Ford F-150 Complaints (2005)

1,112 consumer complaints on file.

#10682659February 10, 2015
ELECTRICAL SYSTEM, ENGINE
WE HAVE HAD OUR 2005 F-150 KING RANCH FOR ABOUT 10 YEARS NOW. TODAY (FEB 10,2015), MY WIFE AND OUR ONE YEAR BABE WERE HEADING TO THE POST OFFICE THE TRUCK DISPLAYED A MESSAGE READING "ENGINE FAILSAFE MODE". THE TRUCK LOST ALL POWER, NO STEERING, AND IT STALL ON THE HIGHWAY GOING ABOUT 65 MPH. LUCKILY, SHE SAID THERE WERE VEHICLES BEHIND HER AND SHE PULLED IT OVER WITH NO STEERING AND THE ENGINE DEAD. MY WIFE THEN SAT ON THE HIGHWAY FOR ABOUT 10 MINUTES AND TRIED TO START THE VEHICLE, WHICH STARTED AND THERE WERE NO "ENGINE FAILSAFE MODE" ON DISPLAY ANYMORE. KNOW WITH-IN THE LAST YEAR OUR TRUCK HAS HAD THE CHECK ENGINE LIGHT AND THE ABS LIGHT HAS COME ON AND OFF EVERY OTHER MONTH. I HAVE CHECKED THE FUSES AND HAD REPLACE A FEW BUT AT TIME IT IS NOT THE FUSE. I'VE HAD THE INTERIOR DIM IN AND OUT AND AT TIMES IT DOES NOT WORK AT ALL. BY READING THE F150.NET FORUM FOUND OUT THE A WIRE THAT SPLITS INTO TWO WIRES WAS CORRODED ON THE PASSENGER SIDE FLOOR BOARD, IT SEEMS THAT CONDENSATION OR WATER COME IN AND STAYS IN THAT POCKET WERE THAT WIRING HARNESS GOES THRU. I AM NOW TERRIFIED THAT TRUCK WILL SHUT OFF ON THE HIGHWAY AGAIN WITH MY FAMILY AND I IN IT. THIS SEEMS TO BE A LIFE THREATENING PROBLEM. I HAVE READ THRU SOME FORUMS AND IT SEEMS THAT PEOPLE HAVE CALLED THE FORD DEALERSHIP AND THE SERVICE DEPARTMENT CLAIMED THEY HAVE NEVER HEARD OF THIS PROBLEM, BUT CAN WORK ON IT IF THEY BRING IT IN. BUT THAT FORD CLAIM THAT THEY FIX THE PROBLEM AND THE PEOPLE SAYS THAT THE PROBLEM STILL EXIST. HOPE SOME ONE CAN HELP OR ASSIST US IN FIXING THIS ISSUE NOT JUST FOR OUR FAMILY BUT FOR OTHERS TOO. SINCERELY [XXX] INFORMATION REDACTED PURSUANT TO THE FREEDOM OF INFORMATION ACT (FOIA), 5 U.S.C. 552(B)(6). *TR
Crash:
No
Fire:
No
Injuries:
0
Deaths:
0
#10678556January 23, 2015
ENGINE, UNKNOWN OR OTHER
BOUGHT A 2005 F150 TRITON V8 5.4L NEW IN 2005. I HAVE NOW EXPERIENCED A CAM PHASE PROBLEM WHICH WILL COST APPX 2500 TO REPAIR. TALKING TO MY MECHANIC HE SAID THAT IT WAS NO PROMISE TO FIX THE ISSUE , BECAUSE THESE MOTORS ARE KNOWN FOR THIS ISSUE. WAS TOLD IT WOULD BE EASIER TO PUT ANOTHER MOTOR IN SO I WOULDN'T HAVE TO WORRY ABOUT ,IF IT WOULD FIX THE PROBLEM. MY BROTHER HAS A 2008 FORD WITH THE SAME MOTOR AND HAD THE SAME PROBLEM ,BUT HIS MOTOR AFTER HAVING THE CAM PHASER'S REPLACED BLEW UP AND HAD TO REPLACE THE MOTOR. AFTER RESEARCHING AND TALKING TO SEVERAL ASE QUALIFIED MECHANICS THEY ALL SAID THAT THERE'S AN ISSUE WITH THE 5.4 LITER TRITON MOTOR. UPON CALLING FORD MOTOR COMPANY AS I WELL FIGURED WOULD HAPPEN THEY SAID THAT THEY WOULDN'T HELP