Ford F-150 Complaints (2002)

821 consumer complaints on file.

#10262938March 24, 2009
VEHICLE SPEED CONTROL
TL*THE CONTACT OWNS A 2002 FORD F-150. THE CONTACT'S VEHICLE WAS REPAIRED ACCORDING TO NHTSA CAMPAIGN ID NUMBER 05V388000 (VEHICLE SPEED CONTROL) IN 2005. FOUR YEARS LATER, WHILE DRIVING APPROXIMATELY 70 MPH, THE VEHICLE SPEED CONTROL SPONTANEOUSLY ENGAGED ITSELF FOLLOWED BY A PERIOD OF IMMOBILITY. ONE WEEK LATER, WHEN ATTEMPTING TO ENTER THE VEHICLE, THE CONTACT NOTICED FLAMES ERUPTING FROM THE ENGINE COMPARTMENT. WITHIN MINUTES, THE VEHICLE WAS COMPLETELY ENGULFED IN FLAMES AND THE FIRE DEPARTMENT ARRIVED TO EXTINGUISH THE FIRE. THE VEHICLE WAS COMPLETELY DESTROYED. IT HAS NOT YET BEEN DETERMINED WHAT CAUSED THE FAILURE. HE CALLED THE DEALER AND WAS REFERRED TO THE MANUFACTURER. THE CONTACT CALLED THE MANUFACTURER AND IS CURRENTLY WAITING FOR A RESPONSE. HE HAS COPIES OF THE FIRE REPORT AND PICTURES OF THE FAILED INCIDENT. THE FAILURE AND CURRENT MILEAGES WERE 100,000. UPDATED 05/05/09 *BF THE CONSUMER BELIEVED THE FIRE WAS A RESULT OF THE RECALL. THE CONSUMER STATED THE CRUISE CONTROL SWITCH WAS MOUNTED TO THE VEHICLE BRAKES SYSTEM, IN WHICH SUBSEQUENT FIRES IS CAUSED BY BRAKE FLUID LEAKING ONTO THE SWTICH WHICH WOULD IGNITE. UPDATED 05/06/09.*JB
Crash:
No
Fire:
Yes
Injuries:
0
Deaths:
0
#10261639March 12, 2009
ENGINE AND ENGINE COOLING
2002 FORD F-150 W/ 5.4 L V-8 ENGINE----SPARK PLUGS KEEP BLOWING OUT OF ENGINE. *TR
Crash:
No
Fire:
No
Injuries:
0
Deaths:
0
#10261493March 11, 2009
SEAT BELTS
ON SEVERAL OCCASIONS, MY PASSENGER FRONT SEAT BUCKLE TO THE SEAT BELT BECOMES UNSECURED WHILE TRAVELING. I TOOK IT TO THE LOGANVILLE FORD DEALERSHIP AND THEY STATED NO RECALLS HAVE BEEN ESTABLISHED ON THE ITEM. SEVERAL COMPLAINTS WERE MADE ON THE NHTSA SITE, HOWEVER, NO RECALLS ARE NOTED. A RECALL WAS ISSUED ON THE 2001 FORD F150 AND SHOULD BE EXTENDED TO INCLUDED 2002. THIS IS AN EXTREME SAFETY HAZARD WHICH COULD RESULT IN THE DEATH OF A PASSENGER IN THE VEHICLE. *TR
Crash:
No
Fire:
No
Injuries:
0
Deaths:
0
#10261435March 10, 2009
SERVICE BRAKES, HYDRAULIC, VEHICLE SPEED CONTROL
TL*THE CONTACT OWNS A 2002 FORD F150. THE VEHICLE WAS REPAIRED ACCORDING TO NHTSA CAMPAIGN ID NUMBER 05V388000 (VEHICLE SPEED CONTROL). A HARNESS WAS INSTALLED, BUT IT DID NOT REMEDY THE HARNESS AND VEHICLE SPEED CONTROL SWITCH FAILURES BECAUSE THERE WAS NO LEAK AT THE TIME. CURRENTLY, BRAKE FLUID IS LEAKING AROUND THE SWITCH FROM THE MASTER CYLINDER AND THE CRUISE CONTROL. THE DEALER AND MANUFACTURER STATED THAT THEY PREVIOUSLY REPAIRED THE CRUISE CONTROL SWITCH, BUT THE CONTACT DISAGREES. THE DEALER AGREES THAT IT NEEDS TO BE REPAIRED CURRENTLY; HOWEVER, THE CONTACT WOULD BE RESPONSIBLE FOR THE EXPENSES. THE FAILURE MILEAGE WAS 140,000.
