Ford F-150 Complaints (2004)

2,029 consumer complaints on file.

#11023776September 16, 2017
UNKNOWN OR OTHER
VEHICLE FRAME RUSTED OUT ON BOTH SIDES. COULD NOT PASS PA. INSPECTION.
Crash:
No
Fire:
No
Injuries:
0
Deaths:
0
#11022872September 12, 2017
ENGINE, POWER TRAIN, UNKNOWN OR OTHER
TRUCK DIED, LOST ALL POWER WHILE DRIVING DOWN THE ROAD. THIS HAS HAPPENED 5 - 6 TIMES THROUGH THE YEARS STARTING AROUND 2010. SOMETIMES DRIVING DOWN FREEWAY SOMETIMES DRIVING SLOWLY INTO DRIVEWAY. BATTERY WAS CHECKED, IT WAS OKAY AND CONNECTED FINE. VARIOUS OTHER ENGINE PROBLEMS LATER INCLUDE A RATTLE NOISE AND LOW RPM. RUNNING HOT, CHUGGING ALONG LIKE RUNNING OUT OF GAS, ETC. HAVING TO PULL OVER TILL IT COULD GO AGAIN. CURRENTLY JUST A LITTLE OVER 100,000 MILES.
Crash:
Yes
Fire:
No
Injuries:
1
Deaths:
0
#11022064September 7, 2017
ENGINE
WHILE DRIVING THE VEHICLE AT HIGHWAY SPEEDS - RPMS ON ENGINE BEGIN TO FLUCTUATE BETWEEN 2000 AND 750. AT NEXT STOP, ENGINE DIES, BUT WILL IMMEDIATELY RESTART. NO ENGINE MALFUNCTION CODES WHEN CHECKED WITH AN OBD II READER, AND THE CHECK ENGINE LIGHT DOES NOT ILLUMINATE.
Crash:
No
Fire:
No
Injuries:
0
Deaths:
0
#11015066August 14, 2017
ELECTRICAL SYSTEM
TL* THE CONTACT OWNED A 2004 FORD F-150. WHILE THE VEHICLE WAS PARKED IN THE DRIVEWAY, A NEIGHBOR ALERTED THE CONTACT THAT THE VEHICLE WAS ON FIRE. THERE WERE NO WARNING INDICATORS ILLUMINATED PRIOR TO THE FIRE. THE FIRE DEPARTMENT ARRIVED AND EXTINGUISHED THE FIRE. A FIRE REPORT WAS FILED. THERE WERE NO INJURIES. THE VEHICLE WAS TOTALED. THE DEALER AND THE MANUFACTURER WERE NOT CONTACTED. THE FAILURE MILEAGE WAS APPROXIMATELY 150,000.
Crash:
No
Fire:
Yes
Injuries:
0
Deaths:
0
#11010812July 26, 2017
FUEL/PROPULSION SYSTEM
FUEL TANK LEAKS PROFUSELY AFTER BEING FILLED PAST HALF WAY ABOUT 11 GALLONS
Crash:
No
Fire:
No
Injuries:
0
Deaths:
0
#11005226July 14, 2017
ENGINE, UNKNOWN OR OTHER, EXTERIOR LIGHTING
TO BEGIN WITH I HAD TO HAVE ALL 4 WINDOWS REPAIRED. THE MECHANISM THAT RAISES AND LOWERS THE WINDOWS BROKE. SINCE THIS WAS BOUGHT AS A USED VEHICLE, THERE WAS NO WARRANTY. SO I PD. $150. TO $175.00 EACH. WAS TOLD FORD KNEW OF THIS PROBLEM BUT SINCE IT WASN'T A "SAFETY FACTOR" NO RECALL WAS ISSUED. I FEEL LIKE THIS IS QUITE UNFAIR TO THE CONSUMER. WE PURCHASE A VEHICLE THAT HAS A GOOD REPUTATION AND THEN ARE TOLD THAT THIS EXPENSE IS OUR BABY TO TAKE CARE OF. I