Ford F-150 Complaints (2007)

488 consumer complaints on file.

#11021668September 6, 2017
ENGINE
I BOUGHT TRUCK ABOUT 2 YEARS AGO TOOK TO FORD TO HAVE TRANNY FLUSH ON IT ASKED THEM ABOUT THE TICKING NOISE COMING FROM ENGINE THEY TOLD ME THAT IT WAS NORMAL ON THE 5.4 TRITON ABOUT A WEEK AGO THE TICKING GOT LOUDER AND LOOKED UP PROBLEMS AND FOUND THAT THERE IS A DESIGN FLAW IN ENGINE THAT CAUSES CAM PHASERS FAIL ND OIL PRESSURE DROPS TO ZERO FORD KNOWS ABOUT PROBLEM BUT WHN YOU CALL THEY TELL YOU THAT YOU NEED TO REPLACE THE ENGINE WELL LOOKED UP FORUMS AND PEOPLE WHO HAVE REPLACED THE MOTOR HAD SAME PROBLEMS WITH IT LATER ON YESTERDAY I WAS DRIVING TAKING MY 2 DAUGHTERS TO SCHOOL WHEN ALL OF A SUDDEN THE ENGINE SHUT OFF I LOST BRAKES AND STEERING. THE TRUCK BEHIND ME HAD TO LOCK UP ITS BRAKES TO KEEP FROM HITTING ME AND MY KIDS SO I AM WRITING YOU TO SEE IF YOU CAN LOOK INTO THIS MY KIDS WERE SO SCARED THE TRUCK SLOWED INSTANTLY WHEN THE ENGINE FAILED I HAD MY FRIEND TOW IT BACK TO MY HOUSE WHERE I CHECKED THE CAM SENSORS AND CHANGED THEM AND DID NOT START STILL DOES NOT START NOW THERE ARE 1000'S OF PEOPLE ON FORUMS TALKING ABOUT THIS IS IT GOING TO TAKE SOMEONE GETTING KILLED BEFORE FORD OWNS UP TO THERE PROBLEMS THEY ARE IGNORING AND HAVING THE CONSUMER PAY AYWHERE FROM 3500- 8000 DOLLARS TO REPAIR THIS I FIRST ASKED WHEN I BOUGHT TRUCK WITH 81,000 MILES ON IT
Crash:
No
Fire:
No
Injuries:
0
Deaths:
0
#11010312July 24, 2017
STRUCTURE:BODY
I BOUGHT THIS TRUCK JUNE 28 2010. ON 2-11-14 I TOOK IT TO FORD DEALER BECAUSE OF FRAME ROT AND WAS TOLD THEY COULD NOT COVER THE REPAIR. I HAD IT REPAIRED AT A WELDING SHOP. THE TRUCK FRAME IS NOW SO BAD THAT IT IS UNSAFE AND WILL NOT PASS INSPECTION. IT HAS SEPARATED AT FACTORY WELD. OBVIOUS MANUFACTURING DEFECT.
Crash:
No
Fire:
No
Injuries:
0
Deaths:
0
#11006246July 18, 2017
SERVICE BRAKES
WHILE UNDER WARRANTY THE ROTORS BECAME WARPED. I TOOK THE TRUCK INTO THE DEALER AND THEY GROUND THE ROTORS WHICH MADE THEM THINNER AND MORE VULNERABLE TO WARPING WHICH OCCURRED IMMEDIATELY. FORD REFUSED TO REPLACE THE ROTORS. THE PADS WERE FINE INDICATING THAT THE PROBLEM WAS NOT AN OPERATOR PROBLEM. I TOOK THE TRUCK TO AN INDEPENDENT REPAIR SHOP WHERE THEY CONCLUDED THAT THE ROTORS WERE NOT SUFFICIENT FOR THE VEHICLE. THEY REPLACED THE ROTORS WITH A MORE SUBSTANTIAL ROTOR AT A COST OF $1400 AND I HAVE HAD NO PROBLEM SINCE.