Crash:
No
Fire:
No
Injuries:
0
Deaths:
0
#10261383March 9, 2009
POWER TRAIN
I WAS DRIVING ON THE HIGHWAY HOME. ALL OF A SUDDEN A LOUD BANG HAPPENED UNDER THE HOOD THAT WAS FOLLOWED BY A CONSTANT PUFFING SOUND. THE TRUCK LOST POWER AND STARTED MISSING. ALL I COULD SMELL WAS GASOLINE. I PULLED OVER TO FIND A COIL ON PLUG SITTING ON TOP OF ENGINE, ALSO HAD A SPARK PLUG SITTING 7 INCHES AWAY FROM COP. I WAS VISITED THE FORD DEALERSHIP AND WAS TOLD THAT PLUGS ARE KNOWN TO HAVE COME OUT OF THE ENGINE AND WAS NOT A NEW PROBLEM. THEY TOLD ME THAT FORD WAS NOT FIXING THIS PROBLEM, BUT HAD A FORD APPROVED WAY TO FIX THE PROBLEM. THE COST WOULD BE AROUND 500 DOLLARS FOR INSERT AND AROUND 3500 DOLLARS FOR NEW HEADS WITCH IS THE ONLY GUARANTEE THAT THIS WOULD PREVENT THIS FROM HAPPENING AGAIN. FORD PLANS NOT TO RECALL THIS PROBLEM, THEY ARE FULLY AWARE THAT THIS HEADS HAS 4 THREADS HOLDING THE PLUG IN, WHEN THEY COME LOSE THE THREADS ARE DESTROYED FROM THE POUNDING CAUSED BY THE COMPUSTION PROCESS. THIS VERY DANGEROUS, COIL SPARK CAN IGNITED FUEL SPRAYED IN THE ENGINE COMPARTMENT CAUSING FIRE, LOSE OF CONTROL AND PERSONAL INJURY OR DEATH, DEPENDING ON THE CIRCUMSTANCE. I HAVE A FAMILY AND THEY COULD HAVE BEEN SERIOUSLY INJURED WHEN THIS HAPPENED. PLEASE DO SOMETHING TO MAKE THIS FROM HAPPENING TO ANY ONE ELSE, AND BEFORE SOMEONE LOSES THEIR LIFE. THE COIL ON PLUG OS LOCATED UNDER THE FUEL RAIL AND HAS ENOUGH FORCE TO DAMAGE THE FUEL RAIL CAUSE IT BREAK AND SPILL GASOLINE ALL OVER THE ENGINE, WHICH COULD CAUSE AN EXPLOSION. I HAD A INSERT INSTALLED AND A NEW PLUG INSERTED WAS TOLD THERE IS NO GUARANTEE THE SPARK PLUG WOULD STAY IN. *TR
Crash:
No
Fire:
No
Injuries:
0
Deaths:
0
#10261094March 8, 2009
STRUCTURE
PAINT PEELING IN SMALL SHEETS AROUND EDGES OF HOOD. SEVERAL COMPLAINTS FOUND ONLINE BUT, CAN FIND NO RECALL ON VEHICLE. HAS ALUMINUM HOOD ALSO. ONLY PAINT PEELING AS PRIMER STILL SHOWING. *TR
Crash:
No
Fire:
No
Injuries:
0
Deaths:
0
#10261112March 8, 2009
STRUCTURE:FRAME AND MEMBERS
THE FACTORY PAINT ALREADY HAS TO BE REPAINTED THE WHOLE PAINT JOB IS CRACKED ALL OVER THE TRUCK SO BAD THAT IT WILL HAVE TO BE SANDED TO THE METAL AND COST OVER 4000 TO REPAINT. *TR
Crash:
No
Fire:
No
Injuries:
0
Deaths:
0
#10261038March 7, 2009