FEEL LIKE THIS WAS VERY UNFAIR TO THIS CONSUMER. I HAVE PURCHASED FORDS FOR YEARS WITH NO COMPLAINTS UNTIL NOW. ALSO, THE HEADLIGHTS DEVELOPED A LEAK AND FILLED WITH WATER THUS SHORTING OUT MY RIGHT HEADLIGHT,AND IS SLOWLY DOING THE SAME TO THE LEFT ONE. I HAVE BEEN TOLD THAT JUST THE BURNED OUT BULBS CANNOT BE REPLACED,THAT THE WHOLE ASSEMBLY HAD TO BE REPLACED AND THIS IS AT A COST OF APPROX. $175 TO $200. PER ASSEMBLY. THIS IS OUTRAGEOUS. ALSO,THERE IS A PROBLEM WITH WHAT USED TO BE "POINTS & PLUGS" WHICH ARE NOW A "COIL" ASSEMBLY. THIS PROBLEM DEVELOPED APPROX. 6 MONTHS AGO. ACCORDING TO THE READOUTS I HAVE GOTTEN, THE #1 PLUG IS MISFIRING APPROX. EVERY 1,000 REVOLUTIONS WHICH CAUSES A MISS IN THE ENGINE AND WAS VERY ALARMING TO ME SINCE I WAS ON THE HIGHWAY ABOUT 200-250 MILES FROM HOME, TRAVELING BY MYSELF. SO, ANOTHER EXPENSE IS LOOMING. I REALIZE THERE ARE EXPENSES TO OWNING A VEHICLE. I DO NOT EXPECT TO NOT HAVE ANY PROBLEMS OR REPAIRS WITH MY VEHICLE,BUT I DID NOT ANTICIPATE THIS MANY. NOR DID I EXPECT THE COST OF THE REPAIR PARTS ALONE TO BE SO OUTRAGEOUS. I AM ON A FIXED INCOME AND HAD I ANTICIPATED THESE PROBLEMS I WOULDN'T & #8203; HAVE MADE THIS PURCHASE. I TRULY LOVE MY TRUCK, BUT IS THERE ANYWAY THESE OTHER REPAIRS CAN BE DONE FOR A LESSER AMT? I'VE ALREADY PD. TO REPLACE MOTOR & ROTORS IN ALL 4 WINDOWS. ANY HELP YOU CAN GIVE ME WOULD BE GREATLY APPRECIATED. THANK YOU. [XXX] ('PARTS OF THIS DOCUMENT HAVE BEEN REDACTED TO PROTECT PERSONALLY IDENTIFIABLE INFORMATION PURSUANT TO THE FREEDOM OF INFORMATION ACT (FOIA), 5 U.S.C. 552(B)(6).'
Crash:
No
Fire:
No
Injuries:
0
Deaths:
0
#11003911July 9, 2017
STEERING
WHILE DRIVING MY STEERING LOCKED UP BECAUSE THE STEERING SHAFTS LOCKED UP. CAUSING ME TO WRECK MY TRUCK.
Crash:
Yes
Fire:
No
Injuries:
0
Deaths:
0
#11002683July 2, 2017
ENGINE, UNKNOWN OR OTHER
COMPLETE ENGINE FAILURE LESS THAN 100,000 MILES. DRIVER AND FRONT PASSENGER WINDOW MOTOR FAILURE.
Crash:
No
Fire:
No
Injuries:
0
Deaths:
0
#11000332June 21, 2017
STEERING
WHILE DRIVING HOME I MADE A RIGHT TURN ON TO MY STREET AND THEN THE WHEEL SPUN ALL TGE WAY TO THE LEFT. I HAD NO CONTROL OF STEERING AND THE TRUCK HIT A GUARD RAIL. STEERING WHEEL DOESN'T TURN THE TIRES AT ALL NOW. THE STEERING WAS STIFF BEFORE ACCIDENT. I BELIEVE THAT THE RACK AND PINION SNAPPED. TRUCK IS A TOTAL LOSE. NO RECALLS FROM FORD FOR MY VIN.