WITH THE COST AND THAT THERE WAS NOR RECALL. CONSUMERS SHOULD BE ABLE TO GET MORE THAN 100,000 MILES OUT OF A VEHICLE THEY BUY. IF FORD WANTS TO KEEP CUSTOMERS HAPPY THEY SHOULD ADDRESS THEPROBLEM AND THE GOVERNMENT SHOULD BE MORE VIGILANT IN ASSURING THE CONSUMER IS PROTECTED FROM COMPANIES WHOSE PRODUCT DOSEN'T MEET STANDARDS. I WOULD LIKE TO SEE THE GOVERNMENT TO LOOK AT ALL COMPLAINTS THROUGH A SURVEY ON THIS MOTOR TO FIND A SOLUTION FOR THE CONSUMER. *TR
Crash:
No
Fire:
No
Injuries:
0
Deaths:
0
#10678292January 22, 2015
ENGINE
TL* THE CONTACT OWNS A 2005 FORD F-150. THE CONTACT STATED THAT AFTER STARTING THE VEHICLE, THE ENGINE MISFIRE AND THE CHECK ENGINE WARNING LIGHT ILLUMINATED. THE PROBLEM RECURRED MULTIPLE TIMES. THE VEHICLE WAS TAKEN TO AN INDEPENDENT MECHANIC. THE TECHNICIAN DIAGNOSED THAT THE SPARK PLUG WAS FRACTURED AND THAT NEEDED TO BE REPLACED. THE VEHICLE WAS REPAIRED. THE MANUFACTURER WAS MADE AWARE OF THE FAILURE. THE FAILURE MILEAGE WAS 90,000.
Crash:
No
Fire:
No
Injuries:
0
Deaths:
0
#10676416January 19, 2015
ENGINE
SPARK PLUG BLEW OUT OF HEAD. *TR
Crash:
No
Fire:
No
Injuries:
0
Deaths:
0
#10676255January 17, 2015
ELECTRICAL SYSTEM, ENGINE, POWER TRAIN
2005 F150 GOES INTO "FAIL SAFE MODE" AND SHUTS DOWN WHILE DRIVING. IT ONLY OCCURRED ONCE PER YEAR STARTING AT 65,000 MILES, BUT NOW HAPPENS EVERY 3-4 WEEKS AT 114,000 MILES. ONCE THE ENGINE SHUTS DOWN, I PUT THE TRANSMISSION INTO NEUTRAL WHILE COASTING AND IT RESTARTS EASILY. THE ENGINE LIGHT ILLUMINATES FOR 3-4 DAYS AND THEN TURNS OFF. IN RESEARCHING THE ISSUE, IT SEEMS TO BE A RATHER COMMON PROBLEM WITH THIS VEHICLE AND IS USUALLY CAUSED BY A FAULTY THROTTLE BODY. FORD STATES THAT THEY ARE AWARE OF THE PROBLEM. *TR
Crash:
No
Fire:
No
Injuries:
0
Deaths:
0
#10671828January 12, 2015
ENGINE, POWER TRAIN
I OWN THE ABOVE MENTION VEHICLE, THERE WAS NO DISCLOSURE TO ME AT THE TIME OF PURCHASE OF A VERY SERIOUS DESIGN FLAW WITH THE SPARK PLUGS THAT COULD AND LIKELY WILL BREAK OFF IN THE ENGINE DURING REPLACEMENT AND THE EXTREME COST IN CHANGING THESE PLUGS AROUND 900 TO 1000 DOLLARS IF NO PLUGS BREAK OFF AND EVEN MORE IN THE PLUGS DO BREAK OFF OR HEADS HAVE TO REMOVED TO EXTRACT THE PLUGS EVEN WORSE PIECES OF PRSHELL COULD FALL INTO THE ENGINE CYLINDER AND CAUSE ENGINE DAMAGE TO AROUND 8000 DOLLARS NOW THAT I AWARE OF THE EXTREME COST 3 OR 4 TIMES THE AMOUNT FOR ROUTINE MAINTENANCE OF CHANGING SPARK PLUGS IN THESE FORD VEHICLES FORD IS NO HELP AT ALL SAYING ITS NOT A SAFETY ISSUE I CANT HELP IT THE DESIGN FLAW WITH THESE LONG 2 PIECE PLUGS IS SO SERIOUS AND THE PRICE GOUGING OF THE CONSUMER FOR THE COST TO CHANGE SPARK PLUGS IS SO EXPENSIVE AND SO BAD I STRONGLY FEEL THAT THE