VEHICLE SPEED CONTROL
2002 FORD F-150 FIRE RESULT OF CRUISE CONTROL SWITCH. *TR
Crash:
No
Fire:
Yes
Injuries:
0
Deaths:
0
#10259967February 25, 2009
POWER TRAIN:AUTOMATIC TRANSMISSION
MY 2002 F-150 SUPERCREW 4X2 WITH 4.6LV8 EXPERIENCED A FAILURE OF THE AUTOMATIC TRANSMISSION ON SATURDAY AT ONLY 75K MILES. THE RESULT IS A REBUILD/REPLACEMENT FOR >$2000.00! I DON'T TOW ANYTHING WITH THE VEHICLE AND IT ISN'T ABUSED. THIS TYPE OF FAILURE IS VERY PREMATURE! THE TRUCK HAS BEEN VERY WELL MAINTAINED. MY MECHANIC SAYS THERE IS A HISTORY WITH THIS TRANSMISSION IN THE FORD TRUCKS/SUV'S HAVING LUBRICATION PROBLEMS. FORD SHOULD STEP UP AND TAKE RESPONSIBILITY FOR THE DESIGN DEFECT! *TR
Crash:
No
Fire:
No
Injuries:
0
Deaths:
0
#10259326February 19, 2009
VEHICLE SPEED CONTROL
VEHICLE WAS PARKED IN MY DRIVEWAY AND CAUGHT FIRE. THE FIRE IGNITED MY OTHER VEHICLE THAT WAS PARKED NEXT TO IT AND ALSO CAUSED DAMAGES TO MY HOME. BOTH VEHICLES WERE A TOTAL LOSS. *TR
Crash:
No
Fire:
Yes
Injuries:
0
Deaths:
0
#10258922February 17, 2009
ENGINE AND ENGINE COOLING
MY 2002 FORD F-150 BLEW A SPARK PLUG RIGHT OUT OF THE CYLINDER WHILE DRIVING ON RT 85 IN CONNECTICUT. THE DANGER FROM THIS WAS GREAT AS THERE WAS GAS SPLASHED THROUGHOUT THE ENGINE COMPARTMENT. WENT T THE FORD DEALER AND THEY PLAYED DOWN THE SITUATION AND SAID IT WOULD COST $600.00 TO FIX. I ALSO INCURRED A $200.00 TOWING BILL, AND HAD TO REPLACED A SPARK PLUG COIL WHICH WAS DAMAGED BY THE SPARK PLUG TO THE TUNE OF $100.00. THE INTERNET HAS PROVIDED INFORMATION THAT THIS IS A SIGNIFICANT PROBLEM WITH FORD V-8 ENGINES, AND I'M WONDERING WHY THE NHTSA LETS THIS CONTINUE...MANY PEOPLE ARE SUFFERING FINANCIAL LOSS, AND SAFETY ISSUES WITH FIRES THAT RESULT FROM THIS SITUATION. *TR
Crash:
No
Fire:
No
Injuries:
0
Deaths:
0
#10258368February 11, 2009
STRUCTURE
PAINT COMING OFF IN LARGE AREAS. *TR
Crash:
No
Fire:
No
Injuries:
0
Deaths:
0
#10258293February 10, 2009
ENGINE AND ENGINE COOLING
