Ford F-150 Complaints (1999)

1,044 consumer complaints on file.

#10458390May 17, 2012
FUEL SYSTEM, GASOLINE:STORAGE:TANK ASSEMBLY:MOUNTING
1999 FORD F-150. CONSUMER WRITES IN REGARDS TO RECALL REPAIRS NOT BEING COMPLETED *TGW THE DEALER INFORMED THE CONSUMER THAT ONE OF THE TWO STRAPS WAS COMPLETELY ROTTED AND JUST HANGING THERE AND NOT SUPPORTING ANYTHING. THEREFORE, THE GAS TANK WAS BEING HELD IN PLACE BY ONLY ONE STRAP. THE DEALER STATED THEY COULD NOT MAKE THE REPAIRS DUE TO THE CORROSION, AS IT HAD AFFECTED THE FRAME WHERE THE GAS TANK ATTACHED TOO. THE CONSUMER STATED EVER SINCE HE WENT TO THE DEALER, THERE IS AN ODOR OF GAS EMITTING FROM THE VEHICLE. *JB
Crash:
No
Fire:
No
Injuries:
0
Deaths:
0
#10458208May 12, 2012
SERVICE BRAKES
BRAKE LINES RUSTED OUT. FIRST WAS THE PASSENGER SLIDE FRONT, THEN THE IN 2008 THE RIGHT REAR PASSENGER SIDE RUSTED OUT. NOW THE FRONT DRIVER SLIDE BRAKE LINE RUSTED OUT. I PURCHASED THE TRUCK IN OHIO AUGUST 1999. I MOVED TO NORTH CAROLINE IN JUNE OF 2000. WITH THE OCCASIONAL TRIP TO OHIO THE TRUCK HAS BEEN HOUSED IN NORTH CAROLINA FROM 6/1/2000 TO PRESENT DAY. I WOULD EXPECT THIS IF HAD REMAINED IN OHIO BUT NOT FROM A SOUTHERN TRUCK. I QUESTION THE QUALITY OF THE STEEL BRAKE LINES. ARE OTHER PEOPLE HAVE THE SAME TROUBLE??? *TR
Crash:
No
Fire:
No
Injuries:
0
Deaths:
0
#10456158April 23, 2012
FUEL SYSTEM, GASOLINE
TL* THE CONTACT OWNS A 1999 FORD F150. THE CONTACT STATED THAT THERE WAS RUST AND CORROSION ON THE FUEL TANK. NEITHER THE DEALER NOR THE MANUFACTURER WAS NOTIFIED OF THE FAILURE. THE VEHICLE WAS NOT REPAIRED. THE FAILURE MILEAGE WAS 117,000.
Crash:
No
Fire:
No
Injuries:
0
Deaths:
0
#10455648April 18, 2012
ENGINE AND ENGINE COOLING
TL* THE CONTACT OWNS A 1999 FORD F-150. THE CONTACT STATED THAT THE EXHAUST MANIFOLD STARTED BREAKING AWAY FROM THE VEHICLE. THE CONTACT TOOK THE VEHICLE TO A MECHANIC AND WAS INFORMED THAT THE BOLTS HOLDING THE MANIFOLD IN PLACE HAD RUSTED AND BROKEN OFF. THE CONTACT WAS ALSO INFORMED THAT THIS WAS A COMMON FAILURE. THE FAILURE MILEAGE AND CURRENT MILEAGES WERE 291,000.
