Ford F-150 Complaints (2021)

1,308 consumer complaints on file.

#11737918May 14, 2026
EXTERIOR LIGHTING
Both of the Daytime Running Lamps (DRLs) on my 2021 F150 have failed. They cost `$2,000 each to replace. They are LEDs, and were billed as never needing replacement, and certainly not under 50k miles. A quick search shows that this is a common issue with 2021+ F150s, and looking around on the road, I notice many with the same issue. This failure of safety equipment reduces visibility and could contribute to accidents.
Crash:
No
Fire:
No
Injuries:
0
Deaths:
0
#11737760May 14, 2026
SERVICE BRAKES
When I'm driving my truck, usually when I have come to a stop on an incline, the parking/emergency brake will engage on its own. For example, most recently I was pulling out of a driveway with an incline. I was stopped at the bottom of the driveway to wait for the roadway to clear before I pulled out. When I hit the gas to go, the rear wheels skidded and the truck came to a stop in the oncoming traffic lane. I looked at the dashboard and saw that the parking brake symbol was on, indicating that the parking brake had engaged. I did not engage the parking brake- the truck did it on it's own.
Crash:
No
Fire:
No
Injuries:
0
Deaths:
0
#11737648May 13, 2026
ENGINE, FUEL/PROPULSION SYSTEM, UNKNOWN OR OTHER
This is a continuation/escalation of NHTSA complaint 11689917. My 2021 Ford F-150 has experienced repeated fuel-system/electrical fuel-pump failures. The vehicle previously stalled and later cranked but would not start, returning code P0627 “Fuel Pump A Control Circuit / Open.” The in-tank fuel pump was replaced at owner expense for approximately $1,400 at an independent service center in September of 2025, but the repair did not permanently resolve the issue. The vehicle has now again lost fuel pressure/propulsion while traveling approximately 50 mph on a two-lane highway in a similar manner to prior failures. I was able to get the vehicle off the roadway, and it required towing back to my residence. This is approximately the fourth or fifth fuel-related failure, including stalls at low speed and non-start conditions related to fuel in parking lots. The symptoms appear consistent with Ford/NHTSA recall 25V455 / Ford recall 25S75, but my VIN was not included in the affected group. I am concerned that the recall population may be too narrow or that the remedy does not address the full defect pattern.
Crash:
No
Fire:
No
Injuries:
0
Deaths:
0
#11737490May 13, 2026
POWER TRAIN
My 2021 Ford F-150 with the 10-speed transmission has started shifting very hard and making grinding noises while accelerating. The truck will sometimes hesitate between gears and then slam into gear unexpectedly. I have also experienced sudden hard downshifts while driving at normal speeds. The issue seems to be getting worse over time. The grinding noise and harsh shifting are most noticeable during acceleration, but the transmission also feels rough during normal driving. At times it feels like the transmission is slipping before catching again. This creates a safety concern because the truck can unexpectedly jerk, hesitate, or downshift hard in traffic and at highway speeds. I have seen many similar complaints online involving the Ford 10R80 transmission, including issues related to harsh shifting and internal transmission problems. Ford has also issued technical service bulletins related to this transmission. No warning lights consistently appeared before the issue started. The problem has happened multiple times and can be reproduced during regular driving. The vehicle has not yet been fully repaired or diagnosed at the time of this report. The transmission and vehicle are available for inspection upon request.
Crash:
No
Fire:
No
Injuries:
0
Deaths:
0
#11736773May 9, 2026
ENGINE, POWER TRAIN, ELECTRICAL SYSTEM
The truck rapidly accelerated while I was slowly rolling into a parking spot with my foot on the brake. The harder I pushed the brake the more it seemed to accelerate. I luckily avoided hitting anything. I forced the gear shifter out of Drive into park. No warning lights or messages. I contacted 3 Ford dealerships and all said they haven’t heard of this nor do they think they could identify this problem if I brought it in.
Crash:
No
Fire:
No
Injuries:
0
Deaths:
0
#11736589May 8, 2026
POWER TRAIN
Sudden and unexpected downshifting from 4th to 1st gear when driving.