I OWN A 2002 FORD F-150 XLT 4X4 WITH A TRITION 5.4L V-8. I WENT OUT TO START IT THIS MORNING AND I HEARD A LOUD NOISE THAT SOUNDED LIKE A SHOT WENT OFF. THEN MY TRUCK STARTED SHAKING AND MAKING A CHUGGING NOISE. I SHUT IT OFF AND OPENED THE HOOD AND FOUND THAT ONE OF MY SPARK PLUGS JUST BLEW OUT OF THE ENGINE. IT BROKE THE COIL AND STRIPPED OUT THE THREADS WHERE THE SPARK PLUG GOES. I HAD TO HAVE IT TOWED TO A MECHANIC AND IT COST $503.83 FOR THE REPAIR. THE MECHANIC TOLD ME THIS WAS A COMMON PROBLEM WITH THE TRITION ENGINES. I WENT ONLINE AND DID SOME RESEARCH AND FOUND MANY COMPLAINTS OF THE SAME SUBJECT. I THINK FORD NEEDS TO ISSUE A RECALL TO FIX THIS PROBLEM. *TR
Crash:
No
Fire:
No
Injuries:
0
Deaths:
0
#10257560February 5, 2009
LATCHES/LOCKS/LINKAGES, EQUIPMENT:MECHANICAL:CARRIER/RACK
I OWN A 2001 FORD F150 LARIET TRUCK, WHICH I BOUGHT NEW, AND HAVE ONLY APX. 75000 MILES ON IT. I WASH IT REGULARLY AND EVEN SPRAY UP UNDER TRUCK TO REMOVE SALTS EVERY TIME I WASH IT. LUCKILY, OR BETTER, BLESSEDLY, WHILE POISONING MY TRUCK IN MY CAR-PORT THE CABLE HOLDING THE SPARE TIRE(FULL SIZE..ABOUT 100 POUNDS) SNAPPED AND THE TIRE, TIRE BRACKET, AND CABLE (CRIMPED) KNUCKLE FELL ONTO THE CAR PORT. THIS CABLE SHEARED EXACTLY AT THE KNUCKLE AND IT DID SO WITH-OUT ANY PROVOCATION. BY THE GRACE OF GOD, IT DID NOT STOP WHILE I WAS DOING 70 MILES AN HOUR GOING DOWN THE HIGHWAY. IF IT HAD I'M SURE THERE WOULD HAVE BEEN SO MUCH DESTRUCTION TO THE REAR OF MY TRUCK THAT I WOULD NOT BE ABLE TO WRITE THIS. LET ME GO ON TO SAY, I REALLY LIKE THIS TRUCK, IT IS VERY SOLID, VERY RELIABLE, AND ONE OF THE BEST RIDES I'VE EVER OWNED IN MY 53 YEARS OF LIFE. I AM EITHER EXTREMELY LUCKY OR BLESSED THAT THIS HAPPENED IN MY DRIVE. IN FACT, ONLY 5 DAYS BEFORE, MY WIFE, SON AND I HAD RETURNED FROM A TRIP TO WEST VIRGINIA. THIS WAS A TRIP OF 700 MILES AND WE HAD TAKEN HER TAHOE BECAUSE IT HAS 4 WHEEL DRIVE AND MY FORD DOES NOT!!! *TR
Crash:
No
Fire:
No
Injuries:
0
Deaths:
0
#10257360February 3, 2009
ENGINE AND ENGINE COOLING:ENGINE, FUEL SYSTEM, GASOLINE
WHILE DRIVING AT 45 MPH ON LEVEL SURFACE THE #5 SPARK PLUG WAS EJECTED FROM IT'S HOLE DAMAGING THE COIL OVER PLUG CAUSING ARCING FROM THE COIL TO THE ENGINE. THE VEHICLE IMMEDIATELY SLOWED DRAMATICALLY AND THE SMELL OF GASOLINE WAS APPARENT. LUCKILY THERE WAS VERY LIGHT TRAFFIC AND I WAS ABLE TO PULL TO THE SIDE OF THE ROAD AND SHUTDOWN THE ENGINE. I IDENTIFIED THE PROBLEM AND HAVING SOME MECHANICAL TRAINING KNEW ENOUGH TO DISCONNECT THE FUEL INJECTOR WIRE FOR THE #5 CYLINDER. THIS WAS THE ONLY WAY I COULD SAFELY MOVE THE VEHICLE. HAD I NOT KNOWN WHAT TO DO, AN ENGINE COMPARTMENT EXPLOSION WOULD HAVE EASILY RESULTED. *TR
