Ford F-150 Complaints (2001)

1,236 consumer complaints on file.

#10148732January 26, 2006
POWER TRAIN:DRIVELINE:DRIVESHAFT
DT*: THE CONTACT STATED WHILE ATTEMPTING TO SHIFT FROM DRIVE TO REVERSE, THE VEHICLE MADE A CLICKING SOUND AND WOULD NOT MOVE FORWARD. THE CONTACT PHYSICALLY PUSHED THE VEHICLE INTO THE DRIVEWAY. AFTER FURTHER INSPECTION, THE CONTACT DETERMINED THE DRIVE SHAFT WAS BROKEN. THE DRIVE SHAFT BROKE IN TWO ALONG THE WELDS. THE DRIVE SHAFT WAS REMOVED AND TAKEN TO THE DEALER. THE DEALER SUGGESTED SENDING THE PART TO THE MANUFACTURER FOR INSPECTION. UPDATED 2/28/2006 - *NM
Crash:
No
Fire:
No
Injuries:
0
Deaths:
0
#10148304January 22, 2006
POWER TRAIN:MANUAL TRANSMISSION
DIFFICULTY IN SHIFTING, CLUTCH TO THE FLOOR/NON-RESPONSIVE. UPON TAKING IN TO DEALER PROBLEM WAS DUE TO CLUTCH SLAVE CYLINDER FAILURE. THIS RENDERED THE VEHICLE NON-OPERABLE. DEALER REPLACED CLUTCH SLAVE CYLINDER AND WAS AUTHORIZED TO REPLACE CLUTCH DUE TO WEAR AND LABOR INVOLVED SHOULD IT FAIL IN THE NEAR FUTURE. *JB
Crash:
No
Fire:
No
Injuries:
0
Deaths:
0
#10147062January 6, 2006
VEHICLE SPEED CONTROL
DT*: THE CONTACT STATED THERE IS A RECALL, NHTSA CAMPAIGN # 05V388000, ON THE VEHICLE REGARDING THE VEHICLE SPEED CONTROL. THE PARTS NEEDED TO REPAIR THE VEHICLE ARE NOT AVAILABLE AT THE LOCAL DEALERSHIP. THE CONTACT SPOKE TO THE MANUFACTURER WHO HAS CONFIRMED THE PARTS ARE NOT AVAILABLE. ALTHOUGH A INTERIM REPAIR HAS BEEN PERFORMED BY THE DEALER, THE PART HAVE NOT BEEN REPLACED DUE TO THE UNAVAILIBILITY OF PARTS.
Crash:
No
Fire:
No
Injuries:
0
Deaths:
0
#10146309December 28, 2005
SEAT BELTS:FRONT:BUCKLE ASSEMBLY
DT: THE CONTACT STATED THE SEAT BELT O FRONT PASSENGER'S SEAT WILL NOT BUCKLE; IT WAS REPLACED 4 YEARS AGO. THE DEALER AND MANUFACTURER WERE CONTACTED, AND THEY STATED THERE WERE NO RECALLS THE SEAT BEAT BUCKLE HAS NOT BEEN REPAIRED.*AK
Crash:
No
Fire:
No
Injuries:
0
Deaths:
0
#10145527December 17, 2005
ENGINE AND ENGINE COOLING:ENGINE
I HAVE A 2001 FORD F150 WITH A 4.2L V6 ENGINE AND AT 97,500 MILES IT STARTED TO LEAK ANTIFREEZE. A MECHANIC TOLD ME THAT IT IS A PROBLEM THAT HE HAS SEEN IN MANY F150 TRUCKS WITH THE 4.2L V6. HE SAID THAT THE LOWER INTAKE GASKET AS WELL AS THE TIMING COVER GASKET HAVE TO BE REPLACED TO FIX THIS PROBLEM. *JB
Crash:
No
Fire:
No
Injuries:
0
Deaths:
0
#10145412December 15, 2005
ELECTRICAL SYSTEM, VEHICLE SPEED CONTROL:CRUISE CONTROL
