Ford F-150 Complaints (2001)

1,236 consumer complaints on file.

#10410638July 6, 2011
FUEL SYSTEM, GASOLINE
TL* THE CONTACT OWNS A 2001 FORD F150. THE CONTACT STATED THAT WHILE APPROACHING A TRAFFIC LIGHT, THE FUEL TANK SEPARATED FROM THE VEHICLE CAUSING GASOLINE FUEL TO SPILL OVER THE ROADWAY. THE VEHICLE WAS TOWED TO A LOCAL MECHANIC WHO DISCOVERED THAT THE FUEL TANK STRAPS WERE CORRODED. THE VEHICLE WAS NOT REPAIRED. THE MANUFACTURER WAS CONTACTED AND THEY ADVISED THAT THE FAILURE WAS UNDER INVESTIGATION. THE FAILURE AND CURRENT MILEAGE WAS 115,000. UPDATED 08/15/11 *BF THE CONSUMER STATED BOTH STRAPS FAILED, BREAKING IN THE MIDDLE OF THE STRAP. THE TANK DID DROP TO THE GROUND AND WAS DRAGGED A SHORT DISTANCE. THERE WAS DAMAGE TO THE FUEL TANK AND IT HAD TO BE REPLACED. UPDATED 08/24/11 UPDATED 08/31/11 *BF THE VEHICLE HAS SINCE BEEM REPAIRED. UPDATED 09/01/11
Crash:
No
Fire:
No
Injuries:
0
Deaths:
0
#10410610July 5, 2011
FUEL SYSTEM, OTHER, FUEL SYSTEM, GASOLINE:STORAGE:AUXILLARY TANK
I WAS DRIVING SOUTH ON HWY 41 IN MILWAUKEE, WI. WHEN I HEARD A DRAGGING SOUND UNDER TRUCK. I PULLED OFF HWY AND DISCOVERED MY GAS TANK WAS DRAGGING FOR APPROX. 2 MILES. WHY IT DIDN'T BLOW UP I AM NOT SURE. TWO STRAPS SNAPPED. I HAD JUST FILLED THE TANK W/ $75.00 IN GAS AND HAD TRUCK TOWED AND APPROX. COST OF GETTING TRUCK FIXED IS $700.00 PLUS THE TOW. *KB
Crash:
No
Fire:
No
Injuries:
0
Deaths:
0
#10410415July 4, 2011
FUEL SYSTEM, GASOLINE, STEERING
I HAVE A 2001 FORD F150 REGULAR CAB LONG BED WITH 75,000 MILES. WHILE DRIVING AT APPROXIMATELY 40 MPH THE RIGHT INNER TIE ROD BROKE CAUSING THE VEHICLE TO SHUDDER SIGNIFICANTLY UNTIL I WAS ABLE TO STOP THE VEHICLE. THIS BRIEF SHUDDERING CAUSED THE REAR FUEL TANK STRAP TO SNAP IN HALF PRIMARILY DUE TO EXCESSIVE CORROSION OF THE STRAP. LOSS OF THE SUPPORTING STRAP CAUSED THE REAR OF THE TANK TO DROP ALMOST TO GROUND LEVEL WHICH ALSO BROKE THE FILLER INLET OFF OF THE TOP OF THE TANK, COMPLETELY DISCONNECTING THE FILLER TUBE AND PRESENTING A LARGE HOLE FOR FUEL TO ESCAPE. BOTH OF THESE FAILURES ARE NOT WHAT I WOULD EXPECT FROM A VEHICLE WITH ONLY 75,000 MILES ON THE ODOMETER. EITHER COULD HAVE RESULTED IN SERIOUS INJURY OR PROPERTY DAMAGE. *TR
Crash:
No
Fire:
No
Injuries:
0
Deaths:
0
#10410016June 30, 2011
FUEL SYSTEM, GASOLINE
TL* THE CONTACT OWNS A 2001 FORD F-150. THE CONTACT STATED WHILE DRIVING APPROXIMATELY 35 TO 40 MPH HE NOTICED THE TANK HAD DETACHED FROM THE VEHICLE. WHEN HE INSPECTED THE VEHICLE HE NOTICED THAT TWO STRAPS WERE FRACTURED AND WERE SEVERELY RUSTED, BUT NO FUEL HAD SPILLED OUT OF THE FUEL TANK. THE VEHICLE WAS NOT INSPECTED BY A DEALER NOR WAS IT REPAIRED. THE FAILURE AND CURRENT MILEAGE WAS APPROXIMATELY 126,000.
