Ford Explorer Complaints (1995)

843 consumer complaints on file.

#11209182May 22, 2019
STEERING, SUSPENSION
THE STEERING COLUMN AND ALL THE PARTS ASSOCIATED WITH THE STEERING OF THE VEHICLE WERE AFFECTED WHEN THE BOLTS THAT HOLD THE CLAMPS THAT SECURE THE BUSHINGS TO THE STEERING COLUMN BEGAN TO LOOSEN. I EXAMINED THE AREA CAREFULLY AND NOTICED THAT BECAUSE THE BOLTS LOOSENED, THE CLAMPS WERE GIVEN TOO MUCH PLAY. WITHIN A SHORT WHILE, A MONTH OR TWO, THE ENTIRE STEERING COLUMN AND THE SHIFTER WERE COMPLETELY SECURED BY ONE BROKEN CLAMP THAT HELD ITS PLACE BECAUSE OF THE BUSHINGS AND A LOOSE BOLT. THE OTHER CLAMP WAS ALSO BROKEN BUT WAS LAYING ON THE FLOOR BOARD. IT WASN'T AN EXPENSIVE FIX. I CUSTOMIZED A METAL CLAMP FOR EACH OF THE TWO PLACES THE WENT. THEY ARE THE SAME CLAMPS THE ELECTRICIANS USE TO SECURE CABLES AND WIRES TO THE WALLS AND CEILINGS. I USED THE ONES MADE FROM BRONZE. THEY ARE MORE PLIABLE TO SHAPE FOR AN ALMOST PERFECT FIT. WITH A LITTLE GREASE ABOVE AND BELOW THE BUSHINGS AND ALSO SOME WHERE THE NOW BRONZE CLAMPS HOLD THE BUSHINGS, I BELIEVE THAT THE STEERING COLUMN IS AS SAFE AS CAN BE. ALSO, THE PLASTIC THAT HOLDS THE CABLE THAT IS USED TO ADJUST THE SHIFT INDICATOR NEEDS TO BE MADE OF A DIFFERENT MATERIAL. I'LL GET TO THAT SOON.
Crash:
No
Fire:
No
Injuries:
0
Deaths:
0
#11092061May 5, 2018
ELECTRICAL SYSTEM, STEERING, UNKNOWN OR OTHER
I GOT IN MY CAR A BATTERY LESS THAN 2 WEEKS OLD WAS ALMOST DEAD NOTHING WAS PLUGGED IN OR ON I DROVE GOT ON THE FREEWAY ABOUT 20 MIN ON FREEWAY CAR STOPS WON'T MOVE MAKES REV NOISE EVENTUALLY STARTS LONG ENOUGH TO STOP AGAIN AT BOTTOM OF FREEWAY EXIT STARTS AGAIN GET IN INTO GAS STATION I SIT IN GAS STATION FOR ABOUT 12 HOURS ADD 5 QUARTS OF TRANSMISSION FLUID EVENTUALLY CAR WILL LET ME DRIVE ABOUT TWO BLOCKS BUT COME TO FIND OUT I WAS DRIVING WELL ON FIRE RACE TO GET MY DOG AND I OUT CAR CATCHES COMPLETELY ON FIRE FIRE MAN SAYS IT ELECTRIC UNDER HOOD NO PREVIOUS PROBLEMS OTHER THAN THE BATTERY AND THE OD OFF LIGHT COMING ON AND OFF I HAD THE CAR ABOUT A MONTH POLICE REPORT NUMBER1702207 OAKLAND CA POLICE DEPARTMENT
Crash:
No
Fire:
Yes
Injuries:
0
Deaths:
0
#10888226July 25, 2016
ELECTRICAL SYSTEM, FUEL/PROPULSION SYSTEM
INTERMITTENT STARTING PROBLEMS AND STALLS WHILE DRIVING
Crash:
No
Fire:
No
Injuries:
0
Deaths:
0
#10705229April 12, 2015
SEATS, ELECTRICAL SYSTEM
