Ford F-150 Complaints (2018)

2,327 consumer complaints on file.

#11713887January 28, 2026
ENGINE
The cam phasers have gotten so loud that it sounds like a diesel. Ford did some software "fix" that did nothing. I am concerned about trashing the motor if the timing jumps. These defective phasers are well know problems and extremely costly to repair. Ford has advised me to do the repair but they are quoting $5-6k for a fix of something they know was a defective design. My truck has 111k miles now but the rattle has been there almost from the start.
Crash:
No
Fire:
No
Injuries:
0
Deaths:
0
#11713917January 28, 2026
POWER TRAIN
CDF Drum - Transmission Transmission unable to find gear, repeatedly skips when downshifting. Slips when engine braking. Unable to safely exit traffic on the highway. Problem is reproduced at dealer. A common issue nation-wide. Hefty repair bill on a young truck. (90,000 miles) No warning lamps, messages, or symptoms.
Crash:
No
Fire:
No
Injuries:
0
Deaths:
0
#11713959January 28, 2026
SERVICE BRAKES
My truck has the same issue with the brake master cylinder bleeding back into the brake booster. Luckily I caught it before I left work. The reservoir was totally empty on the back half supplying the front brakes. At home pulled the vacuum hose and did the dip stick test and there was brake fluid in the brake booster . There is already a safety recall on the 2017-2018 f150 brake master cylinder but only with the 3.5motor. The 2.7 has the same brake master cylinder so I cannot see why only the 3.5 motor would have a recall??? Ford will not do anything about it and they don’t even have a part until sometime in March.
Crash:
No
Fire:
No
Injuries:
0
Deaths:
0
#11713549January 27, 2026
UNKNOWN OR OTHER
Door locks freeze open in cold weather due to a spring issue that freezes up with very little moisture. It has happened multiple times over the last couple years. Basically, you open the door and when you go to close, the door latch doesn't engage. Here is a video that shows the issue in detail. [XXX] In order to operate the vehicle at that point, you have to hold the door closed manually. INFORMATION REDACTED PURSUANT TO THE FREEDOM OF INFORMATION ACT (FOIA), 5 U.S.C. 552(B)(6)
Crash:
No
Fire:
No
Injuries:
0
Deaths:
0
#11713440January 26, 2026
UNKNOWN OR OTHER
At various times vehicle can take up to 3 minutes or restart of vehicle for the back up camera to shut off after reversing
Crash:
No
Fire:
No
Injuries:
0
Deaths:
0
#11712873January 23, 2026
POWER TRAIN, FORWARD COLLISION AVOIDANCE: ADAPTIVE CRUISE CONTROL
Since buying my Ford 2018 F150 Raptor, I have had constant issues and problems with the 10R80 Transmission shifting irradictly, harsh engagements, stalling between gears while losing power, loud metal noises in the transmission/under the truck, and damage already done to the transfer case and transmission resulting in a truck that needs a new transmission, CDF, and transfer case. I have had this truck worked on 8 times on the transfer case, and constant reprogramming of the PCM because the technicians at the dealerships did not know how to completely fixed it and just followed the TSBs that were given by Ford. Most of which they just reprogrammed the PCM and the adaptive learning program which Ford said it was most likely causing the issues. In 2023 they found damage inside the transfer case with metal bore damage and two valves, which they replaced, it worked for a year, and now my transmission is completely damaged permentaly from not solving the initial issues. As of October of 2025, the new TSB 25-2474 and TSB 25-2475 which addresses replacing the entire transmission and/or CDF. Of which Ford knew the whole time. This past month I was almost in 7 accidents due to the transmission shifting suddenly, not shifting at all and stalling going through an intersection with cars behind me, and Ford told me this whole time that the harsh shifts were normal or desired in these performance trucks. I have three kids under the age of [XXX] who ride with me in this truck, and almost risked their lives trying to fix these issues and almost involved in accidents from the transmission failing. The transmission and transfer case/valve bodies have been worked on at least 6 times under warranty, but now it just expired and Ford is stating they cant do anything now because it is expired, yet it is now completely broken. Ford is quoting 12,000 for a new transmission, transfer case, and CDF Valve. Even though they did not fix the original issues this whole time. INFORMATION REDACTED PURSUANT TO THE FREEDOM OF INFORMATION AC
Crash:
No
Fire:
No
Injuries:
0
Deaths:
0
#11712654January 22, 2026
POWER TRAIN
While attempting a left-hand turn across two lanes of oncoming traffic, the vehicle experienced a sudden and total loss of motive power. Upon acceleration, the 10R80 transmission slipped out of gear, causing the engine RPMs to spike (rev) without transferring power to the wheels. This left the vehicle momentarily stationary in the path of oncoming traffic, nearly resulting in a broadside collision. After a delay, the transmission violently engaged, causing the vehicle to lunge forward with enough force to spin the tires and nearly cause a loss of steering control. There were no prior warning lights, "limp mode" indicators, or messages on the dashboard before or during the failure. The vehicle was taken to a Ford dealership, where technicians confirmed a failure internal to the 10R80 transmission. The service department stated this is a "known issue" with this transmission model and recommended a full replacement. This failure represents a significant safety hazard due to the unpredictable loss of power in high-stakes driving situations.