FEDERAL GOV SHOULD STEP INTO THE MATTER AND HELP THE CONSUMERS OUT AND NOT ALLOW FORD TO GET BY WITH THIS EXTREME BAD DESIGN FLAW AND THE OUTRAGEOUS COST THEY ARE CHARGING AND THE FED GOV SHOULD FORCE FORD TO RECALL ALL AFFECTED VEHICLES AND MANDATE THAT FORD EAT THE COST OF CHANGING THESE SPARK PLUGS AND PUT IN THE NEWLY DEVELOPED PLUGS THAT ARE NOT PRONE TO BECOME SEIZED TO THE ENGINE AND FORD SHALL DO SO AT NO COST TO THE CONSUMER SAFETY OR NOT IT IS JUST UNBELIEVABLE THEY CAN GET BY WITH SUCH A SERIOUS DESIGN FLAW WITH SUCH A HIGH EXPENSE TO THE CONSUMER FOR SOMETHING THAT IS SUPPOSED TO BE ROUTINE. *TR
Crash:
No
Fire:
No
Injuries:
0
Deaths:
0
#10667084December 18, 2014
POWER TRAIN:TRANSFER CASE (4-WHEEL DRIVE)
TL* THE CONTACT OWNS A 2005 FORD F-150. THE CONTACT STATED THAT WHILE DRIVING AT APPROXIMATELY 25 MPH, THE FOUR WHEEL DRIVE ACTIVATED INDEPENDENTLY AS A LOUD ABNORMAL NOISE EMITTED FROM THE FRONT OF THE VEHICLE. THE FAILURE OCCURRED ON NUMEROUS OCCASIONS. THE VEHICLE WAS TAKEN TO A DEALER WHERE IT WAS REPAIRED ON NUMEROUS OCCASIONS BUT THE FAILURE PERSISTED. THE REPAIR SPECIFICS WERE NOT AVAILABLE. THE MANUFACTURER WAS NOTIFIED OF THE FAILURE. THE APPROXIMATE FAILURE MILEAGE WAS 58,000.
Crash:
No
Fire:
No
Injuries:
0
Deaths:
0
#10662067December 3, 2014
STEERING
CORROSION OF THE U-JOINTS ON THE LOWER STEERING SHAFT OF MY 2005 FORD F150 (4.6 L) IS CAUSING THE STEERING TO MALFUNCTION. STEERING WILL NOT RETURN TO CENTER AFTER TURNING, EVEN AT MODERATE SPEEDS. THE VEHICLE DRIVES AS IF IT HAS NO POWER STEERING. LUBRICATION OF THESE JOINTS WILL REMEDY THE PROBLEM FOR A PERIOD OF A WEEK OR SO, BUT THE PROBLEM PERSISTS. THIS IS A KNOWN DESIGN FLAW THAT HAS BEEN RECALLED IN OTHER FORD MODELS WITHIN SIMILAR MANUFACTURE DATES. I LIVE IN A COLD WEATHER STATE WHERE THE PROBLEM IN THE RECALLED VEHICLES HAS BEEN NOTED TO BE MORE OF AN ISSUE. THERE ARE MANY ONLINE COMPLAINTS REGARDING THIS DESIGN FLAW IN THE F150. THE COST FOR ME TO REPLACE THIS PART WILL RANGE FROM $300 TO $600. HOWEVER, THE REPLACEMENT PARTS ARE MADE WITHIN THE SAME ORIGINAL OEM DESIGN. THE PARTS NEED TO BE CORRECTED SO THAT REPLACEMENTS WILL NOT FALTER AS WELL. IT IS VERY SCARY TO THINK THAT I MAY NOT BE ABLE TO RELY ON MY STEERING DURING DIFFICULT WEATHER SITUATIONS. *JS
Crash:
No
Fire:
No
Injuries:
0
Deaths:
0
#10660063November 21, 2014
ENGINE
TL* THE CONTACT OWNS A 2005 FORD F-150. WHILE DRIVING APPROXIMATELY 60 MPH, THE ENGINE STALLED AND THE ENGINE FAILURE SYSTEM WARNING LIGHT ILLUMINATED. THE VEHICLE WAS RESTARTED AFTER MULTIPLE ATTEMPTS. THE VEHICLE WAS NOT DIAGNOSED OR REPAIRED. THE MANUFACTURER WAS NOT NOTIFIED OF THE FAILURE. THE APPROXIMATE FAILURE MILEAGE WAS 103,000.
