Ford F-150 Complaints (2005)

1,112 consumer complaints on file.

#10439137December 9, 2011
STEERING
TL* THE CONTACT OWNS A 2005 FORD F-150. THE CONTACT STATED THAT THE PRESSURE HOSE WAS LOOSING POWER STEERING FLUID RAPIDLY. THE CONTACT HAD TAKEN THE VEHICLE TO A MECHANIC AND WAS TOLD THAT THE PRESSURE HOSE HAD COMPLETELY ROTTED. THE DEALER INFORMED THE CONTACT THAT THE PART NEEDED FOR REPAIRS WAS ON BACK ORDER BECAUSE THE MANUFACTURER HAD REDESIGNED THE PART, BUT WAS NOT MAKING IT AVAILABLE AS OF YET. THE VIN WAS NOT AVAILABLE. THE FAILURE MILEAGE WAS 64,000 AND THE CURRENT MILEAGE WAS 65,000.
Crash:
No
Fire:
No
Injuries:
0
Deaths:
0
#10438822December 6, 2011
FUEL SYSTEM, GASOLINE, ENGINE AND ENGINE COOLING
THE PROBLEM STARTED IN 2010, IT NOW HAS HAPPEN THREE TIMES THIS YEAR MY 2005 FORD F-150 SUPERCAB HAS WITHOUT ANY WARNING, EITHER LOST ALL POWER OR THE ENGINE WAS REDUCED TO IDLE RPM AT HIGHWAY SPEEDS. A TOTAL OF FIVE TIMES THIS HAS HAPPEN SINCE I BOUGHT THE TRUCK. ITS HAPPEN IN ALL TYPS OF DRIVING, HIGHWAY SPEEDS, CITY DRIVING, ACCELERATION AND AT A STEADY SPEED. I HAVE HAD TO MANEUVER ACROSS BUSY FREEWAY LANES WHILE COASTING. IN THREE OF THE INCIDENTS IN WHICH THE ENGINE STALLED, I HAD TO ACCOMPLISH THIS WITHOUT POWER STEERING OR BRAKES. IN ANOTHER INCIDENT, THE ENGINE WAS IDLING SO P/S AND P/B WERE FUNCTIONING, BUT THERE WAS NO RESPONSE TO THROTTLE INPUTS FOR ACCELERATION. THE CHECK ENGINE AND "WRENCH" WARNING LIGHTS WERE ILLUMINATED ON THE DASHBOARD. AFTER TURNING OFF THE IGNITION SWITCH, THE VEHICLE RE-STARTED AND I WAS ABLE TO CONTINUE, THE WRENCH LIGHT WENT OFF AFTER RESTART, BUT THE CHECK ENGINE LIGHT REMAINED ILLUMINATED UNTIL I HAVE IT RESET. I BEEN VERY FORTUNATE THAT I HAVE NOT BEEN IN AN ACCIDENT. THIS PROBLEM IS INTERMITTENT AND COMES WITH ABSOLUTELY NO WARNING, IT IS CLEARLY A SAFETY ISSUE. I NOW WILL NOT LET MY FAMILY DRIVE THE TRUCK. *TR
Crash:
No
Fire:
No
Injuries:
0
Deaths:
0
#10438019December 1, 2011
ENGINE AND ENGINE COOLING
TL* THE CONTACT OWNS A 2005 FORD F150. THE CONTACT STATED THAT WHILE DRIVING 60 MPH, A LOUD NOISE WAS EMITTED FROM THE ENGINE COMPARTMENT. THE CONTACT MENTIONED THAT THE FAILURE RECURRED TWICE. THE VEHICLE WAS TAKEN TO THE DEALER WHO DIAGNOSED THAT THE SPARK PLUGS WERE NOT TORQUED CORRECTLY, CAUSING THE SPARK PLUGS TO BE SPEWED FROM THE ENGINE BLOCK. THE MANUFACTURER WAS MADE AWARE OF THE FAILURE WHO DID NOT OFFER ANY ASSISTANCE SINCE THE VEHICLE WAS NOT INCLUDED IN ANY RECALLS. THE VEHICLE WAS REPAIRED. THE FAILURE MILEAGE WAS 87,000 AND THE CURRENT MILEAGE WAS 120,000.