PRELIMINARY DATA.. FORD F150 2001 SUPERCREW WAS LEFT UNATTENDED WHILE SHOPPING. UPON RETURN I NOTED A PUDDLE OF FLUID THAT WAS NOT PRESENT EARLIER UNDER THE VEHICLE. UPON LEANING DOWN ON THE DRIVERS SIDE FRONT TO INSPECT FOR THE SOURCE OF THE LEAK SMALL FLAMES WERE NOTED IN THE ENGINE COMPARTMENT. UPON OPENING THE HOOD FOR FURTHER INSPECTION IT WAS NOTED THAT THE REAR DRIVER SIDE OF THE ENGINE COMPARTMENT WAS ON FIRE (APPEARING TO ME AND OTHER OBSERVERS TO BE ELECTRICAL IN NATURE) WITH THE BRAKE FLUID RESERVOIR COMPLETED MELTED. THE FLAMES FIRST OBSERVED WERE FORCED BY THE MOLTEN PLASTIC DRIPPING DOWN INTO THE ENGINE COMPARTMENT. THE FIRE DEPARTMENT WAS NOTIFIED BUT THANKS TO SOME EMPLOYEES OF THE SHOP AND THE AVAILABILITY THERE OF AN APPROVED EXTINGUISHER, THE FIRE WAS TERMINATED BEFORE THE ARRIVAL OF THE FIRE DEPARTMENT SOME 7 MINUTES LATER. COMMENTS WERE MADE BY OTHERS AND LATER BY INTERNET RESEARCH THAT THE DAMAGE HAS ALL OF THE APPEARANCES OF BEING FORCED BY THE SPEED CONTROL DEACTIVATION SWITCH ISSUE. THE VEHICLE IS CURRENTLY UNDER EVALUATION BY A FORD DEALERSHIP AND MY INSURANCE COMPANY. FORTUNATELY THE VEHICLE WAS UNOCCUPIED AT THE TIME AND WAS IN THE MIDDLE OF A STRIP CENTER PARKING LOT WITH NO VEHICLES AROUND IT SHOULD THE FIRE HAD TIME TO DEVELOP FURTHER. EARLIER OR LATER, IT COULD HAVE EASILY CONSUMED MY HOME.*JB
Crash:
No
Fire:
Yes
Injuries:
0
Deaths:
0
#10144707December 7, 2005
ENGINE AND ENGINE COOLING:ENGINE
TOOK TRUCK TO DEALER AFTER HEARING LOW END TICKING SOUND AND MIL LIGHT, TOLD IT WAS TENSIONER AND MANIFOLD SPACER. PICKED UP TRUCK 8 DAYS LATER AND STILL HAD PROBLEM, RETURNED AND TOLD BY HEAD MECH. THAT IT WAS A NORMAL SOUND. DROVE HOME AND IT WAS MISSING BADLY. RETURNED WAS TOLD HAD A BAD PLUG, TRUCK IS STILL TICKING AND LOUDLY. DEALER WASHED HANDS OF PROBLEM.*JB
Crash:
No
Fire:
No
Injuries:
0
Deaths:
0
#10144446December 5, 2005
POWER TRAIN:CLUTCH ASSEMBLY
THE SLAVE CYLINDER ON THE CLUTCH ASSEMBLY LEAKS MAKING THE CLUTCH INOPERABLE AND THE DRIVER UNABLE TO DISENGAGE THE TRANSMISSION. THE PROBLEM IS WELL KNOWN WITH FORD F150 OWNERS YET THERE HAS NOT BEEN A RECALL ISSUED. *NM
Crash:
No
Fire:
No
Injuries:
0
Deaths:
0
#10143346November 21, 2005
SERVICE BRAKES, HYDRAULIC:FOUNDATION COMPONENTS:DISC:CALIPER