Crash:
No
Fire:
No
Injuries:
0
Deaths:
0
#10659883November 20, 2014
SEAT BELTS
TL* THE CONTACT OWNS A 2005 FORD F-150. THE CONTACT STATED THAT THE AIR BAG WARNING LIGHT REMAINED ILLUMINATED. THE INDEPENDENT MECHANIC DIAGNOSED THAT THE SEAT BELT PRETENSIONERS NEEDED TO BE REPLACED. THE VEHICLE WAS REPAIRED. THE MANUFACTURER WAS NOTIFIED OF THE FAILURE. THE APPROXIMATE FAILURE MILEAGE WAS 33,000.
Crash:
No
Fire:
No
Injuries:
0
Deaths:
0
#10659056November 18, 2014
ELECTRICAL SYSTEM
AFTER THE RECALL TO PREVENT A SHORT BETWEEN HORN AND AIR BAG WAS COMPLETED IN 2011 A SHORT TIME THEREAFTER IN THE MIDDLE OF THE NIGHT THE HORN CAME ON BY ITSELF IN THE LOCKED VEHICLE WITH NO ONE IN IT. AFTER TRYING EVERYTHING I COULD THINK OF LIKE STARTING THE ENGINE AND PUSHING THE HORN BUTTON NUMEROUS TIMES. I WAS ABOUT READY TO DISCONNECT THE BATTERY WHEN IN ANGER I HIT THE CENTER OF THE STEERING WHEEL VERY HARD WITH MY HAND AND THE HORN STOPPED BLOWING. FROM THAT DAY ON THE AIRBAG WARNING LIGHT STAYS ON WHEN THE ENGINE RUNS. AND THE HORN BLOWS HALF AS LOUD AS IT ORIGINALLY DID WHEN ACTIVATED. FORD SAYS ITS MY PROBLEM BECAUSE THE RECALL WAS ALREADY COMPLETED. ONLY PROBLEM HERE IS THAT THEIR WAS NO PROBLEM AT ALL UNTIL AFTER THE RECALL WORK. *TR
Crash:
No
Fire:
No
Injuries:
0
Deaths:
0
#10659123November 18, 2014
ENGINE, ELECTRICAL SYSTEM
OVER THE PAST 5 YEARS I HAVE HAD MY TRUCK GO INTO FAIL SAFE MODE. MY TRUCK WILL FLASH FAIL SAFE AND I WILL LOSE ALL POWER TO THE VEHICLE. I'M ABLE TO COAST TO A STOP. I HAVE BEEN ABLE TO RE START MY VEHICLE AND CONTINUE DRIVING. *TR
Crash:
No
Fire:
No
Injuries:
0
Deaths:
0
#10652508November 4, 2014
AIR BAGS
TL* THE CONTACT OWNS A 2005 FORD F-150. THE CONTACT STATED THAT THE AIR BAG WARNING LIGHT ILLUMINATED. THE FAILURE RECURRED TWICE. THE VEHICLE WAS TAKEN TO THE DEALER FOR DIAGNOSIS. THE TECHNICIAN DIAGNOSED THAT THE FRONT SEAT BELT PRETENSIONER WAS DEFECTIVE AND NEEDED TO BE REPLACED. THE VEHICLE HAS BEEN REPAIRED. THE MANUFACTURER WAS NOTIFIED OF THE FAILURE. THE APPROXIMATE FAILURE MILEAGE WAS 33,000.