Crash:
No
Fire:
No
Injuries:
0
Deaths:
0
#10437456November 28, 2011
VISIBILITY
TL* THE CONTACT OWNS A 2005 FORD F-150. THE CONTACT STATED THAT WHILE DRIVING APPROXIMATELY 45 MPH, HE HEARD A LOUD POPPING NOISE COMING FROM THE FRONT DRIVERS DOOR AND THE WINDOW FELL DOWN INTO THE DOOR PANEL. THE VEHICLE WAS NOT TAKEN TO THE DEALER FOR DIAGNOSTIC TESTING. THE VEHICLE WAS NOT REPAIRED. THE APPROXIMATE FAILURE MILEAGE WAS 62,000.
Crash:
No
Fire:
No
Injuries:
0
Deaths:
0
#10436881November 23, 2011
VISIBILITY
I HAVE HAD TWO WINDOW REGULATORS FAIL AND THE WINDOWS COME CRASHING DOWN UNEXPECTED WHILE DRIVING AT HIGH SPEED IN FORD F150 AND NOT TOUCHING THE WINDOW CONTROLS. THE WINDOWS WILL NOT GO BACK UP AND HAVE HAD TO BE FIXED. I LIVE IN NORTHERN CLIMATE WITH BAD WEATHER AND THE CONDITIONS ARE DANGEROUS TO DRIVE IN WITH A WINDOW DOWN AND CHILDREN IN THE BACK SEAT. *TR
Crash:
No
Fire:
No
Injuries:
0
Deaths:
0
#10435702November 15, 2011
POWER TRAIN
TL* THE CONTACT OWNS A 2005 FORD F-150. THE CONTACT STATED THAT THE FOUR WHEEL DRIVE FEATURE MALFUNCTIONED, CAUSING THE VEHICLE TO ENGAGE THE FOUR WHEEL DRIVE SYSTEM WHILE DRIVING 60 MPH. THE FRONT END OF THE VEHICLE SHOOK VIOLENTLY WHEN THE FAILURE OCCURRED. THE CONTACT TOOK THE VEHICLE TO THE DEALER WHERE THE DEALER REPLACED THE FOUR WHEEL DRIVE SENSOR BECAUSE WATER HAD ENTERED THE OLD SENSOR AND CAUSED THE MALFUNCTION. THE REPLACING OF THE FOUR WHEEL DRIVE SENSOR DID NOT REMEDY THE ISSUE. THE CONTACT CALLED THE MANUFACTURER AND THEY ADVISED THE CONTACT TO TAKE THE VEHICLE BACK TO THE DEALER. THE FAILURE MILEAGE WAS 70,000.