Crash:
No
Fire:
No
Injuries:
0
Deaths:
0
#11712503January 21, 2026
POWER TRAIN
The contact owns a 2018 Ford F-150. The contact stated while driving at an undisclosed speed, the transmission independently shifted gear. The contact stated that when the failure occurred, there was a hard banging sound coming from the transmission. In addition, the contact stated that the transmission had skipped gears and had independently shifted into neutral(N) intermittently. There was no warning light illuminated. The dealer was made aware of the failure and the contact was advised that a diagnostic test was needed. The vehicle was not diagnosed or repaired by an independent mechanic or dealer. The contact was advised by a member of an online forum to contact the NHTSA Hotline to report the known failure. The manufacturer was not made aware of the failure. The failure mileage was approximately 90,000.
Crash:
No
Fire:
No
Injuries:
0
Deaths:
0
#11712508January 21, 2026
UNKNOWN OR OTHER
REAR VIEW CAMERA DISPLAYS BLANK WHEN SHIFTING INTO REVERSE. IS AVAILABLE FOR INSPECTION. CAMERA IS UNUSABLE AND CREATES A SAFETY HAZARD. F-150 NOT CURRENTLY INCLUDED IN KNOWN ISSUE IN OTHER MODELS OF F SERIES TRUCKS, BUT OBVIOUSLY THIS IS A KNOWN ISSUE
Crash:
No
Fire:
No
Injuries:
0
Deaths:
0
#11711795January 18, 2026
POWER TRAIN
F150 errors shifting, clunky shifts. Transmission rebuild at 105,000 mi, then again at 160,000 mi, then again at 163,000 miles. And total replacement at 163,300 mi.
Crash:
No
Fire:
No
Injuries:
0
Deaths:
0
#11711485January 16, 2026
POWER TRAIN
The contact owns a 2018 Ford F-150. The contact stated that upon returning to the residence in another vehicle, the contact became aware that the vehicle was missing. The contact's son soon became aware that the vehicle was in the woods by the residence. Upon locating the vehicle, the contact noticed that the doors were locked and that the vehicle was still in park(P). The contact stated that the vehicle had shifted out of gear and had rolled backwards into the wooded area. The contact called the dealer and was informed that there were no recalls on the VIN. The contact was then referred to the manufacturer for assistance. The manufacturer was notified of the failure, and an appointment was scheduled to have the vehicle diagnosed by a dealer. The vehicle was towed to the dealer, and after a diagnostic was performed, the dealer discovered no defects with the vehicle. The vehicle was not repaired. The failure mileage was unknown.
Crash:
No
Fire:
No
Injuries:
0
Deaths:
0
#11710922January 14, 2026
STRUCTURE:BODY
Door latches freeze, and door won’t stay closed. Operator must drive while holding the door shut. Super-unsafe.
Crash:
No
Fire:
No
Injuries:
0
Deaths:
0
#11710642January 13, 2026
POWER TRAIN
My 2018 Ford F150 only has 30,500 miles on it. There is a well known issue with the 2018-2022 Ford 10 speed transmissions, where the CDF drum fails and causes many transmission related issues. I started to show symptoms of this failure, very rough shifts from 1-3 gear, transmission would hesitate and not shift into the next gear, sometimes it would even aggressively downshift while just maintaining vehicle speed. The symptoms quickly got worse. I ended up stuck at a light because after it turned green, my vehicle wouldnt move, and i notcied it was stuck in 7th gear. I tried to manually downshift, but it wouldnt, as cars behind me were honking at me as i held up traffic. Eventually i started to accelerate from a stop in 7th gear, and then the transmission slammed into 1st gear. I brought my truck to Ford the next morning and they diagnosed it as a failing transmission with internal issues that needed to be replaced for over $13,000 dollars, reduced to $9800. This is at just 30,000 miles. I called around to other transmission shops and found a shop that would rebuild the transmission for $5000. I picked the truck up from the dealer to bring the the transmission shop, and it was just plain dangerous to drive. It downshifted from 4th to 1st going around a turn overrevving the engine,constant delayed shifts and rough shifts. I felt very unsafe driving this vehicle in this condition. All of these symptoms are amplified when the weather is cold and the transmission is still warming up. Ford knows about this issue, and has many Technical service bulletins related to the issue and how to diagnose it. Most recent is 25-2126 which is from March 31st 2025, I actually found it on the NHTSA website. Surprisingly there were no warning lights or anything that showed up, but i know others with the same issue have received warning lights. Ford would not provide any asssistance with the repair as my vehicle was less than 2 months out of my extended warranty end date.