Crash:
No
Fire:
No
Injuries:
0
Deaths:
0
#10455242April 14, 2012
SERVICE BRAKES, HYDRAULIC
THREE BRAKE LINES RUSTED OUT AND LEAKING IN LAST 2 YEARS INCIDENT DATE IS AN ESTIMATE. *TR
Crash:
No
Fire:
No
Injuries:
0
Deaths:
0
#10454329April 6, 2012
SERVICE BRAKES, HYDRAULIC:FOUNDATION COMPONENTS:HOSES, LINES/PIPING, AND FITTINGS, SERVICE BRAKES, HYDRAULIC
TL* THE CONTACT OWNS A 1999 FORD F-150. WHILE DRIVING APPROXIMATELY 45 MPH, THE CONTACT DEPRESSED THE BRAKE PEDAL AND NOTICED THE BRAKE PEDAL DROPPED TO THE FLOOR BOARD ABNORMALLY. THE CONTACT USED THE EMERGENCY BRAKE AND WAS ABLE TO STOP THE VEHICLE. THE VEHICLE WAS NOT TAKEN TO THE DEALER FOR DIAGNOSTICS. THE CONTACT INSPECTED THE VEHICLE AND NOTICED BRAKE FLUID LEAKING FROM THE BRAKE LINES AS A RESULT OF CORROSION OF THE BRAKE LINES. THE VEHICLE WAS NOT REPAIRED. THE APPROXIMATE FAILURE MILEAGE WAS 157,000. UPDATED 05/08/12*LJ
Crash:
No
Fire:
No
Injuries:
0
Deaths:
0
#10448137February 16, 2012
FUEL SYSTEM, GASOLINE
GAS TANK STRAPS ERODED OFF-TANK WAS DRAGGING ON GROUND. *TR
Crash:
No
Fire:
No
Injuries:
0
Deaths:
0
#10447183February 8, 2012
STRUCTURE:FRAME AND MEMBERS:UNDERBODY SHIELDS, FUEL SYSTEM, GASOLINE
I BROUGHT IN MY 1999 FORD F150 TO GET AN INSPECTION AND GET A RECALL PERFORMED ON THE STRAPS THAT HOLD THE GAS TANK ON. THE GARAGE HAD THE VEHICLE FOR 6 DAYS BEFORE THEY INFORMED ME THAT THEY IN FACT COULD NOT PERFORM THE SAFETY UPGRADE BECAUSE THE FRAME OF THE TRUCK HAS TOO MUCH RUST. I BELIEVE THAT FORD MOTOR COMPANY IS RESPONSABLE FOR NOT PROVIDING ADEQUETTE PROTECTION FRO THE ELEMENTS ON THE FRAMES OF THIS MAKE/MODEL OF VEHICLE. I CALLED THE FORD MOTOR COMPANY AND WAS TOLD THAT THEY WERE ONLY RESPONSABLE FOR THE GAS TANK STRAPS AND NOT THE FRAME SO THEY WERE NOT REQUIRING THEIR DEALERSHIP TO DO THE UPGRADES. WHEN MY BEST FRIENDS 1999 TOYOTA TACOMA HAD THE SAME EACT PROBLEM ON HIS TRUCK THE TOYOTA COMPANY PAID TO PUT A NEW FRAME ON HIS TRUCK DUE TO A RECALL OF THE FRAME. THE REST OF MY FORD TRUCK IS IN GREAT CONDITION AND HAS AROUND 120,000 MILES ON IT. I HAVE HAD NO OTHER ISSUES WITH THE TRUCK EXCEPT FOR THE FRAME. BECAUSE OF THIS ISSUE THE ONLY REAL CHOICE I HAVE AT THIS POINT IS TO SCRAP THE TRUCK AND BUY ANOTHER VEHICLE. *TR
Crash:
No
Fire:
No
Injuries:
0
Deaths:
0
#10445760January 29, 2012
VEHICLE SPEED CONTROL
WHILE USING THE CRUISE CONTROL A FEW TIMES....WHEN I TAP IT ONCE TO DISENGAGE, MY VEHICLE SPEEDS UP! THEN I HAVE TO HOLD THE BUTTON DOWN & GENTLY TAP ON THE BRAKES TO DISENGAGE THE CRUISE CONTROL. IT'S NOT REALLY A BIG DEAL BECAUSE I'M EXPECTING THIS TO HAPPEN, BUT THERE COULD BE THAT ONE TIME WHERE I MIGHT NOT BE ABLE TO DISENGAGE THE CRUISE CONTROL! *TT
Crash:
No
Fire:
No
Injuries:
0
Deaths:
0
#10444904January 23, 2012
FUEL SYSTEM, GASOLINE
TL* THE CONTACT OWNS A 1999 FORD F-150. THE CONTACTED STATED THAT WHILE REFUELING THE VEHICLE, FUEL LEAKED FROM UNDER THE VEHICLE ABNORMALLY. THE VEHICLE WAS TAKEN TO A PRIVATE MECHANIC. THE MECHANIC STATED THAT THE FILLER NECK WAS DETACHED FROM THE TANK. THE MANUFACTURER WAS CONTACTED AND THE VEHICLE WAS REPAIRED. THE FAILURE MILEAGE WAS 127,847 AND THE CURRENT MILEAGE WAS UNKNOWN.