95 FORD EXPLORER PARKED IN CARPORT WITH ENGINE SHUT OFF FOR 5 MIN WHILE CARRIED GROCERIES UP STAIRS - I HAD LEFT DOG IN CRATE TIL FINISHED UNLOADING BUT WHEN I CAME DOWN NOTICED ELECTRICAL SMELL, GOT OUT LOOKED AROUND CAR BUT DID NOT NOTICE ANY BURNING, GOT DOG OUT AND RETURNED IN THREE MINUTES TO FIND KEY NO LONGER UNLOCKED DOOR AND COULD NOT SEE THROUGH WINDOWS - WHEN DOOR WAS OPENED SMOKE BELLOWED OUT, INTERIOR WAS COVERED WITH BLACK SOOT, A HOLE BIGGER THAN A BASKETBALL WAS BURNT OUT OF SEAT AND BACK OF DRIVER'S SEAT WAS PARCHED - HAD I NOT HAD THE WINDOWS COMPLETELY UP IT MOST LIKELY WOULD HAVE TO CONTINUED TO BURN. *TR
Crash:
No
Fire:
Yes
Injuries:
0
Deaths:
0
#10676819January 20, 2015
ENGINE
TL* THE CONTACT OWNS A 1995 FORD EXPLORER. THE CONTACT STATED THAT THE VEHICLE FAILED TO START. THE VEHICLE WAS TAKEN TO AN INDEPENDENT MECHANIC, WHO DIAGNOSED THAT THERE WAS AN ELECTRICAL FAILURE. THE VEHICLE WAS NOT REPAIRED. THE MANUFACTURER WAS NOT MADE AWARE OF THE FAILURE. THE FAILURE MILEAGE WAS 130,000. THE VIN WAS UNAVAILABLE.
Crash:
No
Fire:
No
Injuries:
0
Deaths:
0
#10676209January 17, 2015
SEATS
SOME ELECTRICAL COMPONENT UNDER THE FRONT DRIVERS SEAT CAUGHT FIRE, CONSUMING THE SEAT PORTION OF THE ASSEMBLY. *TR
Crash:
No
Fire:
Yes
Injuries:
0
Deaths:
0
#10668163December 24, 2014
ELECTRICAL SYSTEM
TL* THE CONTACT OWNS A 1995 FORD EXPLORER. THE CONTACT STATED THAT WHILE DRIVING AT 60 MPH, THE ACCELERATOR PEDAL WAS DEPRESSED BUT THE VEHICLE FAILED TO ACCELERATE. IN ADDITION, THE VEHICLE STALLED AND THE CHECK ENGINE WARNING LIGHT ILLUMINATED. THE VEHICLE COULD BE RESTARTED. THE FAILURE RECURRED ON SEVERAL OCCASIONS. THE VEHICLE WAS TAKEN TO AN INDEPENDENT MECHANIC WHERE IT WAS DIAGNOSED THAT THE ELECTRICAL SYSTEM FAILED. THE VEHICLE WAS NOT REPAIRED. THE MANUFACTURER WAS MADE AWARE OF THE FAILURE. THE FAILURE MILEAGE WAS 190,000.
Crash:
No
Fire:
No
Injuries:
0
Deaths:
0
#10650767October 28, 2014
POWER TRAIN
MY VEHICLE WILL NOT GO IN REVERSE. *TR
Crash:
No
Fire:
No
Injuries:
0
Deaths:
0
#10574452March 24, 2014
SUSPENSION
TL* THE CONTACT OWNS A 1995 FORD EXPLORER. THE CONTACT STATED THAT THE SWAY BAR WAS FRACTURED. THE VEHICLE WAS TAKEN TO INDEPENDENT MECHANIC, WHO DIAGNOSED THAT THE LINK ROD NEEDED TO BE REPLACED. THE FAILURE RECURRED TWICE OVER A ONE YEAR PERIOD. THE VEHICLE WAS REPAIRED. THE MANUFACTURER WAS NOTIFIED OF THE PROBLEM. THE APPROXIMATE FAILURE MILEAGE WAS 60,000.