Crash:
No
Fire:
No
Injuries:
0
Deaths:
0
#10995797June 19, 2017
STEERING
STEERING BINDS SO TIGHTLY WHEN VEHICLE IS IN MOTION THAT IT TAKES SIGNIFICANT FORCE TO TURN WHEEL. ONCE WHEEL GETS PAST AND FREE OF THE BINDING POSITION IT TRAVELS TOO FAR CREATING A NEED FOR A STEERING CORRECTION. I BELIEVE THAT THE TWO PIECE STEERING SHAFT AND THE TWO UNIVERSAL JOINTS ARE WORN AND CAUSING THE PROBLEM. IT FEELS LIKE YOU HAVE LOST POWER STEERING, HOWEVER NOT THE CASE. AS THE POWER STEERING FLUID IS AT THE PROPER LEVEL. THERE ARE NO FLUID LEAKS, FORD HAS RECALLED EXPEDITIONS AND LINCOLNS FOR THIS ISSUE, WHY NOT THE F-150 PICKUP TRUCKS?
Crash:
No
Fire:
No
Injuries:
0
Deaths:
0
#10991443May 24, 2017
ENGINE
FILED A CLAIM WITH THE STATE OF CALIFORNIA BUREAU OF AUTOMOTIVE REPAIR ON 4-3-17, COMPLAINT # OC 2017005088, AGAINST FOUR ENTITIES INCLUDING: EL CAJON, CA FORD DEALER, CERTIFIED CAR CLINIC, FORD AUTOMOTIVE INC., AND DREW/PENSKE FORD REGARDING MY 2007 5.4 TRITON FORD F-150 TRUCK PLATINUM SPARK PLUG DEFECT. I WAS TOLD BY THE BAR THAT MY COMPLAINT WOULD BE FILED WITH YOUR AGENCY. I WOULD LIKE TO VERIFY IN WRITING THAT YOUR AGENCY HAS RECEIVED THE STATE OF CALIFORNIA BAR COMPLAINT.
Crash:
No
Fire:
No
Injuries:
0
Deaths:
0
#10991301May 23, 2017
ENGINE
I NEED REPLACE SPARKS PLUS NO VARY LIKE DO THEY SAID FORD F150 5.4 POSIBLE LOOS PICE INSIDE MOTOR
Crash:
No
Fire:
No
Injuries:
0
Deaths:
0
#10990901May 22, 2017
ENGINE
TL* THE CONTACT OWNS A 2007 FORD F-150. WHILE DRIVING APPROXIMATELY 40 MPH, THE ENGINE WARNING INDICATOR ILLUMINATED. THE VEHICLE WAS TAKEN TO THE DEALER WHERE IT WAS DIAGNOSED THAT THE ENGINE SPARK PLUGS NEEDED TO BE REPLACED. THE VEHICLE WAS NOT REPAIRED. THE MANUFACTURER WAS NOT NOTIFIED OF THE FAILURE. THE APPROXIMATE FAILURE MILEAGE WAS 70,000.
Crash:
No
Fire:
No
Injuries:
0
Deaths:
0
#10985516May 13, 2017
STRUCTURE:BODY
FRAME IS COMPLETELY RUSTED THROUGH TO THE POINT THAT IT CANNOT BE REPAIRED AND IS UNSAFE. IT CANNOT PASS A STATE SAFETY INSPECTION AND HAS DETERIORATED TO THE POINT WHERE IT CANNOT EVEN BE PUT ON A LIFT BECAUSE IT HAS NO STRUCTURAL INTEGRITY. THERE ARE LARGE HOLES RUSTED THROUGH AND WHERE IT HASN'T ENTIRELY RUSTED THROUGH, THE METAL HAS DETERIORATED TO BEING LESS THAN HALF OF ITS ORIGINAL THICKNESS. THE PROBLEM WENT UNNOTICED BECAUSE THE REST OF THE TRUCK SHOWED NO SIGNS OF ANY ADVANCED DETERIORATION.
Crash:
No
Fire:
No
Injuries:
0
Deaths:
0
#10983415May 3, 2017
ENGINE
PICKED UP MY SON FROM SCHOOL AND WHILE DRIVING DOWN THE HIGHWAY AT 55MPH I HEARD A LOUD NOISE AND IT GOT REALLY LOUD . MY SPARK PLUG JUST BLEW OUT FOR NO REASON.
