Ford Expedition Complaints (2021)

242 consumer complaints on file.

#11630149December 11, 2024
STEERING
The contact owns a 2021 Ford Expedition. The contact stated that the vehicle was difficult to steer and was pulling to the left and to the right. There was no warning lights illuminated. The EPAS system was turned off by the owner. The vehicle was taken to an independent mechanic for an alignment. The vehicle was repaired but the failure recurred. The contact received notification of NHTSA Campaign Number: 24E055000 (Steering); however, the part to do the recall repair was not yet available. The local dealer was contacted. The contact stated that the manufacturer had exceeded a reasonable amount of time for the recall repair. The manufacturer was made aware of the issue. The contact requested a buy back, but the vehicle failed to meet the requirements. The approximate failure mileage was 24,000. VIN tool confirms parts not available.
Crash:
No
Fire:
No
Injuries:
0
Deaths:
0
#11629636December 9, 2024
ENGINE, POWER TRAIN
The contact owns a 2021 Ford Expedition. The contact state while driving 55 MPH, there were abnormal sounds coming from the engine and the transmission. The temperature gauge warning light was illuminated. The vehicle was taken to a Chevrolet dealer twice to be diagnosed. The contact was informed that the transmission needed to be replaced. The transmission was replaced, and the vehicle was repaired. After the second repair the contact noticed that the engine was overheating. The vehicle was taken to a Ford dealer and the transmission was replaced another time. The manufacturer was notified of the failure but offered no assistance. The approximate failure mileage was 89,035.
Crash:
No
Fire:
No
Injuries:
0
Deaths:
0
#11627259November 25, 2024
ELECTRICAL SYSTEM
My car continues to have electrical problems since 14 months after my purchase. I have reported it to Ford service multiple times as well as Corporate. Each time the same problem happens, I report it here as well. This is the 5th time that this has happened. Each time it has happened, I am at a red light and while waiting, my car just shuts off completely. In the beginning I could press my start button after 1-2 minutes and my car would restart. However, the 4th time it took 9 minutes before my car would start up. It happened again this past week. It took no longer than a minute for my car to start up again. I went to my local dealership and after they took a look, they just think the button with the "A and an arrow circling it" just triggered something and thats why it shut off. They told me there was nothing that they could do. My battery looked fine. This has happened so many times to my vehicle and its the same response, "my car is fine," it just triggered because it's "cold outside." Just tired of the Ford Corporation not fixing this problem in the Expedition. I have read stories on here with the same issue. Be aware if you drive this vehicle because one day someone will seriously get hurt.
Crash:
No
Fire:
No
Injuries:
0
Deaths:
0
#11625916November 18, 2024
EXTERIOR LIGHTING
Passenger side front headlight failure. The LED turns purple. Appears this is a common problem on vehicle with this type of headlight assembly F series as well. Dealers claim they don't know about it but a quick search to find its a common issue. Available for inspection. Light failure, confirmation is it is now always that way. Was inspected at the dealership and informed it was $3000 to replace the light assembly. No warning driver in front of me informed me to the issue.
Crash:
No
Fire:
No
Injuries:
0
Deaths:
0
#11625267November 14, 2024
POWER TRAIN
The contact owns a 2021 Ford Expedition. The contact stated that while driving at various speeds, the vehicle would hesitate upon the depression of the accelerator pedal without warning. During one failure, the contact shifted the vehicle from drive(D) to park(P) and the vehicle began to roll backward as though the vehicle were in neutral(N). The contact then shifted the vehicle back to drive(D) and the vehicle resumed normal operation. The vehicle was taken to a dealer where the contact was informed that the only way to diagnose the problem would be to duplicate the failure. The manufacturer was also notified of the failure and the contact was given the same information as the dealer. The contact was then referred to the NHTSA Hotline to file a complaint. The vehicle had yet to be diagnosed or repaired. The failure mileage was approximately 41,000.