Crash:
No
Fire:
No
Injuries:
0
Deaths:
0
#10652575November 4, 2014
STRUCTURE:BODY, ENGINE, AIR BAGS, EXTERIOR LIGHTING
FRONT END COLLISION INTO THE REAR OF ANOTHER TRUCK. WHOLE FRONT END DAMAGED THROUGH RADIATOR, HOOD, HEADLIGHTS, BUMPERS ETC. AIRBAG NEVER DEPLOYED AND UPON RETURN OF VEHICLE AFTER REPAIRS, I AM NOW GETTING A CODE 42 THAT THE SENSOR IS BAD AND AFTER RESEARCH FIND OUT THERE IS A RECALL ON THIS BUT FOR THE OPPOSITE REASON BUT ALSO NOW UNDERSTAND THERE ARE CORROSION ISSUES WITH THE CONNECTION OF THE SENSOR ALSO. HOPE THIS HELPS. PLEASE ADVISE WHAT TO DO, WILL FORD FIX THIS WHOLE PROBLEM AND REPLACE WITH A NEW SENSOR AND THE WIRE CHAFFING PROBLEM? THANK YOU IN ADVANCE! *TR
Crash:
Yes
Fire:
No
Injuries:
0
Deaths:
0
#10651510October 30, 2014
VEHICLE SPEED CONTROL
TL* THE CONTACT OWNS A 2005 FORD F-150. THE CONTACT STATED THAT WHILE APPROACHING A TRAFFIC LIGHT, THE BRAKES WERE ENGAGED AND THE VEHICLE SURGED FORWARD. THE CONTACT MENTIONED THAT EXTREME FORCE WAS REQUIRED IN ORDER TO STOP THE VEHICLE. ALSO, THE CONTACT STATED THAT THE SAFE MODE AND CHECK ENGINE LIGHT ILLUMINATE AS THE VEHICLE STALLED. THE CONTACT HAD TO WAIT SEVERAL MINUTES BEFORE THE VEHICLE RESTARTED. THE VEHICLE WAS TAKEN TO THE DEALER. THE TECHNICIAN DIAGNOSED THAT THE THROTTLE BODY NEEDED TO BE REPLACED. THE VEHICLE WAS REPAIRED. THE MANUFACTURER WAS NOTIFIED OF THE FAILURE. THE APPROXIMATE FAILURE MILEAGE WAS 30,000.