Crash:
No
Fire:
No
Injuries:
0
Deaths:
0
#10409396June 29, 2011
FUEL SYSTEM, GASOLINE:STORAGE:TANK ASSEMBLY:MOUNTING, FUEL SYSTEM, GASOLINE
BOTH FRONT AND REAR FUEL TANK STRAPS ARE BROKE. TANK IS BEING HELD UP BY FUEL LINE IN REAR. FRONT STRAP BEING HELD ON BY PLASTIC COVER ONLY. IN THE PROCESS OF REPAIRING NOW AT A FORD DEALERSHIP. PARTS COST IS APPROX. $80, LABOR IS STILL NOT CALCULATED. THE CONSUMER STATED BOTH STRAP BROKE IN THE MIDDLE DUE TO SEVERE RUST; THE REAR MORE THAN THE FRONT. THE FUEL LINE WAS STILL IN GOOD SHAPE. IT WAS SUPPORTING THE REAR TANK AFTER THE STRAP BROKE. THE TANK NEVER HIT THE GROUND. WHILE BOTH STRAPS WERE RUSTED OUT COMPLETELY IN THE MIDDLE, THERE WAS A PIECE OF PLASTIC BETWEEN THE STRAP AND THE TANK. THE PLASTIC WAS MOLDED AROUND THE STRAPS WELL ENOUGH THAT THE FRONT OF THE TANK WAS SUPPORTED BY THE PLASTIC PIECE EVEN THOUGH THE METAL STRAP HAD RUSTED AWAY. HOWEVER, THE BACK STRAP HAD RUSTED AWAY TO A POINT THAT THE STRAP FELL AND THE TANK WAS ONLY BEING SUPPORTED BY THE FUEL LINE. UPDATED 09/21/11 *TR
Crash:
No
Fire:
No
Injuries:
0
Deaths:
0
#10408930June 26, 2011
ENGINE AND ENGINE COOLING:ENGINE
WHILE DRIVING DOWN INTERSTATE STARTED TO HEAR A LOAD POPPING NOISE FROM ENGINE. IMMEDIATELY PULLED OVER TO FIND THAT ONE OF THE SPARK PLUGS HAD BLOWN OUT OF THE HEAD. HAD TO BE TOWED. STILL WAITING OF COST OF REPAIRS. RESEARCHING ONLINE, IT APPEARS THAT THIS IS COMMON ISSUE WITH THIS MOTOR. *TR
Crash:
No
Fire:
No
Injuries:
0
Deaths:
0
#10408754June 24, 2011
ELECTRICAL SYSTEM
TL* THE CONTACT OWNS A 2001 FORD F-150. THE CONTACT STATED THAT WHILE DRIVING APPROXIMATELY 25 MPH HE BEGAN TO SEE SMOKE RISE FROM UNDER THE HOOD. THE VEHICLE WAS STOPPED AND SHUT OFF. WHILE EXAMINING THE VEHICLE, THE CONTACT NOTICED SOME OF THE WIRES UNDER THE HOOD WERE ON FIRE. THE FIRE WAS EXTINGUISHED. UPON REENTERING THE VEHICLE, THE CONTACT ALSO NOTICED THAT THE ANTI LOCK BRAKING SYSTEM LIGHT WAS ILLUMINATING ON THE INSTRUMENT PANEL. THE VEHICLE WAS NOT TAKEN TO HAVE THE FAILURE DIAGNOSED OR REPAIRED. THE FAILURE MILEAGE WAS 130,000.