Crash:
No
Fire:
No
Injuries:
0
Deaths:
0
#11623483November 4, 2024
ELECTRICAL SYSTEM, SERVICE BRAKES, UNKNOWN OR OTHER
I was on my way to my daughter's school. We got off the on ramp to her school and while waiting at the red stop light, my car stalled. The wheels locked. My brake pedal and gas pedal were not working when the stop light turned green. The car dashboard was showing the power to be on but nothing was working. After a minute, the battery light and the a light with the arrow that kind of circles around it started blinking. I put my hazards and waved people behind me to go around me. After a few minutes, my car started to go backwards on the on-ramp. I looked back and could feel and see my car going backwards toward the cars behind me. The traffic behind me on the on-ramp started to honk at me. They could see what was happening too. I put the car from drive to park and put my emergency brake and the car stopped. I called 911 and explained what was happening. After a few more minutes, two men in two different vehicles came and offered to help push my car. One of them asked me to put my car in neutral but my car was not allowing me to turn to the different shifts. All of a sudden my car starts blinking again. One of the guys told me to try to press the power again. All of a sudden my car starts powering up again. I thanked the two men and finished dropping off my daughter to school. From the time my car stalled and turned back on was about 8-9 minutes. This car has shown problems over and over with Ford. I have had 3 new car batteries since owning this vehicle in the 3 years I've had it. I've reported all the different car issues on the NHTSA website. I just had my oil changed a few months ago. My car just had a few things fixed in June. I have never been so shaken up like this before. My legs and hands could not stop shaking. I couldn’t stop crying. I’ve never been so scared in my life in this vehicle. This was the first time my kid was with me when my car has stalled like this. For my car to lose complete function was the scariest moment in my life with my kid.
Crash:
No
Fire:
No
Injuries:
0
Deaths:
0
#11621562October 23, 2024
VISIBILITY:WINDSHIELD WIPER/WASHER
The contact owns a 2021 Ford Expedition. The contact stated that while the vehicle was parked, the contact noticed a puddle of blue windshield washer fluid on the ground underneath the vehicle. In addition, the contact stated that the washer fluid was also coming into the front floorboards of the vehicle. The contact stated that due to the failure, the interior of the vehicle had an awful odor and mold. The vehicle was taken to the dealer; however, the failure could not be duplicated. The vehicle was not diagnosed or repaired by an independent mechanic or the dealer. In addition, the contact stated that he had not refilled the windshield washer fluid reservoir in 6 months due to the failure. The manufacturer was made aware of the failure. The failure mileage was approximately 27,000.
Crash:
No
Fire:
No
Injuries:
0
Deaths:
0
#11621154October 21, 2024
POWER TRAIN
When stopped, the auto start stop comes on and the engine turns off. Suddenly a warning comes on and says that the vehicle has to be put in park and push the start button to start the engine again. It will not start automatically when the brake pedal is released. This has happened a number of times. I have not been to the dealer.
Crash:
No
Fire:
No
Injuries:
0
Deaths:
0
#11618638October 8, 2024
ENGINE, POWER TRAIN, VEHICLE SPEED CONTROL
At 40,000 miles Transmission skips gears going from 3-4 4-5 and 7-8. Transmission jolts hard when put into reverse. Valve body was replaced which fixed the issue for a couple of months and now the same issues are occurring.
Crash:
No
Fire:
No
Injuries:
0
Deaths:
0
#11618074October 4, 2024
ELECTRICAL SYSTEM, ENGINE
The Engine is shutting off completely. I am getting the message "Shift to P. the Restart Engine" This happened as the light changed to green. Heavy morning work traffic was behind me and I had never seen this before and called Ford Service manager and he had no answer. This is very dangerous especially during traffic.
Crash:
No
Fire:
No
Injuries:
0
Deaths:
0
#11612740September 5, 2024
POWER TRAIN
Transmission slams into gear when coming out of park, into drive
Crash:
No
Fire:
No
Injuries:
0
Deaths:
0
#11612738September 5, 2024
POWER TRAIN
The Powertrain control system has detected an internal PCM communications error PCM will invoke failure mode effect management.
Crash:
No
Fire:
No
Injuries:
0
Deaths:
0
#11612417September 3, 2024
POWER TRAIN
Shifting from park to drive on a level surface, the transmission will sporadically slam into gear so hard that the vehicle lurches forward. By the time I got to the dealership, it would not duplicate the problem. This vehicle has had the transmission rebuilt/replaced 4 times for this issue (among other issues), and there is less that 40,000 miles on the vehicle. The transmission also slams into gear on 3rd, 5th, and sometimes 6th (upshift and downshift). It will sporadically downshift when at highway speeds regardless of changes in speed or incline.