Crash:
No
Fire:
No
Injuries:
0
Deaths:
0
#10535670August 15, 2013
SEAT BELTS
DRIVER'S SIDE SEAT BELT LATCH IS DEFECTIVE, (SPRING?) IT IS DIFFICULT TO LATCH AND REPEATEDLY UNLATCHES DURING DRIVE TIMES. I WAS TICKETED FOR THIS PROBLEM. *TR
Crash:
No
Fire:
No
Injuries:
0
Deaths:
0
#10511821May 13, 2013
VEHICLE SPEED CONTROL, ENGINE
THE VEHICLE DOESN'T SHIFT SINCE ITS MISSING THE TRANSMISSION WIRING HARNESS O/D SENSOR CANT LOCATE A REPLACEMENT PART THE CHECK ENGINE LIGHT GOES ON ALL THE TIME IT USES A LOT OF ANTIFREEZE SPEED CONTROL DON'T WORK FUEL PUMP KEEPS GOING OUT. *TR
Crash:
No
Fire:
No
Injuries:
0
Deaths:
0
#10488135December 12, 2012
VEHICLE SPEED CONTROL
THIS IS A COMPLAINT ABOUT FORD'S RECALL PROCESS. I RECENTLY RECEIVED A SAFETY RECALL NOTICE REGARDING A FIRE HAZARD. I HAVE NOT OWNED MY 1995 EXPLORER FOR AT LEAST FIVE YEARS. WHEN I CALLED THE NUMBER LISTED IN THE RECALL NOTICE I GOT A DEPARTMENT AT FORD - THE MAN SAID THEY CONTRACT OUT THEIR RECALLS TO A THIRD PARTY AND THAT HE COULD NOT HELP ME, NOR COULD HE GIVE ME THEIR NUMBER. HE SAID THE COMPANY GETS OWNER INFORMATION BY USING THE DMV. IF THEY HAD DONE THAT THEY WOULD KNOW I HAVE NOT OWNED THIS VEHICLE IN MANY YEARS. THIS RECALL NOTICE WAS ABOUT A FIRE HAZARD AND OBVIOUSLY WILL NOT GET TO THE PERSON WHO MAY NOW OWN THE VEHICLE, SO IT ISN'T A VERY EFFECTIVE RECALL. THE THIRD PARTY COMPANY WHO IS DOING THIS FOR FORD IS NOT DOING A VERY GOOD JOB ON SOMETHING AS CRITICAL AS A SAFETY RECALL. *TR
Crash:
No
Fire:
No
Injuries:
0
Deaths:
0
#10475384September 14, 2012
VEHICLE SPEED CONTROL, WHEELS, ELECTRICAL SYSTEM, POWER TRAIN
I WAS DRIVING MY CAR WHEN IT BEGAN TO DOWN SHIFT AROUND 35MPH. EVENTUALLY, AFTER ADDING MORE GAS, IT KICKED INTO GEAR. MY VEHICLE IS AN AUTOMATIC. ONCE IT DOWN SHIFTS, THE OD LIGHT BEGINS FLASHING ON AND OFF. IT HAS NOW BEEN DOING THIS CONSISTENTLY. THE DRIVE IS NOT A SMOOTH DRIVE AND WHEN I AM GOING APPROXIMATELY 50-60MPH OR MORE, THE CAR BEGINS TO SHAKE. *TR
Crash:
No
Fire:
No
Injuries:
0
Deaths:
0
#10475390September 14, 2012
VEHICLE SPEED CONTROL
SINCE I'VE PURCHASED THIS VEHICLE, THE CRUISE CONTROL HAS NEVER WORKED. *TR
Crash:
No
Fire:
No
Injuries:
0
Deaths:
0
#10470395August 13, 2012
FUEL/PROPULSION SYSTEM
TL* THE CONTACT OWNS A 1995 FORD EXPLORER. THE CONTACT STATED THAT HE NOTICED THAT THERE WAS A FUEL LEAK. THE VEHICLE WAS TAKEN TO THE DEALER WHO DIAGNOSED THAT THE FUEL TANK NEEDED TO BE REPLACED. THE VEHICLE WAS NOT REPAIRED. THE MANUFACTURER WAS MADE AWARE OF THE FAILURE WHO DID NOT OFFER ANY ASSISTANCE SINCE THE VEHICLE WAS NOT INCLUDED IN ANY RECALLS. THE FAILURE MILEAGE WAS 56,000.
