Ford F-150 Complaints (2005)

1,112 consumer complaints on file.

#10285842September 30, 2009
VISIBILITY:POWER WINDOW DEVICES AND CONTROLS
MY 2005 FORD F150 HAS AGAIN FOR THE 3RD TIME HAD A SIDE WINDOW FALL INTO THE DOOR PANEL OF THE TRUCK. MY UNDERSTANDING THIS IS A VERY COMMON OCCURRENCE WITH THIS MODEL YEAR TRUCK, AND SINCE THIS IS VERY DISTRACTING WHEN IT OCCURS I FELT COMPELLED TO REPORT IT. MY WISH IS FOR THE NHTSA TO ENCOURAGE FORD MOTOR TO RECALL THIS MODEL YEAR VEHICLE, AND REPAIR THE PROBLEM. OH ONE LAST THING, THE SERVICE ADVISERS AT FORD HAS TOLD ME THEY ARE REPLACING THE NEW FAILING WINDOW REGULATORS WITH EXACT SAME DEFECTIVE PART. *TR
Crash:
No
Fire:
No
Injuries:
0
Deaths:
0
#10285884September 30, 2009
POWER TRAIN:DRIVELINE
2005 F-150 DRIVESHAFT GOES BAD PREMATURELY. THE MIDDLE JOINT IN A 2 PIECE DRIVE SHAFT IS CHEAPLY MADE AND UNSERVICEABLE. IT CAUSES DRIVETRAIN VIBRATION AND COULD FAIL CAUSING INJURY TO PASSENGERS OR OTHER DRIVERS THOUGH A ACCIDENT. THE PART FAILURE IS A COMMON OCCURRENCE IN THIS VEHICLE AND MANY HAVE BEEN ALREADY REPLACED. MY 2005 F-150 HAS 72000 MILES ON IT. THE DRIVESHAFT IS BAD AND MUST BE REPLACED. MANY OTHER TRUCKS HAVE THE SAME PROBLEM AND DO NOT KNOW WHAT IT IS. I PAID A DEALERSHIP TO DIAGNOSE THE PROBLEM. IT TOOK THEM AWHILE TO FIGURE IT OUT. UNFORTUNATELY I DID NOT HAVE THE MONEY FOR THE REPAIR. I COULD NOT SEE SPENDING 900 DOLLARS FOR THE SAME DEFECTIVE PART. I AM STILL LOOKING FOR A REASONABLE AND QUALITY REPLACEMENT. DRIVE SHAFTS HISTORICALLY LAST A LOT LONGER THAN THE ONES FORD IS PUTTING OUT . THIS IS A DANGEROUS AND EXPENSIVE DEFECT. PEOPLE ARE SPENDING MONEY TRYING TO FIX A VIBRATION AND OVERLOOKING THE DRIVESHAFT BECAUSE IT IS SO HARD TO BELIEVE THAT THE DRIVESHAFT IS BAD. SO IT IS OVERLOOKED FOR SOME BY THE TIME THEY FIGURE IT OUT IT COULD BE TOO LATE FOR THE PASSENGER OR A INNOCENT MOTORIST SHARING THE ROAD WITH THEM. DO THE RIGHT THING MAKE FORD PAY FOR OR REPLACE THESE DRIVESHAFTS. TIME IS TICKING AWAY AND THE MILES ARE CLICKING OFF ON ALL THOSE TRUCKS WITH THESE DRIVE SHAFTS. *TR
Crash:
No
Fire:
No
Injuries:
0
Deaths:
0
#10285601September 29, 2009
ENGINE AND ENGINE COOLING:ENGINE
TL*THE CONTACT OWNS A 2005 FORD F150. DURING A ROUTINE INSPECTION A TECHNICIAN CONCLUDED THAT FIVE OF THE EIGHT SPARK PLUGS SEPARATED FROM THE ENGINE HEAD; HOWEVER, NO REPAIRS WERE MADE. THE MANUFACTURER WAS NOTIFIED AND NO ASSISTANCE WAS PROVIDED. THE FAILURE AND CURRENT MILEAGES WERE 50,000.