Crash:
Yes
Fire:
No
Injuries:
0
Deaths:
0
#10995486June 16, 2017
STRUCTURE:BODY
I HAVE A 2004 FORD F-150 XL EXTENDED CAB PICK UP WITH 140,000 MILES. I RECENTLY PURCHASED NEW TIRES AND AN EXHAUST . DROPPED OF THE TRUCK AT THE MECHANIC TO HAVE ITEMS INSTALLED. RECEIVED A CALL THE NEXT MORNING THAT THERE WAS A PROBLEM, SO WENT IN TO SEE WHAT THE ISSUE WAS. TURNS OUT THE FRAME OF THE TRUCK HAS ROTTED ON BOTH THE PASSENGER AND DRIVERS SIDE, WHERE THE BED MEETS THE CAB. WHEN THEY TRIED TO LIFT THE TRUCK TO INSTALL THE TIRES THE TRUCK DIDN'T MOVE, THE LIFT JUST STARTED CRUSHING THROUGH THE FRAME RAIL. QUITE DEVASTATING NEWS TO RECEIVE SINCE THE TRUCK RUNS AND DRIVES GREAT, BUT IS NOW A BIG HUNK OF SCRAP. WORRISOME ALSO AS I HAD JUST TAKEN MY FAMILY ON A 7 HOUR TRIP IN THE TRUCK A MONTH EARLIER AND HATE TO CONSIDER WHAT COULD HAVE HAPPENED IF WE HAD BEEN INVOLVED IN AN ACCIDENT. I FEEL THAT IN THIS DAY AND AGE A 13 YEAR OLD TRUCK SHOULD NOT EXPERIENCE THIS ISSUE AND THE MANUFACTURER SHOULD STEP UP AND TAKE SOME RESPONSIBILITY FOR THEIR PRODUCT. BUILT FORD TOUGH. YEAH, RIGHT.
Crash:
No
Fire:
No
Injuries:
0
Deaths:
0
#10993749June 7, 2017
STRUCTURE:BODY
TL* THE CONTACT OWNS A 2004 FORD F-150. THE CONTACT STATED THAT THE REAR DRIVER SIDE FRAME OF THE VEHICLE WAS RUSTED OUT NEAR THE FUEL TANK. THE CONTACT TOOK THE VEHICLE TO THE LANGLEY FORD DEALER WHO STATED THAT THE VEHICLE WAS NOT INCLUDED IN ANY RECALL REGARDING THE FRAME. THE VEHICLE WAS NOT OFFICIALLY DIAGNOSED OR REPAIRED. THE MANUFACTURER WAS MADE AWARE OF THE FAILURE AND CONFIRMED THE DEALER'S INFORMATION. THE APPROXIMATE FAILURE MILEAGE WAS 124,000. UPDATED 08/09/17*LJ *TR
Crash:
No
Fire:
No
Injuries:
0
Deaths:
0
#10993498June 6, 2017
POWER TRAIN, STEERING
TL* THE CONTACT OWNS A 2004 FORD F-150. THE CONTACT STATED THAT THE STEERING SHAFT LOCKED UP SEVERAL TIMES. IN ADDITION, THE OEM PART FOR THE SHIFTER CABLE WAS BLACK AND NOW IT WAS PLASTIC WITH A COATED METAL. THE CONTACT WAS UNCERTAIN IF THE CHANGE OF THE OEM PART WAS STRUCTURALLY SOUND BECAUSE THE SHIFT CABLE HAD TO BE REPLACED MORE THAN ONCE. THE MANUFACTURER WAS NOTIFIED OF THE FAILURE AND PROVIDED NO SOLUTION. THE VIN WAS UNKNOWN. THE APPROXIMATE FAILURE MILEAGE WAS 211,240.
Crash:
No
Fire:
No
Injuries:
0
Deaths:
0
#10991722May 25, 2017
ENGINE
ON 5/21/08 SPARK PLUG # 3 POPPED OUT WHILE I WAS DRIVING DOWN THE FREEWAY I HAD IT REPAIRED. THEN ON 1/8/13 SPARK PLUG #3 CAME OUT OF MY 2004 FORD F150 AND I TOOK MY TRUCK TO FORD . WHEN THEY WERE REPLACING THE THREADS ON #3, #5 POPPED OUT SO THEY REPLACED THE HELIX COILS ON IT AS WELL. IN APRIL MY TRUCK START HAVING THE SAME ISSUE WITH THE # 1 SPARK PLUS. THIS DOES NOT SEEM LIKE SOMETHING THAT SHOULD JUST HAPPEN. THERE SHOULD HAVE BEEN A RECALL ON THIS A LONG TIME AGO.