Crash:
No
Fire:
No
Injuries:
0
Deaths:
0
#10468967August 2, 2012
ELECTRICAL SYSTEM, SEATS
VEHICLE WAS PARKED ON A RESIDENTIAL STREET AND ENGINE HAD BEEN OFF FOR 30 MINUTES. DRIVER WAS SITTING IN VEHICLE MAKING PHONE CALLS WHEN HE SMELLED SMOKE AND SAW FLAMING WIRE UNDER DRIVER'S SEAT. DRIVER ESCAPED UNHARMED AND WAS ABLE TO REMOVE SOME CONTENTS BUT VEHICLE WAS FULLY ENGULFED IN FLAME WITHIN A FEW MINUTES, DESTROYING VEHICLE ENTIRELY, MELTING PAVEMENT, BURNING NEARBY GRASS AND TREES, AND MELTING BUMPER AND PAINT ON A NEARBY PARKED VEHICLE. FIRE DEPARTMENT ARRIVED TO EXTINGUISH VEHICLE. *TR
Crash:
No
Fire:
Yes
Injuries:
0
Deaths:
0
#10448641February 21, 2012
SERVICE BRAKES, HYDRAULIC
I AM WIRTING BECAUSE THERE ARE SEVERAL RECALLS ON MY VEHICLE HOWERVER I WAS TOLD THAT THE RECALLS ARE VIN SPECIFIC. MEANING THAT EVEN THOUGH MY VEHICLE IS EXPERIANCEING THE SAME PROBLEMS OF CARS THAT HAVE BEEN RECALLED OF THE SAME MAKE MODEL AND MODEL YEAR THE MANUFACTURE IS NOT REQUIRED TO CORRECT THE DEFECT. I HAVE A PROBLEM WITTH THAT BECAUSE IT PLACES THE PUBLIC AT RISK. IN MY CASE I HAVE A 1995 FORD EXPLORER. THE VEHICLE HAS BEEN RECALLED FOR PROBLEMS WITH THE TIE RODS, SWAY BAR LINKS, AND BRAKES. ALL ISSUES THAT ARE SAFTEY RELATED. I HAVE TALKED WITH OTHER OWNERS WITH THE SAME CAR THAT HAVE THE EXCAT ISSUES. OBVIOUSLY THE PROBLEM IS SYSTEMIC AND PLACES THE PUBLIC AT RISK AS THIS WAS ONE OF THE BEST SELLING MODELS OF THAT YEAR. I AM ASKING THAT YOU ISSUE A RECALL ALL VEHICLES OF THIS MAKE AND MODEL FOR THAT YEAR. THIS WOULD ALLEVIATE THE SAFTEY RISK CASUED BY THE DEFECT. I BELIEVE THAT YOUR OFFICE AND THE MANUFACTURE SHOULD TAKE REASONABLE STEPS TO ADRESS THE ISSUE AND ACT IN THE PUBLICS INTEREST. PLEASE CONTACT ME. *TR
Crash:
No
Fire:
No
Injuries:
0
Deaths:
0
#10444749January 21, 2012
SUSPENSION, STRUCTURE, SERVICE BRAKES, HYDRAULIC
I HAVE A 1995 FORD EXPLORER AND THE DEALER REFUSES TO HONOR SOME OF THE RECALLS THAT HAVE BEEN ORDERED FOR MY VEHICLE THE RECALLS ARE LISTED BELOW RECALL DATE: MAR 15, 1995 MODEL AFFECTED: 1995 FORD EXPLORER SUMMARY: THE INNER TIE ROD ASSEMBLIES WERE IMPROPERLY MANUFACTURED AND CAN FRACTURE CAUSING SHAKING OR SHIMMY AT LOW SPEEDS. DEALERS WILL INSPECT THE INNER TIE RODS AND REPLACE THE SUSPECT TIE RODS. POTENTIAL UNITS AFFECTED: 49300 RECALL DATE: MAR 15, 1995 MODEL AFFECTED: 1995 FORD EXPLORER SUMMARY: IN SOME OF THE VEHICLES, BRAKE TUBES WERE MISROUTED BETWEEN THE MASTER CYLINDER AND THE HYDRAULIC CONTROL UNIT AND RESULTS IN EXCEEDING THE ALLOWABLE STOPPING DISTANCES AS REQUIRED BY FMVSS NO. 105, "HYDRAULIC BRAKE SYSTEMS." IN ADDITION, SEALS WITHIN THE MASTER CYLINDER COULD BE ABRADED BY THIS CONDITION OVER TIME RESULTING IN AN INTERNAL