Crash:
No
Fire:
No
Injuries:
0
Deaths:
0
#10285297September 25, 2009
VISIBILITY:POWER WINDOW DEVICES AND CONTROLS
NO REAL EVENT, JUST PULLING INTO DRIVEWAY ,HEARD LOUD POP AND PASSENGER SIDE WINDOW WENT DOWN, AND STAYED THAT WAY. *TR
Crash:
No
Fire:
No
Injuries:
0
Deaths:
0
#10284887September 22, 2009
VISIBILITY
DEFECTIVE WINDOW REGULATOR ON DRIVER'S SIDE DOOR. WINDOW FELL INSIDE THE DOOR. REGULATOR HAD TO BE REPLACED. *TR
Crash:
No
Fire:
No
Injuries:
0
Deaths:
0
#10284889September 22, 2009
VISIBILITY
DEFECTIVE WINDOW REGULATOR ON DRIVER SIDE REAR DOOR, WINDOW FELL INSIDE OF DOOR. REGULATOR HAD TO BE REPLACED. COST $413.00. *TR
Crash:
No
Fire:
No
Injuries:
0
Deaths:
0
#10284888September 22, 2009
VISIBILITY
DEFECTIVE WINDOW REGULATOR ON PASSENGER SIDE FRONT DOOR. WINDOW FELL DOWN INSIDE OF DOOR. REGULATOR HAD TO BE REPLACED. *TR
Crash:
No
Fire:
No
Injuries:
0
Deaths:
0
#10284366September 17, 2009
VISIBILITY:POWER WINDOW DEVICES AND CONTROLS
2005 FORD F150, 18,350 MILES. DRIVER SIDE WINDOW REGULATOR FAILED WHEN WINDOW WAS CLOSED. LOUD BANG. WINDOW DROPPED INTO DOOR PANEL. ONLINE RESEARCH AND FORD DEALER CONFIRMED A FREQUENT FAILURE PROBLEM. SAFETY ISSUE DUE TO INABILITY TO CLOSE WINDOW. THIS SHOULD BE A SAFETY RECALL ISSUE DEALER REPLACED REGULATOR ASSEMBLY, COST $193.45. *TR
Crash:
No
Fire:
No
Injuries:
0
Deaths:
0
#10284094September 16, 2009
VISIBILITY:POWER WINDOW DEVICES AND CONTROLS
EVERY TIME I ROLL UP THE WINDOW FROM THE DRIVER SIDE I HEARD A LITTLE NOISE LIKE SAND BETWEEN THE GLASS AND THE DOOR SO ONE DAY I WAS DRIVING ON THE HIGHWAY AND THE WINDOW FELL INSIDE THE DOOR AND IT WAS RAINING. THE PROBLEM IS THE WINDOW REGULATOR. THERE IS A LOT OF PEOPLE WITH THE SAME PROBLEM . I BARELY USE MY TRUCK AND I ALWAYS USE THE A/C SO I DON'T KNOW HOW THIS COULD HAPPEN IF I DON'T ROLL THAT INDOW DOWN OFTEN. *TR
Crash:
No
Fire:
No
Injuries:
0
Deaths:
0
#10283885September 14, 2009
VISIBILITY:POWER WINDOW DEVICES AND CONTROLS
TL*THE CONTACT OWNS A 2005 FORD F150. THE CONTACT STATED THAT TWO POWER REGULATORS HAVE FAILED. THE DRIVER AND PASSENGER SIDE WINDOWS HAVE FALLEN OFF TRACK INSIDE THE DOOR. THE CONTACT DOES NOT HAVE A WARRANTY FOR THE VEHICLE AND IS REQUIRED TO PAY FOR THE REPAIRS. THE MANUFACTURER ADVISED THE CONTACT THAT THERE ARE NO EXISTING RECALLS AND THAT THEY ARE AWARE OF THE FAILURE. THE FAILURE MILEAGE WAS 60,000.