Crash:
No
Fire:
No
Injuries:
0
Deaths:
0
#11736298May 7, 2026
POWER TRAIN
Truck fails to accelerate when transmission is in second gear, travelling at low speed (typically under 10 MPH) and at low RPMs (typically ~1,500). Regardless of amount of pressure applied to accelerator, the truck will remain at low RPM and speed for up to 10 seconds. This problem occurs frequently and has been reproduced by a Ford dealer. Ford TSB 25-2302 describes this problem, but in my case a DTC is not present. Because a DTC is not present, the Ford dealer refuses to proceed with corrective actions as outlined in TSB without charging me for diagnostics and labor, although the truck is still under warranty. Failure to accelerate puts me and others at risk when attempting to merge, when accelerating in slow traffic conditions, etc.
Crash:
No
Fire:
No
Injuries:
0
Deaths:
0
#11736235May 7, 2026
POWER TRAIN
The contact owns a 2021 Ford F-150. The contact received notification of NHTSA Campaign Number: 23V896000(POWER TRAIN); however, the part to do the recall repair was unavailable. The local dealer was contacted and it was confirmed that the part was not available. The contact stated that the manufacturer exceeded a reasonable amount of time for the recall repair. The manufacturer was made aware of the issue. The contact had experienced the failure. Wheel replacing the tires the mechanic discovered that the rear driver side wheel bolt had failed and the rear wheel shaft assemblies and axles were replaced. The failure mileage was 36,495.
Crash:
No
Fire:
No
Injuries:
0
Deaths:
0
#11735873May 5, 2026
POWER TRAIN
The contact owns a 2021 Ford F-150. The contact stated that while driving at various would not properly accelerate, the transmission experienced random downshifting and shifting into neutral and lurching forward and the wrench warning light had displayed. The vehicle was taken to the local o rally who diagnosed that the transmission was faulty and needed to be replaced. The failure mileage was 105,000.
Crash:
No
Fire:
No
Injuries:
0
Deaths:
0
#11735555May 4, 2026
EXTERIOR LIGHTING
My 2021 Ford F-150 Lariat has a repeated failure of the front LED daytime running/perimeter lighting (Driver's Side). The light was intermittently dim before failing completely. This occurred around 94,000 miles. Because this lighting is part of the truck’s front visibility system, the failure creates a safety concern, especially in daylight, rain, fog, and low-light conditions. Based on owner reports, this may be a widespread defect affecting other 2021+ F-150 trucks. I request NHTSA evaluate this issue for a possible defect investigation and recall.
Crash:
No
Fire:
No
Injuries:
0
Deaths:
0
#11735550May 4, 2026
POWER TRAIN
The contact owns a 2021 Ford F-150. The contact stated that while driving at an undisclosed speed, a loud rattling noise was heard coming from the vehicle, with no warning lights illuminated. The contact received notification of NHTSA Campaign Number 23V896000 (Power Train); however, the parts required to perform the recall repair were not yet available. The vehicle was taken to multiple dealers, where it was diagnosed that the left and right rear axle shaft assemblies had failed and needed to be replaced. The contact also stated that the dealer found an axle bolt inside the rim of the vehicle. The vehicle was not repaired, and the dealers confirmed that the remedy parts were not yet available. The contact stated that the manufacturer had exceeded a reasonable amount of time to complete the recall repair. The contact also stated that the failure recurred, and the right-side axle is beginning to detach. The manufacturer was made aware of the failure. The approximate failure mileage was 90,000.
Crash:
No
Fire:
No
Injuries:
0
Deaths:
0
#11735305May 2, 2026
EXTERIOR LIGHTING
Daytime Running Lamps, vertical beam on driver side does not function after 4 years. Research shows it's likely melting the headlight assembly components during overheating and burnout.
Crash:
No
Fire:
No
Injuries:
0
Deaths:
0
#11735287May 2, 2026
POWER TRAIN
NHTSA Recall Number23V896. The bolt on my shaft has been broken for 9 MONTHS. Ford and Dealer giving me the run around. PARTS ARE NOT AVAILABLE!!!.
Crash:
No
Fire:
No
Injuries:
0
Deaths:
0
#11734744April 30, 2026
VISIBILITY/WIPER, ELECTRICAL SYSTEM
The rear window basically has 3 parts. Driver side, center sliding section, and passenger side. Only the driver side section defrost. According to online forums specifically for Ford trucks, this is a common issue. Ford’s Special Service Message (SSM) 48490 does reference this as a known issue.