LEAK AND A FURTHER REDUCTION IN BRAKE PERFORMANCE. REMEDY: DEALERS WILL REROUTE THE BRAKE TUBES. POTENTIAL UNITS AFFECTED: 8100 RECALL DATE: JAN 31, 1996 MODEL AFFECTED: 1995 FORD EXPLORER SUMMARY: VEHICLE DESCRIPTION: MULTI-PURPOSE PASSENGER VEHICLES. THIS IS NOT A SAFETY RECALL IN ACCORDANCE WITH FEDERAL REGULATION 573. HOWEVER, IT IS DEEMED A SAFETY IMPROVEMENT CAMPAIGN BY THE AGENCY. THE CAMPAIGN WILL REINFORCE THE BRACKET ATTACHMENTS OF THE REAR LIFTGATE GAS ASSIST CYLINDERS WHICH COULD PULL AWAY FROM THE INSIDE OF THE LIFTGATE. REMEDY: FORD DEALERS WILL REINFORCE THE BRACKET ATTACHMENTS. POTENTIAL UNITS AFFECTED: 1029380 RECALL DATE: NOV 28, 2000 MODEL AFFECTED: 1995 FORD EXPLORER SUMMARY: VEHICLE DESCRIPTION: SPORT UTILITY VEHICLES. UNDER CERTAIN CONDITIONS, A FRONT SWAY BAR LINK CAN FRACTURE. DEALERS WILL REPLACE BOTH THE LEFT AND RIGHT FRONT SWAY BAR LINKS. POTENTIAL UNITS AFFECTED: 810,000. *TR
Crash:
No
Fire:
No
Injuries:
0
Deaths:
0
#10444582January 19, 2012
UNKNOWN OR OTHER
PURCHASED VEHICLE FROM PRIVATE SELLER. I ASKED THE SELLER WHY THE O/D LIGHT OFF WAS FLASHING ON THE DASH. HE SAID HE HAD NO EXPERIENCE WITH ENGINES AND HE DIDN'T KNOW WHAT IT WAS FOR. THE NEXT DAY, I WAS CHECKING ALL FLUIDS AND LEVELS. ANYWAY, I LOOK IN THE TRANSMISSION FILLING AREA AND NOTICED THE LEVEL WAS WAAAYYY PAST FULL (ABOVE CROSSBAR AREA); I SEE THAT THERE IS ONLY MILKY-PINK LIKE SUBSTANCE IN IT. FROM ALL THE RESEARCH I HAVE DONE ALREADY, I THINK THE PINK SUBSTANCE IS A MIXTURE OF TRANSMISSION FLUID AND ANTI-FREEZE. I HAVE NOT HAD A CHANCE (OR THE MONEY) TO KNOW EXACTLY WHAT IS WRONG WITH IT, BUT I DO KNOW THAT ANTI-FREEZE IS NOT SUPPOSED TO BE IN THE TRANSMISSION FLUID AREA(S). MY GUESS IS THAT THE PROBLEM WAS CAUSED BY AN INTERNAL FAILURE IN THE RADIATOR COOLING LINE. I BELIEVE THAT FORD SHOULD RECALL THESE TRANSMISSIONS BECAUSE THEY KNOW IT IS A MAJOR PROBLEM. PLEASE, IS THERE ANYONE THAT HAS ALREADY STARTED A CLASS-ACTION LAWSUIT ON FORD BECAUSE OF THIS MATTER? KNOWING THAT THEY ARE SELLING (OR SOLD) A DEFECTIVE PRODUCT TO HUNDREDS OF THOUSANDS OF CUSTOMERS.THIS HAS TO BE A MANUFACTURER ISSUE! THE CONSUMER SHOULD NOT BE RESPONSIBLE FOR THIS ISSUE. *TT
Crash:
No
Fire:
No
Injuries:
0
Deaths:
0
#10442017January 1, 2012
POWER TRAIN
DRIVING IN LIGHT CITY TRAFFIC, "OVERDRIVE" INDICATOR LIGHT BEGAN BLINKING ON AND OFF A FEW SECONDS AFTER PULLING AWAY FROM A TRAFFIC LIGHT, ENGINE RACED AND WOULDN'T UPSHIFT, THEN IT JUST COASTED TO A STOP, AND WOULDN'T GO ANYMORE. WE HAD TO HAVE VEHICLE FLATBEDDED TO A REPAIR SHOP, AND FOUND TRANSMISSION NEEDED A COMPLETE REBUILD, WHICH COST ABOUT $3,800. *TR
Crash:
No
Fire:
No
Injuries:
0
Deaths:
0

← Back to Ford Explorer