Crash:
No
Fire:
No
Injuries:
0
Deaths:
0
#10283807September 13, 2009
SEAT BELTS
VEHICLE IS AN 05 FORD F150 FX4 CREW CAB. DRIVER'S SEATBELT UNLATCHING WHILE DRIVING. IT HAPPENS ABOUT EVERY OTHER DAY OF DRIVING EVERYDAY. SOMETIMES IT HAPPENS ON A SUDDEN BRAKE, BUMPS, OR SUDDEN ACCELERATION. SOMETHING IN THE SEATBELT LATCH IS NOT HOLDING THE BUCKLE GOOD. IF A CRASH OCCURS, DRIVER WILL BE EJECTED FROM THE VEHICLE EVENTHOUGH DRIVER IS BUCKLED UP. *TR
Crash:
No
Fire:
No
Injuries:
0
Deaths:
0
#10283366September 9, 2009
VISIBILITY:POWER WINDOW DEVICES AND CONTROLS
WINDOW FELL DOWN (FROM A FULLY UP POSITION) INTO DRIVER-SIDE DOOR WHILE IN HEAVY TRAFFIC. SOUND RESEMBLED A GUN-SHOT WHICH DISTRACTED MY ATTENTION FROM THE ROAD AND NEARLY CAUSED AN ACCIDENT. RESEARCH SHOWS THIS TO BE A COMMON FAILURE IN SOUTHERN AND WESTERN STATES DUE TO HEAT-RELATED COMPONENT FAILURES. REPAIRS HAVE NOT BEEN MADE AT THIS TIME DUE TO HIGH COST OF PARTS AND LABOR. VEHICLE ONLY HAS 36K MILES AND HAS BEEN VERY WELL TAKEN CARE OF AND SERVICED REGULARLY. DUE TO THE NUMBER OF INCIDENTS OF FAILURE OF THE POWER WINDOW SYSTEM IN THESE TRUCKS, FORD SHOULD ISSUE A RECALL BEFORE SOMEONE GETS HURT. PERHAPS CLASS-ACTION LITIGATION WOULD FORCE THE MANUFACTURER TO TAKE RESPONSIBILITY FOR THIS OBVIOUS DESIGN FAILURE. *TR
Crash:
No
Fire:
No
Injuries:
0
Deaths:
0
#10283424September 9, 2009
VISIBILITY:POWER WINDOW DEVICES AND CONTROLS
I OWN A 2005 FORD F150. IT HAS 63,000 MILES AND IS WELL TAKEN CARE OF. JULY THE 7TH, 2009 THE PASSENGER SIDE WINDOW DROPPED DUE TO A REGULATOR FAILURE. I REPLACED IT AT AN EXTREMELY HIGH COST. THEN ON AUGUST 28TH, 2009 THE DRIVERS SIDE WINDOW FELL. NEITHER TIME WAS I IN A SITUATION THAT ENDANGERED ME BUT I WAS IN A THUNDERSTORM WHILE THE FIRST WINDOW WAS DOWN AND NOT FIXED. DO YOU KNOW WHAT IT IS LIKE TO RUN ALONG SIDE AN 18 WHEELER DURING A RAIN STORM. OF COURSE I PULLED OVER AND STOPPED. THIS IS A DANGEROUS PART FAILURE. THE DROPPING NOISE IS TREMENDOUS. SCARE THE WITS OUT OF YOU PLUS THE WEATHER COULD MAKE THE SITUATION WORSE. THE REALLY SCARY THING IS THEY ARE REPLACING THESE REGULATORS WITH THE SAME THING THAT FAILED. LOOK AT THE WEB ABOUT FORD WINDOW REGULATOR FAILURES. THERE ARE HUNDREDS AND HUNDREDS OF THEM AND THEN THINK ABOUT THE NUMBER OF DRIVERS THAT DO NOT KNOW ABOUT THIS PROBLEM OTHER THAN THEY MAY HAVE HAD A FAILURE AND NOT KNOW THERE IS AN EPIDEMIC. *TR
Crash:
No
Fire:
No
Injuries:
0
Deaths:
0
#10282734September 3, 2009
FUEL SYSTEM, GASOLINE