THE TWO MOUNTING BOLTS FOR THE FRONT BRAKE CALIPERS COME LOOSE. IT HAS HAPPENED TWICE, IN EACH CASE IT HAS OCCURRED ON THE LEFT AND RIGHT FRONT CALIPERS. BOTH TIMES IT HAS HAPPENED AFTER A BRAKE JOB. AFTER APPROXIMATELY 200-300 MILES ON THE NEW PADS, THE CALIPER BOLTS CAN BE RE-TIGHTENED AND DO NOT COME LOOSE AGAIN. *JB
Crash:
No
Fire:
No
Injuries:
0
Deaths:
0
#10142562November 14, 2005
ENGINE AND ENGINE COOLING:ENGINE:GASOLINE:BELTS AND ASSOCIATED PULLEYS
DT: THE CONSUMER'S VEHICLE WAS AT A RED LIGHT AND HEARD A LOUD POPPING NOISE FROM THE UNDERNEATH THE HOOD. UPON ACCELERATION THE VEHICLE BEGAN TO SHAKE. THE CONSUMER PULLED OVER TO INSPECT THE VEHICLE AND DISCOVERED A SPARK PLUG WAS LYING ON TOP OF THE ENGINE. THE CONSUMER LATER DROVE THE VEHICLE TO A REPAIR SHOP. THE MECHANIC INSPECTED THE VEHICLE AND CONSULTED A FORD DEALER. THE MECHANIC USED A HEEL COIL TO RESOLVE THE PROBLEM AS SUGGESTED BY THE FORD DEALER. THE VEHICLE COULD NOT BE COMPLETELY REPAIRED DUE TO A LACK OF TOOLS TO SET THE TIMING CHAIN ON THE VEHICLE. FORD DID NOT HAVE THESE SPECIAL TOOLS AVAILABLE TO THE PUBLIC. NO FURTHER REPAIRS COULD BE MADE BY THE MECHANIC AT THIS TIME. *AK (12/02/05)*SC
Crash:
No
Fire:
No
Injuries:
0
Deaths:
0
#10140743October 25, 2005
SEAT BELTS:FRONT
FRONT PASSENGER SIDE SAFETY BELT LATCH DOES RELEASES AT ANY GIVEN TIME. IT ALWAYS LATCHES WITH NO PROBLEMS AND APPEARS SECURE, YET WILL COME UNDONE WHILE DRIVING. THIS LATCH RELEASES WITH EASE WHILE DRIVING AT ANYTIME. THIS HAS BECOME MORE PREVALENT NOW THAT MY KIDS ARE OLD ENOUGH TO BE IN THE FRONT SEAT. WHEN TESTING ITS SECURITY AFTER INITIALLY LATCHING, IT WILL COME UNLATCHED WHEN TUGGING ON THE STRAP HARD. THIS LATCH HAS ALREADY BEEN CHECKED FOR FOREIGN OBJECTS AND NONE WERE FOUND. THE FORD DEALERSHIP CONTINUES NOT TO CHECK FOR DEFECT WITHOUT CHARGE AND AM VERY UPSET ABOUT THAT. THEY STATE THAT MY VIN NUMBER IS NOT INCLUDED IN THIS RECALL, BUT DEFINITELY HAS THE SAME PROBLEMS AS THE OTHERS. I AM VERY CONCERNED WITH THE SAFETY NOW THAT MY KIDS ARE ABLE TO RIDE IN THE FRONT PASSENGER SEAT. SINCE OWNERSHIP, THERE HAVE BEEN EVENTS EVERY TIME A PASSENGER SAT UP FRONT. THERE HAVE BEEN NO DEATHS, INJURIES, FIRES, DAMAGE AS YET.*JB
Crash:
No
Fire:
No
Injuries:
0
Deaths:
0
#10140587October 24, 2005
ENGINE AND ENGINE COOLING:ENGINE