Crash:
No
Fire:
No
Injuries:
0
Deaths:
0
#10983125May 2, 2017
ENGINE, SUSPENSION
TL* THE CONTACT OWNS A 2007 FORD F-150. WHILE DRIVING 45 MPH, THE VEHICLE DECELERATED AND THE CHECK ENGINE WARNING INDICATOR ILLUMINATED. THE FAILURE RECURRED NUMEROUS TIMES. THE VEHICLE WAS TAKEN TO THE DEALER WHERE IT WAS DIAGNOSED THAT THE SPARK PLUGS AND THE COIL SPRINGS NEEDED TO BE REPLACED. THE VEHICLE WAS NOT REPAIRED. THE MANUFACTURER WAS MADE AWARE OF THE FAILURE. THE MANUFACTURER ADVISED THE CONTACT TO CALL NHTSA TO CHECK FOR ANY OPEN RECALLS. THE FAILURE MILEAGE WAS 88,000.
Crash:
No
Fire:
No
Injuries:
0
Deaths:
0
#10978690April 16, 2017
VEHICLE SPEED CONTROL
DURING SHIFTING ON STREETS AND HWY'S MY RPMS RAMP UP TO 3000-5000. I HAVE BEEN DRIVING WHILE MAINTAINING SPEED AND THEN THE RPMS WILL RAMP UP THEN THE SPEED STEADILY DROPS WHILE MY FOOT IS STILL ON THE ACCELERATOR. TURNING THE OVERDRIVE OFF SEEMS TO HELP OCCASIONALLY. I HAVE ALSO ATTEMPTED TO BRAKE AT LIGHTS AND THE RPMS WILL RAMP UP AND LURCH FORWARD ALMOST CAUSING ME TO REAR END OTHER VEHICLES. THIS IS A MAJOR SAFETY CONCERN AND I DONT UNDERSTAND WHY FORD HASN'T ISSUED A RECALL AND ADDRESSED THIS SAFETY HAZARD. MY O/D LIGHT OCCASIONALLY FLASHES AND WHEN IN "PARK" THEN PUTTING THE GEAR IN "REVERSE" IT WOULDN'T OPERATE AND WHERE MY DIGITAL MILEAGE IS SAID "TRANS FAULT". I TURNED THE VEHICLE OFF, THEN BACK ON AND THE O/D WAS OFF AND WAS ABLE TO BACK UP. NONE OF MY WARNING LIGHTS HAVE COME ON AT ALL. OCCASIONALLY AT A STOP SIGN WHEN I ATTEMPT TO ACCELERATE THERE'S A DELAY IN MOVEMENT. SPEED VARIES AT TIMES OF INCIDENTS.
Crash:
No
Fire:
No
Injuries:
0
Deaths:
0
#10956278February 22, 2017
ENGINE
SPARK PLUG BLEW OUT OF HEAD.
Crash:
No
Fire:
No
Injuries:
0
Deaths:
0
#10950347February 8, 2017
FUEL/PROPULSION SYSTEM
THE FUEL PUMP DRIVER MODULE, WHICH IS LOCATED EXTERNAL TO TANK MOUNTED ON FRAME, FAILED BECAUSE IT CORRODED THRU TO THE INSIDE OF UNIT. AT THE TIME OF FAILURE CAR WAS PARKED, BUT WHAT WOULD HAPPEN IF ON HIGHWAY AND FUEL PUMP STOPPED WORKING? FORD WOULD NOT REPLACE THE PART EVEN THOUGH THEY KNEW THERE WAS A PROBLEM BECAUSE IT WAS REDESIGNED WITH STAND-OFFS TO PREVENT DISSIMILAR METAL REACTION.