Crash:
No
Fire:
No
Injuries:
0
Deaths:
0
#10985703May 15, 2017
SEAT BELTS, ELECTRICAL SYSTEM:SOFTWARE, FUEL/PROPULSION SYSTEM, ENGINE
TL* THE CONTACT OWNS A 2004 FORD F-150. THE CONTACT STATED THAT THE VEHICLE EXPERIENCED STALLING WITHOUT WARNING. IN ADDITION, THE SEAT BELT WOULD NOT LATCH. THE DEALER DIAGNOSED THAT THE VEHICLE'S SOFTWARE NEEDED TO REFLASHED. THE VEHICLE WAS REPAIRED, BUT THE FAILURE RECURRED. THE CONTACT HAD THE ENGINE REPLACED AFTER IT WAS DIAGNOSED THAT THERE WAS WATER IN THE OIL PAN AND A FUEL ROD FAILURE. THE FAILURE RECURRED. THE MANUFACTURER WAS NOTIFIED OF THE FAILURES. THE VEHICLE WAS REPAIRED. THE FAILURE MILEAGE WAS APPROXIMATELY 50,000.
Crash:
No
Fire:
No
Injuries:
0
Deaths:
0
#10984213May 8, 2017
AIR BAGS
TAKATA RECALL I WAS IN A ACCIDENT LAST WEEK. NONE OF MY AIRBAGS DEPLOYED IT WAS A FRONT END ACCIDENT WHICH RESULTED IN THE WINDSHIELD AND NEARLY ALL GALSS BEING BROKEN AS WELL AS THE OTHER VEHICLES AIRBAGS DEPLOYING. NOT A SINGLE AIRBAG IN MY VEHICLE DEPLOYED. I WAS DOING APPROXIAMATELY 43 MPH AND THE OTHER VEHICLE PULLED OUT IN FRONT OF ME CAUSING ME TO T-BONE THE OTHER VEHICLE. NONE OF MY AIRBAGS DEPLOYED.
Crash:
Yes
Fire:
No
Injuries:
3
Deaths:
0
#10983645May 5, 2017
STRUCTURE:BODY
TL* THE CONTACT OWNS A 2004 FORD F-150. WHILE PERFORMING ROUTINE MAINTENANCE ON THE VEHICLE, THE CONTACT BECAME AWARE OF EXTREME CORROSION TO THE SUBFRAME OF THE VEHICLE. THE CONTACT WAS CONCERNED THAT THE VEHICLE COULD FRACTURE AND SEPARATE AT THE CENTER BETWEEN THE BED AND THE CABIN. THE VEHICLE WAS NOT DIAGNOSED OR REPAIRED. THE MANUFACTURER WAS NOTIFIED OF THE FAILURE. THE APPROXIMATE FAILURE MILEAGE WAS 75,000.
Crash:
No
Fire:
No
Injuries:
0
Deaths:
0
#10983709May 5, 2017
POWER TRAIN
THE WHOLE VEHICLE VIBRATES AND SHUDDERS AT HIGHWAY SPEED WITH NOW WARNING. IT NOW FEELS AS IF THE REAR AXLE IN MOVING, GIVE AN ODD SENSATION WHEN APPLYING THE GAS PEDAL OR TAKING YOUR FOOT OFF THE GAS PEDAL. I AM A TECHNICIAN BY TRADE, SO I PUT THE TRUCK UP ON THE LIFT AT MY SHOP AND HAVE NOTICED THE PINION IN THE REAR DIFFERENTIAL HAS SIGNIFICANT UP AND DOWN MOVEMENT. AFTER RESEARCHING A BIT, IT SEEMS THE PINION AND RING GEAR GALL THEMSELVES, I'M NOT SURE IF THE PINION BEARING FAILED CAUSING THIS. OR IF THE RING AND PINION FAILED CAUSING THE BEARING TO FAIL. AT ANY RATE THERE SEEMS TO BE A LOT OF INDIVIDUALS WITH MY EXPERIENCE, A QUICK SEARCH ONLINE MAY PROVIDE A SCOPE OF THE ISSUE.