Crash:
No
Fire:
No
Injuries:
0
Deaths:
0
#10435122November 10, 2011
ENGINE AND ENGINE COOLING
WHILE DRIVING TO WORK #5 SPARKPLUG BLEW OUT OF THE BLOCK. WITH THE ENGINE STILL RUNNING FUMES OR GAS VAPORS FROM THE SPARKPLUG HOLE AND THE SPARK FROM THE COIL PACK CAN CAUSE THE ENGINE TO CATCH FIRE OR EVEN EXPLODE!!!! CAUSING BODILY INJURY OR DEATH TO THE OCCUPANT OF THE VEHICLE. *TR
Crash:
No
Fire:
No
Injuries:
0
Deaths:
0
#10434825November 8, 2011
ENGINE AND ENGINE COOLING
AUTO RAN GREAT,FUEL MILEAGE REAL GOOD,THEN SPARKPLUG BLEW OUT WITHOUT ANY ADVANCE INDICATION OF A PROBLEM. *TR
Crash:
No
Fire:
No
Injuries:
0
Deaths:
0
#10433855November 1, 2011
TIRES, TIRES:TREAD/BELT
TL* THE CONTACT OWNS A 2005 FORD F-150 EQUIPPED WITH COOPER DISCOVERER H/T TIRES, SIZE 245/65R17, DOT NUMBER: UP15C56. THE CONTACT WAS DRIVING 55 MPH WHEN THE FRONT PASSENGER SIDE TIRE EXPERIENCED TREAD SEPARATION, CAUSING IT TO SHRED TO PIECES. THE CONTACT MERGED TO THE SHOULDER WHERE HE CHANGED THE TIRE AND INSTALLED THE SPARE. THE FRONT FENDER OF THE VEHICLE WAS DAMAGED AS A RESULT OF THE TIRE FAILURE. THE CONTACT STATED THAT THERE WERE NO ROAD HAZARDS PRESENT THAT COULD HAVE CONTRIBUTED TO THE FAILURE. THE VEHICLE WAS TAKEN FOR ROUTINE MAINTENANCE PRIOR TO THE FAILURE AND THERE WERE NO FAILURES FOUND WITH THE TIRES, WHICH WERE INSPECTED. THE DEALER WAS NOTIFIED OF THE FAILURE WHO FILED A CLAIM WITH THE MANUFACTURER ON BEHALF OF THE CONTACT. THE MANUFACTURER OF THE TIRE WAS NOTIFIED WHO ADVISED THAT THEY WOULD CONTACT HIM AT A LATER DATE. THE TIRE FAILURE MILEAGE WAS 8,000. THE VEHICLE FAILURE MILEAGE WAS 24,000.
Crash:
Yes
Fire:
No
Injuries:
0
Deaths:
0
#10433036October 27, 2011
POWER TRAIN
I WAS COMING TO A STOP WHEN THE TRANSMISSION WOULD NOT RELEASE FROM GEAR AND THEN FINALLY DID WITH A LOUD CLUNK. WHEN I WENT TO DRIVE FORWARD THE ENGINE REVVED UP AND THEN JUMPED INTO GEAR JUMPING THE TRUCK FORWARD. THERE WAS NO WARNING FOR A TRANSMISSION FAILURE IT ALL OF A SUDDEN LOST ALL GEARS. THE MECHANIC AT THE FORD DEALERSHIP SAID IT WAS A KNOWN ISSUE TO THEM AND THAT ONE OF THE INTERNAL SEALS PROBABLY BROKE AND CAUSED A "CATASTROPHIC TRANSMISSION FAILURE." *TT
Crash:
No
Fire:
No
Injuries:
0
Deaths:
0
#10432464October 22, 2011
ENGINE AND ENGINE COOLING
CAMSHAFT PHASERS FAILED SO ENGINE WOULD NOT IDLE, CAUSING A VERY DANGEROUS SITUATION AT STOP SIGNS HAVING TO CONSTANTLY REV ENGINE TO KEEP RUNNING. REPAIR COST $3,897.73. THROUGH INTERNET INVESTIGATION HAVE FOUND MY PARTICULAR YEAR AND ENGINE (5.4L TRITON) HAS A HISTORY OF THIS FAILURE. TOLD THAT A NON-MOTORCRAFT OIL FILTER CAN RELEASE DEBRIS THAT CLOGS A LUBRIVATION PORT IN THE CAM PHASERS WHICH IN TURN DESTROYS THEM. NO INFO. OF THIS SORT WAS EVER RELAYED TO ME ON PURCHASE OF VEHICLE. I HAVE NO REASON TO BELIEVE I HAVE EVER USED ANYTHING BUT A MOTORCRAFT OIL FILTER. A 2005 VEHICLE W/ A $3900.00 MECHANICAL REPAIR IS UNACCEPTABLE. HAVE CONTACTED FORD UNTIL I HAVE EXHAUSTED MY ATTEMPTS. THEY FINALLY TOLD ME THIS WAS THE END OF OUR COMMUNICATIONS. *TR