Crash:
No
Fire:
No
Injuries:
0
Deaths:
0
#10256622January 28, 2009
ENGINE AND ENGINE COOLING:ENGINE
MY 2002 F150 RECENTLY SPIT OUT A SPARK PLUG, STRIPPING THE THREADS OF THE ALUMINUM CYLINDER HEAD. THE SERVICE SHOP WHERE I TOOK IT TOLD ME THAT IT'S BEEN A MAJOR PROBLEM WITH FORD TRUCKS FOR SOME TIME, AND REFUSED TO FIX IT. *TR
Crash:
No
Fire:
No
Injuries:
0
Deaths:
0
#10256418January 26, 2009
VEHICLE SPEED CONTROL
01/22/09 I PARK MY 2002 F150 AT WORK AT ABOUT 4:00PM. ABOUT 04:40PM THE FIRE ALARM SOUNDED. MY TRUCK WES ON FIRE, I HAD JUST PARK IT! THE FIRE MAN SAID IT WAS ON THE RECALL LIST FOR FIRE'S. *TR
Crash:
No
Fire:
Yes
Injuries:
0
Deaths:
0
#10256262January 25, 2009
ENGINE AND ENGINE COOLING
ON MY BIRTH DAY I EXPERIENCED SOMETHING LIKE NEVER BEFORE I BLEW THE #4 SPARK PLUG ON THE PASSENGER SIDE BROUGHT IT BACK TO WORK WHAT A ROUGH RIDE. THEN STARTED TO LOOK IN THE HOLE WITH A BORE SCOPE TO FIND OUT THE TREADS WERE GONE YEAH. CALLED AROUND TO FIND OUT HOW MUCH IT WOULD COST ME AND THE CHEAPEST WAS A MACHINE SHOP CALLED LENTECH AUTOMOTIVE AT A PRICE OF 300.00 NOT BAD BUT I MADE SOME MORE CALLS AND FOUND A KIT TO DO IT AT BENSONS AUTOPARTS 65.00 HOPE THIS WILL FIX IT. *TR
Crash:
No
Fire:
No
Injuries:
0
Deaths:
0
#10255558January 19, 2009
VISIBILITY, ELECTRICAL SYSTEM, STRUCTURE
THE WINDSHIELD OF MY F150 FORD KING RANCH LEAKS AND HAS DONE DAMAGE TO THE FUSE BOX AND RUST IS OCCURRING IN LOCATIONS NOT EASILY ACCESSED BY WATER. *TR
Crash:
No
Fire:
No
Injuries:
2
Deaths:
0
#10255243January 15, 2009
ENGINE AND ENGINE COOLING:ENGINE
TL*THE CONTACT OWNS A 2002 FORD F-150. WHILE DRIVING 35 MPH, THE SPARK PLUGS FAILED. THE CONTACT PULLED THE VEHICLE OVER AND EXAMINED UNDERNEATH THE HOOD. A WITNESS STATED THAT THERE WAS A NOISE WHEN THIS OCCURRED. THE VEHICLE WAS RESTARTED AND POPPING NOISES WERE HEARD. THE VEHICLE WAS TOWED TO A FORD DEALER AND THEY STATED THAT NOTHING COULD BE DONE AND THE CONTACT WOULD BE RESPONSIBLE FOR THE REPAIRS. THERE WERE NO COMPLAINTS FOUND FOR THIS VEHICLE. THE VEHICLE HAS BEEN REPAIRED. THE FAILURE MILEAGE WAS 43,332 AND CURRENT MILEAGE WAS 43,600.
Crash:
No
Fire:
No
Injuries:
0
Deaths:
0

← Back to Ford F-150