Crash:
No
Fire:
Yes
Injuries:
0
Deaths:
0
#10408567June 22, 2011
POWER TRAIN:AUTOMATIC TRANSMISSION
TL* THE CONTACT OWNS A 2001 FORD F-150. THE CONTACT STATED WHILE THE VEHICLE WAS SLOWING DOWN TO STOP, THE ENGINE RPMS WOULD INCREASE, THE GEAR ENGAGED AND THE VEHICLE LUNGED FORWARD. THE VEHICLE WAS TAKEN TO THE DEALER WHO DIAGNOSED THAT THE TRANSMISSION WAS DEFECTIVE AND NEEDED TO BE REPLACED. THE REMEDY DID NOT REPAIR THE FAILURE. THE FAILURE RECURRED AT 11,000 MILES AND THE DEALER STATED THAT THE TRANSMISSION WAS DEFECTIVE AND NEEDED TO BE REPLACED AGAIN. THE MANUFACTURER WAS MADE AWARE OF THE FAILURE AND REFERRED HIM TO NHTSA. THE VEHICLE WAS NOT REPAIRED. THE FAILURE MILEAGE WAS 37,000 AND THE CURRENT MILEAGE WAS 48,000.
Crash:
No
Fire:
No
Injuries:
0
Deaths:
0
#10407529June 20, 2011
ENGINE AND ENGINE COOLING:ENGINE
WAS DRIVING NORMALLY WHEN I STARTED HEARING A LOUD POPPING NOISE FROM ENGINE. TOOK TO MECHANIC AND WAS TOLD THE SPARK PLUG BLEW OUT - WAS ALSO TOLD THIS IS A "COMMON" PROBLEM WITH FORD TRITON ENGINES AND A DESIGN FLAW WITH THE ENGINE (TOO FEW THREADS ON SPARK PLUGS) *TT
Crash:
No
Fire:
No
Injuries:
0
Deaths:
0
#10407312June 17, 2011
ELECTRICAL SYSTEM
I HAVE A 2001 F150 TRUCK I WENT TO LEAVE WORK I STARTED MY TRUCK AND WENT TO PUT IT IN GEAR TO LEAVE WHEN I SMELLED SOMETHING BURNING I NOTICED SMOKE COMING FROM UNDER MY HOOD I OPEN TO HOOD TO FIND A FIRE AT THE MASTER CYLINDER . I GRAB THE PLUG THAT WAS BURNING AND YANKED IT OUT OF THE TRUCK , IT BURN A HOLE IN MY RESERVOIR HOLDING MY BRAKE FLUID AND MY HAND. *TR
Crash:
No
Fire:
Yes
Injuries:
0
Deaths:
0
#10407316June 17, 2011
ELECTRICAL SYSTEM
2001 F150,,,, I WAS DRIVING DOWN THE ROAD A FEW WEEKS AGO AT AROUND 50 TO 55 MPH , WHEN I HEARD A LOUD POPPING NOISE COMING FROM MY TRUCK . I PULLED OVER RIGHT AWAY, IT SOUNDED LIKE A BAD EXHAUST LEAK. I LOOKED ALL UNDER THE TRUCK AND COULDN'T FIND ANY LEAK , SO I HAD MY SON TOW ME HOME , AS I OPENED THE HOOD AND STARTED THE TRUCK I HEARD THE NOISE COMING FROM THE TOP OF THE MOTOR, AFTER LOOKING CLOSER WITH A FLASHLIGHT I FOUND THE PROBLEM THE NUMBER 7 PLUG HAD BEEN BLOWN RIGHT OF THE HEAD AND WAS LAYING ON TOP OF THE INTAKE,BREAKING THE COIL PACK IN THE PROCESS. IT STRIPPED THE THREADS RIGHT OUT OF THE HEAD,,,I DID FIND A REPAIR KIT AT NAPA FOR $220.00 AND IT STILL IS NOT RUNNING RIGHT , AND I ALSO LEARNED THEY ONLY MAKE A REPAIR KIT FOR THE FORD MOTORS NO OTHER MAKE HAS THIS REPAIR KIT,, SO IT SOUND LIKE FORD HAS A DEFECT WITH THE HEADS NO OTHER MAKE HAS THIS ISSUE. *TR
Crash:
No
Fire:
No
Injuries:
0
Deaths:
0
#10407121June 16, 2011
FUEL SYSTEM, GASOLINE
TL* THE CONTACT OWNS A 2001 FORD F-150. THE CONTACT STATED THAT ONE THE FUEL TANK STRAPS FRACTURED FROM THE VEHICLE. THE VEHICLE WAS NOT REPAIRED. THE MANUFACTURER WAS MADE AWARE OF THE FAILURE. THE FAILURE AND CURRENT MILEAGE WAS 110,000.