Crash:
No
Fire:
No
Injuries:
0
Deaths:
0
#10432465October 22, 2011
ENGINE AND ENGINE COOLING
VEHICLE MISFIRED ON ACCELERATION ON HIGHWAY. WAS AWARE OF SPARK PLUG EJECTIONS W/ MY PARTICULAR YEAR AND MODEL AFTER GOING THROUGH CAMSHAFT PHASER REPAIRS. (2005 F-150 W/ 5.4L TRITON ENGINE). MECHANIC SUGGESTED REPLACING ALL FACTORY SPARK PLUGS W/ NEW DESIGNED SPARK PLUG KIT TO ELIMINATE EJECTION PROBLEM. I DID SO AT A COST OF $831.52. COSTS TO DATE $4729.25 WITHIN THE LAST 2 MONTHS ON A 2005 VEHICLE. UNACCEPTABLE. RESEARCHED ON INTERNET AND FOUND THIS TO BE A VERY WELL KNOWN PROBLEM. NO MENTION OF IT FROM THE DEALER UPON PURCHASE. FORD HAS TURNED THEIR BACK ON THIS (AND THE CAMSHAFT PHASER DEFECT). I AM A SMALL CONTRACTOR WHOSE LIVELIHOOD DEPENDS ON THIS VEHICLE. THE PURCHASE PRICE OF $35,890.00 PLUS TAX AND LICENSE WAS A HUGE INVESTMENT FOR ME (I PAID CASH AND DRAINED MY SAVINGS SO I WOULD NOT HAVE MONTHLY PAYMENT). SO THESE ADDITIONAL COSTS TO AN ALMOST NEW VEHICLE HAVE DRAINED MY ACCOUNT AGAIN. *TR
Crash:
No
Fire:
No
Injuries:
0
Deaths:
0
#10429910October 14, 2011
AIR BAGS:FRONTAL:DRIVER SIDE:INFLATOR MODULE
2005 FORD F-150. CONSUMER WRITES IN REGARDS TO NOTICE RECEIVED CONCERNING THE POSSIBILITY OF THE CLOCKSPRING TO DRIVER SIDE FRONTAL AIR BAG WIRE HARNESS TO CHAFE ON THE HORN MOUNTING PLATE *TGW
Crash:
No
Fire:
No
Injuries:
0
Deaths:
0
#10429909October 14, 2011
AIR BAGS:FRONTAL:DRIVER SIDE:INFLATOR MODULE
2005 FORD F150. CONSUMER WRITES IN REGARDS TO RECALL CONCERNING THE CHAFING OF WIRING HARNESS, THAT MAY CAUSE DRIVER SIDE AIR BAG TO DEPLOY WHICH MAY CAUSE INJURY OR LOSS OF CONTROL OF VEHICLE *TGW THE DEALER INFORMED THE CONSUMER THERE WERE NO PARTS AVAILABLE. AS OF SEPTEMBER 6, 2011, THE RECALL STILL HAD NOT BEEN PERFORMED. *JB
Crash:
No
Fire:
No
Injuries:
0
Deaths:
0
#10429944October 12, 2011
AIR BAGS
TL* THE CONTACT OWNS A 2005 FORD F-150. THE CONTACT STATED THAT THE VEHICLE WAS INCLUDED IN THE RECALL ASSOCIATED WITH NHTSA CAMPAIGN ID NUMBER 11V107000 (AIR BAGS:FRONTAL:DRIVER SIDE INFLATOR MODULE). THE VEHICLE WAS TAKEN TO AN AUTHORIZED DEALER AND THE CONTACT WAS INFORMED THAT THE PARTS NECESSARY TO REMEDY THE FAILURE WERE UNAVAILABLE. THE PARTS HAD SINCE BEEN UNAVAILABLE FOR APPROXIMATELY FIVE MONTHS. THE MANUFACTURER WAS NOT MADE AWARE OF THE FAILURE. THE FAILURE MILEAGE WAS 57,000 AND THE CURRENT MILEAGE WAS 60,000.