Crash:
No
Fire:
No
Injuries:
0
Deaths:
0
#11710646January 13, 2026
ENGINE
2018 3.5 Ecoboost with plastic oil pan. Ford acknowledges poor engineering and changed production to a single aluminum oil pan half way through 2018 production, but refused to fix the trucks already built. The RTV sealant leaks on the plastic oil pan causing reliabilities and protentional safety issues with the engine components if not caught in due time. Ford issued a TSB 20-2015 report out for fixing the issue. I have been to three ASA certified mechanic shops and all shops refuse to work on the truck. My only option is to go to a FORD dealership and they won't complete the permanent fix of putting in the full aluminum pan. The independent mechanics say they won't work on the truck due to liability issues. They said the truck always comes back to get fixed again. I have done two diagnostics testing with the ASA certified mechanics. They confirmed the oil pan leak as the issue and state reliability/engine safety issues of the truck. There are no warning lights or gauges showing abnormality prior or currently showing. Just a consistent large puddle of oil on the pavement under the truck.
Crash:
No
Fire:
No
Injuries:
0
Deaths:
0
#11710597January 13, 2026
ELECTRICAL SYSTEM:INSTRUMENT PANEL:SPEEDOMETER/ODOMETER
Odometer Fraud. The contact intended to purchase a 2018 Ford F-150. The contact stated that after the Carfax report was retrieved, and it was discovered that there was a mileage discrepancy. The vehicle was a private sale. The contact stated that the vehicle was listed on Facebook Marketplace with 97,000 miles. Upon test-driving the vehicle, the contact confirmed that the Odometer reading was 97,000; however, the contact later discovered that the Carfax report listed the mileage at 240,565 on July 14, 2025.
Crash:
No
Fire:
No
Injuries:
0
Deaths:
0
#11710175January 11, 2026
SEAT BELTS
The wire that holds the passenger side front seatbelt to the floor snapped in half. The truck has never been in any kind of accident. There has been a motor put in under warranty. After that a few months later the ac compressor died. Also the passenger side turbo oil return line started leaking. There is also a hard start when engine is cool. Nothing but problems. But the seatbelt is very important.
Crash:
No
Fire:
No
Injuries:
0
Deaths:
0
#11709955January 9, 2026
POWER TRAIN
I have a 10 speed transmission in my 2018 f150. I started noticing harsh shifting and came to fine out it is from the known issue that ford has acknowledged. The cds clutch drum slipped do ti fault parts. I contacted ford and they refused to help and said that my vehicle was out of warranty even though they acknowledged the service bulletin they stated that there was no recall at this time. I had to pay over $8,000 out of pocket and be without a truck for over a month.
Crash:
No
Fire:
No
Injuries:
0
Deaths:
0
#11709315January 7, 2026
POWER TRAIN
The contact owns a 2018 Ford F-150. The contact stated that while driving approximately 30-40 MPH, the vehicle started jerking and shifting abnormally. There were no warning lights illuminated. The vehicle was taken to the local dealer, where it was determined that the failure was related to DTC: P076F/10R80, and the dealer informed the contact that the transmission needed to be replaced. The vehicle was not repaired. The manufacturer was contacted and confirmed there was no recall coverage for the issue. The approximate failure mileage was 102,000.
Crash:
No
Fire:
No
Injuries:
0
Deaths:
0
#11709280January 6, 2026
ELECTRICAL SYSTEM
Backup camera shows blue screen. Appears to be faulty wiring harness or connection. Impacted driver safety when backing up. Previously replaced camera due to suspected camera failure. Fix lasted less than a year before blue screen returned. No other warnings or indications.
Crash:
No
Fire:
No
Injuries:
0
Deaths:
0
#11708813January 5, 2026
POWER TRAIN, VEHICLE SPEED CONTROL, ELECTRICAL SYSTEM
This vehicle has the 10R80 10 speed transmission, the same transmission that is in the Mustang that is under recall now. That was reset at a Ford dealership in 2023 I believe. It was not acting up at that time, they "fixed" it then while it was in. Now a few years later this problem is VERY PERSISTANT now, constantly missing, skipping, and losing power trying to accelerate trying to get on to busy roads and highways, it loses power and skips through all the gears from 1st to 10th back down to 4, then 6 then 2 then back to 9 and 10. I have almost been hit numerous times from this action. It is also causing the dash lights to turn off and come back on. Also effecting my 4 wheel drive, it will not engage. This should be a SAFTEY RECALL and Ford needs to take of it.
Crash:
No
Fire:
No
Injuries:
0
Deaths:
0

← Back to Ford F-150