Crash:
No
Fire:
No
Injuries:
0
Deaths:
0
#10441987December 31, 2011
SERVICE BRAKES, HYDRAULIC
FORTUNATELY, I WAS UNDER 1/2 MILE FROM MY HOUSE. MY ROAD DEAD ENDS ONTO ANOTHER. I APPLIED THE BRAKES AND THE PEDAL WENT TO THE FLOOR AS I APPROACHED THE STOP SIGN. I WENT THROUGH THE STOP SIGN AND INTO THE DRAINAGE DITCH ON THE OTHER SIDE OF THE ROAD. BECAUSE MY VEHICLE IS 4 WHEEL DRIVE, I WAS ABLE TO GET OUT OF THE DITCH AND RETURN HOME. UPON INSPECTION, I FOUND THAT THE BRAKE LINE THAT GOES FROM THE FRONT TO THE REAR WAS RUSTED AND FAILED. THERE WAS LITTLE DAMAGE FROM THE CRASH, JUST A FENDER THAT NEEDS REPLACED. I AM ANAL WITH REGARD TO MY VEHICLES CONDITION AND MAINTENANCE. TO HAVE A FAILURE LIKE THIS ON A WHAT IS SUPPOSED TO BE THE BEST BUILT TRUCK IS ABSURD AND TOTALLY UNACCEPTABLE! MY BROTHERS 1999 HONDA, MY STEP SON'S 1991 NISSAN STANZA (RECENTLY SOLD) A 1993 GEO PRIZM (I.E. TOYOTA COROLLA!!!) RECENTLY SOLD HAD ZERO RUST ON ANY BRAKE FITTING, BRAKE LINE OR FUEL LINE. *KB
Crash:
Yes
Fire:
No
Injuries:
0
Deaths:
0
#10440407December 19, 2011
SERVICE BRAKES, HYDRAULIC
TL* THE CONTACT OWNS A 1999 FORD F-150. THE CONTACT STATED THAT WHEN DEPRESSING THE BRAKE PEDAL, THE PEDAL WOULD FEEL SPONGY AS IF THE VEHICLE WAS NOT GOING TO STOP. THE CONTACT WOULD HAVE TO CONTINUOUSLY PUMP THE BRAKE PEDAL FOR THE VEHICLE TO COME TO A COMPLETE STOP. THE CONTACT REFERENCED NHTSA CAMPAIGN ID NUMBER: 05V388000 (VEHICLE SPEED CONTROL) AND STATED THAT THE VEHICLE WAS REPAIRED UNDER THE RECALL BUT TO NO AVAIL. THE DEALER ALSO REPAIRED THE LEAK IN THE BRAKE LINE BUT NOT THE AIR THAT WAS BEING RELEASED AND CAUSING THE BRAKES TO NOT PERFORM PROPERLY. THE MANUFACTURER WAS NOTIFIED OF THE FAILURE BUT ADVISED THE CONTACT THAT THE DEFECT WAS NOT DIRECTLY RELATED TO THE RECALL. THE FAILURE AND THE CURRENT MILEAGE WAS 204,000.