Crash:
No
Fire:
No
Injuries:
0
Deaths:
0
#11610170August 22, 2024
POWER TRAIN
The power train failed to accelerate and completely disengaged. While trying to avoid being t-boned by another car, the vehicle failed to accelerate when required. The RPM gauge showed the acceleration demand but it did not transfer to the power train. Luckily the car running the red light swerved to miss us because we were not able to proactively avoid the collision. Ford first replaced the transmission plate, after recurrence is now offering a transmission rebuild under warranty. Now out of warranty, concerned issues will continue as Ford dealer not forthcoming on the repairs being done stating multiple issues are not related.
Crash:
No
Fire:
No
Injuries:
0
Deaths:
0
#11608787August 15, 2024
FUEL/PROPULSION SYSTEM
My catalytic converter of my 2021 expedition is going out. We had a 2019 Ford Expedition Texas Edition and I had the same issue. We purchased our current expedition in April of 2023. This spring the converter was signaled with the check engine light and since then my vehicle has had issues with acceleration, it consumes gas at an extremely high rate and my engine works harder over time. My concern is that my vehicle will have an engine malfunction or put me into bankruptcy by the amount of gas it consumes per trip. I found that many other expeditions from the years 2018-2022 have similar issues to mine, in fact one of my friends in town had the same issue. I reported my issue to Ford and they said they would not repair. My vehicle has less than 80k miles on it.
Crash:
No
Fire:
No
Injuries:
0
Deaths:
0
#11606955August 7, 2024
POWER TRAIN
Expedition has roughly 33,000 miles on it. I took it into the dealer for service b/c the transmission was acting jumpy. By the time it got to the dealer for service, Pacifico Marple Ford deemed it undrivable and it needs a new transmission. I don't think the transmission should have went that quickly.
Crash:
No
Fire:
No
Injuries:
0
Deaths:
0
#11604517July 25, 2024
ELECTRICAL SYSTEM, BACK OVER PREVENTION: WARNINGS
The 360 degree backup camera displays a black screen when activated in both reverse and forward parking mode. This causes myself & any other driver to not have clear vision around the vehicle while in reverse posing a severe safety hazard. This problem has been reported & confirmed diagnostically from my local dealership as well as reported to Ford Motors itself resulting in a case being opened regarding the safety issue. I have been told by Ford on multiple occasions that they will expedite my case & call me back with information, however it has been over 6 weeks and I have had to call them e Rey time to follow up. This back up camera safety issue has already been recalled on other makes & models of Ford vehicles including the year model before my vehicle. My dealership told me that although this exact same issue is recalled on other vehicles, I would need to pay the estimated $1500 to repair my issue. This has caused me and my family a significant amount of stress because we have young children, drive carpool for elementary school and need to be able to see our surroundings dings when backing up and parking. Several times I have come close to hitting something when parking because I can’t see from the camera. The NTHSB has also issued safety recalls for Ford backup cameras having this exact same issue and this is a huge safety issue for my model Ford as well. Ford knows there’s a safety issue and is not taking this seriously. We intentionally paid extra for this camera to ensure adequate vision while reversing and parking, this is unacceptable on Ford’s part to not escalate this issue and repair the defective camera at no cost. I desperately need help in getting Ford to fix this before a serious avoidable injury or accident occurs. I do not have another car I can drive and am stressed every time I drive now.
Crash:
No
Fire:
No
Injuries:
0
Deaths:
0
#11604190July 24, 2024
POWER TRAIN
The transmission in this vehicle has been consistently needing repair. It is available for inspection. Concerned transmission will fail and leave family stranded. The problem has been reported to the dealer and the manufacturer 8 times over the past two years and they are still unable to fix the transmission. The vehicle has also had error messages about the problem.
Crash:
No
Fire:
No
Injuries:
0
Deaths:
0
#11603546July 20, 2024
UNKNOWN OR OTHER
Unknown, it appears to be a Transmission issue the vehicle shifts hard, loses power while driving, and delayed acceleration.
Crash:
No
Fire:
No
Injuries:
0
Deaths:
0
#11603115July 18, 2024
POWER TRAIN
The contact owns a 2021 Ford Expedition. The contact stated that while at a four-way stop, the vehicle failed to move, and downshifted to first gear. The check engine warning light was illuminated. The vehicle was taken to the local dealer, where it was diagnosed and determined that the transmission needed to be replaced. The vehicle was repaired. The manufacturer was contacted and referred the contact to the NHTSA Hotline. The failure mileage was approximately 115,000.
Crash:
No
Fire:
No
Injuries:
0
Deaths:
0

← Back to Ford Expedition