SINCE JUNE OF 2009, MY 2005 FORD F-150 SUPERCREW HAS, WITHOUT ANY WARNING, EITHER LOST ALL POWER OR THE ENGINE WAS REDUCED TO IDLE RPM AT HIGHWAY SPEEDS THREE TIMES. EACH TIME, I WAS IN RUSH-HOUR TRAFFIC AND HAD TO MANEUVER ACROSS BUSY LANES WHILE COASTING. IN THE TWO INCIDENTS IN WHICH THE ENGINE STALLED, I HAD TO ACCOMPLISH THIS WITHOUT POWER STEERING OR BRAKES. IN THE THIRD INCIDENT, THE ENGINE WAS IDLING SO P/S AND P/B WERE FUNCTIONING, BUT THERE WAS NO RESPONSE TO THROTTLE INPUTS FOR ACCELERATION. THE CHECK ENGINE AND "WRENCH" WARNING LIGHTS WERE ILLUMINATED ON THE DASHBOARD. AFTER TURNING OFF THE IGNITION SWITCH FOR SEVERAL SECONDS, THE VEHICLE RE-STARTED AND WAS ABLE TO ACCELERATE NORMALLY, BUT THE CHECK ENGINE LIGHT REMAINED ILLUMINATED FOR SEVERAL DAYS (THE "WRENCH" LIGHT WENT OFF AFTER RE-START). I WAS FORTUNATE IN THAT I AM A VERY CONFIDENT DRIVER AND WAS ABLE TO QUICKLY ASSESS THE SITUATION AND REACT PROPERLY TO GET SAFELY TO THE SIDE OF THE ROAD. IF MY WIFE HAD BEEN DRIVING THE VEHICLE, I FEAR THAT SHE WOULD NOT HAVE BEEN SO LUCKY. IN DOING RESEARCH ON THIS PROBLEM ON THE INTERNET, IT APPEARS TO BE WIDE SPREAD OVER MULTIPLE VEHICLES (F-150, EXPEDITION, ETC.) MANUFACTURED IN THE 04-05 TIME FRAME. AS THIS PROBLEM IS INTERMITTENT AND COMES WITH ABSOLUTELY NO WARNING, IT IS CLEARLY A SAFETY ISSUE FOR DRIVERS OF THESE FORD VEHICLES. I HAVE CHECKED MY VIN ON THE FORD WEBSITE, AND THERE HAS BEEN NO RECALL ISSUED. PLEASE HELP! *TR
Crash:
No
Fire:
No
Injuries:
0
Deaths:
0
#10282683September 2, 2009
AIR BAGS:FRONTAL
MY SON, 49 YEARS OLD, WAS BACKING OUT OF HIS DRIVEWAY, ON LEVEL GROUND, AND THE AIRBAG BLEW UP IN HIS FACE. HIS HEAD WAS TURNED SIDEWAYS LOOKING IN THE SIDE MIRROR HURTING HIS NECK. TOOK THE PICKUP TO THE FORD DEALER SHIP IN GAINESVILLE, TX. THEY REPLACED THE AIRBAG AND OTHER PARTS AND SAID A WIRE SHORTED OUT IN THE STEERING COLUMN A DEFECTIVE WIRE. THIS COULD HAVE KILLED MY SON IF HE HAD BEAN DRIVING DOWN THE HIGHWAY AT 70 MILES PER HOUR.THIS WAS A FORD 150 2005 PICKUP. *TR
Crash:
No
Fire:
No
Injuries:
0
Deaths:
0
#10282227August 29, 2009
VISIBILITY
I WAS DRIVING MY 2005 FORD F150 AND ALL OF A SUDDEN BAM SOUNDED AS IF SOMEONE THROUGH SOMETHING AT MY PASSENGER WINDOW. THE NOISE STARTLED ME SO BAD I ENDED UP SWERVING INTO THE NEXT LANE AND ALMOST CRASHING, COME TO FIND OUT; MY WINDOW FELL INTO THE DOOR AND IS NOW BROKEN. UPON LOOKING INTO THE SITUATION I HAVE REALIZED MANY OTHER COMPLAINTS ONLINE ABOUT POWER WINDOW REGULATOR. THINGS LIKE THIS NEED TO BE RECALLED AND TAKEN CARE OF FOR THE SAFETY OF THE DRIVER. *TR
Crash:
No
Fire:
No
Injuries:
0
Deaths:
0
#10282263August 29, 2009
VISIBILITY:POWER WINDOW DEVICES AND CONTROLS