Crash:
No
Fire:
No
Injuries:
0
Deaths:
0
#10440038December 15, 2011
FUEL SYSTEM, GASOLINE:STORAGE:TANK ASSEMBLY:MOUNTING
TL* THE CONTACT OWNS A 1999 FORD F-150. THE CONTACT RECEIVED NOTIFICATION OF NHTSA CAMPAIGN ID NUMBER: 11V385000 (FUEL SYSTEM, GASOLINE:STORAGE:TANK ASSEMBLY:MOUNTING) AND TOOK THE VEHICLE TO THE DEALER FOR REPAIRS. DURING THE RECALL REPAIRS, THE FUEL TANK BEGAN LEAKING ABNORMALLY DUE TO CORROSION OF THE FUEL TANK AND STRAPS. THE MANUFACTURER WAS CONTACTED AND THEY ADVISED THE CONTACT THAT THEY WOULD NOT REPLACE THE TANK OR THE STRAPS. THE FAILURE AND THE CURRENT MILEAGES WERE APPROXIMATELY 208,846. UPDATED 01/18/2012*LJ UPDATED 02/29/12
Crash:
No
Fire:
No
Injuries:
0
Deaths:
0
#10440099December 15, 2011
EXTERIOR LIGHTING
TL* THE CONTACT OWNS A 1999 FORD F-150. THE CONTACT WAS DRIVING 45 MPH WHEN THE DIMMER SWITCH CAUGHT ON FIRE AND MELTED THE WIRES. THE CONTACT MENTIONED THAT THE HEADLIGHTS WERE INOPERABLE. THE VEHICLE WAS NOT TAKEN TO THE DEALER AND THE MANUFACTURER WAS NOT MADE AWARE OF THE FAILURE. THE VEHICLE WAS NOT REPAIRED. THE FAILURE AND THE CURRENT MILEAGE WAS 171,000.
Crash:
No
Fire:
Yes
Injuries:
0
Deaths:
0
#10438823December 6, 2011
EXTERIOR LIGHTING
JUST WONDERING IF MY TRUCK IS ON THOSE RECALLS. *TR
Crash:
No
Fire:
No
Injuries:
0
Deaths:
0
#10438671December 5, 2011
SERVICE BRAKES, HYDRAULIC
FRONT BRAKES:: GRADUAL UNKNOWN BRAKING DEGRADATION OVER TIME UNTIL IT GOT TO THE POINT I HAD TO PUMP THE BRAKES LIKE AS IF A BRAKE LINE WAS SUCKING AIR OR THE MASTER CYLINDER WAS GOING BAD, IN ORDER TO STOP. UPON INVESTIGATING I FOUND THAT BOTH DUST SHIELDS ON THE FRONT BRAKES WERE EXTREMELY RUSTED AND THE RUST PIECES WERE FALLING BETWEEN THE FRONT INBOARD BRAKE PADS AND REAR ROTOR SURFACES CAUSING EXTREME CONTAMINATION OF THE BACKSIDE OF BOTH ROTORS TO THE POINT THAT LESS THAN 50% CONTACT SURFACE WAS LEFT. SINCE THE INBOARD BRAKE PADS DO MORE STOPPING THAN THE OUTSIDE BRAKE PADS IT'S A VERY DANGEROUS SITUATION. TO ADD TO THE DANGER THE FRONT BRAKING SYSTEM DOES ABOUT 75% OF A VEHICLES TOTAL BRAKING. AND, IF IT HAPPENS ON A LONG DOWN HILL GRADE WITH ALLOT OF BRAKING, IT CAN CAUSE THE FRONT BRAKE FLUID TO BOIL INSIDE THE CALIPERS GIVING SOMEONE ONE HELL-OF-A WILD RIDE. IN FACT, ONE DAY I HAD TO HIT THE BRAKES WITHOUT HAVING TIME TO PUMP THEM AND JUST ABOUT