Crash:
No
Fire:
No
Injuries:
0
Deaths:
0
#10406948June 15, 2011
SEAT BELTS
TWO OF THE SEAT BELT BUCKLES IN THE REAR HAVE FAILED. THE LITERALLY FELL APART AND WHEN REASSEMBLED, NO LONGER WORK PROPERLY IN THAT THEY FAIL TO LATCH. THIS IS A DIFFERENT FAILURE MODE THAN MY DRIVER SEAT BUCKLE THAT HAD FALSE LATCHING AND WAS THE SUBJECT OF A RECALL FOR SOME VINS (NOT MINE). *TR
Crash:
No
Fire:
No
Injuries:
0
Deaths:
0
#10406949June 15, 2011
FUEL SYSTEM, OTHER
GAS TANK STRAP RUSTED AND BROKER AND HANGING, DRAGGING. AS A CONSEQUENCE THE REAR OF THE TANK HAS DROPPED CONSIDERABLY. AS A TEMPORARY FIX, ANOTHER STRAP WAS FABRICATED USING THE OLD STRAP AS A TRACER. THIS HAPPENED BEFORE ANY TALK OF COMPLAINTS OR INVESTIGATIONS WAS HEARD ABOUT. *TR
Crash:
No
Fire:
No
Injuries:
0
Deaths:
0
#10406854June 14, 2011
ENGINE AND ENGINE COOLING:ENGINE
TL* THE CONTACT OWNS A 2001 FORD F150. THE CONTACT STATED WHILE THE VEHICLE WAS PARKED IN THE DRIVEWAY, THE ENGINE CAUGHT ON FIRE. THE LOCAL FIRE DEPARTMENT WAS UNABLE TO LOCATE THE EXACT ORIGIN OF THE FIRE. A FIRE REPORT WAS NOT FILED. THE FAILURE WAS BEING INVESTIGATED BY THE CONTACT'S INSURANCE COMPANY. THE FAILURE AND CURRENT MILEAGE WAS 170,000.
Crash:
No
Fire:
Yes
Injuries:
0
Deaths:
0
#10406868June 14, 2011
FUEL SYSTEM, GASOLINE
TL* THE CONTACT OWNS A 2001 FORD F150. THE CONTACT STATED WHILE MAKING A RIGHT TURN AT APPROXIMATELY 10 TO 15 MPH, THE VEHICLE FUEL TANK SEPARATED AS FUEL SPILLED ONTO THE HIGHWAY. THE VEHICLE WAS TAKEN TO THE LOCAL MECHANIC WHO DIAGNOSED CORROSION OF THE FUEL TANK AND STRAPS. THE FUEL TANK AND STRAPS WERE REPLACED. THE MANUFACTURER WAS CONTACTED AND THEY ADVISED THAT THE FAILURE WAS NOT RECALLED. THE FAILURE MILEAGE WAS 129,000 AND THE CURRENT MILEAGE WAS 130,000.