Crash:
No
Fire:
No
Injuries:
0
Deaths:
0
#11734397April 28, 2026
FUEL/PROPULSION SYSTEM, ELECTRICAL SYSTEM
Brought F150 in for scheduled service - oil change. Also asked for inspection of a problem with the fuel door hatch that was causing "Refuel Error" messages on the instrument panel and several grinding noises every time the fuel release button was pressed. Note that I have an active extended Ford Premiumcare warranty. Dealership diagnosis was that the fuel door solenoid was bad, verified that the gears could be heard grinding with this part. However, there is no separate motor part, therefore the entire fuel door assembly must be replaced. Ford warranty system does not cover this part because it is considered "Body and Structural". I called Ford Protect to discuss this, and explained the motor defect and problem, that this has nothing at all to do with wear & tear or body damage. They explained that in this case, the dealership should call and get the part pre-authorized with the justification. Seelye Ford called and tried to do this on 28 April 2026, but ultimately was still denied by Ford. The attached service report from Seelye describes the technician findings and confirms the bad solenoid and audible gear grinding sound coming from the fuel door assembly - and that the entire assembly must be replaced. As this is related to the fuel system and has a defective motor, this is an example a safety defect that should not only be repaired on this vehicle, but for other vehicles with similar problems. Note that the dealership also pointed out that Ford appears to have created this part layout with the intent of having the motor be a separate part, but ultimately did not offer that option, only a full housing replacement, which is excluded because it is mostly made of plastic and metal, which is considered to be structural in nature, despite being a part of the fuel system that has active motor buttons and instrumentation sensors for driver interaction.
Crash:
No
Fire:
No
Injuries:
0
Deaths:
0
#11733991April 27, 2026
POWER TRAIN
The contact owns a 2021 Ford F-150. The contact stated that while driving at an undisclosed speed, the vehicle experienced a loss of automotive power. No warning light was illuminated. Additionally, while depressing the brake pedal, the vehicle jerked, and the transmission unexpectedly downshifted to first gear. The failure had occurred twice. The vehicle was not diagnosed or repaired by an independent mechanic or the dealer. The contact associated the failure with NHTSA Campaign Number: 22V188000 (Power Train); however, the VIN was not included in the recall. The manufacturer was not made aware of the failure. The failure mileage was approximately 83,000.
Crash:
No
Fire:
No
Injuries:
0
Deaths:
0
#11733908April 26, 2026
EXTERIOR LIGHTING
DRL led strips premature failure. The vehicle is only 5 years old and the DRL on the fog lights and the headlight assembly are failing. Multiple f150s in this year range are experiencing similar issues. This poses a safety risk due to not being able to properly see and be seen due to poor lighting.
Crash:
No
Fire:
No
Injuries:
0
Deaths:
0
#11733727April 25, 2026
FUEL/PROPULSION SYSTEM
I am submitting a formal safety complaint regarding my 2021 Ford F-150 Lariat 5.0L V8, which is included in recall 25V455 (Ford campaign 25S75) involving low-pressure fuel pump failure that may cause engine stall while driving. Ford announced this recall in 2025, acknowledging a potential safety-related defect that can result in loss of propulsion. However, as of April 2026, no repair remedy has been made available for my vehicle. This extended delay leaves owners operating vehicles with a known safety defect and no practical means to correct it. An unexpected engine stall while driving creates a serious hazard, particularly in highway traffic, intersections, merging conditions, or when towing. Owners should not be left indefinitely without a repair after a manufacturer has identified a defect significant enough to warrant a federal recall. I respectfully request that NHTSA review the prolonged delay in remedy availability for recall 25V455 and require timely corrective action, clear owner communication, and appropriate interim measures where necessary. Please also review whether affected owners are receiving adequate notice regarding expected repair timing and risk mitigation steps while awaiting a permanent fix.
Crash:
No
Fire:
No
Injuries:
0
Deaths:
0
#11733635April 24, 2026
POWER TRAIN
With less than 44,000 miles on my truck it suddenly began to shift in an eradic manner. It is undriveable. This is the Ford 10 speed 10 R 80 transmission. The truck is only 5 years old but is out of warranty by 17 days. Seems strange.
Crash:
No
Fire:
No
Injuries:
0
Deaths:
0
#11733228April 23, 2026
POWER TRAIN
The contact owns a 2021 Ford F-150. The contact received notification of NHTSA Campaign Number: 23V896000 (Power Train); however, the part to do the recall repair was not yet available. The contact stated that the manufacturer had exceeded a reasonable amount of time for the recall repair. The dealer was made aware of the issue and confirmed that parts were on backorder. The manufacturer was not made aware of the issue. The contact had not experienced a failure.
Crash:
No
Fire:
No
Injuries:
0
Deaths:
0

← Back to Ford F-150