Crash:
No
Fire:
No
Injuries:
0
Deaths:
0
#10948952February 1, 2017
ELECTRICAL SYSTEM
TRUCK WOULDN'T START. UPON FURTHER INSPECTION FOUND THE FUEL PUMP DRIVER MODULE FAILED DUE TO CORROSION. THE PART WAS BOLTED TO THE CROSS MEMBER ON THE BACK OF THE FRAME. THE BOTTOM OF THE PART IS ALUMINUM AND THE CROSS MEMBER IS STEEL, AND THEY WERE BOLTED FLUSH TOGETHER. REPLACED THE PART AND TRUCK WORKS FINE. I WOULD LIKE FORD TO ACKNOWLEDGE THAT THEY HAVE AN ISSUE WITH THIS AND REIMBURSE ALL PARTIES WHO HAVE HAD THIS PROBLEM.01
Crash:
No
Fire:
No
Injuries:
0
Deaths:
0
#10948357January 29, 2017
ENGINE
A SPARK PLUG BACKED OUT. STRIPPED THE THREADS IN THE HEAD. THIS HAPPENED WHILE DRIVING THE TRUCK. *TR
Crash:
No
Fire:
No
Injuries:
0
Deaths:
0
#10947736January 26, 2017
SERVICE BRAKES, POWER TRAIN
PUT TRUCK IN REVERSE, IT SPED UP AND BRAKES DID NOT WORK. STOPPED BY BACKING INTO A TREE, THEN DROVE FINE. THREE DAYS LATER CAME TO AN INTERSECTION AND WAS UNABLE TO STOP. HIT ANOTHER VEHICLE IN THE INTERSECTION.
Crash:
Yes
Fire:
No
Injuries:
1
Deaths:
0
#10946476January 19, 2017
STRUCTURE:BODY
TL* THE CONTACT OWNS A 2007 FORD F-150. AFTER THE CONTACT GRABBED THE SAFETY HANDLE ON THE DRIVER'S SIDE DOOR, IT DETACHED FROM THE VEHICLE. THE VEHICLE WAS TAKEN TO THE DEALER WHERE IT WAS CONFIRMED THAT THE HANDLE DETACHED AND NEEDED TO BE REPLACED. THE VEHICLE WAS NOT REPAIRED. THE MANUFACTURER WAS NOT NOTIFIED OF THE FAILURE. THE FAILURE MILEAGE WAS APPROXIMATELY 70,000.
Crash:
No
Fire:
No
Injuries:
0
Deaths:
0
#10923845November 2, 2016
ENGINE
TL* THE CONTACT OWNS A 2007 FORD F-150. WHILE DRIVING APPROXIMATELY 20 MPH, THERE WAS A KNOCKING NOISE COMING FROM THE ENGINE AND THE VEHICLE STALLED. THE VEHICLE WAS TOWED TO A DEALER WHERE IT WAS DIAGNOSED THAT THE NUMBER THREE SPARK PLUG DETACHED AND NEEDED TO BE REPLACED THE VEHICLE WAS REPAIRED. THE MANUFACTURER WAS MADE AWARE OF THE FAILURE. THE FAILURE MILEAGE WAS APPROXIMATELY 102,890. UPDATED 08/09/17*LJ *CN
Crash:
No
Fire:
No
Injuries:
0
Deaths:
0
#10920158October 31, 2016
ENGINE
CRACKED OR WARPED EXHAUST MANIFOLD. I'VE HAD IT LOOKED AT BY TWO AUTO MECHANICS AND HAVE READ ONLINE WITH THIS WIDESPREAD PROBLEM.
Crash:
No
Fire:
No
Injuries:
0
Deaths:
0
#10905085September 9, 2016
ENGINE
WHILE DRIVING MY TRUCK SUDDENLY LOST POWER AND SHIFTED INTO "LIMP HOME MODE" WHILE THE WRENCH AND CHECK ENGINE LIGHT CAME ON. THIS HAPPENED TO ME A FEW YEAR BACK AS WELL SO I IMMEDIATELY ASSUMED IT WAS THE THROTTLE BODY OR SENSOR GOING BAD. I BROUGHT INTO THE FORD DEALERSHIP WHO CONFIRMED TO ME IT WAS THE THROTTLE BODY THAT WENT OUT. THIS IS NOW THE 3 THROTTLE BODY THAT MY TRUCK HAD HAD (9 YEARS OLD AND 130,000 MILES). AFTER DOING RESEARCH I SAW WHERE FORD HAD THIS SAME ISSUE WITH OTHER MODEL VEHICLES AND INSTEAD OF RECALLING EXTENDED WARRANTIES TO COVER THE COST OF REPLACEMENT. THIS IS EXTREMELY DANGEROUS AS IF IT OCCURS WHEN MERGING INTO TRAFFIC YOU LOSE ALL ABILITY TO ACCELERATE. I THINK FORD HAS A MAJOR ISSUE HERE THAT IT IS REFUSING TO ADDRESS.
Crash:
No
Fire:
No
Injuries:
0
Deaths:
0

← Back to Ford F-150