HIT A KID ON A BIKE THAT DARTED OUT FROM BETWEEN 2 CARS. THAT'S WHEN I DECIDED I HAD BETTER DO SOMETHING ABOUT THE PROBLEM. I SUSPECT FORD HAS BEEN LOVING IT BECAUSE NON-MECHANICAL PEOPLE WILL NEVER KNOW OR FIND OUT AND FORD WILL JUST RIP PEOPLE OFF FOR A MAJOR BRAKE OVERHAUL IN THE TUNE OF $600.00 AND THROW EVERYTHING AWAY SO NOBODY WILL EVER KNOW. THIS IS AN EXTREMELY DANGEROUS SITUATION BECAUSE IT'S SUCH A GRADUAL DEGRADATION OF BRAKING. THE FIX IS TO REPLACE BOTH DUST SHIELDS (FORD P/N= 2L3Z - 2K004 - AA) "THE PRIMARY CAUSE" OF THE PROBLEM. I TOOK MANY PICTURES WITH MY DIGITAL CAMERA OF ALL THE COMPONENTS AND CAN E-MAIL THEM TO NHTSA . I ALSO HAVE ALL THE FRONT BRAKE COMPONENTS; 2 ROTORS, 4 BRAKE PADS, 2 DUST SHIELDS. THE ROTORS ARE VERY HEAVY BUT I WOULD BE HAPPY TO PACK EVERYTHING UP AND SEND IT TO NHTSA IF YOU PAY THE SHIPPING. *TR
Crash:
No
Fire:
No
Injuries:
0
Deaths:
0
#10437895November 30, 2011
ELECTRICAL SYSTEM, ENGINE AND ENGINE COOLING
STARTED THE TRUCK UP AN BLAST OFF! DONT KNOW WHERE THE PLUG WENT BUT IT WAS GONE AFTER I HEARD A LOUD BANG. *KB *TR
Crash:
No
Fire:
No
Injuries:
0
Deaths:
0
#10437542November 28, 2011
FUEL SYSTEM, GASOLINE
TL* THE CONTACT OWNS A 1999 FORD F150. THE CONTACT STATED WHILE DRIVING AT APPROXIMATELY 20 MPH, THE FUEL TANK DETACHED FROM THE VEHICLE. THE VEHICLE WAS TAKEN TO THE DEALER WHO PERFORMED A DIAGNOSTIC. THE FAILURE WAS LOCATED AT THE FUEL TANK STRAP FRAME RAIL, WHICH WAS CORRODED AND CAUSED THE FUEL STRAPS TO CORRODE. THE VEHICLE WAS NOT REPAIRED. THE FAILURE AND THE CURRENT MILEAGE WAS 100,000.
Crash:
No
Fire:
No
Injuries:
0
Deaths:
0
#10434190November 4, 2011
FUEL SYSTEM, GASOLINE, STRUCTURE:BODY
TL* THE CONTACT OWNS A 1999 FORD F-150. THE CONTACT STATED WHILE REFUELING THE VEHICLE, FUEL EMITTED FROM THE FUEL TANK. THE CONTACT ALSO STATED THE UNDER CARRIAGE WAS CORRODED. THE VEHICLE WAS TAKEN TO THE DEALER FOR DIAGNOSTIC TESTING. THE MANUFACTURER WAS NOTIFIED OF THE FAILURE. THE VEHICLE WAS NOT REPAIRED AND THE VIN WAS UNKNOWN. THE FAILURE AND CURRENT MILEAGE WAS 223,000.
Crash:
No
Fire:
No
Injuries:
0
Deaths:
0
#10432469October 22, 2011
ENGINE AND ENGINE COOLING
CYLINDER 5 SPARK PLUG BLEW OUT WHILE DRIVING, WRECKING THE THREADING IN THE SPARK PLUG HOLE AND THE COIL. *TR
Crash:
No
Fire:
No
Injuries:
0
Deaths:
0

← Back to Ford F-150