Crash:
No
Fire:
No
Injuries:
0
Deaths:
0
#10981441April 29, 2017
AIR BAGS, POWER TRAIN
TAKATA RECALL.
Crash:
No
Fire:
No
Injuries:
0
Deaths:
0
#10979368April 19, 2017
ENGINE
TL* THE CONTACT OWNS A 2004 FORD F-150. THE CONTACT STATED THAT WHILE STATIONARY, THE CAMSHAFT PHASER MALFUNCTIONED. THE CONTACT STATED THAT THERE WAS A KNOCKING NOISE COMING FROM THE ENGINE OF THE VEHICLE. IN ADDITION, THE SPARK PLUGS AND THE TIMING CHAIN WERE THE SOURCE OF THE FAILURE AS WELL. THE VEHICLE WAS NOT DIAGNOSED OR REPAIRED. THE MANUFACTURER WAS MADE AWARE OF THE FAILURE. THE FAILURE MILEAGE WAS 139,000.
Crash:
No
Fire:
No
Injuries:
0
Deaths:
0
#10971017April 6, 2017
FUEL/PROPULSION SYSTEM, POWER TRAIN, VEHICLE SPEED CONTROL
WITH MY FOOT ON THE BRAKE, I PUT THE TRUCK IN REVERSE TO BEGIN BACKING OUT OF A DRIVEWAY. I APPLIED A LITTLE GAS TO SLOWLY BACKUP AROUND THE TURN IN THE DRIVE. AS I WAS ROLLING BACKWARDS, I HAD MY FOOT ON THE BRAKE BECAUSE I WAS NAVIGATING PAST OTHER PARKED VEHICLES. AS I WAS CLEARING ONE OF THE VEHICLES, THE TRUCK SUDDENLY JOLTED BACKWARDS HITTING A TREE. SO THEN, WITH MY FOOT ON THE BRAKE, I PUT THE TRUCK IN DRIVE SO THAT I COULD PULL FORWARD AWAY FROM THE TREE. AS I BEGAN TO PRESS ON THE GAS PEDAL AND THE TRUCK INSTANTLY THRUST FORWARD, HITTING ANOTHER TREE, STOPPING THE TRUCK & KNOCKING THE TREE OVER. IT HAPPENED WITH SUCH POWER THAT THE WHEELS SPUN DOWN INTO THE MULCH BED BEFORE I WAS ABLE TO BRAKE, PUT THE TRUCK INTO PARK AND REMOVE THE KEYS TO TURN IT OFF. WHILE THE DAMAGE ON THE BACK BUMPER WAS MINIMAL, THE DAMAGE TO THE FRONT OF THE TRUCK WAS EXTENSIVE & THE INSURANCE COMPANY DECLARED THE TRUCK A TOTAL LOSS. THERE WAS ONE OTHER TIME, WHILE ON THE LOCAL HIGHWAY AT A STOPLIGHT, WITH MY FOOT ON THE BRAKE, THAT THE TRUCK BEGAN TO THRUST FORWARD ON ITS' OWN. AFTER IT FIRST ROCKED FORWARD, I PRESSED THE BRAKE ALL THE WAY TO THE FLOOR WHICH PREVENTED IT FROM ACTUALLY MOVING FORWARD ANY MORE. ONCE THE LIGHT TURNED GREEN, THE TRUCK SEEMED TO RETURN TO NORMAL FUNCTIONING. THIS INCIDENT OCCURRED AROUND THE TIME I WAS DUE FOR A TUNE-UP SO I FIGURED IT WAS A FLUKE AND WOULD HAVE BEEN RESOLVED WITH THE TUNE UP.
Crash:
Yes
Fire:
No
Injuries:
0
Deaths:
0

← Back to Ford F-150