Crash:
No
Fire:
No
Injuries:
0
Deaths:
0
#10406000June 12, 2011
FUEL SYSTEM, GASOLINE, FUEL SYSTEM, GASOLINE:STORAGE:TANK ASSEMBLY:MOUNTING
THE FRONT STRAP THAT HOLDS THE GAS TANK ON MY 2001 F-150 HAS RUSTED OFF. I READ WHERE YOU ARE INVESTIGATING THIS FAILURE. IS THERE A CURRENT RECALL? UPDATED 09/14/11 *BF THE STRAP RUSTED AWAY AND BROKE AT A PLACE WHERE THE STRAP WAS BOLTED TO THE FRAME ON THE LEFT SIDE. THE REST OF THE STRAP WAS VERY RUSTY AND CORRODED AND ALSO APPEARED TO BE READY TO FAIL. THE TANK DID NOT DROP. THE BACK STRAP SHOWED SIGNS OF HEAVY RUST. UPDATED 09/21/11 *TR
Crash:
No
Fire:
No
Injuries:
0
Deaths:
0
#10406009June 12, 2011
ELECTRICAL SYSTEM
I OWN A 2001 FORD F150 LARIAT 1/2 TON PICKUP TRUCK WITH 95,000 ORIGINAL MILES ON IT. ON MY WAY TO WORK I NOTICED IT BEGAN RUNNING VERY ERRATIC AND THE SERVICE ENGINE LIGHT CAME ON, I IMMEDIATELY TOOK IT TO THE SHOP. THE DIAGNOSTIC CHECK REVEALED THE #7 COIL WIRE WAS IN NEED OF REPLACEMENT. THE SHOP ADVISED ME TO CHANGE ALL COIL WIRES AND SPARK PLUGS AS I WAS NEARING THE 100,000 MILE MARK, THE COST WAS $1,200. I OPTED TO JUST HAVE THE SPARK PLUGS CHANGED AND THE # 7 COIL WIRE REPLACED FOR $240. THE NEXT DAY THE SHOP CALLED AND SAID THERE WAS A BIG PROBLEM, THE #7 SPARK PLUG BROKE OFF DURING THE EXTRACTION. THE $240.00 COST IS NOW $1800.00. THE SHOP SAID THE HEAD WOULD NEED TO BE REMOVED TO REPLACE THE BROKEN SPARK PLUG. I HAVE NO CHOICE BUT TO HAVE THE WORK DONE AS THE SHOP TOLD ME THERE WAS A BIG PROBLEM WITH SPARK PLUGS SHEARING OFF DURING REMOVAL BECAUSE OF POOR DESIGN, THEY COMMENTED THE SPARK PLUGS HAVE A 100,000 MILE GUARANTEE TO WORK, HOWEVER, THE ENGINEERS DIDN'T FIGURE ON HOW BAD THE PLUGS MIGHT DETERIORATE MAKING REMOVAL TURN INTO A FINANCIAL FIASCO. *TR
Crash:
No
Fire:
No
Injuries:
0
Deaths:
0
#10406041June 12, 2011
FUEL SYSTEM, GASOLINE, FUEL SYSTEM, GASOLINE:STORAGE:TANK ASSEMBLY:MOUNTING
NO WARNING AT ALL. I WAS DRIVING 10-15 MPH COMING TO A STOP WHEN THE ENTIRE GAS TANK FELL OFF MY 2001 FORD F150 CREW CAB TRUCK. AN ENTIRE TANK OF GAS LEAKED ALL OF THE ROAD AND REQUIRED THE FIRE DEPARTMENT TO BE CALLED FOR SAFETY AND CLEAN UP. I HAD TO HAVE MY TRUCK TOWED TO A REPAIR SHOP, WHERE IT AWAITS DIAGNOSIS TOMORROW. IT APPEARS THAT THE STRAPS AND TANK HAD COMPLETELY RUSTED. I'M LUCKY NOTHING IGNITED SINCE I WAS ABLE TO PULL OVER AND WAS DRIVING SO SLOW. UPDATED 09/14/11 *BF UPDATED 09/16/11 *TR
Crash:
No
Fire:
No
Injuries:
0
Deaths:
0
#10405964June 11, 2011
FUEL SYSTEM, GASOLINE
ON 6/10/2011. MY 18 YEAR OLD SON HAD BORROWED MY 2001 FORD F-150. HE HAD STOPPED TO FILL THE FUEL TANK AND CONTINUE ON HIS ERRAND WHEN THE GAS TANK STRAPS SUDDENLY FAILED,DROPPING THE FUEL TANK ONTO THE GROUND WHILE IN MOTION. NO INJURIES OR FIRE RESULTED FROM THE INCIDENT BUT A FULL TANK OF FUEL WAS SPILLED ONTO THE GROUND CREATING A HAZARDOUS MATERIAL SITUATION, CLOSING DOWN THE ROAD FOR A SIGNIFICANT PERIOD OF TIME TO ALLOW FOR CLEANUP. I DON'T HAVE THE FINAL COST FOR REPAIRS OR CLEANUP AND I DON'T KNOW IF AND HOW INSURANCE WOULD COVER THE COST. I WAS SURPRISED TO LEARN THAT THIS HAS HAPPENED TO OTHER SIMILAR YEAR FORD TRUCKS YET NO INFORMATIONAL WARNINGS WERE ISSUED. *TR
Crash:
No
Fire:
No
Injuries:
0
Deaths:
0

← Back to Ford F-150