Crash:
No
Fire:
No
Injuries:
0
Deaths:
0
#10649880October 25, 2014
AIR BAGS
THE "AIRBAG" INDICATOR LIGHT CAME ON. STAYED ON FOR ABOUT 6 WEEKS WHEN VEHICLE WAS IN USE, THEN TURNED OFF. NOW, A MINUTE OR SO AFTER STARTING VEHICLE AN ALARM SOUNDS, 5 LOW SOUNDING BEEPS IN 5 ROUNDS, WILL DO IT ABOUT EVERY 30 MINUTES, SAME ALARM CYCLE. ACCORDING TO THE OWNERS MANUAL THIS IS AN INDICATION OF A PROBLEM WITH THE AIRBAG SYSTEM. I THOUGHT I WAS RESPONSIBLE FOR HAVING THIS FIXED. CURRENTLY WITH MY SCHEDULE AND FINANCIAL SITUATION I HAVE BEEN PUTTING OFF SERVICING THIS ISSUE HOWEVER, I HEARD ON THE NEWS EARLIER THIS WEEK ABOUT SEVERAL RECALLS AND MY VEHICLE FITS INTO THIS. I HAVE NOT RECEIVED ANY RECALL NOTICE FROM FORD. I'M NOT SURE IF MY VEHICLE IS ACTUALLY PART OF THIS, THIS IS WHY MY INQUIRY TO YOU. PLEASE ADVISE *TR
Crash:
No
Fire:
No
Injuries:
0
Deaths:
0
#10644142October 12, 2014
ENGINE
I HAVE OWNED MY FORD TRUCK FOR ALMOST 8 YEARS AND I HAVE EXPERIENCED NOTHING BUT BAD LUCK WITH THIS ENGINE AND ME AND OTHER FORD OWNERS AGREE THAT THIS ENGINE IS 1 OF THE WORST ENGINES THAT FORD HAS PRODUCED AND THEY KNOW IT. AND ARE RELUCTANT TO DO ANYTHING ABOUT IT. AND ITS COSTING ME THOUSANDS TO REPLACE SPARK PLUGS AND CAMPHASERS. MY TRUCK NOW WILL STALL WHEN PUT IN REVERSE. IT ALSO HAS A LOUD TICKING NOISE TO IT. I KNOW ITS THE CAMPHASERS AGAIN WHICH I ALREADY REPLACE ABOUT 4 YEARS AGO.THIS TRUCK IS COSTING ME MORE THAN ITS WORTH. I ONLY HAVE 85000 MILES ON IT. FORD NEEDS TO DO SOMETHING ABOUT THIS PROBLEM. ME AND OTHER FORD OWNERS OF THIS MODEL CANT KEEP SLAMMING MONEY INTO SOMETHING THAT IS A COMPLETE FAILURE FROM THE START. THIS TRUCK IS DANGEROUS AND THE PROBLEM NEEDS SOLVED. *TR
Crash:
No
Fire:
No
Injuries:
0
Deaths:
0
#10641000October 9, 2014
ENGINE AND ENGINE COOLING, ELECTRICAL SYSTEM
2005 FORD F-150. CONSUMER WRITES IN REGARDS TO SPARK PLUGS AND COILS PROBLEM. *SMD THE CONSUMER STATED THE VEHICLE STALLED, UPON ACCELERATION. THE CONSUMER ALSO STATED THE CHECK ENGINE LIGHT ILLUMINATED AND FLASHED WHEN A SPARK PLUS MISFIRED. *JB
Crash:
No
Fire:
No
Injuries:
0
Deaths:
0
#10643527October 9, 2014
SUSPENSION:FRONT:STABILIZER BAR, AIR BAGS, SEAT BELTS
TL* THE CONTACT OWNS A 2005 FORD F-150. THE CONTACT STATED THAT THE AIR BAG LIGHT ILLUMINATED ON THE INSTRUMENT PANEL. THE VEHICLE WAS TAKEN TO AN INDEPENDENT MECHANIC FOR DIAGNOSTIC TESTING. THE TECHNICIAN DIAGNOSED THAT THE SEAT BELT PRETENSIONER AND STABILIZER BAR NEEDED TO BE REPLACED. THE VEHICLE WAS REPAIRED. HOWEVER, THE DEALER ADVISED THE CONTACT THAT THE SEAT BELTS WERE NOT COVERED UNDER WARRANTY. THE MANUFACTURER WAS NOT NOTIFIED OF THE FAILURE. THE APPROXIMATE FAILURE MILEAGE WAS 33,000.
Crash:
No
Fire:
No
Injuries:
0
Deaths:
0
#10643574October 9, 2014
FUEL/PROPULSION SYSTEM
TL* THE CONTACT OWNS A 2005 FORD F-150. THE CONTACT STATED THAT THE VEHICLE FAILED TO RESTART AFTER BEING SHUT OFF. THE VEHICLE WAS TOWED TO THE CONTACT'S RESIDENCE. THE CONTACT REPAIRED THE FUEL PUMP DRIVE MODULE. THE MANUFACTURER WAS NOTIFIED OF THE FAILURE. THE APPROXIMATE FAILURE MILEAGE WAS 123,000.
Crash:
No
Fire:
No
Injuries:
0
Deaths:
0

← Back to Ford F-150