OUR FORD F150 HAS 46,000 MILES ON IT. ON FRIDAY THE 14TH MY HUSBAND WAS DRIVING DOWN A RESIDENTIAL STREET WHEN HE HEARD A LOUD BANGING UNDER THE HOOD. HE PULLED OVER RIGHT AWAY AND THE ENGINE DIED. HE LOOKED UNDER THE HOOD AND COULD SEE THAT THE DISTRIBUTOR CAP WAS BROKEN AND FLOPPING AROUND. HE HAD A FRIEND TOW THE TRUCK TO THE FRIENDS RESIDENCE SO THAT THE TRUCK WOULDN'T BE LEFT ON THE SIDE OF THE ROAD. MY HUSBAND THEN CALLED A TOW COMPANY TO TOW THE TRUCK 18 MILES TO A NEARBY DEALERSHIP TO EXAMINE THE TRUCK. WE WERE TOLD THAT THE SPARK PLUG THREADS WERE STRIPPED AND THAT NEW HEADS WOULD BE REQUIRED TO REPAIR OUR TRUCK. WE WERE ALSO INFORMED THAT OUR EXTENDED WARRANTY DID NOT COVER THIS REPAIR AND THAT OUR BILL WOULD BE APPROX $3,200.00. AFTER THE TOW BILL, PARTS, LABOR AND RENTAL CAR WE ARE NOW UP TO $3,500.00 IN EXPENSES. *JB
Crash:
No
Fire:
No
Injuries:
0
Deaths:
0
#10140516October 23, 2005
ENGINE AND ENGINE COOLING:ENGINE
2001 FORD F150 SUPERCREW 5.4 LITER TRITON V8 ENGINE. ON SEPT 16, 2005 MY TRUCK EXPERIENCED A #7 SPARK PLUG BLOWOUT. THE HEAD WAS REPLACED. ONE MONTH LATER, THE OTHER HEAD EXPERIENCED A SPARK PLUG BLOWOUT. IT SEEMS THERE ARE NOT ENOUGH THREADS TO HOLD THE SPARK PLUGS IN THE ENGINE DURING NORMAL OPERATIONS. THE ENGINE ONLY HAS 71,000 MILES ON IT. AT 60,000 MILES, THE FORD SERVICE CENTER REPLACED THE SPARK PLUGS IN ACCORDANCE WITH THE FORD MOTOR COMPANY MANUFACTURER SPECIFICATIONS AND RECOMMENDED MAINTENANCE SCHEDULE. *NM
Crash:
No
Fire:
No
Injuries:
0
Deaths:
0
#10140245October 19, 2005
ENGINE AND ENGINE COOLING
DT: 2001 FORD F150. THE CONTACT STATED, ON OCTOBER 16, 2005 THE SPARK PLUG FLEW OUT OF HIS VEHICLE. THE VEHICLE WAS NOT ABLE TO BE DRIVEN AT THAT TIME. IT WAS PULLED OFF THE ROAD AND TOWED TO A LOCAL SHOP. THE MECHANIC DID NOT KNOW WHY THIS OCCURRED. ACCORDING TO FORD, THEY HAVE NOT HEARD OF THIS PROBLEM. THE VEHICLE HAS NOT BEEN FIXED AT THIS TIME. THE HEAD NEEDS TO BE REPLACED AS A RESULT.*AK
Crash:
No
Fire:
No
Injuries:
0
Deaths:
0
#10140112October 18, 2005
VEHICLE SPEED CONTROL:CRUISE CONTROL
ON THE EVENING OF OCT. 4, 2005 AT 5:50 PM, I ARRIVED HOME FROM WORK AND PARKED MY 2001 FORD F150 SUPERCREW IN MY GARAGE. I HAD A NORMAL EVENING AND RETIRED TO BED AT 10:00 PM AT APPROXIMATELY 11:30PM THE SMOKE DETECTOR IN MY HOME AWAKENED ME. I JUMPED OUT OF BED AND RAN TO THE OTHER SIDE OF MY HOUSE AND OBSERVED THROUGH THE DOOR INTO THE GARAGE, MY F150 ON FIRE. THE FLAMES WERE FULLY INVOLVING THE FRONT OF THE CAR WITH FLAMES SHOOTING OUT OF BOTH WHEEL WELLS AND JUST INSIDE THE WINDSHIELD ON THE DRIVERS SIDE. I CALLED 911 AND THE FIRE DEPARTMENT ARRIVED QUICKLY BUT TOO LATE TO SAVE MY TRUCK OR MY HOUSE AND CONTENTS WHICH WERE SUBSEQUENTLY DESTROYED. I DID NOT KNOW OF NOR DID I RECEIVE A NOTIFICATION OF THE RECALL FROM FORD REGARDING THE CRUISE CONTROL SWITCH. AS A MATTER OF FACT I HAVE YET TO RECEIVE NOTICE. *JB