Crash:
No
Fire:
No
Injuries:
0
Deaths:
0
#10429216October 9, 2011
VISIBILITY:POWER WINDOW DEVICES AND CONTROLS
WINDOW REGULATOR FAILURE. *TR
Crash:
No
Fire:
No
Injuries:
0
Deaths:
0
#10429120October 7, 2011
ENGINE AND ENGINE COOLING
TL* THE CONTACT OWNS A 2005 FORD F-150. WHILE STOPPED, THE CONTACT HEARD A TICKING SOUND COMING FROM THE ENGINE. THE VEHICLE WAS TAKEN TO THE DEALER FOR DIAGNOSTIC TESTING WHERE THE TECHNICIAN STATED THAT THE CAM PHASER AND THE TENTIONERS WOULD HAVE TO BE REPLACED. THE VEHICLE WAS NOT REPAIRED. THE APPROXIMATE FAILURE MILEAGE WAS 39,000.
Crash:
No
Fire:
No
Injuries:
0
Deaths:
0
#10428394October 3, 2011
ELECTRICAL SYSTEM, VISIBILITY:POWER WINDOW DEVICES AND CONTROLS
I JUST BOUGHT THIS VECHILE WITH IN THE PAST 2 WEEKS AND THE WINDOW ON THE DRIVER SIDE, MADE A LOUD GRINDING SOUND .....THEN A LOUD BANG AS THE WINDOW FELL DOWN IN THE DOOR! I'M VERY LUCKY THAT I DID NOT TOTAL MY VECHILE AS I WAS PULLING INTO MAIN TRAFFIC ON A BUSY ROAD THAT I LIVE ON! THIS WAS MY DADS OLD VECHILE AND HE HAD THE SAME PROBLEM WITH THE PASSENGER SIDE.....NOT TO LONG AGO! ALSO HAVE BEEN DOING SOME DIGGING ON THIS ISSUE AND I SEE THAT QUITE A FEW OTHER PEOPLE HAVE BEEN GOING THROUGHT THE SAME PROBLEM AS WELL! JUST MAKING FIRST FEW PAYMENTS AND BOOM!!!! THERE GO'S A BUNCH OF MONEY ON A SAFETY PART THAT REALLY NEEDS FIXED! FORD .........WAKE UP AND FIX THIS ISSUE ALREADY!!! *TR
Crash:
No
Fire:
No
Injuries:
0
Deaths:
0
#10428276October 3, 2011
STRUCTURE
THE PAINT IS PEELING OFF DOWN TO THE METAL ON THE ROOF OF MY TRUCK. THIS IS A $38,000 TRUCK THAT I HAVE KEPT WASHED AND WAXED SINCE I BOUGHT IT. FORD WILL NOT CLAIM RESPONSIBILITY. *TR
Crash:
No
Fire:
No
Injuries:
0
Deaths:
0
#10427760September 28, 2011
POWER TRAIN
TL* THE CONTACT OWNS A 2005 FORD F-150. THE CONTACT STATED THAT THE TRANSMISSION WOULD SLIP AT ANYTIME AT SPEEDS AROUND 60 MPH. THE VEHICLE HAD THE TRANSMISSION REPLACED IN MARCH OF 2011. THE FAILURE RECURRED ON SEPTEMBER 8, 2011. THE VEHICLE WAS REPAIRED BUT THE FAILURE RECURRED ON THE SEPTEMBER 23,2011. THE DEALER WAS IN THE PROCESS OF DIAGNOSING THE FAILURE. THE MANUFACTURER WAS NOT CONTACTED. THE FAILURE MILEAGE WAS UNAVAILABLE AND THE CURRENT MILEAGE WAS 84,855.
Crash:
No
Fire:
No
Injuries:
0
Deaths:
0

← Back to Ford F-150