:
0
#10882727July 5, 2016
AIR BAGS
TL* THE CONTACT OWNS A 2006 FORD F-150. WHILE DRIVING APPROXIMATELY 55 MPH, TWO DEER JUMPED IN THE MIDDLE OF THE ROAD. THE CONTACT SLAMMED ON THE BRAKE PEDAL TO AVOID THE ANIMALS. AS A RESULT, THE VEHICLE DROVE INTO A DITCH AND ROLLED OVER THREE TIMES. NONE OF THE FRONTAL AIR BAGS DEPLOYED. A POLICE REPORT WAS NOT FILED AND THERE WERE NO INJURIES REPORTED. THE MANUFACTURER WAS NOT NOTIFIED OF THE FAILURE. THE VEHICLE WAS TOWED AND WAS BEING EVALUATED BY THE INSURANCE COMPANY. THE VEHICLE WAS NOT REPAIRED. THE APPROXIMATE FAILURE MILEAGE WAS 114,000.
Crash:
Yes
Fire:
No
Injuries:
0
Deaths:
0
#10882756July 5, 2016
ENGINE
TOOK IN FOR A TUNE UP. BROKE OFF 7 SPARK PLUGS. GOT PIECE IN ENGINE. HAD TO TAKE ENGINE APART. TUNE UP WAS TO BE $535. NOW IT IS $2300.00
Crash:
No
Fire:
No
Injuries:
0
Deaths:
0

← Back to Ford F-150