I HAVE A 2005 FORD F-150 CREW CAB. IN SHORT, THE WINDOW REGULATORS ARE FAILING AT A HIGH RATE, AND YET THE ISSUE IS NO BEING ADDRESSED AT ALL. HOW IS THIS A SAFETY ISSUE, YOU MIGHT ASK? THE WINDOWS- WITHOUT WARNING- WILL MAKE A LOUD POP AND SIMPLY FALL DOWN INTO THE DOOR PANELS. WHEN YOU ARE IN A RAIN STORM OR IF IT IS SNOWING, THIS IS AN ISSUE (ESPECIALLY WITH CHILDREN IN THE VEHICLE). THE LOUD THUD IS ENOUGH TO POSSIBLY MAKE ONE HAVE AN ACCIDENT ON THE ROAD. FORD HAS YET TO ISSUE A TECHNICAL SERVICE BULLETIN OR FORMAL RECALL FOR THIS ISSUE. SOMEONE NEEDS TO LOBBY ON THE BEHALF OF SAFETY OR A CLASS ACTION LAWSUIT SHOULD BE INITIATED.... PLEASE ADVISE. *TR
Crash:
No
Fire:
No
Injuries:
0
Deaths:
0
#10282065August 28, 2009
POWER TRAIN:MANUAL TRANSMISSION, PARKING BRAKE
DRIVING ON ROAD IN SCHOOL ZONE (25 MILES PER HOUR) CHILDREN PLAYING ON SIDEWALK. CHILDREN WERE JUMPING ON OFF SIDEWALK INTO STREET. APPLIED MY BRAKES. HEARD CLUNK IN THE BACK OF THE TRUCK THEN - NO BRAKE. USED EMERGENCY BRAKE TO STOP. FAILURE OCCURRED AS AXLE BROKE, APPARENTLY LOOSE FOR LONG TIME - NOT ORIGINAL OWNER, PURCHASED FROM DEALER. C CLAMP HOLDING AXLE IN PLACE IS DISSOLVED INTO SMALL PIECES CAUSING AXEL TO COME OUT. CALIPER IS TOAST (ONLY THING HOLDING AXLE INTO PLACE) ROTOR, BRAKE PAD, ALL REAR AXLE COMPONENTS - COMPLETELY FAILED, CAUSED OVER $3,000 IN REPAIRS TO TRUCK. EXTENDED WARRANTY WON'T COVER STATING WHEN THE TIRE RUBBED AGAINST THE CURB - THEY CONSIDER THAT AS IMPACT - FORD WANTS NO PART IN FIXING - SAID NO REPORTED PROBLEMS WITH C-CLAMP (NO RECALLS) OR AXEL BREAKING OR SLIPPING AWAY. A TRUE NIGHTMARE! - YOU PAY FOR EXTENDED WARRANTY - BUT THEY DON'T PAY FOR THE REPAIR, YOU BUY A TRUCK FROM A DEALER, YET THEY DON'T CHECK SAFETY - ONLY TIRES, WIPERS AND SMALL STUFF. CONSUMER IS FORCED TO BEAR ANY DEFECTIVE PARTS ON THEIR OWN. REALLY FRUSTRATED. *TR
Crash:
No
Fire:
No
Injuries:
0
Deaths:
0
#10281820August 26, 2009
INTERIOR LIGHTING
TL*THE CONTACT OWNS A 2005 FORD F150. THE CONTACT STATED HIS VEHICLE CAUGHT FIRE. THE LIGHT BULB IN THE CONSOLE WHERE THE SHIFT LEVER IS LOCATED FELL OUT ON THE INSIDE AND BURNED A HOLE THROUGH THE SIDE. THE VEHICLE WAS TAKEN TO THE DEALER TO BE REPAIRED AND THE BULB WAS REPLACED. CONTACT DID NOT KNOW HIS VIN NUMBER. THE FAILURE MILEAGE WAS 53,000. BL
Crash:
No
Fire:
Yes
Injuries:
0
Deaths:
0
#10281888August 26, 2009
VISIBILITY:POWER WINDOW DEVICES AND CONTROLS
I WAS JUST DRIVING DOWN THE ROAD AND WENT TO ROLL MY WINDOW DOWN (POWER WINDOWS) ON THE DRIVER SIDE AND ALL OF A SUDDEN IT FELL INSIDE THE DOOR. NOW IT WON'T GO UP OR DOWN. I READ OVER 1000 COMPLAINTS ABOUT THIS SAME PROBLEM AND FORD REFUSES TO FIX IT, THEY WANT OVER $400 TO FIX IT. I OWN A 2005 FORD F-150 LARIAT. THIS IS DANGEROUS AND SHOULD BE A RECALL ITEM FOR SAFETY FROM FORD. *TR
Crash:
No
Fire:
No
Injuries:
0
Deaths:
0

← Back to Ford F-150