Crash:
No
Fire:
Yes
Injuries:
0
Deaths:
0
#10140015October 17, 2005
ENGINE AND ENGINE COOLING:ENGINE
DT: THE CONTACT OWNS 2001 FORD F-150. THERE IS A CLATTERING SOUND COMING FROM THE ENGINE. UPON INSPECTION OF THE VEHICLE THE DEALER STATED THAT THE ENGINE NEEDED TO BE REPLACED. THE REASON FOR REPLACEMENT WAS THAT THERE WAS A ROD KNOCKING IN THE ENGINE. THE MANUFACTURER HAS NOT BEEN CONTACTED. *AK UPDATED 11/16/05. *JB
Crash:
No
Fire:
No
Injuries:
0
Deaths:
0
#10140038October 17, 2005
VEHICLE SPEED CONTROL:CRUISE CONTROL
2001 FORD F-150 FORD PICK UP TRUCK CAUGHT FIRE. ALSO CAUSING DAMAGE TO OUR 2002 CAMPER. *JB
Crash:
No
Fire:
Yes
Injuries:
0
Deaths:
0
#10139594October 13, 2005
ENGINE AND ENGINE COOLING
DT: THE CONSUMER OWNS A 2001 FORD F150. ON 9-2-05 WHILE DRIVING ON INTERSTATE HE HEARD A LOUD POP AND LOST POWER, PULLED OVER AND FOUND THAT A SPARK PLUG BLEW OUT OF THE ENGINE. THE CONSUMER DROVE THE VEHICLE TO THE DEALERSHIP, THEY SAID THAT THE ENGINE HEAD WOULD HAVE TO BE REPLACED AND THE COST WOULD BE OVER $3000. THE CONSUMER HAD IT REPAIRED AT A COST OF $33000. THE CONSUMER TALKED TO SEVERAL DIFFERENT DEALERSHIPS AND THEY OFFERED NO ASSISTANCE. *AK (11/17/05) *SC
Crash:
No
Fire:
No
Injuries:
0
Deaths:
0
#10136941October 6, 2005
POWER TRAIN:DRIVELINE:DIFFERENTIAL UNIT
DT: THE CONSUMER STATED THAT THE REAR DIFFERENTIAL ON HIS 2001 FORD F150 RUSTED. THE CONSUMER WAS HAVING THE VEHICLE FIXED. THE VEHICLE WAS REGULARLY MAINTAINED. THE DEALERSHIP/MANUFACTURER WERE NOT NOTIFIED. THE CONSUMER SAID THAT THE RUSTING STARTING ABOUT A YEAR AGO.*AK THE CONSUMER STATED THE REAR DIFFERENTIAL COVER HAS RUSTED THROUGH AND WAS LEAKING FLUID. THE RUST WAS NOT ISOLATED TO JUST ONE SPOT. *JB
Crash:
No
Fire:
No
Injuries:
0
Deaths:
0
#10138425October 4, 2005
POWER TRAIN:AUTOMATIC TRANSMISSION
TRANSMISSION LOCKED UP AND WOULD NOT MOVE IN REVERSE HAD TO BE TOWED TO TRANSMISSION SHOP TOTAL REBUILD COST OF $2000 SHOP SAID HE SEES 2 A WEEK WITH THIS PROBLEM 2001 FORD F150 46000 MILES AUTOMATIC TRANSMISSION. *JB
Crash:
No
Fire:
No
Injuries:
0
Deaths:
0

← Back to Ford F-150